National Building Code And Construction Health And Safety In Nigeria

oresegun adedapo tolulope F/HD/06/3510041 INTRODUCTION WHAT ARE BUILDING CODES According to Microsoft learning essentials (Encarta 2008), Building codes, are municipal and state laws regulating the construction of buildings and prescribing minimum requirements for fire protection, sanitation, and safety. Such laws are intended primarily to set standards for new construction but also to prevent the continued use of buildings deficient in these respects. Often attacked as confiscatory, these laws have been held by the courts to be within the police power of the state. The advent of building codes could be traced as far back as 1790 B.C. when the code of HAMMURABI came into existence. The code stressed the point of that the safety of the occupants should be put into consideration during the construction of such building otherwise, heavy penalties awaits the builder of such a building if the building eventually collapse. The code of HAMMURABI states as follows: if a man builds for another and the building collapse and kills the owner, the builder will be put to death. If the building kills the son of the owner, the son of the builder will be put to death. If the building destroys the property of the owner, the builder will replace the damaged property. 1

oresegun adedapo tolulope F/HD/06/3510041 THE NATIONAL BUILDING CODE IN NIGERIA The National Building Code is a document that was signed into law in 2007 by the civilian regime of Chief Olusegun Obasanjo after a series of building collapse in Nigeria especially in Lagos. The government as at that time felt that there was need to put a stop to the incessant collapse and also, to eventually to put Nigeria into a more planned status. This reason gave bought about the advent of the National building code. GENERAL CONTENT The National Building Code has 4 Parts and 14 sections Part 1 This part contains 3 sections and deals with the administration.  Section 1

Citation

 Section 2

Definitions

 Section 3

Administration by committee

2

oresegun adedapo tolulope F/HD/06/3510041 Part 2 This part deals with the technicality in the building process in the following sections  Section 4

Building typology

 Section 5

The construction process by elemental classification

 Section 6

Environmental requirements



Section 7,8,9

The professionals and their responsibilities

 Section 10

The building materials and their components

 Section 11

Construction

 Section 12

Post construction technology requirements

Part 3 This part deals with the enforcement of the code  Section 13

Control of building works.

Part 4 This part contains schedules and references 3

oresegun adedapo tolulope F/HD/06/3510041  Section 14

Referenced standards

And on the final note contains the compliance form. HEALTH AND SAFETY IN CONSTRUCTION Health as defined by Longman’s Dictionary of Contemporary English is a state of being well in body and mind and free from disease while Safety is described by the same dictionary as a condition of being free from danger, harm or risk. Bokinni (2006) on the other hand describe Safety as a control of recognized hazards to attain an acceptable level of risk. Naturally, the effect of construction on Safety, Health and the surrounding environment would vary from particular operations starting with extraction of building materials from quarries and methods by which the extraction is occurring, transportation, preparation of building materials at site and construction of works processes. Health and Safety in Building construction projects should be a major concern for everybody in the construction industry but it is a pity that it in this part of the world especially in Nigeria, enough attention is not been given to the issue. In the Civil and building construction works which involve excavation, and/or demolition, concrete work, painting, roofing, operation of machines, plant and equipment, use of hand tools and many other operations call for attention from 4

oresegun adedapo tolulope F/HD/06/3510041 relevant authorities, regulatory bodies, societies, scientists, professionals and businessmen to establish safety and health management programs and laws governing construction works activities. Health and Safety is an inevitable aspect of construction and this is so because the only time an employee will perform his duties is when the employee is in good health and is sure of a safety working condition. This boils to the fact that a worker will perform his duties to the fullest only when he is sure that even when an accident occurs he will be taken good care of. One of the most important things that an employer should provide to his employees is safety even at a low risk site. At sites where heavy machinery is being used; it is certain that the level is higher because of the mechanical movement of parts of such machinery and therefore for the employee that will be monitoring or operating such machinery will be exposed to accidents. In a case like this, it should be known that the level of safety that will be provided will be much more than that of a site where ordinary hand tools are been used. Based on the above, we now understand that the level of Safety and Health protection will be higher nowadays because of the rapid mechanization of the construction industry and the accidents that may occur will definitely be more fatal. 5

oresegun adedapo tolulope F/HD/06/3510041 ACCIDENTS ON CONSTRUCTION SITE Accidents are some unpleasant and damaging happenings or occurrence that happens unexpectedly or by chance or by mistake. (Longman’s Dictionary of Contemporary English). Encarta Dictionary also state that accidents are mishap which are unplanned and unfortunate events that result into damage, injury or upset of some kind. Accidents on construction sites cannot be over emphasized; it could happen as a result of a mistake or lack of concentration or even natural disaster. Accidents can occur even when the job to be done is minimal and could be very disastrous. ACCIDENT INVESTIGATION The rationale behind investigation of accidents is to determine the causes of such with a view of preventing a reoccurrence, gather data for use in any criminal or civil proceedings, to enable confirm or refuse of a claim or injuries benefit and paper notifications to be made to enforcing agency. During the investigation of an accident the following should be answered: • What caused the accident • Who was involved in the accident 6

oresegun adedapo tolulope F/HD/06/3510041 • When did it occur • Whether the person involved was wearing protective clothing • How it could have been prevented • How it will not re-occur ACCIDENT REPORTING Reporting or recording accidents should be a day-to-day thing as the work progresses. On this note, it makes it important for an accident register book to exist on site in which all types of minor injuries such as bruises, to major accidents like imputing disability and fatal be recorded. Death or dangerous injuries should be reported by the quickest means (usually telephone) and subsequently confirmed in writing as soon as possible. The report should state the date and time of the occurrence, full name and occupation of the injured person, the place of the occurrence and a brief description of the circumstance. Below is a format an accident record and information it contains: Full Name: Occupation: Nature of injury/condition: Place of occurrence: 7

oresegun adedapo tolulope F/HD/06/3510041 Date and time: Brief description of circumstances: Action taken: ACCIDENT CONTROL When an accident occur , it only shows that something has gone wrong with one or more process of the job or some elements of carelessness on the part of the workers or an employer has created an unsafe condition of work. Therefore an employer or site supervisor should put in place all necessary prevention or control materials and take control of contributory causes of the accident. The employer or site supervisor should also know the physical and mental state of the workers to be sure of the safety level of the site. In ascertaining a reasonable safety control level, the site supervisor should put into consideration the following: 1. Supervisor safety analysis • job hazard analysis • enforcement of safety rules • adequate safety knowledge • promotion of employee participation in safety • development of safety working condition 8

oresegun adedapo tolulope F/HD/06/3510041 2. Mental condition of worker 3. Physical condition of worker Other measures of accident control as explained by Bokinni (2006) are highlighted below: The work environment 1. All floors should be clean, not slippery and free from debris 2. Stairs, gangways and loading bays should be adequately guarded and maintained 3. Adequate illumination for workspace 4. Holes, edges and opening should be adequately protected. 5. Display of standard warning signs where hazard exists 6. Materials and components should be stacked correctly 7. Projecting objects or obstacles should be adequately protected. Protective clothing Provision of protective clothing and equipments are as well important. For safety purpose, workers on a construction site should be adequately protected using the following clothing or \ and equipments • safety helmets • safety boots • welding shields 9

oresegun adedapo tolulope F/HD/06/3510041 • vision goggles • waist safety belts for ladders • Industrial gloves. • green welder’s gauntlet • dust mask • Ear defenders. E.t.c OCCUPATIONAL HEALTH AND SAFETY IN CONSTRUCTION SITES. Occupational Health is the promotion and maintenance of the higher degree of physical, mental and social well-being of workers in all occupations. At the construction workplaces the workers are exposed to hazards of occupational diseases and injuries and the adverse effects of excessively long hours of work. Machines, plants and other sophisticated construction equipment posse danger to the operators, who in most cases do not have prior skills for operating such machines or plants. Occupational health services should be concerning with the preventive measures laid down to guide the employers the workers and their representatives on the requirements for a safe healthy working environment. A worker should be assigned duties in relation to his physical and mental health and skills. 10

oresegun adedapo tolulope F/HD/06/3510041 Further, employers should have complete control over their employees and therefore ensure adherence to safety practices. The company must comply with all provisions of safety and health regulations that pertain to the construction works itself. HEALTH AND SAFETY PROGRAMMES Safety program on a project is set by the prime contractor’s project manager who maps out a program of safety measures commensurate with the size of the project and the conditions and hazards peculiar to it. (Mwombeki, 2005). Programs for construction safety as stated by Mwombeki include: • Adequate first aid facilities and trained personnel and Safety committee comprising of key personnel –supervisors, safety personnel and company doctor. • Disaster control programs, which should be maintained by the in-charge who is a qualified personnel. •

Crew leaders who hold brief meetings with workers under their supervisor at least once a week to discuss the safety operation of their crew and workers, and specific problems (held after the safety committee meeting)

• Safety instructions given to all new workers as part their introduction

11

oresegun adedapo tolulope F/HD/06/3510041 •

Special mass safety meetings called by the project engineer (all workers attend this meeting)

•

Safety devices designed to prevent injury and accidents during building and road construction works.

•

Management and supervisors visit the workers and inspect the works and participate in the safety programs periodically.

•

Evaluation and review of programs as required by changing conditions to address new problems that may arise.

OBJECTIVES OF THE PROGRAMME According to Bamishile (2004) the programme’s main objectives are listed as follows • To secure the health, safety and welfare of all those who work or visit the work site. • To protect persons other than persons listed above against risk to health and safety arising out of, or in connection with the activities of persons working on the site. •

To control the admission into the atmosphere of noxious or offensive substance.

• To control the keeping and use of explosion or highly flammable or otherwise dangerous substance. 12

oresegun adedapo tolulope F/HD/06/3510041 • To control the use on site of substance that may be hazardous to health. HEALTH AND SAFETY POLICY This a legislative instrument put in place to ensure that at all times , the safest and healthiest working conditions is provide at a work site using measures of international standard. It also states the responsibilities at the top management to the general to the general workforce. SAFETY ARRANGEMENTS OF THE POLICY. • The management will make known all the risk and health hazard as far as the construction site is concerned. • The management of the firm will ensure a qualitative training of personnel as regards safety on site. •

The construction manager / safety manager will identify the main hazards on the construction site and set additional rules and regulation.

• In the case of accidents, the procedure laid down for accident reporting will be followed and the result of accident analysis will be available to management and the health and safety committee.

13

oresegun adedapo tolulope F/HD/06/3510041

HEALTH AND SAFETY COMMITTEE This is a committee that ensures a reduced level of risks to health and safety on site and it comprises of: 1. SENIOR PROJECT MANAGER - Chairman/ Safety manager. 2. PROJECT MANAGER – Secretary 3. PROJECT SUPERVISOR – Member 4. SCAFFOLD SUPERVISOR – Member HEALTH AND SAFETY TRAINING In order to promote safety awareness on maintenance site, the operators of the site at all levels should be trained for the safety and health on site. This training programme is to be arranged at least once every month and must be compulsory for all site operators. The issues to be treated are listed below; • Causes of accidents • Cost of accidents • Accident preventions • Health and safety regulations • Duties and responsibilities of participants 14

oresegun adedapo tolulope F/HD/06/3510041 • Emergency procedures •

Machine and equipment testing, inspection and maintenance.

TOOLS USED IN HEALTH AND SAFETY ADMINISTRATION • Health and safety register • Health and safety briefing sessions • Minutes of meeting of health and safety committee. • Dates and names of participants of health and training programme. SOME SECTIONS OF THE NATIONAL BUILDING CODE RELEVANT TO HEALTH AND SAFETY Section 7.43.1 states that “The provisions of this section are intended to maintain or increase the degree of public safety, health, and general welfare in existing building while permitting repair, alterations, additions, and/or change of use without requiring full compliance with sections 2, 3, 4, 5, 6, 7, 8 and 9, except where compliance with other provisions of this code is specifically required in this chapter. Section 7.43.2.2 state that “Where the code enforcement officer determines that an unsafe condition exists, as provided for in section 2.5, such unsafe condition shall be in accordance to section 2.5. 15

oresegun adedapo tolulope F/HD/06/3510041 Section 7.45.1 states that “The evaluation of the building for fire safety purposes shall be assessed as follows (a) fire safety (b) means of egress and (c) general safety as defined in sections 12.3.2.1, 12.3.2.2, and 12. 3.2.3. Section 7.46.3.1 states that “It shall be unlawful to load any structure, temporary support, scaffolding sidewalk bridge or sidewalk shed or any other device or construction equipment during the construction or demolition of any building or structure in excess of its safe working capacity as provided in section 8 for allowable loads and working stresses. Section 7.46.3.2 states that “Whenever any doubt arises as to the structural quality or strength of scaffolding plank or other construction equipment, such material shall be replaced, or the code enforcement officer shall require a strength test to four times the superimposed live load to which the material or structural member is to be subjected. The member shall sustain the test load without failure. Section 7.46.4.1 states that “When inspection of any construction operation reveals that any unsafe or irregular conditions exists, code enforcement officer shall notify the owner and direct the owner to take necessary remedial measures to remove the hazard or violation. Sections 7.46.4.2 states that “Unless the owner so notified proceeds to comply with the orders of the code enforcement officer within 7 days, the code enforcement 16

oresegun adedapo tolulope F/HD/06/3510041 officer shall have full power to correct the usage condition as provided in sections 2.3.6.2 and 2.6. All expenses incurred in the correction of such unsafe condition shall be a lien on the property. Section 7.46.4.3 states that “When the strength and adequacy of any scaffolding or construction equipment is in doubt, or when any complaint is made, the code enforcement officer shall inspect the equipment and shall prohibit its use until tested as required in section 13.1.6.2 or until all danger is removed. Section 13.5.1 states that “All building or structures regulated by this code and other related technical codes which are structurally inadequate or have inadequate means of egress, or which constitute a fire hazard, or are otherwise dangerous to life and property are, for the purpose of this section, unsafe. Section 13.5.2 states that “(g) building service equipment or installations regulated by such codes, which constitute a fire, electrical, or health hazard, or unsanitary condition, or is otherwise dangerous to human life is for the purpose of this section, unsafe. (h) any use of buildings, structures unable to sustain the design loads specified in this code are hereby designated as unsafe building appendages.

17

oresegun adedapo tolulope F/HD/06/3510041 (i) all such unsafe buildings, structures or appendages and building services equipment and installations are hereby declared to be public nuisances and shall be abated by repair, rehabilitation, depletion or removal in accordance with the procedure set forth in this code. These and many more sections in the code have spelt out the minimum level of risk a worker should be exposed to and it has also stated the minimum requirement for health and safety on every construction site. THE RELEVANCE OF THE NATIONAL BUILDING CODE TO HEALTH AND SAFETY IN CONSTRUCTION The National Building Code has been of a reasonable advantage to the construction industry in Nigeria especially in the aspect of health and safety of workers on site. The provisions of the Code with respect to health and safety has been of tremendous help in stating the responsibilities of the parties involved In the construction industry in providing health and safety. Originally the average Nigerian worker does not know his right as pertain to health and safety and will see the provision of the same as a favour or privilege instead of a right. But the code has shown that it is one of the primary duties of the employer to ensure a good and safe working condition. 18

oresegun adedapo tolulope F/HD/06/3510041

CONCLUSION In conclusion the National Building Code addressed the issue of health and safety in the construction industry amongst other issues addressed. The emergence of the National Building Code will also make construction work to be carried out in the safest possible working conditions. The National Building Code, if properly followed and implemented, will prune the construction industry of all forms of unsafe acts, unsafe working condition, and unsafe process of construction.

19

oresegun adedapo tolulope F/HD/06/3510041

REFERENCE Bokinni . S .K. (2006) Building aftercare, Tony terry publisher, Lagos. Bamishile .A. (2004) Building Production Management, Wemimo Adetayo Publishers , Lagos Federal Republic of Nigeria National Building Code (2006) LexisNexis Butterworks, South Africa. Bokinni. S. K (1999) Give the art of safety awareness, accident prevention a new look (unpublished) pg (1,3 ,9) Bokinni .S. K (2002) Industrial Safety and Accident Prevention (unpublished) CALIFORNIA HEALTH AND SAFETY CODE -- SECTIONS 105400-105430. www.hse.com Hassan et al. Perception Of Building Construction Workers Towards Safety, Health And Environment, unpublished. www.um.edu.my/hassan.pdf Health and Safety Executive www.hse.com Mwombeki F.K. (2005). Occupational Health & Safety Challenge in Construction Sites in Tanzania, unpublished, www.hse.com 20

oresegun adedapo tolulope F/HD/06/3510041 Occupational Health and Safety Policy Administrative Policies Administration and Governance. www.uottawwa.ca

21