1996 Escort Maintenance Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

General Information *[BK00050( ALL)05/95]

thirty-two pica chart:0060629-D

1

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

Table of Contents

General Maintenance Information ............... 3 What Maintenance Schedule Do You Follow? ................................................................ 6 Normal Schedule............................................... 7 Severe Duty Schedule ................................... 27 Owner Maintenance Checks ........................ 54

*[BK00110( ALL)05/95]

twenty-two pica chart:0060691-A

2

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

Maintenance Schedule and Record *[BK00125(BEF )05/93] quarter page art:0060553-B

*[BK00200( ALL)01/95] *[BK00300( ALL)01/95]

*[BK00350( ALL)01/95]

General Maintenance Information The required Scheduled Maintenance Services listed in this booklet are considered essential to the proper operation, safety and performance of your Ford Motor Company vehicle. We recommend that you also perform the Owner Maintenance Checks listed. These services are matters of day-to-day care that are also important to the proper operation of your vehicle. The recommended lubricants, fluids and service parts conforming to Ford Specifications are available from your dealer. This booklet gives you a place to record the services that are performed on your vehicle so that you can keep a record of when parts should be checked or replaced. Give your Maintenance Schedule and Record booklet to the dealer service manager.

3

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK00400( ALL)01/95] *[BK00500( ALL)01/95]

Maintenance: An investment

*[BK01300( ALL)01/95]

To assure the durability of your vehicle and its emission control systems, it is necessary that scheduled maintenance be performed at the designated intervals.

*[BK01400( ALL)05/95]

Ford strongly recommends the use of genuine Ford replacement parts. If other than Ford or Motorcraft parts or Ford authorized remanufactured parts are used for maintenance replacements or for the service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability. It is the owner’s responsibility to determine the equivalency of such parts. Please consult your warranty booklet for complete warranty information.

*[BK01410( ALL)05/95] *[BK01415(BEF )05/95]

No Cost PCV Valve Replacement

An investment which will pay dividends in the form of improved reliability, durability, and resale value.

THE PCV VALVE IS A CRITICAL EMISSION COMPONENT. YOUR DEALER WILL REPLACE THE VALVE AT NO COST AT 60,000 MILES/96,000 KILOMETERS (EXCEPT CANADA AND CALIFORNIA VEHICLES).

4

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK01435( ALL)06/94] *[BK01455( ALL)06/94]

*[BK01462( ALL)01/95] *[BK01464( ALL)01/95] *[BK01466( ALL)08/93]

Wheel Lug Nuts Wheel lug nuts must be retightened to proper torque specifications at 500 miles/800 km of new vehicle operation (100 miles/160 km for vehicles equipped for snowplowing). Proper torque specifications are provided in your Owner Guide. Also retighten to proper torque specification at 500 miles/800 km after (1) any wheel change or (2) any other time the wheel lug nuts have been loosened. PRE-DELIVERY CHECK

❑ Pre-Delivery Service Inspection Completed

four pica chart:0060627-A

5

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

What Maintenance Schedule Do You Follow? *[BK01701(BEF )02/95] *[BK01801(BEF )01/95]

Normal Schedule Follow the Normal Schedule for most normal everyday driving conditions.

*[BK01901(BEF )01/95]

Severe Duty Schedule

*[BK02001(BEF )01/95]

Follow the Severe Duty Schedule if your driving habits FREQUENTLY include one or more of the following conditions:

*[BK02101(BEF )05/93] *[BK02201(BEF )01/95] *[BK02301(BEF )01/95]

❑ Towing a trailer or carrying a heavy load. ❑ Operating in severe dust conditions. ❑ Extensive idling, such as police, taxi or

*[BK02401(B F )05/93] *[BK02501(B F )05/93] *[BK02600(BEF )01/95]

❑ Snowplowing ❑ Off-Road operation ❑ Short trips of less than 10 miles (16

door-to-door delivery service.

km) when outside temperatures remain below 0˚F (-18˚C).

6

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

Normal Schedule *[BK29000(BEF )01/95]

NOTE: Items for Emission Control Service are shown in this type and style.

*[BK29100(BEF )02/91]

For items marked with number in parentheses such as (1), see footnote at end of this section. NOTE: Rear axle lube quantities must be replaced every 100,000 miles (160,000 km) or if the axle has been submerged in water. Otherwise, the lube should not be checked or changed unless a leak is suspected or repair required.

*[BK29350(BEF )02/95]

Regular Maintenance Intervals for the Normal Schedule

*[BK29400(BEF )01/95] *[BK29500(BEF )01/95] *[BK29700(BEF )05/94] *[BK29900(B F )08/94] *[BK30000(BEF )04/93]

5,000 MILES (8,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK30150(BEF )04/94]

❑ Lubricate steering linkage suspension,

shift linkage.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped).

Normal Schedule 7

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK30200(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK30225(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

loose parts. Remove any foreign material trapped by exhaust system shielding.

*[BK30250(BEF )08/93] four pica chart:0060627-A

*[BK30300(BEF )01/95] *[BK30400(BEF )01/95] *[BK30475(BEF )08/93]

10,000 MILES (16,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK31100(BEF )01/95] *[BK31200(BEF )01/95] *[BK31300(B )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK31400(BEF )05/94] *[BK31700(B F )08/94] *[BK31800(B F )04/93]

❑ Rotate tires and adjust air pressure. (1)(2) ❑ Check clutch reservoir fluid level. ❑ Lubricate transfer case shift lever pivot bolt

*[BK31900(BEF )04/93]

❑ Inspect and lubricate automatic transmission

15,000 MILES (24,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

and control rod connecting pins (4x4). shift linkage.

8 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK32000(BEF )04/94]

❑ Lubricate steering linkage suspension,

*[BK32200(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK32300(BEF )04/94] *[BK32400(BEF )05/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect exhaust system for leaks, damage or

*[BK32450(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK32650(BEF )04/94]

❑ Change fuel filter (Recommended but not

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). slide rails.

loose parts. Remove any foreign material trapped by exhaust system shielding.

required for California Certified Vehicles).

*[BK32675(BEF )04/93] four pica chart:0060627-A

*[BK32700(BEF )01/95] *[BK32800(BEF )01/95] *[BK33050(BEF )04/93]

20,000 MILES (32,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

Normal Schedule 9

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK33500(BEF )01/95] *[BK33600(BEF )01/95] *[BK33700(BEF )05/94] *[BK33900(B F )08/94] *[BK34000(BEF )04/93]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK34150(BEF )04/94]

❑ Lubricate steering linkage suspension,

*[BK34200(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK34225(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

25,000 MILES (40,000 Kilometers)

shift linkage.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

*[BK34250(BEF )04/93] four pica chart:0060627-A

10 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK34300(BEF )01/95] *[BK34400(BEF )01/95] *[BK34650(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK34700(BEF )03/94]

❑ Replace air cleaner filter every 30,000 miles

*[BK34800(BEF )03/94]

❑ Replace crankcase emission air filter. If operating

*[BK34850(BEF )01/95] *[BK34851(BEF )03/94] *[BK35400(B F )04/93] *[BK35800(BEF )04/94]

❑ Change automatic transmission fluid.

30,000 MILES (48,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

(48,000 km) or 30 months. If operating in dusty conditions, consult your dealer and/or follow severe duty maintenance schedule. in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.)

NOTE: Except C6 and E4OD transmissions.

❑ Lubricate transfer case shift lever pivot bolt and control rod connecting pins (4x4). ❑ Inspect disc brake system, lubricate caliper slide rails.

*[BK35900(BEF )04/94] *[BK36000(BEF )05/94] *[BK36500(BEF )04/93] *[BK36700(BEF )05/93] *[BK36800(B F )04/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect and lubricate front wheel bearings. ❑ Inspect parking brake system for damage and

*[BK36900(B F )04/93]

❑ Inspect and lubricate spindle needle bearings

*[BK37000(B F )04/93]

❑ Inspect and lubricate hub locks (4x4).

operation. ❑ Lubricate throttle kickdown or TV lever ball studs. ❑ Lubricate front axle R.H. axle shaft slip yoke (4x4). (4x4).

Normal Schedule 11

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK37250(BEF )04/94]

❑ Change fuel filter (Recommended but not

required for California Certified Vehicles).

*[BK37275(BEF )04/93] four pica chart:0060627-A

*[BK37300(BEF )01/95] *[BK37400(BEF )01/95] *[BK37550(BEF )05/94] *[BK37700(B F )08/94] *[BK37800(BEF )04/93]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK37950(BEF )04/94]

❑ Lubricate steering linkage suspension,

*[BK38000(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK38025(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

35,000 MILES (56,000 Kilometers)

shift linkage.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

*[BK38050(BEF )04/93] four pica chart:0060627-A

12 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK38100(BEF )01/95] *[BK38200(BEF )01/95] *[BK38300(BEF )04/93]

40,000 MILES (64,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK38900(BEF )01/95] *[BK39000(BEF )01/95] *[BK39100(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK39200(BEF )05/94] *[BK39500(B F )08/94] *[BK39600(B F )04/93]

❑ Rotate tires and adjust air pressure. (1)(2) ❑ Check clutch reservoir fluid level. ❑ Lubricate transfer case shift lever pivot bolt

*[BK39700(BEF )04/93]

❑ Inspect and lubricate automatic transmission

*[BK39825(BEF )04/94]

❑ Lubricate steering linkage suspension,

*[BK39850(BEF )04/94]

❑ Change fuel filter (Recommended but not

*[BK40000(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK40100(BEF )04/94] *[BK40200(BEF )05/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect exhaust system for leaks, damage or

45,000 MILES (72,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

and control rod connecting pins (4x4). shift linkage.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). required for California Certified Vehicles). slide rails.

loose parts. Remove any foreign material trapped by exhaust system shielding.

Normal Schedule 13

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK40250(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK40450(BEF )04/93] four pica chart:0060627-A

*[BK40500(BEF )01/95] *[BK40600(BEF )01/95] *[BK40700(BEF )06/94]

50,000 MILES (80,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Change engine coolant initially at 50,000 miles

(80,000 km) or 48 months. Thereafter, change engine coolant every 30,000 miles (48,000 km) or 36 months (Gasoline engines only).

*[BK40900(BEF )04/93] four pica chart:0060627-A

*[BK41300(BEF )01/95] *[BK41400(BEF )01/95] *[BK41500(BEF )05/94] *[BK41800(BEF )04/93]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Inspect and lubricate automatic transmission

*[BK41950(BEF )04/94]

❑ Lubricate steering linkage suspension,

*[BK42000(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

55,000 MILES (88,000 Kilometers)

shift linkage.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

14 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK42025(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK42050(BEF )04/93] four pica chart:0060627-A

*[BK42100(BEF )01/95] *[BK42200(BEF )01/95] *[BK42250(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK42300(BEF )04/95] *[BK42500(BEF )03/94]

❑ Replace spark plugs (Gasoline engines only). ❑ Replace air cleaner filter every 30,000 miles

*[BK42600(BEF )03/94]

❑ Replace crankcase emission air filter. If operating

*[BK42700(BEF )05/94] *[BK42900(BEF )06/94]

❑ Replace PCV valve. (3) ❑ Check thermactor hoses and clamps.

*[BK43100(BEF )05/93] *[BK43600(B F )04/93]

❑ Inspect accessory drive belt condition. ❑ Lubricate transfer case shift lever pivot bolt

*[BK43625(BEF )01/95]

❑ Change automatic transmission fluid.

60,000 MILES (96,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

(48,000 km) or 30 months. If operating in dusty conditions, consult your dealer and/or follow severe duty maintenance schedule. in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.)

(Recommended, not required.)

and control rod connecting pins (4x4).

Normal Schedule 15

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK43626(BEF )03/94] *[BK43850(BEF )04/94]

NOTE: Except C6 and E4OD transmissions.

*[BK44000(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK44100(BEF )04/94] *[BK44200(BEF )05/94] *[BK44700(BEF )04/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect and lubricate front wheel bearings. ❑ Inspect parking brake system for damage and

*[BK44900(BEF )05/93]

❑ Lubricate throttle kickdown or TV lever ball

*[BK45000(B F )04/93]

❑ Inspect and lubricate spindle needle bearings

*[BK45100(B F )04/93] *[BK45200(B F )04/93] *[BK45250(B F )04/93]

❑ Inspect and lubricate hub locks (4x4). ❑ Change transfer case oil (4x4). ❑ Lubricate front axle R.H. axle shaft slip yoke

*[BK45300(B F )04/93] *[BK45450(BEF )04/93]

❑ Change manual transmission oil.

❑ Change fuel filter (Recommended but not

required for California Certified Vehicles). slide rails.

operation. studs. (4x4).

(4x4).

four pica chart:0060627-A

16 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK45500(BEF )01/95] *[BK45600(BEF )01/95] *[BK45625(BEF )05/94] *[BK45635(BEF )04/94]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Lubricate steering linkage suspension,

*[BK45655(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK45660(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK45665(BEF )04/93]

❑ Inspect and lubricate automatic transmission

*[BK45675(B F )08/94] *[BK45690(BEF )07/93]

❑ Check clutch reservoir fluid level.

65,000 MILES (104,000 Kilometers)

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

shift linkage.

four pica chart:0060627-A

*[BK45700(BEF )01/95] *[BK45800(BEF )01/95] *[BK45850(BEF )04/93]

70,000 MILES (112,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

Normal Schedule 17

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK45900(BEF )01/95] *[BK46000(BEF )01/95] *[BK46005(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK46007(BEF )05/94] *[BK46010(BEF )04/94]

❑ Rotate tires and adjust air pressure. (1)(2) ❑ Lubricate steering linkage suspension,

*[BK46030(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK46035(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK46040(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK46055(BEF )04/94] *[BK46065(BEF )04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

*[BK46075(BEF )04/93]

❑ Inspect and lubricate automatic transmission

*[BK46080(B F )08/94] *[BK46085(B F )04/93]

❑ Check clutch reservoir fluid level. ❑ Lubricate transfer case shift lever pivot bolt

75,000 MILES (120,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

slide rails.

required for California Certified Vehicles). shift linkage.

and control rod connecting pins (4x4).

*[BK46097(BEF )04/93] four pica chart:0060627-A

18 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK46100(BEF )01/95] *[BK46200(BEF )01/95] *[BK46225(BEF )06/94]

80,000 MILES (128,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Change coolant every 30,000 miles (48,000

km) or

36 months.

*[BK46280(BEF )04/93] four pica chart:0060627-A

*[BK46300(BEF )01/95] *[BK46400(BEF )01/95] *[BK46405(BEF )05/94] *[BK46410(BEF )04/94]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Lubricate steering linkage suspension,

*[BK46430(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK46435(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK46440(BEF )04/93]

❑ Inspect and lubricate automatic transmission

*[BK46451(B F )08/94] *[BK46475(BEF )04/93]

❑ Check clutch reservoir fluid level.

85,000 MILES (136,000 Kilometers)

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

shift linkage.

four pica chart:0060627-A

Normal Schedule 19

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK46500(BEF )01/95] *[BK46600(BEF )01/95] *[BK46850(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK46900(BEF )03/94]

❑ Replace air cleaner filter every 30,000 miles

*[BK47000(BEF )03/94]

❑ Replace crankcase emission air filter. If operating

*[BK47015(BEF )05/93] *[BK47025(BEF )04/94]

❑ Inspect accessory drive belt condition. ❑ Change fuel filter (Recommended but not

*[BK47030(BEF )04/93]

❑ Inspect parking brake system for damage and

*[BK47035(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK47040(BEF )04/94] *[BK47045(BEF )05/94] *[BK47051(BEF )05/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect and lubricate front wheel bearings. ❑ Lubricate throttle kickdown or TV lever ball

*[BK47055(B F )04/93] *[BK47060(B F )04/93]

❑ Inspect and lubricate hub locks (4x4). ❑ Inspect and lubricate spindle needle bearings

*[BK47065(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK47067(BEF )01/95]

❑ Change automatic transmission fluid.

90,000 MILES (144,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

(48,000 km) or 30 months. If operating in dusty conditions, consult your dealer and/or follow severe duty maintenance schedule. in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.)

required for California Certified Vehicles). operation.

slide rails.

studs.

(4x4).

and control rod connecting pins (4x4).

20 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK47068(BEF )03/94] *[BK47080(B F )04/93]

NOTE: Except C6 and E4OD transmissions.

❑ Lubricate front axle R.H. axle shaft slip yoke (4x4).

*[BK47090(BEF )04/93] four pica chart:0060627-A

*[BK47100(BEF )01/95] *[BK47200(BEF )01/95] *[BK47210(BEF )05/94] *[BK47220(BEF )04/94]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Lubricate steering linkage suspension,

*[BK47240(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK47245(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK47251(BEF )04/93]

❑ Inspect and lubricate automatic transmission

*[BK47260(B F )08/94] *[BK47280(BEF )04/93]

❑ Check clutch reservoir fluid level.

95,000 MILES (152,000 Kilometers)

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

shift linkage.

four pica chart:0060627-A

Normal Schedule 21

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK47300(BEF )01/95] *[BK47400(BEF )01/95] *[BK47500(BEF )05/93]

100,000 MILES (160,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ All rear axle lube quantities must be replaced every 100,000 miles (160,000 axle has been submerged in Otherwise, the lube should or changed unless a leak is repair required.

km) or if the water. not be checked suspected or

*[BK47550(BEF )04/93] four pica chart:0060627-A

*[BK47600(BEF )01/95] *[BK47700(BEF )01/95] *[BK47705(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK47707(BEF )05/94] *[BK47710(BEF )04/94]

❑ Rotate tires and adjust air pressure. (1)(2) ❑ Lubricate steering linkage suspension,

*[BK47725(BEF )04/94]

❑ Change fuel filter (Recommended but not

*[BK47730(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK47735(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

105,000 MILES (168,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). required for California Certified Vehicles). loose parts. Remove any foreign material trapped by exhaust system shielding.

22 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK47740(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK47751(BEF )04/94] *[BK47770(BEF )04/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect and lubricate automatic transmission

*[BK47775(B F )08/94] *[BK47780(B F )04/93]

❑ Check clutch reservoir fluid level. ❑ Lubricate transfer case shift lever pivot bolt

slide rails.

shift linkage.

and control rod connecting pins (4x4).

*[BK47795(BEF )04/93] four pica chart:0060627-A

*[BK47800(BEF )01/95] *[BK47900(BEF )01/95] *[BK47925(BEF )06/94]

110,000 MILES (176,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Change coolant every 30,000 miles (48,000

km) or

36 months.

*[BK47980(BEF )04/93] four pica chart:0060627-A

*[BK48000(BEF )01/95] *[BK48100(BEF )01/95] *[BK48105(BEF )05/94] *[BK48110(BEF )04/94]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (1)(2) ❑ Lubricate steering linkage suspension,

*[BK48130(BEF )05/93]

❑ Inspect exhaust system for leaks, damage or

115,000 MILES (184,000 Kilometers)

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). loose parts. Remove any foreign material trapped by exhaust system shielding.

Normal Schedule 23

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK48135(BEF )05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK48140(BEF )04/93]

❑ Inspect and lubricate automatic transmission

*[BK48151(B F )08/94] *[BK48175(BEF )04/93]

❑ Check clutch reservoir fluid level.

shift linkage.

four pica chart:0060627-A

*[BK48200(BEF )01/95] *[BK48300(BEF )01/95] *[BK48400(BEF )05/93] *[BK48425(BEF )05/93] *[BK48550(BEF )01/95]

❑ Change engine oil and replace oil filter. ❑ Replace spark plugs (Gasoline engines only). ❑ Inspect accessory drive belt condition. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK48600(BEF )06/94]

❑ Replace air cleaner filter every 30,000 miles

*[BK48700(BEF )03/94]

❑ Replace crankcase emission air filter. If operating

*[BK48800(BEF )01/95] *[BK49000(BEF )06/94]

❑ Replace PCV valve. ❑ Check thermactor hoses and clamps.

120,000 MILES (192,000 Kilometers)

and check coolant strength every 15,000 miles (24,000 km) or 12 months.

(48,000 km) or 30 months. If operating in dusty conditions, consult your dealer and/or follow severe duty maintenance schedule. in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.)

(Recommended, not required.)

24 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK49010(BEF )04/93]

❑ Inspect parking brake system for damage and

*[BK49020(BEF )04/94]

❑ Inspect disc brake system, lubricate caliper

*[BK49030(BEF )04/94] *[BK49040(BEF )05/94] *[BK49051(BEF )05/93]

❑ Inspect drum brake systems, hoses and lines. ❑ Inspect and lubricate front wheel bearings. ❑ Lubricate throttle kickdown or TV lever ball

*[BK49055(B F )04/93] *[BK49060(B F )04/93]

❑ Inspect and lubricate hub locks (4x4). ❑ Inspect and lubricate spindle needle bearings

*[BK49065(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK49067(BEF )01/95] *[BK49068(BEF )03/94] *[BK49080(B F )04/93] *[BK49085(B F )04/93] *[BK49090(B F )04/93]

❑ Change automatic transmission fluid.

*[BK49125(BEF )04/94]

operation.

slide rails.

studs.

(4x4).

and control rod connecting pins (4x4).

NOTE: Except C6 and E4OD transmissions.

❑ Change manual transmission oil. ❑ Change transfer case oil (4x4). ❑ Lubricate front axle R.H. axle shaft slip yoke (4x4).

❑ Change fuel filter (Recommended but not

required for California Certified Vehicles).

*[BK49175(BEF )04/93] four pica chart:0060627-A

Normal Schedule 25

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK49201(BEF )03/94]

(1) Wheel lug nuts must be retightened to proper torque specifications at 500 miles/800 km of new vehicle operation (100 miles/160 km and 500 miles/800 km for vehicles equipped with dual rear wheels or equipped for snowplowing). Proper torque specifications are provided in your Owner Guide. Also retighten to proper torque specification at 500 miles/800 km after (1) any wheel change or (2) any other time the wheel lug nuts have been loosened.

*[BK49425(BEF )05/94]

(3) At 60,000 miles (96,000 km) your dealer will replace the PCV valve at no cost except on Canada and California vehicles.

26 Normal Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

Severe Duty Schedule *[BK49700( ALL)01/95]

NOTE: Items for Emission Control Service are shown in this type and style.

*[BK49800( ALL)01/95]

For items marked with a number in parentheses such as (1), see footnote at the end of this section.

*[BK49900( ALL)05/93]

NOTE: The Severe Duty Schedule provides maintenance intervals for replacing your air cleaner filter if you drive in severe dust conditions. However, the conditions you drive in may require even more frequent air cleaner replacement intervals than those shown. Check with your dealer. NOTE: Rear axle lube quantities must be replaced every 99,000 miles (165,000 km) or if the axle has been submerged in water. Otherwise, the lube should not be checked or changed unless a leak is suspected or repair required.

*[BK50050( ALL)01/95]

Maintenance Intervals for Severe Duty Schedule

Severe Duty Schedule 27

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK50100( ALL)01/95] *[BK50200( ALL)01/95] *[BK50450( ALL)04/93]

3,000 MILES (5,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK50501( ALL)01/95] *[BK50601( ALL)01/95] *[BK50650( ALL)94/93] *[BK50701(B F )08/94] *[BK50801( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK50901( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK50910( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK51001( ALL)08/94]

❑ Lubricate steering linkage suspension,

6,000 MILES (10,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK51150( ALL)04/93] four pica chart:0060627-A

28 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK51201( ALL)01/95] *[BK51301( ALL)01/95] *[BK51350( ALL)04/93]

9,000 MILES (15,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK51401( ALL)01/95] *[BK51501( ALL)01/95] *[BK51901(B F )08/94] *[BK52001( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK52101( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK52110( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

12,000 MILES (20,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

*[BK52350( ALL)04/93] four pica chart:0060627-A

*[BK52401( ALL)01/95] *[BK52501( ALL)01/95] *[BK52550( ALL)05/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK52601( ALL)94/93]

❑ Rotate tires and adjust air pressure. (3)(5)(6)

15,000 MILES (25,000 Kilometers)

and check coolant strength every 15,000 miles (25,000 km) or 12 months.

Severe Duty Schedule 29

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK52701(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK52801( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK52901( ALL)04/94] *[BK53001( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

and control rod connecting pins (4x4). caliper slide rails. (2)

required for California Certified Vehicles).

*[BK53050( ALL)04/93] four pica chart:0060627-A

*[BK53101( ALL)01/95] *[BK53201( ALL)01/95] *[BK53301(B F )08/94] *[BK53501( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK53601( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK53610( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK53801( ALL)08/94]

❑ Lubricate steering linkage suspension,

18,000 MILES (30,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK54050( ALL)04/93] four pica chart:0060627-A

30 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK54101( ALL)01/95] *[BK54201( ALL)01/95] *[BK54225( ALL)01/95] *[BK54250( ALL)04/93]

21,000 MILES (35,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Change automatic transmission fluid.

four pica chart:0060627-A

*[BK54301( ALL)01/95] *[BK54401( ALL)01/95] *[BK54501( ALL)94/93] *[BK54801( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Inspect and lubricate automatic transmission

*[BK54901( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK54910( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK55101( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK55301( ALL)05/93]

❑ Lubricate throttle kickdown or TV lever ball

24,000 MILES (40,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) studs.

*[BK55350( ALL)04/93] four pica chart:0060627-A

Severe Duty Schedule 31

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK55401( ALL)01/95] *[BK55501( ALL)01/95] *[BK55550( ALL)04/93]

27,000 MILES (45,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK55601( ALL)01/95] *[BK55701( ALL)01/95] *[BK55800( ALL)05/94]

❑ Change engine oil and replace oil filter. ❑ Replace air cleaner filter every 30,000 miles

*[BK55950( ALL)05/95]

❑ Inspect engine cooling system, hoses, and clamps;

*[BK55985( ALL)04/93]

❑ Replace crankcase emission air filter. If operating

*[BK56100(B F )08/94] *[BK56200( ALL)04/93]

❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK56300( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK56350( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

30,000 MILES (50,000 Kilometers)

(50,000 km) or 30 months. If operating in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (1) and check coolant strength every 15,000 miles (25,000 km) or 12 months.

in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.) (1)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

32 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK56400( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK56600(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK56700( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK56800( ALL)04/94] *[BK56900( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

*[BK57000( ALL)05/93] *[BK57100( ALL)04/93]

❑ Inspect and lubricate front wheel bearings. (2) ❑ Inspect parking brake system for damage and

*[BK57200(B F )04/93] *[BK57300(B F )04/93]

❑ Change manual transmission oil. ❑ Lubricate front axle R.H. axle shaft slip yoke

*[BK57400(B F )04/93]

❑ Inspect and lubricate spindle needle bearings

*[BK57500(B F )04/93] *[BK57550( ALL)04/93]

❑ Inspect and lubricate hub locks (4x4).

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) and control rod connecting pins (4x4). caliper slide rails. (2)

required for California Certified Vehicles).

operation.

(4x4). (4x4).

four pica chart:0060627-A

*[BK57600( ALL)01/95] *[BK57700( ALL)01/95] *[BK57750( ALL)94/93] *[BK58050( ALL)04/93]

33,000 MILES (55,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6)

four pica chart:0060627-A

Severe Duty Schedule 33

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK58100( ALL)01/95] *[BK58200( ALL)01/95] *[BK58600(B F )08/94] *[BK58700( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK58800( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK58850( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK58900( ALL)08/94]

❑ Lubricate steering linkage suspension,

36,000 MILES (60,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK59050( ALL)04/93] four pica chart:0060627-A

*[BK59100( ALL)01/95] *[BK59200( ALL)01/95] *[BK59250( ALL)04/93]

39,000 MILES (65,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

34 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK59300( ALL)01/95] *[BK59400( ALL)01/95] *[BK59425( ALL)01/95] *[BK59450( ALL)94/93] *[BK59500(B F )08/94] *[BK59600( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Change automatic transmission fluid. ❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK59700( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK59750( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK59800( ALL)08/94]

❑ Lubricate steering linkage suspension,

42,000 MILES (70,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK59950( ALL)04/93] four pica chart:0060627-A

Severe Duty Schedule 35

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK60000( ALL)01/95] *[BK60100( ALL)01/95] *[BK60150( ALL)05/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK60300(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK60400( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK60500( ALL)04/94] *[BK60600( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

45,000 MILES (75,000 Kilometers)

and check coolant strength every 15,000 miles (25,000 km) or 12 months. and control rod connecting pins (4x4). caliper slide rails. (2)

required for California Certified Vehicles).

*[BK60650( ALL)04/93] four pica chart:0060627-A

*[BK60700( ALL)01/95] *[BK60800( ALL)01/95] *[BK60900( ALL)01/95]

❑ Change engine oil and replace oil filter. ❑ Change engine coolant initially at 48,000 miles

*[BK61200(B F )08/94] *[BK61300( ALL)04/93]

❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK61400( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

48,000 MILES (80,000 Kilometers)

(80,000 km) or 48 months. Thereafter, change engine coolant every 30,000 miles (50,000 km) or 36 months.

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

36 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK61450( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK61500( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK61800( ALL)05/93]

❑ Lubricate throttle kickdown or TV lever ball

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) studs.

*[BK62150( ALL)04/93] four pica chart:0060627-A

*[BK62200( ALL)01/95] *[BK62300( ALL)01/95] *[BK62340( ALL)94/93] *[BK62350( ALL)04/93]

51,000 MILES (85,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6)

four pica chart:0060627-A

*[BK62400( ALL)01/95] *[BK62500( ALL)01/95] *[BK62600(B F )08/94] *[BK62700( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK62800( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

54,000 MILES (90,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

Severe Duty Schedule 37

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK62850( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK62900( ALL)08/94]

❑ Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK63050( ALL)04/93] four pica chart:0060627-A

*[BK63100( ALL)01/95] *[BK63200( ALL)01/95] *[BK63250( ALL)04/93]

57,000 MILES (95,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK63300( ALL)01/95] *[BK63400( ALL)01/95] *[BK63500( ALL)05/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK63700( ALL)05/94]

❑ Replace air cleaner filter every 30,000 miles

*[BK63800( ALL)04/93]

❑ Replace crankcase emission air filter. If operating

60,000 MILES (100,000 Kilometers)

and check coolant strength every 15,000 miles (25,000 km) or 12 months.

(50,000 km) or 30 months. If operating in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (1) in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (1)

38 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK63900( ALL)05/94] *[BK64000( ALL)06/94]

❑ Replace PCV valve. (7) ❑ Check thermactor hoses and clamps.

*[BK64100( ALL)05/95] *[BK64125( ALL)04/95] *[BK64200( ALL)94/93] *[BK64300(B F )08/94] *[BK64400( ALL)04/93]

❑ Inspect accessory drive belt(s). ❑ Replace spark plugs (Gasoline engines only). ❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK64500( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK64550( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK64600( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK64800(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK64900( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK65000( ALL)04/94] *[BK65100( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

*[BK65400( ALL)05/93] *[BK65500( ALL)04/93]

❑ Inspect and lubricate front wheel bearings. (2) ❑ Inspect parking brake system for damage and

(Recommended, not required.)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) and control rod connecting pins (4x4). caliper slide rails. (2)

required for California Certified Vehicles).

operation.

Severe Duty Schedule 39

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK65600(B F )04/93]

❑ Lubricate front axle R.H. axle shaft slip yoke

*[BK65700(B F )04/93] *[BK65800(B F )04/93] F )04/93] *[BK65900(B *[BK66000(B F )04/93] *[BK66050( ALL)04/93]

❑ Inspect and lubricate spindle needle bearings

(4x4).

(4x4). ❑ Inspect and lubricate hub locks (4x4).

❑ Change transfer case oil (4x4). ❑ Change manual transmission oil.

four pica chart:0060627-A

*[BK66100( ALL)01/95] ALL)01/95] *[BK66200( *[BK66350( ALL)01/95] *[BK66550( ALL)04/93]

63,000 MILES (105,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Change automatic transmission fluid.

four pica chart:0060627-A

*[BK66600( ALL)01/95] ALL)01/95] *[BK66700( F )08/94] *[BK66800(B [BK66900( ALL)04/93] * *[BK67000( ALL)05/93] *[BK67050( ALL)05/94]

66,000 MILES (110,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission shift linkage. ❑ Inspect exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust system shielding. NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler. 40 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK67100( ALL)08/94]

❑ Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK67250( ALL)04/93] four pica chart:0060627-A

*[BK67300( ALL)01/95] *[BK67400( ALL)01/95] *[BK67445( ALL)94/93] *[BK67450( ALL)04/93]

69,000 MILES (115,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6)

four pica chart:0060627-A

*[BK67500( ALL)01/95] *[BK67600( ALL)01/95] *[BK68000(B F )08/94] *[BK68100( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK68200( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK68250( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

72,000 MILES (120,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

Severe Duty Schedule 41

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK68300( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK68600( ALL)05/93]

❑ Lubricate throttle kickdown or TV lever ball

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) studs.

*[BK68650( ALL)04/93] four pica chart:0060627-A

*[BK68700( ALL)01/95] *[BK68800( ALL)01/95] *[BK68850( ALL)05/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK69000(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK69100( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK69200( ALL)04/94] *[BK69300( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

75,000 MILES (125,000 Kilometers)

and check coolant strength every 15,000 miles (25,000 km) or 12 months. and control rod connecting pins (4x4). caliper slide rails. (2)

required for California Certified Vehicles).

*[BK69350( ALL)04/93] four pica chart:0060627-A

42 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK69400( ALL)01/95] *[BK69500( ALL)01/95] *[BK69525( ALL)02/95]

❑ Change engine oil and replace oil filter. ❑ Change engine coolant every 30,000 miles

*[BK69550( ALL)94/93] *[BK69600(B F )08/94] *[BK69700( ALL)04/93]

❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK69800( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK69850( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK69900( ALL)08/94]

❑ Lubricate steering linkage suspension,

78,000 MILES (130,000 Kilometers)

(50,000 km) or 36 months.

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK70350( ALL)06/93] four pica chart:0060627-A

*[BK70400( ALL)01/95] *[BK70500( ALL)01/95] *[BK70550( ALL)04/93]

81,000 MILES (135,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

Severe Duty Schedule 43

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK70600( ALL)01/95] *[BK70700( ALL)01/95] *[BK71100(B F )08/94] *[BK71150( ALL)01/95] *[BK71200( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Change automatic transmission fluid. ❑ Inspect and lubricate automatic transmission

*[BK71300( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK71350( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK71400( ALL)08/94]

❑ Lubricate steering linkage suspension,

84,000 MILES (140,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK71550( ALL)04/93] four pica chart:0060627-A

*[BK71600( ALL)01/95] *[BK71700( ALL)01/95] *[BK71740( ALL)94/93] *[BK71750( ALL)04/93]

87,000 MILES (145,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6)

four pica chart:0060627-A

44 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK71800( ALL)01/95] *[BK71900( ALL)01/95] *[BK72000( ALL)05/94]

❑ Change engine oil and replace oil filter. ❑ Replace air cleaner filter every 30,000 miles

*[BK72150( ALL)05/95]

❑ Inspect engine cooling system, hoses, and clamps;

*[BK72175( ALL)05/95] *[BK72195( ALL)04/93]

❑ Inspect accessory drive belt(s). ❑ Replace crankcase emission air filter. If operating

*[BK72300(B F )08/94] *[BK72400( ALL)04/93]

❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK72500( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK72550( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK72600( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK72800( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK72900( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines.

90,000 MILES (150,000 Kilometers)

(50,000 km) or 30 months. If operating in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (1) and check coolant strength every 15,000 miles (25,000 km) or 12 months.

in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.) (1)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) caliper slide rails. (2)

Severe Duty Schedule 45

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK73000( ALL)04/94]

❑ Change fuel filter (Recommended but not

*[BK73100( ALL)05/93] *[BK73200( ALL)04/93]

❑ Inspect and lubricate front wheel bearings. (2) ❑ Inspect parking brake system for damage and

*[BK73300(B F )04/93] *[BK73400(B F )04/93]

❑ Change manual transmission oil. ❑ Lubricate transfer case shift lever pivot bolt

*[BK73500(B F )04/93]

❑ Lubricate front axle R.H. axle shaft slip yoke

*[BK73600(B F )04/93]

❑ Inspect and lubricate spindle needle bearings

*[BK73700(B F )04/93] *[BK73750( ALL)04/93]

❑ Inspect and lubricate hub locks (4x4).

required for California Certified Vehicles).

operation.

and control rod connecting pins (4x4). (4x4). (4x4).

four pica chart:0060627-A

*[BK73800( ALL)01/95] *[BK73900( ALL)01/95] *[BK74250( ALL)04/93]

93,000 MILES (155,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK74300( ALL)01/95] *[BK74400( ALL)01/95] *[BK74500( ALL)94/93] *[BK74800(B F )08/94] *[BK74900( ALL)04/93]

96,000 MILES (160,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission shift linkage.

46 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK75000( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK75050( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK75100( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK75300( ALL)05/93]

❑ Lubricate throttle kickdown or TV lever ball

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) studs.

*[BK75450( ALL)04/93] four pica chart:0060627-A

*[BK75500( ALL)01/95] *[BK75600( ALL)01/95] *[BK75700( ALL)06/94] *[BK75750( ALL)04/93]

99,000 MILES (165,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Replace rear axle lube.

four pica chart:0060627-A

*[BK75800( ALL)01/95] *[BK75900( ALL)01/95] *[BK76000(B F )08/94] *[BK76100( ALL)04/93]

102,000 MILES (170,000 Kilometers)

❑ Change engine oil and replace oil filter. ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission shift linkage.

Severe Duty Schedule 47

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK76200( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK76250( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK76300( ALL)08/94]

❑ Lubricate steering linkage suspension,

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK76450( ALL)04/93] four pica chart:0060627-A

*[BK76500( ALL)01/95] *[BK76600( ALL)01/95] *[BK76650( ALL)05/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK76700( ALL)94/93] *[BK76750( ALL)01/95] *[BK76800(B F )04/93]

❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Change automatic transmission fluid. ❑ Lubricate transfer case shift lever pivot bolt

*[BK76900( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK77000( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines.

105,000 MILES (175,000 Kilometers)

and check coolant strength every 15,000 miles (25,000 km) or 12 months.

and control rod connecting pins (4x4). caliper slide rails. (2)

48 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK77100( ALL)04/94]

❑ Change fuel filter (Recommended but not

required for California Certified Vehicles).

*[BK77150( ALL)04/93] four pica chart:0060627-A

*[BK77200( ALL)01/95] *[BK77300( ALL)01/95] *[BK77400( ALL)02/95]

❑ Change engine oil and replace oil filter. ❑ Change engine coolant every 30,000 miles

*[BK77700(B F )08/94] *[BK77800( ALL)04/93]

❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK77900( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK77950( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK78000( ALL)08/94]

❑ Lubricate steering linkage suspension,

108,000 MILES (180,000 Kilometers)

(50,000 km) or 36 months.

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK78450( ALL)04/93] four pica chart:0060627-A

Severe Duty Schedule 49

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK78500( ALL)01/95] *[BK78600( ALL)01/95] *[BK78650( ALL)04/93]

111,000 MILES (185,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK78700( ALL)01/95] *[BK78800( ALL)01/95] *[BK78850( ALL)94/93] *[BK78900(B F )08/94] *[BK79000( ALL)04/93]

❑ Change engine oil and replace oil filter. ❑ Rotate tires and adjust air pressure. (3)(5)(6) ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK79100( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

*[BK79150( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK79200( ALL)08/94]

❑ Lubricate steering linkage suspension,

114,000 MILES (190,000 Kilometers)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2)

*[BK79350( ALL)04/93] four pica chart:0060627-A

50 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK79400( ALL)01/95] *[BK79500( ALL)01/95] *[BK79550( ALL)04/93]

117,000 MILES (195,000 Kilometers)

❑ Change engine oil and replace oil filter.

four pica chart:0060627-A

*[BK79600( ALL)01/95] *[BK79700( ALL)01/95] *[BK79800( ALL)05/95]

❑ Change engine oil and replace oil filter. ❑ Inspect engine cooling system, hoses, and clamps;

*[BK79900( ALL)05/94]

❑ Replace air cleaner filter every 30,000 miles

*[BK80100( ALL)04/95] *[BK80300( ALL)04/93]

❑ Replace spark plugs (Gasoline engines only). ❑ Replace crankcase emission air filter. If operating

*[BK80400( ALL)05/95] *[BK80500( ALL)06/94]

❑ Replace PCV valve. ❑ Check thermactor hoses and clamps.

*[BK80600( ALL)05/95] *[BK80800(B F )08/94] *[BK81000( ALL)04/93]

❑ Inspect accessory drive belt(s). ❑ Check clutch reservoir fluid level. ❑ Inspect and lubricate automatic transmission

*[BK81100( ALL)05/93]

❑ Inspect exhaust system for leaks, damage or

120,000 MILES (200,000 Kilometers)

and check coolant strength every 15,000 miles (25,000 km) or 12 months.

(50,000 km) or 30 months. If operating in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (1)

in dusty conditions consult your dealer and/or follow severe duty maintenance schedule. (4.9L, 5.0L man. trans., and 7.5L only.) (1)

(Recommended, not required.)

shift linkage.

loose parts. Remove any foreign material trapped by exhaust system shielding.

Severe Duty Schedule 51

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK81150( ALL)05/94]

NOTE: It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.

*[BK81200( ALL)08/94]

❑ Lubricate steering linkage suspension,

*[BK81400( ALL)05/93]

❑ Lubricate throttle kickdown or TV lever ball

*[BK81500(B F )04/93]

❑ Lubricate transfer case shift lever pivot bolt

*[BK81600( ALL)05/93]

❑ Inspect disc brake system and lubricate

*[BK81700( ALL)04/94] *[BK81800( ALL)04/94]

❑ Inspect drum brake systems, hoses and lines. ❑ Change fuel filter (Recommended but not

*[BK81900( ALL)05/93] *[BK82000( ALL)04/93]

❑ Inspect and lubricate front wheel bearings. (2) ❑ Inspect parking brake system for damage and

*[BK82100(B F )04/93]

❑ Lubricate front axle R.H. axle shaft slip yoke

*[BK82200(B F )04/93]

❑ Inspect and lubricate spindle needle bearings

*[BK82300(B F )04/93] *[BK82400(B F )04/93]

❑ Inspect and lubricate hub locks (4x4). ❑ Change transfer case oil (4x4).

driveshaft U-joint if equipped with grease fittings and lubricate slip yoke (if equipped). (2) studs.

and control rod connecting pins (4x4). caliper slide rails. (2)

required for California Certified Vehicles).

operation. (4x4). (4x4).

52 Severe Duty Schedule

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK82500(B F )04/93] *[BK82505( ALL)04/93]

❑ Change manual transmission oil.

four pica chart:0060627-A

*[BK82510( ALL)05/93]

(1) Extremely dusty conditions will require more frequent replacement of your air filter. check your air filter at 3,000 miles. If it is dirty replace it and then keep replacing it at the same interval (every 3,000 miles). If it’s not dirty, check it again at 6,000 miles and again at 9,000 miles until you determine your unique maintenance interval. Do not go beyond 30,000 miles as described in the chart. If in doubt, see your dealer.

*[BK82520( ALL)05/93]

(2) If you operate your vehicle “off road” in water that is deeper than the hubs (1/2 wheel height) then these items must be serviced daily.

*[BK82530( ALL)05/93]

(3) City delivery vehicles and other unique applications that require constant turning may need more frequent tire rotation. You may need to develop your own tire rotation interval based on your own observations of tire wear. If in doubt, see your dealer.

*[BK82550( ALL)03/94]

(5) Wheel lug nuts must be retightened to proper torque specifications at 500 miles/800 km of new vehicle operation (100 miles/160 km and 500 miles/800 km for vehicles equipped with dual rear wheels or equipped for snowplowing). Proper torque specifications are provided in your Owner Guide. Also retighten to proper torque specification at 500 miles/800 km after (1) any wheel change or (2) any other time the wheel lug nuts have been loosened.

*[BK82560( ALL)05/94]

(6) On dual rear wheel light trucks, rotate the front tires side-to-side without disturbing the rear tires.

*[BK82575( ALL)05/94]

(7) At 60,000 miles (96,000 km) your dealer will replace the PCV valve at no cost except on Canada and California vehicles.

Severe Duty Schedule 53

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

Owner Maintenance Checks *[BK82700( ALL)04/93]

The following lists are vehicle checks and inspections that should be performed by the owner or qualified service technician at the frequencies indicated to help ensure safe, dependable operation of your vehicle.

*[BK82800( ALL)01/95]

Any adverse conditions should be brought to the attention of your dealer or qualified service technician for service advice as soon as possible.

*[BK82900( ALL)01/95]

These Owner Maintenance Checks are generally not covered by warranties and you may be charged for labor, parts and lubricants used.

*[BK83000( ALL)01/95] *[BK83100( ALL)01/95]

When You Stop for Fuel:

❑ Check the engine oil level. ❑ Check coolant level in the coolant recovery reservoir.

*[BK83200( ALL)01/95] *[BK83300( ALL)01/95] *[BK83400( ALL)01/95] *[BK83500( ALL)01/95]

❑ Check the windshield washer fluid level. ❑ Look for low or under-inflated tires.

*[BK83600( ALL)04/93]

❑ Check for vibrations in the steering wheel.

*[BK83700( ALL)04/93]

❑ Notice if your vehicle constantly turns

While Operating Your Vehicle:

❑ Note any changes in the sound of the exhaust or any smell of exhaust fumes in the vehicle. Notice any increased steering effort or looseness in the steering wheel, or change in its straight ahead position. slightly or “pulls” to one side when traveling on smooth, level road.

54 Owner Maintenance Checks

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK83800( ALL)01/95]

❑ When stopping, listen and check for strange

*[BK83900( ALL)04/93]

❑ If any slipping or changes in the operation of

*[BK84000( ALL)04/93]

❑ Check automatic transmission P (Park)

*[BK84100( ALL)04/93] *[BK84200(B F )04/93]

❑ Check parking brake. ❑ Verify proper “Brake” and “AntiLock” bulb

sounds, pulling to one side, increased brake pedal travel or “hard to push” brake pedal. your transmission occur, check the transmission fluid level. function.

check response when starting vehicle.

*[BK84400( ALL)01/95] *[BK84600( ALL)01/95]

❑ Check coolant level in the coolant recovery

*[BK84700( ALL)04/93]

❑ Check the operation of all exterior lamps,

*[BK84800( ALL)04/93]

❑ Check for fluid leaks by inspecting the

*[BK84900( ALL)01/95] *[BK85000( ALL)04/93]

At least monthly: reservoir.

including the brakelamps, turn signals and hazard warning flashers. surface beneath your vehicle for oil, coolant, or other fluid drips. Clean water from the air conditioning system is normal. At least twice a year: (i.e., every Spring and Fall)

❑ Check power steering fluid level. ❑ Check windshield washer spray and wiper operation. Clean wiper blades with clean cloth dampened with washer fluid.

*[BK85100(B F )04/93] *[BK85200( ALL)01/95]

❑ Check fluid level in clutch master cylinder. ❑ Check radiator, heater and air-conditioning

*[BK85300( ALL)04/93]

❑ Check for worn tires and loose wheel lugnuts.

hoses for leaks or damage.

Owner Maintenance Checks 55

File:ltbkb.ex Update:Fri Jun 16 11:12:59 1995

*[BK85400( ALL)04/93] *[BK85500( ALL)04/93] *[BK85600( ALL)04/93] *[BK85900( ALL)04/93] *[BK86000( ALL)01/95] *[BK86100(BEF )04/93]

❑ Clean body and door drain holes. ❑ Flush complete underside of vehicle. ❑ Inspect underbody components for damage. ❑ Check parking brake system. ❑ Check headlamp alignment. ❑ Check lap-shoulder belts for wear and

*[BK86200( ALL)04/93] *[BK86300( ALL)01/95] *[BK86400( ALL)01/95] *[BK86700(B F )04/93]

❑ Inspect seatback latches for proper operation. ❑ Check air pressure in spare tire.

*[BK86900(B F )04/93]

❑ Lubricate door, hood and tailgate hinge locks

*[BK87000( ALL)01/95] *[BK87200( ALL)04/93]

❑ Lubricate door rubber weatherstrips. ❑ Clean battery and terminals, check electrolyte

*[BK87300( ALL)01/95]

If any of these conditions are noted, bring them to the attention of your dealer or qualified service technician as soon as possible.

function.

At least once a year:

❑ Lubricate door, hood, and tailgate hinges and checks.

and latches.

level on low maintenance (auxiliary and replacement) batteries.

56 Owner Maintenance Checks