Pioneer_avh-x1600dvd_x1650dvd_x1690dvd_crt5436_car_dvd_receiver.pdf

ORDER NO.

CRT5436 AVH-X1600DVD/XNUC

DVD RDS AV RECEIVER

AVH-X1600DVD AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC AVH-X1650DVD/XNRD AVH-X1650DVD/XNRI AVH-X1690DVD/XNID

/XNUC

This service manual should be used together with the following manual(s): Model No. CX-3283

Order No. CRT4843

Mech.Module LS2

Remarks DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly

PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2013

K-ZZZ SEPT. 2013 Printed in Japan

1

2

3

4

SAFETY INFORMATION A

CAUTION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING

B

This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used:

C

- Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer.

CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.

CAUTION This product is a class 1 laser product classified under the Safety of laser products, IEC 60825-1:2007, and contains a class 1M laser module. To ensure continued safety, do not remove any covers or attempt to gain access to the inside of the product. Refer all servicing to qualified personnel.

D

E

CAUTION—CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN, DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.

WARNING! The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. F

2

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

Laser diode characteristics Wave length: DVD:660 nm to 670 nm CD:780 nm to 800 nm Focus lens on Maximum output: CD:6.26 mW(Emitting period :9 sec.) DVD:1.27 mW (Emitting period : unlimited)

Additional Laser Caution B

Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD respectively. When Q1103 or Q1104 is shorted between their terminals, the laser diodes for DVD or CD will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.

CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacturer. Discord used batteries according to the manufacturer's instructions.

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

3

1

2

3

4

CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SERVICE PRECAUTIONS ............................................................................................................................... 5 1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5 1.2 NOTES ON SOLDERING .......................................................................................................................... 7 2. SPECIFICATIONS ............................................................................................................................................ 8 2.1 SPECIFICATIONS ..................................................................................................................................... 8 2.2 DISC/CONTENT FORMAT ...................................................................................................................... 21 3. BASIC ITEMS FOR SERVICE........................................................................................................................ 22 3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 22 3.2 PCB LOCATIONS .................................................................................................................................... 23 3.3 JIGS LIST ................................................................................................................................................ 24 3.4 CLEANING............................................................................................................................................... 24 4. BLOCK DIAGRAM.......................................................................................................................................... 26 4.1 OVERALL CONNECTION DIAGRAM...................................................................................................... 26 4.2 BLOCK DIAGRAM ................................................................................................................................... 28 5. DIAGNOSIS.................................................................................................................................................... 39 5.1 OPERATIONAL FLOWCHART ................................................................................................................ 39 5.2 INSPECTION METHOD OF PICKUP UNIT............................................................................................. 40 5.3 DIAGNOSIS FLOWCHART ..................................................................................................................... 43 5.4 ERROR CODE LIST ................................................................................................................................ 63 5.5 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 67 5.6 EEPROM OPERATION EXPLANATION FOR iPhone 5 .......................................................................... 68 6. SERVICE MODE ............................................................................................................................................ 69 6.1 MONITOR TEST MODE .......................................................................................................................... 69 6.2 DVD TEST MODE ................................................................................................................................... 87 7. DISASSEMBLY .............................................................................................................................................. 92 8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 96 8.1 DVD ADJUSTMENT ................................................................................................................................ 96 8.2 PCL OUTPUT CONFIRMATION............................................................................................................ 101 9. EXPLODED VIEWS AND PARTS LIST........................................................................................................ 102 9.1 PACKING ............................................................................................................................................... 102 9.2 EXTERIOR (1) ....................................................................................................................................... 106 9.3 EXTERIOR (2) ....................................................................................................................................... 108 9.4 DVD MECHANISM MODULE (1)............................................................................................................110 9.5 DVD MECHANISM MODULE (2)............................................................................................................112 10. SCHEMATIC DIAGRAM..............................................................................................................................114 10.1 MOTHER PCB (ANALOG BLOCK).......................................................................................................114 10.2 MOTHER PCB (SYSTEM BLOCK) (GUIDE PAGE) .............................................................................116 10.3 MOTHER PCB (SH BLOCK) (GUIDE PAGE) ...................................................................................... 122 10.4 MOTHER PCB (POWER SUPPLY BLOCK) ........................................................................................ 128 10.5 MOTHER PCB (IN/OUT BLOCK) (GUIDE PAGE)............................................................................... 130 10.6 MOTHER PCB (TUNER BLOCK) ........................................................................................................ 136 10.7 INTERFACE PCB ................................................................................................................................ 138 10.8 DVD CORE UNIT (GUIDE PAGE) ....................................................................................................... 140 10.9 SERVICE UNIT (MONITOR) (GUIDE PAGE) ...................................................................................... 146 10.10 SERVICE UNIT (KEYBOARD)........................................................................................................... 152 10.11 WAVEFORMS .................................................................................................................................... 154 11. PCB CONNECTION DIAGRAM.................................................................................................................. 156 11.1 MOTHER PCB ..................................................................................................................................... 156 11.2 INTERFACE PCB................................................................................................................................. 160 11.3 DVD CORE UNIT ................................................................................................................................. 162 11.4 SERVICE UNIT (MONITOR) ................................................................................................................ 164 11.5 SERVICE UNIT (KEYBOARD)............................................................................................................. 168 12. ELECTRICAL PARTS LIST ........................................................................................................................ 169

A

B

C

D

E

F

4

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS

A

1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 3. Please be sure to conduct line process to original status if you make assembling after repair. 4. Please be careful of not to imply static charge onto integrated circuits, etc, when you conduct repair work. Especially, please use soldering iron with its tip grounded. Also, please use a pair of tweezers with static charge protection capability if there is the possibility of contacting to device terminals, and avoid the use of metal-made tweezers. 5. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 6. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 7. Please keep the distance of more than 13 cm from focus lens for safety when you check pickup and make adjustment, and do not look straight at Laser Beam for more than 10 seconds. 8. Please power adjustment when you replaced mechanical area of DVD Mecha Module or DVD core unit. 9. Graphically-illustrated areas become hot . Be careful not to burn yourself.

B

C

Drive IC IC1251

Main IC IC1501

D

10. On this mechanism, Pickup and Spindle Motor can not be replaced at the service site, because a special facility is required for the adjustment after replacing them. So, if Pickup or Spindle Motor is defective, replace the Mechanism Unit. 11. EJECT LOCK MODE for DVD mechanism In order to change the EJECT LOCK status of the mechanism, please perform following procedure. [FORWARD] + [EJECT] -> ACC ON 12. The part listed below is difficult to replace as a discrete component part. When the part listed in the table is defective, replace whole Assy. Mother PCB Mother PCB Mother PCB

IC2101 IC2011 IC1202

BD9876EFJ BD00IA5WEFJ 337S3959

E

Heat pad Heat pad Because there are few exposed portions of a terminal.

F

AVH-X1600DVD/XNUC 5

6

7

8

5

1

13.

A

2

3

4

area and a heat sink becomes hot areas. Be careful not to burn yourself.

MOTHER PCB C801 IC341 IC1821

C2172 L2101 C1979

IC501

IC1302

B

MOTHER PCB IC251

IC2161

IC2101 IC1051 IC1951

C

IC1901 IC1911 IC1921

D

1F & 2F Rear Holder

E

LS2 DVD Mechanism Module Top Case

F

6

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

1.2 NOTES ON SOLDERING A

For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden).

B

The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

7

1

2

3

4

2. SPECIFICATIONS 2.1 SPECIFICATIONS - AVH-X1600DVD/XNUC

A

B

General

DVD Player

Power source ................... 14.4 V DC (10.8 V to 15.1 V allowable) Grounding system ............ Negative type Backup current ................. 5 mA or less Maximum current consumption ................................... 10.0 A Dimensions(W × H × D): D Chassis ............................ 178 mm × 100 mm × 165 mm (7in. × 3-7/8in. × 6-1/2in.) Nose ................................ 171 mm × 97 mm × 9 mm (6-3/4in. × 3-7/8in. × 3/8in.)

System ............................ DVD video, Video CD, CD, WMA, MP3, AAC, DivX, MPEG player Usable discs .................... DVD video, Video CD, CD, CDR/RW, DVD-R/RW/RDL Region number ................ 1 Frequency response......... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio ......... 91 dB(1 kHz) (IHF-A network) (RCA level) Output level: Video ............................... 1.0 Vp-p/75 Ω (±0.2 V) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format .....Ver.7, 7.1, 8, 9, 10, 11, 12(2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver. 10.6 and earlier)

Weight ............................. 1.7 kg (3.7 lbs)

Display Screen size/aspect ratio... 6.1 inch wide/16:9 (effective display area: 136.2 mm × 72.0 mm) Pixels ............................... 1 152 000 (2 400 × 480) Display method ................TFT active matrix, driving type Color system .................... NTSC/PAL/PAL-M/PAL-N/ SECAM compatible Durable temperature range (poweroff) ................................... –4 °F to + 176 °F

C

D

Audio

USB

Maximum power output.... 50 W × 4 70 W × 1/2 Ω (forsubwoofer) Continuous power output ................................... 22W × 4 (50 Hz to 15 000 Hz, 5%THD, 4 Ω load,both channels driven) Load impedance .............. 4 Ω (4Ω to 8Ω (2Ω for 1 ch) allowable)

USB standard specification ................................... USB 1.1, USB 2.0 full speed (For video files) USB 2.0 high speed (For audio files) Maximum current supply ................................... 1.0 A USB Class ....................... MSC (Mass Storage Class), MTP (Media Transfer Protocol) File system....................... FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (Ver. 10.6 and earlier) WAV (MSC Mode only): WAV signal format ........... Linear PCM, MS ADPCM (.wav) Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz, 24 kHz, 32 kHz, 44.1 kHz, 48 kHz MS ADPCM:22.05 kHz, 44.1 kHz

Preoutmaximumoutputlevel ................................... 2.0 V Equalizer (8-Band Graphic Equalizer): Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ 1 kHz/2.5 kHz/8 kHz/10 kHz Gain ................................ ±12 dB HPF: Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –12 dB/oct Subwoofer(mono): Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –18 dB/oct Gain ................................ +6 dB to – 24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................ +12 dB to 0 dB

E

F

8

DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

JPEG (MSC Mode only): JPEG decoding format ..... .jpeg, .jpg, .jpe Pixel Sampling ................. 4:2:2, 4:2:0 Decode Size..................... MAX:8 192 (H) x 7 680 (W), MIN:32 (H) x 32 (W) DivX decodingf ormat (MSC Mode only) ................................... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format (MSC Mode only) ................................... MPEG1, MPEG2, MPEG4 (part 2), MS-MPEG4 (ver.3)

B

FM tuner Frequency range .............. 87.9 MHz to 107.9 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (analog broadcasting) (IHF-A network)

C

AM tuner Frequency range .............. 530 kHz to 1 710 kHz (10 kHz) Usable sensitivity ............. 25 µV(S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (analog broadcasting) (IHF-A network)

D

CEA2006 Specifications

Power output................... 14 W RMS × 4 Channels(4 Ω and 1%THD+N) S/N ratio.......................... 91 dBA (reference: 1 W into 4 Ω)

E

Note Specifications and the design are subject to modifications without notice.

F

AVH-X1600DVD/XNUC 5

6

7

8

9

1

A

2

3

4

- AVH-X1600DVD/XNEW5 General Rated power source........... 14.4 V DC (allowable voltage range: 10.8 V to 15.1 V DC) Grounding system.............. Negative type Backup current ................ 5 mA or less Maximum current consumption ...................................... 10.0 A Dimensions (W × H × D): DIN Chassis .............................. 178 mm × 100 mm × 157 mm Nose ...................................188 mm × 118 mm × 17 mm D Chassis .............................. 178 mm × 100 mm × 165 mm Nose ...................................171 mm × 97 mm × 9 mm Weight ............................... 1.7 kg

B

C

Display Screen size/aspect ratio..... 6.1 inch wide/16:9 (effective display area: 136.2 mm × 72.0 mm) Pixels ................................ 1 152 000(2 400 × 480) Display method ................. TFT active matrix, driving type Color system..................... NTSC/PAL/PAL-M/PAL-N/ SECAM compatible Durable temperature range (power off) ...................................... –20 °C to + 80 °C

D

Audio Maximum power output ..... 50 W × 4 70 W × 1/2 Ω (for subwoofer) Continuous power output... 22 W × 4 (50 Hz to 15 000 Hz, 5%THD, 4 Ω load, both channels driven) Load impedance ............... 4 Ω (4 Ω to 8 Ω (2Ω for 1ch) allowable)

E

Preout maximum output level ..................................... 2.0 V Equalizer (8-Band Graphic Equalizer): Frequency......................... 40 Hz/80 Hz/200 Hz/400 Hz/ 1 kHz/2.5 kHz/8 kHz/10 kHz Gain ................................. ±12 dB HPF: Frequency......................... 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope................................ –12 dB/oct Subwoofer (mono): Frequency......................... 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz

F

10

Slope................................ Gain .................................. Phase ............................... Bass boost: Gain ..................................

–18 dB/oct +6 dB to – 24 dB Normal/Reverse +12 dB to 0 dB

DVD Player System .............................. DVD video, Video CD, CD, WMA, MP3, AAC, DivX, MPEG player Usable discs ..................... DVD video, Video CD, CD, CD-R/RW, DVD-R/RW/RDL Region number ................. 2 Frequency response.......... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio........... 96 dB (1 kHz) (IEC-A network) (RCA level) Output level: Video................................. 1.0 Vp-p/75 Ω (±0.2 V) Number of channels ......... 2 (stereo) MP3 decoding format ....... MPEG-1 & 2 Audio Layer 3 WMA decoding format ...... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format....... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver. 10.6 and earlier) DivX decoding format........ Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi,.divx) MPEG video decoding format ...................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

USB USB standard specification ...................................... USB 1.1, USB 2.0 full speed (For video files) USB 2.0 high speed (For audio files) Maximum current supply ... 1.0 A USB Class......................... MSC (Mass Storage Class), MTP (Media Transfer Protocol) File system........................ FAT16, FAT32 MP3 decoding format ....... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format....... MPEG-4 AAC (iTunes encoded only) (Ver. 10.6 and earlier)

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

WAV (MSC Mode only): WAV signal format............ Linear PCM, MS ADPCM (.wav) Sampling Frequency......... Linear PCM:16 kHz, 22.05 kHz, 24 kHz, 32 kHz, 44.1 kHz, 48 kHz MS ADPCM:22.05 kHz, 44.1 kHz JPEG (MSC Mode only): JPEG decoding format....... .jpeg, .jpg, .jpe Pixel Sampling.................. 4:2:2, 4:2:0 Decode Size..................... MAX:8 192 (H) x 7 680 (W), MIN:32 (H) x 32 (W) DivX decoding format (MSC Mode only) ..................................... Home Theater Ver. 3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format (MSC Mode only) ..................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

B

C

FM tuner Frequency range.............. 87.5 MHz to 108.0 MHz Usable sensitivity.............. 9 dBf (0.8 µV/75Ω ,mono, S/N:30 dB) Signal-to-noise ratio.......... 72 dB(IEC-A network) MW tuner Frequency range.............. 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity.............. 25 µV(S/N:20 dB) Signal-to-noise ratio.......... 62 dB (IEC-A network)

D

LW tuner Frequency range................ 153 kHz to 281 kHz Usable sensitivity.............. 28 µV (S/N:20 dB) Signal-to-noise ratio.......... 62 dB (IEC-A network)

Note Specifications and the design are subject to mod-

E

ifications without notice.

F

AVH-X1600DVD/XNUC 5

6

7

8

11

1

A

2

3

4

3

4

- AVH-X1600DVD/XNUW5

B

C

D

E

F

12

AVH-X1600DVD/XNUC 1

2

5

6

7

8

A

B

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

13

1

A

2

3

4

- AVH-X1650DVD/XNRC

B

General

DVD Player

Power source ................... 14.4 V DC(12.0 V to 14.4 V allowable) Grounding system ............ Negative type Backup current ................. 5 mA or less Maximum current consumption ................................... 10.0 A Dimensions (W × H × D): D Chassis ............................178 mm × 100 mm × 165 mm Nose ................................171 mm × 97 mm × 9 mm Weight .............................1.7 kg

System ............................ DVD video,Video CD, CD, WMA, MP3, AAC, DivX, MPEG player Usable discs .................... DVD video, Video CD, CD, CDR/RW, DVD-R/RW/RDL Region number ................ 3 Frequency response......... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio ......... 96 dB (1kHz) (IEC-A network) (RCA level) Output level: Video ............................... 1.0 Vp-p/75 Ω (±0.2 V) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver.10.6 and earlier) DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

Display Screen size/aspect ratio... 6.1 inch wide/16:9 (effective display area: 136.2 mm × 72.0 mm) Pixels ...............................1 152 000(2 400 × 480) Display method ................TFT active matrix, driving type Color system .................... NTSC/PAL/PAL-M/PAL-N/ SECAM compatible Durable temperature range (power off) ................................... – 20 °C to + 80 °C

C

Audio Maximum power output.... 50 W × 4 70W × 1/2 Ω (for subwoofer) Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5%THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) allowable)

D

Preout maximum output level ................................... 2.0 V Equalizer (8-Band Graphic Equalizer): Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ 1 kHz/2.5 kHz/8 kHz/10 kHz Gain ................................ ±12 dB HPF: Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –12 dB/oct Subwoofer (mono): Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –18 dB/oct Gain ................................ +6 dB to –24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................ +12 dB to 0 dB

E

F

14

USB USB standard specification ................................... USB 1.1, USB2.0 full speed (For video files) USB2.0 high speed (For audio files) Maximum current supply ................................... 1.0 A USB Class ....................... MSC (Mass Storage Class), MTP (Media Transfer Protocol) File system....................... FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (Ver.10.6 and earlier) WAV (MSC Mode only): WAV signal format ........... Linear PCM, MS ADPCM (.wav) Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz, 24 kHz, 32 kHz, 44.1 kHz, 48 kHz MS ADPCM:22.05 kHz, 44.1 kHz

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

JPEG (MSC Mode only): JPEG decoding format ..... .jpeg, .jpg, .jpe Pixel Sampling ................. 4:2:2, 4:2:0 Decode Size..................... MAX:8 192 (H) x 7 680 (W), MIN:32 (H) x 32 (W) DivX decoding format (MSC Mode only) ................................... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format (MSC Mode only) ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

B

FM tuner Frequency range .............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IEC-A network) C

AM tuner Frequency range .............. 530 kHz to 1 640 kHz (10 kHz) 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity ............. 25 µV (S/N:20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)

D

Note Specifications and the design are subject to modifications without notice.

E

F

AVH-X1600DVD/XNUC 5

6

7

8

15

1

A

2

3

4

- AVH-X1650DVD/XNRD

B

General

DVD Player

Power source ................... 14.4 V DC (12.0 V to 14.4 V allowable) Grounding system............ Negative type Backup current ................. 5 mA or less Maximum current consumption ................................... 10.0 A Dimensions (W × H × D): D Chassis ............................ 178 mm × 100 mm × 165 mm Nose ................................ 171 mm × 97 mm × 9 mm Weight ............................. 1.7 kg

System ............................ DVD video, Video CD, CD, WMA, MP3, AAC, DivX, MPEG player Usable discs .................... DVD video, Video CD, CD, CDR/RW, DVD-R/RW/RDL Region number ................ 4 Frequency response......... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio ......... 96 dB(1 kHz) (IEC-A network) (RCA level) Output level: Video ............................... 1.0 Vp-p/75 Ω (±0.2 V) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format....... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver.10.6 and earlier) DivX decoding format....... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

Display Screen size/aspect ratio... 6.1 inch wide/16:9 (effective display area: 136.2 mm × 72.0 mm) Pixels ...............................1 152 000(2 400 × 480) Display method ................TFT active matrix, driving type Color system.................... NTSC/PAL/PAL-M/PAL-N/ SECAM compatible Durable temperature range (power off) ................................... – 20 °C to + 80 °C

C

Audio Maximum power output... 50 W × 4 70 W × 1/2 Ω (for subwoofer) Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5%THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) allowable) Preout maximum output level ................................... 2.0 V

D

Equalizer (8-Band Graphic Equalizer): Frequency........................ 40 Hz/80 Hz/200 Hz/400 Hz/ 1 kHz/2.5 kHz/8 kHz/10 kHz Gain ................................ ±12 dB HPF: Frequency........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –12 dB/oct Subwoofer (mono): Frequency........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –18 dB/oct Gain ................................ +6 dB to –24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................ +12 dB to 0 dB

E

F

16

USB USB standard specification ................................... USB 1.1, USB2.0 full speed (For video files) USB2.0 high speed (For audio files) Maximum current supply ................................... 1.0 A USB Class ....................... MSC (Mass Storage Class), MTP (Media Transfer Protocol) File system....................... FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format....... MPEG-4 AAC (iTunes encoded only) (Ver.10.6 and earlier) WAV (MSC Mode only): WAV signal format ........... Linear PCM, MS ADPCM (.wav) Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz, 24 kHz, 32 kHz, 44.1 kHz, 48 kHz MS ADPCM:22.05 kHz, 44.1 kHz

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

JPEG (MSC Mode only): JPEG decoding format ..... .jpeg, .jpg, .jpe Pixel Sampling ................. 4:2:2, 4:2:0 Decode Size..................... MAX:8 192 (H) x 7 680 (W), MIN:32 (H) x 32 (W) DivX decoding format (MSC Mode only) ................................... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format (MSC Mode only) ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

B

FM tuner Frequency range.............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IEC-A network) C

AM tuner Frequency range.............. 530 kHz to 1 640 kHz (10 kHz) 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity ............. 25 µV(S/N:20 dB) Signal-to-noise ratio ......... 62 dB(IEC-A network)

D

Note Specifications and the design are subject to modifications without notice.

E

F

AVH-X1600DVD/XNUC 5

6

7

8

17

1

A

B

2

3

- AVH-X1650DVD/XNRI

General

DVD Player

Power source ................... 14.4 V DC (12.0 V to 14.4 V allowable) Grounding system ............ Negative type Backup current ................. 5 mA or less Maximum current consumption ................................... 10.0 A Dimensions (W × H × D): DIN Chassis ............................ 178 mm × 100 mm × 157 mm Nose ................................ 188 mm × 118 mm × 17 mm D Chassis ............................ 178 mm × 100 mm × 165 mm Nose ................................ 171 mm × 97 mm × 9 mm Weight ............................. 1.7 kg

System ............................ DVD video, Video CD, CD, WMA, MP3, AAC, DivX, MPEG player Usable discs .................... DVD video, Video CD, CD, CDR/RW, DVD-R/RW/RDL Region number ................ 2 Frequency response......... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio ......... 96 dB(1 kHz) (IEC-A network) (RCA level) Output level: Video ............................... 1.0 Vp-p/75 Ω (±0.2 V) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver.10.6 and earlier) DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

Display C

Screen size/aspect ratio... 6.1 inch wide/16:9 (effective display area: 136.2 mm × 72.0 mm) Pixels ...............................1 152 000 (2 400 × 480) Display method ................TFT active matrix, driving type Color system .................... NTSC/PAL/PAL-M/PAL-N/ SECAM compatible Durable temperature range (power off) ................................... –20 °C to + 80 °C

USB

Audio D

E

F

4

Maximum power output... 50 W × 4 70 W × 1/2 Ω (for subwoofer) Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5%THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) allowable) Preout maximum output level ................................... 2.0 V Equalizer (8-Band Graphic Equalizer): Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ 1 kHz/2.5 kHz/8 kHz/10 kHz Gain ................................ ±12 dB HPF: Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –12 dB/oct Subwoofer (mono): Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –18 dB/oct Gain ................................ +6 dB to – 24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................ +12 dB to 0 dB

18

USB standard specification ................................... USB 1.1, USB2.0 full speed (For video files) USB 2.0 high speed (For audio files) Maximum current supply ................................... 1.0 A USB Class ....................... MSC (Mass Storage Class), MTP (Media Transfer Protocol) File system....................... FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (Ver.10.6 and earlier) WAV (MSC Mode only): WAV signal format ........... Linear PCM, MS ADPCM (.wav) Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz, 24 kHz, 32 kHz, 44.1 kHz, 48 kHz MS ADPCM:22.05 kHz, 44.1k Hz

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

JPEG (MSC Mode only): JPEG decoding format ..... .jpeg, .jpg, .jpe Pixel Sampling ................. 4:2:2, 4:2:0 Decode Size..................... MAX:8 192 (H) x 7 680 (W), MIN:32 (H) x 32 (W) DivX decoding format (MSC Mode only) ................................... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format (MSC Mode only) ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

B

FM tuner Frequency range .............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB(IEC-A network) C

AM tuner Frequency range .............. 530 kHz to 1 640 kHz (10 kHz) 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity ............. 25 µV (S/N:20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)

D

Note Specifications and the design are subject to modifications without notice.

E

F

AVH-X1600DVD/XNUC 5

6

7

8

19

1

A

2

3

4

- AVH-X1690DVD/XNID

B

General

DVD Player

Power source ................... 14.4 V DC (12.0 V to 14.4 V allowable) Grounding system ............ Negative type Backup current ................. 5 mA or less Maximum current consumption ................................... 10.0 A Dimensions (W × H × D): D Chassis ............................178 mm × 100 mm × 165 mm Nose ................................171 mm × 97 mm × 9 mm Weight ............................. 1.7 kg

System ............................ DVD video, Video CD, CD, WMA, MP3, AAC, DivX, MPEG player Usable discs .................... DVD video, Video CD, CD, CDR/RW, DVD-R/RW/RDL Region number ................ 5 Frequency response......... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio ......... 96 dB(1 kHz) (IEC-A network) (RCA level) Output level: Video ............................... 1.0 Vp-p/75 Ω (±0.2 V) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver.10.6 and earlier) DivX decoding format ....... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

Display Screen size/aspect ratio...154.9 mm wide/16:9 (effective display area: 136.2 mm × 72.0 mm) Pixels ............................... 1 152 000 (2 400 × 480) Display method ................TFT active matrix, driving type Color system .................... NTSC/PAL/PAL-M/PAL-N/ SECAM compatible Durable temperature range (power off) ................................... –20 °C to +80 °C

C

Audio Maximum power output... 50 W × 4 70 W × 1/2 Ω (for subwoofer) Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5%THD, 4 Ω load,both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) allowable) Preout maximum output level ................................... 2.0 V Equalizer (8-Band Graphic Equalizer): Frequency ........................ 40 Hz/80 Hz/200 Hz/400 Hz/ 1 kHz/2.5 kHz/8 kHz/10 kHz Gain ................................ ±12 dB HPF: Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –12 dB/oct Subwoofer (mono): Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ............................... –18 dB/oct Gain ................................ +6 dB to – 24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................+12 dB to 0 dB

D

E

F

20

USB USB standard specification ................................... USB 1.1, USB 2.0 full speed (For video files) USB 2.0 high speed (For audio files) Maximum current supply ................................... 1.0 A USB Class ....................... MSC (Mass Storage Class), MTP (Media Transfer Protocol) File system....................... FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver.7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) AAC decoding format ....... MPEG-4 AAC (iTunes encoded only) (Ver.10.6 and earlier) WAV (MSC Mode only): WAV signalf ormat ........... Linear PCM, MS ADPCM (.wav) Sampling Frequency ........ Linear PCM:16 kHz, 22.05 kHz, 24 kHz, 32kHz, 44.1 kHz, 48 kHz MS ADPCM:22.05 kHz, 44.1 kHz

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

JPEG (MSC Mode only): JPEG decoding format ..... .jpeg, .jpg, .jpe Pixel Sampling ................. 4:2:2, 4:2:0 Decode Size..................... MAX:8 192 (H) x 7 680 (W), MIN:32 (H) x 32 (W) DivX decoding format (MSC Mode only) ................................... Home Theater Ver.3, 4, 5.2, 6 (Except ultra and HD) (.avi, .divx) MPEG video decoding format (MSC Mode only) ................................... MPEG1, MPEG2, MPEG4 (part2), MS-MPEG4 (ver.3)

B

FM tuner Frequency range .............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noiseratio ......... 72 dB (IEC-A network) C

AM tuner Frequency range .............. 530 kHz to 1 640 kHz (10k Hz) 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity ............. 25 µV(S/N:20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)

D

Note Specifications and the design are subject to modifications without notice.

E

2.2 DISC/CONTENT FORMAT

is a trademark of DVD Format/Logo Licensing Corporation.

F

AVH-X1600DVD/XNUC 5

6

7

8

21

1

2

3

4

3. BASIC ITEMS FOR SERVICE

3.1 CHECK POINTS AFTER SERVICING A

To keep the product quality after servicing, please confirm following check points. No. 1

Procedures Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check.

Item to be confirmed The customer complain must not be reappeared. Display, video, audio and operations must be normal.

2 DVD

Measure playback error rates at the innermost and outermost tracks by using the test mode with the following disc. DVD test disc (TDV-582)

Deterioration of mecha-drive can be checked. The error rate must be less than the threshold value. (Refer to the chapter of DIAGNOSIS for the threshold value.)

3 DVD

Play back a DVD. (Menu operation; Title/chapter search)

Display, video, audio and operations must be normal.

4 CD

Play back a CD. (Track search)

Display, audio and operations must be normal.

5 FM/AM tuner

Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM.

Display, audio and operations must be normal. * If the reception sensitivity is poorer than normal, the gasket on the FM/AM tuner unit may be damaged or lost.

6

Check whether no disc is inside the product.

The media used for the operating check must be ejected.

7

Appearance check

No scratches or dirt on its appearance after receiving it for service.

B

C

For check items concerning image and voice, please refer to the followings: Check items concerning image Block-noise Crosscut noise Dot noise Distorted image (Image skip) Low brightness Too bright Color fading Partial discoloration

D

Check items concerning voice Distortion Noise Low volume High volume Changes in level Pause of sound

E

F

22

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

3.2 PCB LOCATIONS

A Mother PCB

A

C DVD Core Unit E Service Unit (Keyboard)

D Service Unit (Monitor)

B

B Interface PCB

A:AVH-X1600DVD/XNUC B:AVH-X1600DVD/XNEW5 C:AVH-X1600DVD/XNUW5 D:AVH-X1650DVD/XNRC E:AVH-X1650DVD/XNRD F:AVH-X1650DVD/XNRI G:AVH-X1690DVD/XNID

C

Service Unit(Mother I/F) Consists of Mother PCB Interface PCB Unit Number : CXX6037(A) Unit Number : CXX6035(B) Unit Number : CXX6036(C) Unit Number : CXX6038(D) Unit Number : CXX6039(E) Unit Number : CXX6040(F) Unit Number : CXX6041(G) Unit Name : Service Unit(Mother I/F) Unit Number : YWX5032 Unit Name : DVD Core Unit Unit Number : CXX6055 Unit Name : Service Unit(Monitor) Unit Number : CXX6059 Unit Name : Service Unit(Keyboard)

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

23

1

2

3

4

3.3 JIGS LIST DVD Mechanism Module A

Interface PCB

GGD1222 B

Mother PCB

Service Unit (Monitor)

C

- Jigs List

D

Name Disc

Jig No. TDV-582

Disc 30P FFC

TCD-782 GGD1222

Remarks Skew adjustment, Check points after servicing, Inspection method of Pickup Unit Inspection method of Pickup Unit DVD CORE UNIT <–> MOTHER PCB

- Grease List Jig No. GEM1024 GEM1038 GEM1045

Name Grease Grease Grease

Remarks DVD Mechanism Module DVD Mechanism Module DVD Mechanism Module

E

3.4 CLEANING

Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned DVD pickup lenses

Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008

F

24

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

B

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

25

1

2

3

4

4. BLOCK DIAGRAM

4.1 OVERALL CONNECTION DIAGRAM Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".

AEQ MIC IN AUX IN

WIREDAD WIRED GNDD

VIDEO AUXR AUXL GND

2 3 1

1

WIRED REMOTE

3 4 2

A

JA3641 CKN1106-A

JA3731 CKS6437-A

B

INTERFACE

B

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

8 7 6 5 4 3 2 1

16 1 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

2

GNDA GNDA RLOUT RROUT FLOUT FROUT SWLOUT SWROUT

PREOUT

B.UP GND ACC BGSENS ILM B.REM MUTE P.B. RL+ FL+ RLFLRR+ FR+ RRFR-

YEK5001-A

POWER SUPPLY

WIREDAD WIRED GNDSX GNDSX SXEN SXPWR SXPWR NC SXL GNDA GNDA SXR ASENBO GND STOSX SXTOS GNDD GNDD GNDD BTMICP BTMICN GND NTOSYS

50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28

C

C

JA1631 XKB7001-B

JA801 CKM1376-A

CN1952 CKS6025-A

C

C DVD CORE UNIT

D

30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

VD8 VD8 VD8 PGND PGND PGND VD5 AMUTE XRESET IRQPWR HSTCMD SLVSTS STANBY AGND ANA_R_OUT AGND ANA_L_OUT AGND MOVBS VIDEO_GND WAKEUP DD+ DGND IECOUT DGND SCL SDA CPRST CPRDY

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

CN751

A

CKS6025-A

MOTHER P

A 1/6 AUDIO BLOC A 2/6 SYSTEM BL A 3/6 SH BLOCK A 4/6 POWER SU A 5/6 IN/OUT BLO A 6/6 TUNER BLO CN175

60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33

COMDC POL VCLK OEV STV2 LCDGND HCLK LCDGND LD R5 R4 R3 R2 R1 R0 G5 G4 G3 G2 G1 G0 B5 B4 B3 B2 B1 B0 LCDGND

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

CKS6386-A

E

CN540 CKS6536-A

D

SERVICE UNIT(MONITO

CN5001 CKS6536-A

F

60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 GND DIO1 NC VR1 VR2 VR3 VR4 VR5 VR6 VR7 VR8 VR9 VR10 B0 B1 B2 B3 B4 B5 G0 G1 G2 G3 G4 G5 R0 R1 R2 R3 R4 R5 LOAD L/R AVDD AVDD GND GND HCLK DVDD DIO2 GND GND GND STV2

YT XR YB XL

1 2 3 4

CN5301 CKS6548-A

TOUCH PANEL

TFT LCD

CSX1184

26

CWX4218

AVH-X1600DVD/XNUC 1

2

3

4

44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

G4 G3 G2 G1 G0 B5 B4 B3 B2 B1 B0 LCDGND DIO LCDGND LCDPW LPSYNC V18HI LCDGND PWRVI TEMPSENS PWM_G PWM_R PWM_B KDT1 KDT0 RST REMIN LCDGND MTCHCL MTCHDA TPIRQN KEYGND TOUCHGND TPN33 BLSYNC BLEN DIMMER BLERR BLGND BLGND BLGND ILMB ILMB ILMB 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

CN1701

CKS6605-A

NIT(MONITOR)

CN5001 CKS6536-A

5

NTERFACE PCB

CN3601 CKS6605-A

CN5402

CKS6063-A 1 2 3 4 5 6 7 8 9 10 11

6

RCA V IN OUT

JA1601 JA1621

CKN1091-A CKB1110-A

CKS6536-A

KEYGND ILMB KDT1 LEDR LEDG LEDB TPN33 KDT0 RST REM KEYGND

11 10 9 8 7 6 5 4 3 2 1

22

USB IN VCR_RG VCR_RIN VOUT_G VOUT VCR_LG VCR_LIN VCR_VG VCR_VIN

CKS4497-A

1 2 3 4 5 6 7 8

38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 VIDEO AUXR AUXL GND

26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

2 BCAMIN BCAMGND 1

NAVI_TO_SYS SYS_TO_NAVI VSW5 MONON GUIDEON TVON DSEN CCREM GNDRAU REAUL REAUR OMSEIONSEI+ GNDD GNDAU CCAUR CCAUL ASENBO YS GNDDVD DVDVBS GNDSIG CSYNC CCB CCG CCR

CN3661

1 1

ASENBO GND STOSX SXTOS GNDD GNDD GNDD BTMICP BTMICN GND NTOSYS SYSTON GND ONSEIONSEI+ GUIDEON TVON DTVR DTVAG DTVL GND CSYNC APPPUP ANB GNDSIG ANG GNDSIG ANR GNDSIG AUXV AUXVGND AUXL AUXAGND AUXR AUXAGND BEEP BCAMIN BCAMGND

6 SHIELD2 5 SHIELD1 4 USBGND 3 USB_D+ 2 USB_D1 USB5V

13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

JA3641 CKN1106-A

1 2 3 4 5 6 7 8 9 10

27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 3 4 2

1

AEQ MIC IN AUX IN

ANODE ANODE ANODE NC K1 K2 K3 K4 NC NC

AVDD AVDD GND GND HCLK DVDD DIO2 GND GND GND STV2 UD OEV VCLK GND GND POL XON NC VEEG-6V NC VDDG+18V NC STV1 NC VCOM VCOM

5 6 7

AVH-X1600DVD/XNUC

7

8

NAVI/DTV INTERFACE A

BACK CAMERA INPUT

CKB1106-A

JA3621

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB B

FM/AM ANTENNA

YKS5041-A

JA451

MOTHER PCB C

AUDIO BLOCK

SYSTEM BLOCK

SH BLOCK

POWER SUPPLY BLOCK

N/OUT BLOCK D

TUNER BLOCK

CN1751

CKS6386-A

CN5401 E

CN4801

CKS6063-A

E

SERVICE UNIT (KEYBOARD)

BACKLIGHT

CN5202

CKS6523-A

F

TFT LCD

CWX4218

8

27

1

2

3

4

4.2 BLOCK DIAGRAM

MOTHER PCB (1/3)

8 6 4

RCA V IN/OUT

CN751 VD8

1 2 3 7

17

H

ANA_L_OUT

C

CN1952

8 9 10 11 12 13

TUN_L

SH_L

I J

19

AV SEL IC1 AK42

VD5

TO 2/3 B

VCR_VIN VCR_LIN VOUT

A

JA1621

A

iCOMP

RCA_V

13

VCR_L TUN_L LS_L AUX_L iTV_L SH_L

33

LIN4 27 LIN6 36 LIN3 30 LIN5 40 LIN2 43 LIN1

iCOMP VCR_V

MOVBS

11 9 5 7 3

LS_V AUX_V

AMUTE XRESET IRQPWR HSTCMD SLVSTS STANBY

BCAMIN XRST IRQPW SYSTOLS LSTOSYS STANBY

Q752 DD+

D22 D+ 23

VOUT2

VIN1 VIN2 VIN4 VIN3 VIN5

Q751

SYS+B

M TO 2/3

AMUTE

CN1701 AUXL 29

AUXAGND 45 AUXV 42 BCAMIN 49

C

AVSCK AVSDATA AVSRST

IC1721 NJM4565V DTVL 30 DTVAG 29

2 3

IC1731 (1/2) NJM4565V ONSEI+ 25 ONSEI24

6 5

7

17 9 16 7 8 29

iTV_L

1

SYSTOLS LSTOSYS

IC1731 (2/2) NJM4565V 2 3

STANBY

105 103 104

AMUTE XRST IRQPW TXDVD RXDVD STB

46 SCL 45 SDA 17 RSTN

Q1661

iNAVI

1

EVSEL EVSDA EVSCK SACLK uCOM SAIN

Q1721

SYS+B

SYSTEM IC601 (1/3)

D

35 33 34 36 120

EVSACLK EVSAOUT

A :PDB117A8

B

40 38 36 34 33 32

ANR ANG ANB CSYNC HSYNC VSYNC

GND5

AEQAUXSW

44

B C D :PDB118A8 E F G

L TO 2/3

AEQAUXSW SYSMUTE offset

62 38 1

OFFSET

CN3601 Q601

27

TVON

3

11

A :AVH-X160 B :AVH-X160 C :AVH-X160 D :AVH-X165 E :AVH-X165 F :AVH-X165 G :AVH-X169

2 GUIDEON 4 TXNAVI 5 RXNAVI

GUIDEON 26 SYSTON 22 NTOSYS 21

E

RGBARI

Q1701

ASENBO

BUP_1 100

ASENBO

Q1712 35

APPPUP

VDD33

SOC33_1

102

WREMCONT

AMPPW TELMUTEIN

D E F G

PBSENS ISENS

118 WIREDAD 117 WIRED 67 BEEP

WIREDAD 1 WIRED 2 BEEP 48

F

28

BGSENS ASENS BSENS

68 74 77 76 111 110

AVH-X1600DVD/XNUC 1

2

3

TELMUTE

75

4

BGSENS0

5

6

7

8

A

AEQMICIN

AUX_L

AV SELECTOR IC101 AK4223VQ 13

E.VOL IC251 PML020A 18

VOUT2

MIC SENS Q1662

MIC_IN

SYS+B

33

LIN4 27 LIN6 36 LIN3 30 LIN5 40 LIN2 43 LIN1

LOUT2

22

AV_LOUT1

8

JA1631

IN2L FRONT_L

VIN1 VIN2 VIN4 VIN3

REAR_L PRE_SWL

61

FLOUT

60

RLOUT

59

SWLOUT

4 6 2

PREOUT

11 9 5 7 3

AEQAUXSW

B

VIN5 iNAVI

14

Q1633(1/2)

IN5L

Q1633(2/2)

Q1631

RCAMUTE 54

SYS+B

Q311

VP

BUP_1 SYSMUTE

29

GND5 VOUT1

46 SCL 45 SDA 17 RSTN

14

MONVBS

C

AMP IC341 PA2032A

K TO 2/3

JA801 11 15

Q1661

EVSEL EVSDA EVSCK EVSACLK EVSAOUT

FLIN

RL+

RLIN

RL-

32 STB 31 DATA 30 CLK 28 SACLK 27 SAOUT

FL+ FL-

9

FL+

7

FL-

17

RL+

19

RL-

7 5 8 6

SACLK SAOUT

1

AEQAUXSW

OFFSET

D

STBY

H-SW

OFFSET

25

B.REM

11

FFSET MUTE

AMPMUTE

OFFMUTE

22

Q321

Q301

BUP_1 SYSMUTE SYS+B

A :AVH-X1600DVD/XNUC B :AVH-X1600DVD/XNEW5 C :AVH-X1600DVD/XNUW5 D :AVH-X1650DVD/XNRC E :AVH-X1650DVD/XNRD F :AVH-X1650DVD/XNRI G :AVH-X1690DVD/XNID

BUP_1

FUSE

B.UP

10A

16

POWER SUPPLY

4

AMPPW

TEL MUTE

Q854 (1/2)

TELMUTE

MUTE

10

E

PBSENS Q854(2/2)

PBSENS

P.B.

9

ISENS

Q841

ISENS

ILM

12

BGSENS AVH Q831

BGSENS0

BGSENS

ELMUTE

13

ASENS

Q871(2/2)

ASENS

ACC

14

GSENS0

BSENS BUP_1

AVH-X1600DVD/XNUC 5

F

Q871(1/2)

BSENS

6

7

8

29

1

A

2

3

4

MOTHER PCB (2/3)

A

VIDEO DECODER IC1051 ML86V7675TBZA3A TO 1/3 K

59

MONVBS

CVBS1

RGB VIDEO ISOLATOR IC1002 BH7673G ANR

4

+IN

OUT

Q1002

IC1004 BH7673G ANG

4

B

+IN

OUT

ANB

4

+IN

OUT

4

+IN

OUT

1

iCOMP

GIN1

J TO 1/3

Q1001 1

IC1001 BH7673G CSYNC

RIN1

Q1004 1

IC1003 BH7673G TO 1/3 L

12

1

5

BIN1

Q1003 1

16

CSYNC_A SCL SDA

HSYNC VSYNC

20 21

52

V_SCL0

51

V_SDA0

CHSI VSI

FM/AM ANTENNA

C

iPod CP IC1202 337S3959

RF FRONT END IC IC501 TDA7706

JA451 1

5 16 18

VCC FMMIXIN1 PINDIN LNAIN

8 DACOUTL

TUN_L

57

Q1201

H TO 1/3

SOC33

76

P

D

SDRAM IC1101 M12L128168A-5TG2N SYSTEM uCOM IC601(2/3) A :PDB117A8 B C D :PDB118A8 E F G I2CSDA I2CSCL RSTN

33 34

42 44

31

43

FLASH ROM IC1251

TUNDATA TUNCLK

A D :CXX5989 B C E F G :CXX5991

TUNRST

RESET 3

E SOCXRST

A :AVH-X1600DVD/XNUC B :AVH-X1600DVD/XNEW5 C :AVH-X1600DVD/XNUW5 D :AVH-X1650DVD/XNRC E :AVH-X1650DVD/XNRD F :AVH-X1650DVD/XNRI G :AVH-X1690DVD/XNID

SOCSTB SOCAMUTE1 TXSOC RXSOC SOCIRQPW

93

88

37 95 30 31 94

68 77 202 203 216

F

30

AVH-X1600DVD/XNUC 1

2

3

4

R

P P P P P

5

6

7

8

A

CN1751 (1/2) SH PART uCOM IC1302 R5S72690RW266FP

PG26/LCD_TCON1 PG25/LCD_TCON0 PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1 PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1 PG24/LCD_CLK PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2 PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4 PJ28/SSISCK5/TIOC1B/RTS7 PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2 PJ27/SGOUT_3/TIOC1A/CTS7 PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0 PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK PH0/AN0/PINT0

CL0 DA0

10 l 15

G[0-5]

16 l 21

B[0-5]

22 l 27

191 190 44 43 189

OEV STV2 HCLK

185 183 66 42 239

DIO LPSYNC TPIRQN BLSYNC

223 22 118

BLEN DIMMER BLERR

70 71

MTCHCK MTCHDA

POL VCLK

2 3 4 5 7

LD

9 29 32 47 51

B

D

CN5401

52 53 54 45 46 35

PWRVI

V_SCL0 V_SDA0

PE0/SCL0/TCLKA/LCD_EXTCLK PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK

R[0-5]

TPN33

50

ILMB

58 59 60

C

TAGGING IC1301 MX25L8006EM2I-12G

SOC33

76

PE6/SCL3/RxD6

D

DAC IC1151 WM8761BGED

9

VOUTL

PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6 PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD 88

SH_L

16

USBFLG

24

USBCNT

I

TO 1/3

N TO 3/3 E

RES

USB SW IC751 BD11600NUX 68 77 202 203 216

DP

PJ30/SSIDATA5/TIOC2B/IETxD PE7/SDA3/RxD7 PF7/SSIRxD0/RxD0/SGOUT_3/CTS1 PF8/A23/TxD0 PF16/SD_CD_0/FCE/IRQ4/MMC_CD

DM

PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5

94

JA1601

1

93

3 2

221

4 9

8

USB_D+

7

USB_D-

USB5

USB5V

3

2

USB IF

1

F D+

TO 1/3 M

D-

AVH-X1600DVD/XNUC 5

6

7

8

31

1

A

2

3

4

MOTHER PCB (3/3)

A

DC/DC CONVERTER IC1951 AN33012UA Q1951

P2151

3

VD8 ILMB

4 7

VCC_S2

23

VD5

1

BUP_1

2 24

HSD1 FB1 EN1

Q1952

P2071

PWRVI

VCC VCC_S1

DD8

B

RS1

P2152

FLAG

RS2

8 12

P2081 22

DD5

18

HSD2

SYNC

FB2

EN2

13 9

USB5 REG. IC2161 AN33014UA 24

USB5

2 12

LX

PVCC1

RSO

PVCC2 VCC

FB

8

RSIN

FLAG EN SYNC

C

4

BUP_1

5 6 19

USBFLG

16

USBCNT

N TO 2/3

17

DDC33 REG. IC2101 BD9876EFJ 1

DDC33

LX

4

SOC33

VCC

FB SYNC

SOC33_1

EN

8

BUP_1

5 6

VDEC33 TPN33 BT33

SOC12 REG. IC2011 BD00IA5WEFJ 1

SOC12

2

D

VO

VCC

FB

EN

8

SOC33

5

VDD33 REG. IC1801 NJW4181U3-33B VDD33

1

VOUT

VIN

3

BUP_1

VDEC15 REG. IC2031 NJM2878F3-15 VDEC15

4

VIN

VOUT

CONT

5

VDEC33

1

E

TUN5REG. IC1901 NJM2886DL3-05 TUN5

4

VIN

VOUT

CONT

2

P1951 DD8

1

SYS+B IC1821 NJM2387ADL3 SYS+B

3 4

VOUT

VIN

VADJ

CONT

1 2

BUP_1

F

32

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

SYSTEM uCOM IC601 (3/3) A :PDB117A8 B C D :PDB118A8 E F G 70 64

CN1751 (2/2)

VDCNT8

COMDC

DDCERR

LCDPW TEMPSEN G_PWM R_PWM B_PWM KDT1 KDT0 REMIN NRST

65

119

COMDC

73

LCDPW TMPSENS

124 92

PWM_G

90

PWM_R

88

PWM_B

126

KDT1

127

KDT0

112

REMIN

26

RST

1 31 36 37 38 39

B

D

CN5401

40 41 43 42

DDCCLK

C

69

VDCNT5

D

A :AVH-X1600DVD/XNUC B :AVH-X1600DVD/XNEW5 C :AVH-X1600DVD/XNUW5 D :AVH-X1650DVD/XNRC E :AVH-X1650DVD/XNRD F :AVH-X1650DVD/XNRI G :AVH-X1690DVD/XNID

E

66

SYSPW

F

AVH-X1600DVD/XNUC 5

6

7

8

33

1

B

2

3

4

C

INTERFACE PCB

DVD CORE UNIT

A

FLASH ROM (16M x 2)

CN3601 3

1

BEEP

BUZZER BZ3631

IC1401 CWW5043

JA3731 50 49

WIREDAD WIRED

WIREDAD 2 WIRED 3 GND 1

WIRED REMOTE

IC1402 CWW5044

CN3661 ASENBO 40 NTOSYS 30 SYSTON 29

RESET

ASENBO 9 NAVI_TO_SYS 25 SYS_TO_NAVI 24

12

SDRAM IC1480 M12L64164A-5TG2Y

B

A

CN1701

MOTOR DRIVER IC1251 BA5839FP

27 26 25 24 22 21 17 16 15 13 11

C

ONSEIONSEI+ GUIDEON TVON DTVAG DTVL

ONSEIONSEI+ GUIDEON TVON GNDAU

14 13 21 20 12

CCAUL

CSYNC APPPUP ANB ANG ANR

NAVI DTV INTERFACE

17 18 15 16

LECRGM LECRGP SPDLM SPDLP

WHITE GREEN BLK RED

VO4+ VO4VO3+ VO3-

OPOUT2

10

CCSYNC 4 MONON 22 CCB 3 CCG 2 CCR 1

OPIN2OPOUT3

CN1101 1 2 3 4

OPIN3-

14 12 11 13

T+ FF+ T-

VO2+ VO1+ VO1VO2-

JA3641 6 7 9

AUXAGND AUXL

GND AUXL AUXR VIDEO

AUXV

OPINSL OPOUTSL LDIN CNT MUTE OPOUT1 OPIN1-

2 4 3 1

13

AUX IN

14

VR OPIN2+ OPIN1+ OPIN3+

Q1104

Q1102

Q1103

Q1101

24 23 22 21 9 7 6 4 3 25 26 1 2 5 27

78LD

65LD

JA3621 2

BCAMIN

BCAMIN 2 BCAMGND 1

BACK CAMERA INPUT

PU (DP11)

D

6 10 11 16 17 18 19 20 21

22

TEMP F+H/G+H E+G/E+F B A C D FE1 FE2

VR1101

IMON

VR1102

23

RF

TC E

8

9

Vref

VCC

VCC5

F

34

AVH-X1600DVD/XNUC 1

2

3

4

5

6

1401 W5043

ADOUT LRCK SRCK DACCK SDODAC SCKDAC LTDAC

1402 W5044

OPIN2OPOUT3 OPIN3VR OPIN2+ OPIN1+ OPIN3+

151 150 149 148 57 58 56

2 3 1 16 13 14 15

24 23 22 21 9 7 6

67 62 63 64 127

4

126

3 25

66

26 1 2 5 27

110

CRGDRV LDIN CONT1 CONT2 FD

7

ANALOG LOUT

14

75 70 48 53 54 191 138 144 146 152 47 46 61

AMUTE XRESET IRQPWR HSTCMD SLVSTS STANBY COMPOSITE DD+ IECOUT SCL SDA RESET

MD VCC5

5

VOUT

VD8

4 3

VIN ON/OFF

VHALF

VD5

B

30 29

VD8

VCC5 REG. IC1002 S-1133B50-U5

TD

23 22 21 20 19 18 12 9 8 6 4 3 2

28

C

24

VCC5-AU REG. IC1003 S-1200B50-M5 5

VOUT

Q1102 106

Q1103

CN1952 VOUTL

CN751

EXTRG1 NRES IRQPWR CMDCOMN STSCOMN STANDBY COMPOSITE LOUT ROUT IECOUT I2C_SCL I2C_SDA CP_Reset

VCC5_AU Q1104

DATA LRCK BCK SCK MD MC ML

A

R DRIVER 1251 839FP

OPOUT2

A

12

RAM 1480 64A-5TG2Y

OPINSL OPOUTSL LDIN CNT MUTE OPOUT1 OPIN1-

8

ADAC IC1801 PCM1753DBQ

SYSTEM uCOM IC1501 MN2DS0018MA

OM (16M x 2)

RESET

7

VCC33 REG. IC1004 NJM2855DL1-33

LPCO2

Q1101 104

122 112 111 100 99 98 97 115 116

VR1101

105

VR1102

103

96

VCC33

LPCO1

TEMP F+H_G+H E+G_E+F VIN3RF VIN4RF VIN2RF VIN1RF VIN7 VIN8

3

Vout

1

Vin

VCC12 REG. IC1953 S-1135D12-A6 VCC12

1

VOUT

D

6 4

VIN ON/OFF

CDMPD

DVDMPD

RFINP

S1 HOME HOME

IC1951 TC7SZU04FU 2

1 3

VIN ON/OFF

65 S3

50

4

USB_CLOCK

12EJ

X1950 VDSENS

55

E 121

VD8

48MHz 109 113 114 117 118 119 120

VREFH VIN5 VIN6 VIN3 VIN4 VIN2 VIN1

F

AVH-X1600DVD/XNUC 5

6

7

8

35

1

D

2

3

4

SERVICE UNIT(MONITOR)

A

CN5401 46 | 51

R[0-5]

40 | 45

G[0-5]

34 | 39

B[0-5]

32 52 54 56 57 58 59

B

DIO LD HCLK STV2 OEV VCLK POL

COMDC Q5103

60

25

COMDC

G

LCD33

TEMPSENS THERMISTOR TH5201

4 6

VIN

LX1

CE

LX2 VFB

LCD33 REG. IC5102 MM3479A33P C 30

LCDPW

PWRVI

4 VDD 1 CE

VOUT

AMPOUT CPVCC 5

LCD33

CPPSW

LCD POWER IC5101 R1290K103A

A

CN1751

CPP

24 7 12 20 22

Q5106

21

ILMB

1 2 3 11 26

TPN33 PWRVI

CPPFB VREF DTC Q5101

29

23

LPSYNC

13

CPNFB RT

CPN

17 5 10 15

ILMB

19

D BLSYSC 10 BLEN 9 DIMMER 8 BLERR 7

T MTCHCK 16 MTCHDA 15 TPIRQN 14

E

REMIN 18 RST 19 KDT0 20 KDT1 21 22

Q5402

PWM_B Q5401

23 PWM_R

24

PWM_G

F

36

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

TFT LCD A

CN5001 30 | 35 36 | 41 42 | 47 DIO1 LOAD HCLK 33.3MHz STV2 OEV(Low) VCLK POL

Vcom

LCD

59 29 23 17 15 14 11

B

2 1

GRADATION VOLTAGE

AVDD

27 26

48 | 57

VR[1-10]

VDDG +18V VEEG-6V

6

C

8

DVDD 3.3V

LCD33

22 L/R (Hi) 28 XON (Hi) 10

CN5202 Anode

B

1 | 3

LCD BACKLIGHT DRIVER IC5201 BD81A04EFV-M 1 28 5 27 8 9 10

VCC CS

OUTL OVP LED1 LED2 LED3 LED4

SYNC EN PMW FAIL1 FAIL2

D

BACKLIGHT

20 17 13 14 15 16

K1 5 K2 6 K3 7 K4 8

TOCH PANEL CONTROLLER IC5301 AK4187VN 1 SCL 2 SDA 4 PENIRQN

XN YN YP

CN5301 XL 4 YB 3 YT 1

8 13 12

TOUCH PANEL

E

CN5402 REM 10 RST 9 KDT0 8 KDT1 3 LEDB

6

1 LEDR

LEDG

4

E

CN4801

5

TPN33

7

ILMB

2

AVH-X1600DVD/XNUC 5

6

F

7

8

37

1

E

2

4

SERVICE UNIT(KEYBOARD)

A

CN4801 2

3

REM

REMOTE CONTROL SENSOR IC4801 PNJ4833M 1

VO VCC

5

3

TPN33

KEY MATRIX

D

4 9

CN5402

3

B

6 7 8 10

KDT0 KDT1 RST

S4801, S4802, S4803, S4804, S4805, S4806, S4807, S4808, S4809

D4801

LEDB LEDG LEDR ILMB

C

D

E

F

38

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

5. DIAGNOSIS

5.1 OPERATIONAL FLOWCHART A

RESET

VDD50 : pin 24

VDD50=3.3V? Y

bsens : pin 110

bsens=L?

B

Y asens : pin 111

asens=L? Y

socstb : pin 37

socstb=H?

C

Y

Standby ASENBO : pin 100 ASENBO←H

DDCCLK : pin 65

DDCCLK←Clock Out (Frequency of 413.9 kHz)

D

VDCNT5 : pin 69 VDCNT5, VDCNT8←H VDCNT8 : pin 70 Starts Communication with Display microcomputer E

Source keys operate ↓ Source ON SYSPW : pin 66

SYSPW←H

F

AVH-X1600DVD/XNUC 5

6

7

8

39

1

2

3

4

5.2 INSPECTION METHOD OF PICKUP UNIT A

Disc to be used CD-DA : TCD-782 DVD-Video : TDV-582(GGV1025) Exact judgment cannot be performed if the disk to be used has a crack and dirt. Be careful of handling of a disk enough.

Execution method Refer to the following page for the details of the check 1 and the check 2. B

Replace the CRG chassis

START

PU Lighting? No Check1

Please perform the usual diagnosis.

RF level check

Yes

LD current check C

Check2 Is it OK?

No

Error rate check

Replace the CRG chassis

Yes

Is it OK? No Yes RF level check D

No

Yes

PICK UP cleaned?

No

Perform lens cleaning

Yes Replace the CRG chassis

Check2 Error rate check

Is it OK? No Yes

PICK UP cleaned?

No

Perform lens cleaning

Yes Replace the CRG chassis

E

Ckeck parts other than PICK UP

Finished

F

40

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

Check1 : LD current check Status: [Foucs closed] of TEST MODE No.

Disc

1

GGV1025

Check Point

Threshold

DVDLD1 - VCC5_PU

Remarks: LD current

120 - 780 (mV)

10 - 65 (mA)

DVDLD1

B

C

VCC5_PU

No.

Disc

2

TCD-782

Check Point CDLD1 - VCC5_PU

Threshold

Remarks: LD current

150 - 900 (mV)

10 - 60 (mA)

D

CDLD1

E

VCC5_PU

F

Notes: Please pay attention to the laser diode damage by static electricity. AVH-X1600DVD/XNUC 5

6

7

8

41

1

2

3

4

A

Check : RF level ASMAX value shows the value of RF level. Status: [Foucs closed] of TEST MODE No.

Check Point

Disc

1

GGV1025

8 digits value of ASMAX on display

more than 0000 0B00

2

TCD-782

8 digits value of ASMAX on display

more than 0000 0E00

B

Remarks

Threshold

C

Check2 : Error rate check Status: [Tracking Closed] of TEST MODE D

No.

Disc

Check Point

1

GGV1025

ID:40000

less than 1.000E-3

2

GGV1025

ID:200000

less than 1.000E-3

3

TCD-782

ID:HOME Position

Remarks

Threshold

less than 2.500E-3

E

F

42

AVH-X1600DVD/XNUC 1

2

3

4

5 NO

NO

NO

YES

YES Is the video circuit OK? Execute check 11.

YES Go to FE section check.

NO

YES Is AVCC5 voltage OK? Execute check 8.

Is the image in error?

YES

NO

Is the life of flash memory OK? Conduct check item 12.

Does the operation take time?

LS2 BACK END section flow

NO

NO

NO

6 Product repair

Replace the unit.

YES

The product is normal?(iPod attestation IC)

Go to the product check.

YES

Is the iPod circuit OK? Execute check 14.

YES

Is the iPod play in error?

NO

NO

NO

Replace the unit.

YES

Is the USB circuit OK? Execute check 14.

YES

Is 48 MHz OK? Execute check 13.

YES

Is the USB play in error?

NO

NO

NO

NO

AVH-X1600DVD/XNUC

7

END

YES

Normal?

NO

NO

Go to FE section check.

YES

Is VD8, VCC5 power supply voltage OK? Execute check 7.

YES

Is SDRAM IF OK? Execute check 6.

YES

Standby OK? Execute check 1. NO

NO

NO

8

YES END

NO

Go to FE related repair process.

7

Normal?

YES

Replace the unit.

YES

Is FE section normal?

NO

Go to FE section check.

YES

Is 27 MHz OK? Execute check 5.

YES

Is VSENS OK? Execute check 4.

YES

Reset OK? Execute check 3.

YES

Replace the unit.

*1) With service, even when exchange of a flash ROM is required, please replace core unit . (Since the key etc. are not written in in case of the flash simple substance)

NO

Is VDD5 (VCC33, VCC12) power supply voltage OK? Execute check 2.

6

Repair the defective part. *1)Note

Go to FE section check.

YES

Is the audio circuit OK? Execute check 10.

YES

Is DACCLK normal? Execute check 9.

YES

Is AVCC5 voltage OK? Execute check 8.

YES

Is the sound in error?

YES

Can the playback start?

START

5 8

5.3 DIAGNOSIS FLOWCHART A

B

C

D

E

F

43

1

2

3

4

Check 1: Standby OK? A

Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference. No. 1

Check point

Module No.

Specification value

Unit

STANBY - DGND1

ALL

VCC33 - 0.6 V or more V

Side A B

C

D

GNDD1

STANBY Fig 1.1: STANBY check point

E

F

44

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK? A

VDD5

IC1004 3.3 V output regulator

VCC33 (= 3.3V )

IC1401 IC1402 IC1480 IC1501

FLASH power supply (Data) FLASH power supply (Program) SDRAM power supply DV5 power supply

IC1953 1.2 V output Regulator

VCC12 (= 1.2V )

IC1501 DV5 power supply

Fig 2.1: Power supply configuration B

Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on. Use the “DGND1” test point at the reference. No. 1 2 3

Check point VDD5_1 - DGND1 VCC33_1 - DGND1 VCC12_1 - DGND1

Module No. ALL ALL ALL

Specification value 5.0 ± 0.4 3.3 ± 0.033 1.2 ± 0.015

Unit V V V C

Side A

VCC12 D

E

VCC33 VD5-1

DGND1 Fig 2.2: VDD5, VCC33, VCC12 voltage check points

F

AVH-X1600DVD/XNUC 5

6

7

8

45

1

2

3

4

Check 3: Reset OK? A

Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference. No.

Check point NRES - DGND1

1

B

Module No. ALL

Specification value Unit VCC33 × 0.7 or more V

Side A

C

D

NRES DGND1

Fig 3.1: RESET check point E

F

46

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 4: Is VSENS OK? A

CN1952 HOST I/F VSENS

R1004 R1007

VD8

IC1004 Regulator

VDD5

IC1501 DV5

VCC33 B

STANBY NRES

IC1953 1.2 V output Regulator

VCC12

Fig 4.1: Power supply configuration and VSENS

C

Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference. No.

Check point VSENS - DGND1

1

Module No. ALL

Specification value Unit 0.95 - 1.07 V VD8 = 8.0 ± 0.4 V

Side A

D

E

VSENS

F

DGND1 Fig 4.2: VSENS check point

AVH-X1600DVD/XNUC 5

6

7

8

47

1

2

3

4

Check 5: 27 MHz Normal? A

Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501). IC1501 DVD-LSI OSCO

X1501 27 MHz crystal

OSCI

VCC33

B

VCC12

Fig 5.1: Clock configuration

Turn the power on, and check with DGND being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components. No. 2

Check point

Module No.

Specification value

IC1501 156pin - DGND1

ALL

27 MHz ± 50 ppm

Unit ppm

C

Specification value

GND Fig 5.2: Clock specification value

Side A

D

E

DGND1 IC1501 156pin

F

Fig 5.3: 27 MHz check point

48

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 6: Is SDRAM I/F OK? A

In order to secure the MPEG stream data as the buffer, the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit. Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS. IC1480 SDRAM

MA0 - 11 MDQ0 - 15 MCK XWE(NWE) XCAS(NCAS) XRAS(NRAS) XCSM(NCSM) DQM0 DQM1 BA0 BA1

IC1501 DV5

B

Fig 6.1: SDRAM I/F

Check the conductivity at “check point 1” and “check point 2” without power. In case of NG, check the soldering and defective components throughout the “output t input” of the applicable section. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37

Signal name MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 MDQ0 MDQ1 MDQ2 MDQ3 MDQ4 MDQ5 MDQ6 MDQ7 MDQ8 MDQ9 MDQ10 MDQ11 MDQ12 MDQ13 MDQ14 MDQ15 MCK XWE XCAS XRAS XCSM DQM0 DQM1 BA0 BA1

Check point 1 IC1480 23pin IC1480 24pin IC1480 25pin IC1480 26pin IC1480 29pin IC1480 30pin IC1480 31pin IC1480 32pin IC1480 33pin IC1480 34pin IC1480 22pin IC1480 35pin IC1480 2pin IC1480 4pin IC1480 5pin IC1480 7pin IC1480 8pin IC1480 10pin IC1480 11pin IC1480 13pin IC1480 42pin IC1480 44pin IC1480 45pin IC1480 47pin IC1480 48pin IC1480 50pin IC1480 51pin IC1480 53pin IC1480 38pin IC1480 16pin IC1480 17pin IC1480 18pin IC1480 19pin IC1480 15pin IC1480 39pin IC1480 20pin IC1480 21pin

Check point 2 IC1501 201pin IC1501 203pin IC1501 207pin IC1501 209pin IC1501 208pin IC1501 206pin IC1501 202pin IC1501 200pin IC1501 198pin IC1501 194pin IC1501 199pin IC1501 192pin IC1501 160pin IC1501 162pin IC1501 164pin IC1501 168pin IC1501 170pin IC1501 172pin IC1501 176pin IC1501 178pin IC1501 177pin IC1501 175pin IC1501 171pin IC1501 169pin IC1501 167pin IC1501 163pin IC1501 161pin IC1501 159pin IC1501 183pin IC1501 181pin IC1501 188pin IC1501 189pin IC1501 190pin IC1501 179pin IC1501 180pin IC1501 193pin IC1501 197pin

AVH-X1600DVD/XNUC 5

6

7

C

Specification value 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 47 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5% 56 ohm ± 5%

D

E

F

8

49

1

2

3

4

Side A A

B

Check point 1 (IC1480) C

Check point 2 (IC1501) Fig 6.2: SDRAM I/F check point

D

E

F

50

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 7: Is VD8, VCC5 power supply voltage OK? A

VD8_1

F.E. driver system

VD8_2

Power supply for PU

VCC5 (= 5.0 V )

REG IC for VCC 5 V. Fig 7.1: Power supply configuration

B

Check the voltage at the “VD8_P, VD8_A and VCC5_1” test point while the power is on. Use the “PGND1 and AGND1” test point at the reference. No.

Check point VD8_P - PGND1 VD8_A - AGND1 VCC5_1 - AGND1

1 2 3

Module No. ALL ALL ALL

Specification value 8.0 ± 0.4 8.0 ± 0.4 5.0 ± 0.05

Unit V V V

C

Side A

D

AGND1

VCC5_1 E

VD8_A

PGND1

VD8_P

Fig 7.2: VD8, VCC5 voltage check points F

AVH-X1600DVD/XNUC 5

6

7

8

51

1

2

3

4

Check 8: Is AVCC5 voltage OK? A

IC1003 REG IC for AVCC 5 V.

VD8

AVCC5 (= 5.0 V )

IC1801 Audio-DAC

Fig 8.1: Power supply configuration

Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus. Check with PGND_3 and GNDAU1 being the reference.

B

No.

Check point VD8_A - PGND_3 AVCC5 - GNDAU1

1 2

Module No. ALL ALL

Specification value 8.0 ± 0.4 5.0 ± 0.05

Unit V V

Side A

C

PGND3

D

GNDAU1 AVCC5

VD8_A E

Fig 8.2: VD8, AVCC5 voltage check points

F

52

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 9: Is DACCLK normal? DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501).

A

IC1501 X1501 27MHz crystal

DVD-LSI

DACCLK

VCC33

IC1801 Audio-DAC

VCC12

Fig 9.1: Clock configuration DVD: DVD-REF-A1 TITLE 1 CD: Playback a normal CDDA. Common to all DVD-V compatible modules. Check with DGND being the reference. In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and defective components. Check point 1 (stylus) Media DACCK DVD DACCK CD

No. 1 2

B

Specification value 1 Specification value 2 Specification value 3 2.0 V - VCC33V DGND - 0.8 V 36.8640 MHz ± 300 ppm 2.0 V - VCC33V DGND - 0.8 V 33.8688 MHz ± 300 ppm

Specification value 1

Specification value 2

C

Specification value 3

GND Fig 9.2: Clock specification value Side A

D

E

Check point 2 (IC1501 148 pin)

F

DGND4

Fig 9.3: DACCLK check point AVH-X1600DVD/XNUC 5

6

7

8

53

1

2

3

4

Check 10: Is the audio circuit OK? The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1952). Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F. The digital audio signal (IECOUT), output from DVD-LSI (IC1501).

A

IC1501

IECOUT

DVD-LSI

LRCK ADOUT SRCK

CN1952 HOST I/F LO

IC1801 Audio-DAC

RO

B

GNDAU Fig 10.1: Audio circuit Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB), and check with DGND1 being the reference. In case of NG, check the applicable line, periphery of major components as described in the above drawing, soldering of the peripheral components and defective components. No. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform 1 ADOUT VCC33V - 0.6 V or higher 0.4 V or lower Waveform 1 2 SRCK VCC33V - 0.6 V or higher 0.4 V or lower Waveform 2 3 LRCK VCC33V - 0.6 V or higher 0.4 V or lower Waveform 3

C

Specification value 1

Specification value 2

GND Fig 10.2: Serial 3 lines specification value Side A D

E

DGND1 151pin ADOUT signal 150pin LRCK signal

F

149pin SRCK signal Fig 10.3: Serial 3 lines check points 54

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference. 47 kohm

47 kohm

LO

No.

GNDAU1

Check point 1 (stylus) LO RO

4 5

RO

Specification value (rms) 1400 ± 150 mV 1400 ± 150 mV

Reference waveform Waveform 4 Waveform 4

B

Specification value is the root-mean-square value (rms).

Fig 10.4: Analog audio out (LO, RO) specification value. C

Side A

D

E

GNDAU3

RO

LO

Fig 10.5: Analog audio out check point

F

AVH-X1600DVD/XNUC 5

6

7

8

55

1

2

3

4

Check with DGND1 being the reference.

A

No. 6

Check point 1 (stylus) Specification value 1 Specification value 2 IEC VCC33V - 0.6 V or higher 0.4 V or lower

Specification value 1

Reference waveform Waveform 5

Specification value 2

B

10.6: Digital audio signal (IECOUT) specification value

Side A

C

D

E

IEC

DGND1

Fig 10.7: Digital audio signal (IECOUT) check point

F

56

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 11: Is the video circuit OK? A

Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the HOST I/F (CN1952) via a buffer circuit. CN1952 HOST I/F IC1501 DVD_LSI Video DAC section

Composite

COMPOSITE

Fig 11.1: Video circuit

B

Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with an oscilloscope with GNDV (stylus) being the reference. Set the trigger mode to “TV trigger” and the trigger line to “150 line”. No.

Check point 1 (stylus) COMPOSITE

1

Specification value 1000 mVpp ± 5%

Reference waveform Waveform 6

In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components. PEAK COMPOSITE signal

C

Reference value

Color burst Pedestal level BOTTOM Horizontal sync signal Fig 11.2: Waveform for the case of composite white 100% output Side A

D

E

F

COMPOSITE

GNDV2

Fig 11.3: VIDEO signal check point AVH-X1600DVD/XNUC 5

6

7

8

57

1

2

3

4

Check 12:How to judge whether the flash memory has reached its life or not. A

If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory has reached its life. Make judgment regarding the flash memory life by looking at the display of the LD power on time mode. 1. Let the LD energizing time displayed. (Refer to the LD power on time mode for the method of displaying the LD energizing time.) 2. If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life.

Example:

B

0E000BB8

C

D

E

F

58

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Check 13: 48 MHz Normal? A

CLOCK of a USB circuit is made using the 48 MHz master crystal oscillator (X1950). IC1501 DVD-LSI X1950 48MHz crystal

USB_CLOCK

B

VCC33

Fig 13.1: Clock configuration

VCC12

Turn the power on, and check with DGND1 being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components. No.

Check point IC1501 50pin - DGND1

2

Module No. ALL

Specification value 48 MHz ± 200 ppm

Unit ppm C

Specification value

GND Fig 13.2: Clock specification value

D

Side A

48 MHz

E

DGND1 F

Fig 13.3: 48 MHz check point AVH-X1600DVD/XNUC 5

6

7

8

59

1

2

3

4

Check 14: Is USB Circuit OK? The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD. USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK) in addition to D+ and D-.

A

CN1952 HOST I/F IC1501

CP_RESET

DVD-LSI

I2C_SDA I2C_SCL D+ DDGND

B

Fig. 14-1: USB Circuit

1. USB Memory: Play a song from USB memory and check D+ and D- with the DGND1 standards. 2. iPod: Connect iPod and check CP_RESET, SDATA and SCLOCK with the DGND1 standards until the Pioneer log appears. When iPod Touch or iPhone is connected, the logo is not displayed but only a check mark is displayed. Play a song from iPod and check D+/D- with the DGND1 standards. When it does not conform to the standards, check appropriate line, main parts shown in the above figure,soldering of peripheral parts and malfunctions in parts. No. 1 2 3 4 5

C

Checking spot (stylus) CP_RESET SDATA SCLOCK D+ DStandard value 1

Standard value 2 Standard value 1 VCC33*0.7 or more VCC33*0.7 or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod VCC33*0.7 or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod VCC33*0.7 or more VCC33*0.3 or less VCC33*0.7 or more VCC33*0.3 or less

Standard value 2

Fig.14.2: USB Circuit Communication Wave

D

Side A

E

SDATA CP_RESET

F

D-

60

D+

SCLOCK

DGND1

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

AUDIO CH1 : LO CH2 : RO

CH1 : ADOUT3 Reference voltage:DGND2

A

Reference voltage:GNDAU2

1 V/div. 5 μsec/div

2 V/div. 500 μsec/div

Gt

Gt

Gt

B

Waveform 1

Waveform 4

CH1 : IECOUT

CH1 : SRCK Reference voltage:DGND2

Reference voltage:DGND2

1 V/div. 1 μsec/div

1 V/div. 500 nsec/div

Gt

Gt

Waveform 2

C

Waveform 5

CH1 : LRCK Reference voltage:DGND2

1 V/div. 5 μsec/div

D

Gt

Waveform 3

VIDEO E

[WHITE 100IRE] CH1 : COMPO Reference voltage:GNDV1

200 mV/div. 10 μsec/div

GNDV F

Waveform 6

AVH-X1600DVD/XNUC 5

6

7

8

61

1

2

3

4

USB, IPOD USB memory D+/D- communication waveform It checks with an oscilloscope. Reference voltage : DGND 1 ms/div 2 V/div

USB memory D+/D- communication waveform It checks with an oscilloscope. 200 ns/div 2 V/div Reference voltage : DGND

D-

D-

DGND

DGND

A

DGND

DGND D+

D+

B

Waveform 8

Waveform 7 IPOD D+/D- communication waveform It checks with an oscilloscope. Reference voltage : DGND 1 ms/div 2 V/div

C

IPOD D+/D- communication waveform It checks with an oscilloscope. Reference voltage : DGND 200 ns/div 2 V/div

D-

D-

DGND

DGND

DGND

DGND

D+

D+

Waveform 9

Waveform 10

IPOD CP_RESET signal A relation with NRES, At the time of RESET release (It checks with an oscilloscope. ) Reference voltage : DGND 20 ms/div 1 V/div

IPOD SDA signal It checks by LECORY. Reference voltage : DGND

2 ms/div 1 V/div

CP_RESET

D

DGND

SDA

NRES

DGND DGND

Waveform 12

Waveform 11

IPOD SCL signal It checks by LECORY. Reference voltage : DGND

E

500 μs/div 1 V/div

SCL DGND F

Waveform 13

62

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

5.4 ERROR CODE LIST UART

Error status

OSD *1

Media Error

Meaning

*2

Disc

Generation source USB USB (iPod) (MSC)

Method of reset ACC Off/On

Source Off/On

Eject/ With no device

Play Key

UNPLAYABLE DISC

00h

A disc containing the unplayable format only

X

-

-

X

X

X

-

INCOMPATIBLE DEVICE

00h

USB device that doesn't correspond

-

X

X

X

X

X

-

UNPLAYABLE FILE

00h

USB device of format alone that cannot be reproduced

-

X

-

X

X

X

-

Open Read Error Focus Error(Focus Error in mechanism set up)

(No display) ERROR-02-99

10h 20h

Door open error Transfer start error

X X

-

-

* X

* X

* X

* X

ERROR-02-90

21h

Focus error

X

-

-

X

X

X

X

Surface Error

ERROR-02-9E

22h

Focus error during set up (A focus has never been achieved with that disc.)

X

-

-

-

-

X

-

Address not found (Invalid Track)

ERROR-02-80

23h

Address not found.

X

-

-

X

X

X

X

Spindle Lock

ERROR-02-91

24h

Spindle lock NG(the disc cannot rotate)

X

-

-

X

X

X

X

Carriage HOME

ERROR-02-92

25h

Carriage home NG (The pick up tries to return to carriage home, but it cannot go back and stopped.)

X

-

-

X

X

X

X

ID/SUBCODE Read Error AV CHIP decode Error AV CHIP Recovery NG Error of PLAY BACK Mode Status Disc Data Error Temp Error(In Case of High Temperature) No Disc (including Disc loading and ejecting)

ERROR-02-94

26h

ERROR-02-9A ERROR-02-9B

2Ah 2Bh

ERROR-02-9C

2Ch

ERROR-02-9D

2Dh

THERMAL PROTECTION IN MOTION

30h

ID/SUBCODE Read Error (ID/SUBCODE cannot be read due to scratch or stain.) AV CHIP decode NG(AV chip cannot be decoded.) AV CHIP recovery NG Playback state error (An error due to software bug.) Disc Data NG High temperature(Playback is stopped because the pick up temperature is 89 C or higher.)

40h

Disc has not been inserted. (Including Load in process or Eject in process.)

(No display)

Loading_Mecha Error

(No display)

50h

Communication fault attesting iPod iPod authentication data is abnormal iPod attestation retrying failure iPod attestation time out Error when iPod is connected/ It is generated STALL by the USB communication Error setting iPod Demand timeout when initial is communicated Protocol version non-correspondence Timeout when protocol version is judged

ERROR-02-60 ERROR-02-61 ERROR-02-62 ERROR-02-63

60h 61h 62h 63h

ERROR-02-64

64h

ERROR-02-65

65h

ERROR-02-66

66h

ERROR-02-67

67h

ERROR-02-68

68h

No songs error

(No display) ERROR-02-6A

Loading mechanism error (The disc cannot be clamped.) Communication fault attesting iPod iPod authentication data is abnormal iPod attestation retrying failure iPod attestation time out Error when iPod is connected/ It is generated STALL by the USB communication

X

-

-

X

X

X

X

X X

X X

X -

X X

X X

X X

X X

X

X

-

X

X

X

X

X

-

-

X

X

X

X

X

-

-

X

-

-

-

X

-

-

*

*

*

*

X

X *11

X *11

X

-

X *12

-

X *13 X *13 X *13 X *13

-

X X X X

X X X X

-

X *14 X *14 X *14 X *14

-

-

-

X

X

-

X

-

-

-

X

X

-

X

-

-

-

X

X

-

X

-

-

-

X

X

-

X

-

-

-

X

X

-

X

-

69h

Error setting iPod Demand timeout when initial is communicated Protocol version non-correspondence (It is necessary to Version Up the iPod by iTunes.) Timeout when protocol version is judged iPod does not have music. (It is necessary to put music into iPod by iTunes)

-

-

X

X

-

X

-

6Ah

iPod control forwarding / Intarapta forwarding error

-

-

X

X

-

X

-

ERROR-02-6B

6Bh

Demand timeout iPod's reproducing

-

-

X

X

-

X

-

ERROR-02-6C

6Ch

Remote switch error

-

-

X

X

-

X

-

ERROR-02-6D

6Dh

Remote switch demand timeout

-

-

X

X

-

X

-

ERROR-02-6E

6Eh

Demand timeout to an iPodApl(Pandora)

-

-

X

X

-

X

-

PROTECTED DISC

70h

DRM error (All music cannot be played back due to DRM.)

X

-

-

X

X

X

-

NO ACCESSIBLE DATA AVAILABLE

70h

Region code Error

DIFFERENT REGION DISC

CPRM*7 Key Error *8

iPod control forwarding/ Intarapta forwarding error Demand timeout iPod's reproducing Remote switch error Remote switch demand timeout Demand timeout to an iPodApl(Pandora) DRM Error

-

X

-

X

X

X

-

90h

DRM error (All music cannot be played back due to DRM.) Region code NG (Unable to be played back due to incorrect mechanism region.)

X

-

-

X

X

X

-

UNPLAYABLE DISC

93h

Key Error for playback

X

-

-

X

-

X

-

REQUEST Error Failure in issuing read command (chip dependent)

ERROR-02-A0

A0h

REQUEST_error

X

-

-

X

X

X

X

ERROR-02-A1

A1h

Failure in issuing the read command

X

-

-

X

X

X

X

Adjustment of L0 is NG. Adjustment of L1 is NG. LD system NG Gain adjustment system NG. Gain determining system NG. Servo initial setting related items NG. Disc is not clamped yet. Tracking system NG. Media setting system NG. Focus Error Error of PLAY BACK Mode Status Error of PLAY BACK Mode Status DivX DRM Inofrmation Update Error *10 Error when MCS is connected/ It is generated STALL by the USB communication CBW and CSW forwarding error Audio class band securing failure Audio class FS setting failure Undefined Error

ERROR-02-A2 ERROR-02-A3 ERROR-02-A4 ERROR-02-A5 ERROR-02-A6 ERROR-02-A7 ERROR-02-A8 ERROR-02-A9 ERROR-02-AA ERROR-02-AB

A2h A3h A4h A5h A6h A7h A8h A9h AAh ABh

L0 adjustment is NG. L1 adjustment is NG. LD system NG Gain adjustment system NG. Gain determining system NG. Servo initial setting related items NG. Disc is not clamped yet. Tracking system NG Media setting system NG JUMP over layers NG

X X X X X X X X X X

-

-

X X X X X X X X X X

X X X X X X X X X X

X X X X X X X X X X

X X X X X X X X X X

ERROR-02-B0

B0h

Navigation command error

X

-

-

X

X

X

X

ERROR-02-B1

B1h

Retry over

X

-

-

X

X

X

X

ERROR-02-C1

C1h

DivX DRM inofrmation update error

X

-

-

X

-

-

-

ERROR-02-D0

D0h

Error when MCS is connected / It is generated STALL by the USB communication

-

X

-

-

-

X

-

ERROR-02-D1 ERROR-02-D8 ERROR-02-D9 ERROR-FF-FF

D1h D8h D9h FFh

CBW and CSW forwarding error Audio class band securing failure Audio class FS setting failure Undefined error

X

X -

X X -

X X X

X

X X X X

X

X : Cancel the error by operation.

- : Error is not cancelled by operation.

A

B

C

D

E

* : No setting

*1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower row is for the Touch Panel model and Full GUI (English version). *2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits. *7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card. *8 DVD-VR model only. *10 This occurs when the DRM information update notice is sent from the DVD mecha but no DRM information update response is returned. *11 Although it is USB source, it notifies as an error of DISC source. *12 Although it is USB source, iIt cancels only by Disc eject. *13 Although it is DISC source, it notifies as an error of USB source. *14 Although it is DISC source, It cancels only without Device.

AVH-X1600DVD/XNUC 5

6

7

8

F

63

1

2

3

4

Error messages A

Common AMP Error

This DivX rental has expired.

Protect

This unit fails to operate or the speaker connection is incorrect; the protective circuit is activated. Check the speaker connection. If the message fails to disappear even after the engine is switched off/on, contact your dealer or an authorized Pioneer Service Station for assistance.

The inserted disc contains expired DivX VOD content. Select a file that can be played.

All the files on the connected USB portable audio player/USB memory are protected by Windows Media DRM 9/10. Transfer audio files not protected by Windows Media DRM 9/10 to the USB portable audio player/USB memory and connect.

Video resolution not supported The inserted disc contains a high definition DivX/ MPEG-1/MPEG-2/MPEG-4 file. Select a file that can be played.

Incompatible USB

Tuner B

It is not possible to write it in the flash. No Data Provided This unit cannot receive artist name/song title information. Move to the desirable location with good reception.

This unit’s flash memory used as the temporary storage area is full. Select a file that can be played.

No Data

Your device is not authorized to play this DivX protected video.

This unit cannot receive program service name information. Move to the desirable location with good reception.

This unit’s DivX registration code has not been authorized by the DivX VOD contents provider. Register this unit to the DivX VOD contents provider.

Channel Locked

C

Locked by the radio Parental Control feature. Release the channel lock.

DVD

Unplayable File This type of file cannot be played on this unit. Select a file that can be played. Format Read

Different Region Disc The disc does not have the same region number as this unit. Replace the DVD with one bearing the correct region number.

Sometimes there is a delay between the start of playback and when you start to hear any sound. Wait until the message disappears and you hear sound.

The disc is dirty. Clean the disc.

D

The disc is scratched. Replace the disc. The disc is loaded upside down. Check that the disc is loaded correctly. There is an electrical or mechanical error. Press RESET. Unplayable Disc This type of disc cannot be played on this unit. Replace the disc with one that can be played on this unit. The inserted disc does not contain any playable files. Replace the disc.

E

Protect All the files on the inserted disc are embedded with DRM. Replace the disc. Skipped The inserted disc contains DRM protected files. Play an audio file not embedded with Windows MediaTM DRM 9/10. TEMP The temperature of the unit is outside the normal operating range. Wait until the unit returns to a temperature within the normal operating limits.

F

64

The USB device is not formatted with FAT12, FAT16 or FAT32. The connected USB device should be formatted with FAT12, FAT16 or FAT32. Check USB The USB connector or USB cable has shortcircuited. Check that the USB connector or USB cable is not caught in something or damaged. The connected USB storage device consumes more than maximum allowable current. Disconnect the USB portable audio player/USB memory and do not use it. Turn the ignition switch to OFF, then to ACC or ON and then connect a compliant USB portable audio player/ USB memory. Error-02-9X/-DX Communication failed. Perform one of the following operations. – Turn the ignition switch OFF and back ON. – Disconnect the USB portable audio player/USB memory. – Change to a different source. Then, return to the USB portable audio player/ USB memory.

Video frame rate not supported Error-02-XX/FF-FF

The connected USB device is not supported by this unit. Connect a USB portable audio player or USB memory that is USB Mass Storage Class compliant.

DivX file’s frame rate is more than 30 fps. Select a file that can be played. Audio Format not supported This type of file is not supported on this unit. Select a file that can be played.

This DivX rental has expired. The inserted external storage device contains expired DivX VOD content. Select a file that can be played.

External storage device (USB) Unplayable File This type of file cannot be played on this unit. Select a file that can be played.

Video resolution not supported

There are no songs. Transfer the audio files to the USB portable audio player/USB memory and connect. Security for the connected USB memory is enabled. Follow the USB memory instructions to disable security. Format Read Sometimes there is a delay between the start of playback and when you start to hear any sound. Wait until the message disappears and you hear sound. Skipped The connected USB portable audio player/USB memory contains WMA files that are protected by Windows Media TM DRM 9/10. Play an audio file not embedded with Windows MediaTM DRM 9/10.

The inserted external storage device contains a high definition DivX/MPEG-1/MPEG-2/MPEG-4 file. Select a file that can be played. It is not possible to write it in the flash. This unit’s flash memory used as the temporary storage area is full. Select a file that can be played. Your device is not authorized to play this DivX protected video. This unit’s DivX registration code has not been authorized by the DivX VOD contents provider. Register this unit to the DivX VOD contents provider. Format Read Sometimes there is a delay between the start of playback and when you start to hear any sound. Wait until the message disappears and you hear sound.

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A Communication error occured. Please reconnect your device.

Video frame rate not supported

Error-8D

DivX file’s frame rate is more than 30 fps. Select a file that can be played.

Built-in FLASH ROM encountered an error. Turn the ignition OFF or ON.

Audio Format not supported

Already stored

This type of file is not supported on this unit. Select a file that can be played.

This tag information is already stored in memory. Tag information can only be saved once for any given song. Tag information cannot be saved for the same song more than once.

Creating the Database has failed. The mode was switched to video or JPEG image display while the database was being created. Create the database again.

Communication failed. Disconnect the cable from the iPod. Once the iPod’s main menu is displayed, reconnect the iPod and reset it.

Format Read Sometimes there is a delay between the start of playback and when you start to hear any sound. Wait until the message disappears and you hear sound. Error-02-6X/-9X/-DX

iPod failure. Disconnect the cable from the iPod. Once the iPod’s main menu is displayed, reconnect the iPod and reset it.

Unable to save Bookmark. Try again later.

Error-02-67 The iPod firmware version is old. Update the iPod version. Stop There are no songs. Transfer songs to the iPod. There are no songs in the current list. Select a list that contains songs. Not Found No related songs. Transfer songs to the iPod.

Bluetooth connection failed. Follow the instructions that appear on the screen. Disconnected. Press “ Connect ” to reconnect the device.

The Pandora application has not started running yet. Start up the Pandora application from your iPhone. Unable to save thumb rating. Try again later. Unable to save thumb rating. Try again later.

Memory used for tag information on the iPod is full. Sync the iPod with iTunes and clean up the tagged playlist. Memory full. Tags not stored. Connect iPod. This unit’s flash memory used as the temporary storage area is full. The tag information on this unit is transferred to the iPod automatically when an iPod is connected. Tag transfer failed. Reconnect your iPod. This unit’s tag information cannot transfer to the iPod. Check the iPod and try again.

C

The application list could not be read out. Failed to load the application list. Disconnect the cable from the smartphone, and then connect the smartphone again after a few seconds. Turn the ignition switch OFF and then to ACC or ON. If the error message is still displayed after performing the above action, reset the smartphone. If the error message is still displayed after performing the above action, please contact your dealer or an authorized Pioneer Service Station.

Unable to save Bookmark. Try again later. Pandora system maintenance. Try again later. Pandora system is undergoing maintenance. Try again later. Skip limit reached. Skip limit reached. Do not exceed the skip limit. This version of the Pandora Application is not supported.

There is no supported application on your MirrorLink device.

This version of the Pandora application is not supported. Connect an iPhone that has a compatible version of the Pandora application installed. Check Device Device error message displayed in the Pandora application. Please check your iPhone. Pandora is unable to play music. Please see your Device.

Communication error occurred.

Please create station. Application on Device.

There was a communication error. Disconnect the cable from the smartphone, and then connect the smartphone again after a few seconds.

No station found. Create a station in the Pandora application on your iPhone.

D

No supported applications can be found. Disconnect the cable from the smartphone, and then connect the smartphone again after a few seconds. Turn the ignition switch OFF and then to ACC or ON. If the error message is still displayed after performing the above action, reset the smartphone. If the error message is still displayed after performing the above action, please contact your dealer or an authorized Pioneer Service Station.

Unable to play music from Pandora. Please check your iPhone.

E

Turn the ignition switch OFF and then to ACC or ON. If the error message is still displayed after performing the above action, reset the smartphone. If the error message is still displayed after performing the above action, please contact your dealer or an authorized Pioneer Service Station.

No Active Station No station selected. Select a station.

Tag store failed.

Bluetooth connection lost. Follow the instructions that appear on the screen.

Mirror Link

iTunes tagging (UC, EW5) iPod full. Tags not transferred.

B

Connection failed. Press “Connect ” to retry.

Start up the Pandora Application from your Device.

Communication failed. Disconnect the cable from the iPod. Once the iPod’s main menu is displayed, reconnect the iPod and reset it.

Device has not been registered. Go to “ Bluetooth Connection Menu” to register. No Bluetooth device found. Follow the instructions that appear on the screen.

Pandora R (UC) Error-19

iPod

If there is no ACK after 10 attempted retries at 750 ms, the accessory should assume that communication is interrupted and disconnect from PandoraLink. Please reconnect your iPhone and try again.

Tag information cannot be stored in this unit. Try again.

F

AVH-X1600DVD/XNUC 5

6

7

8

65

1

2

3

4

A

Understanding auto EQ error messages

Launching the application failed. Failed to launch the application. Disconnect the cable from the smartphone, and then connect the smartphone again after a few seconds. Turn the ignition switch OFF and then to ACC or ON. If the error message is still displayed after performing the above action, reset the smartphone. If the error message is still displayed after performing the above action, please contact your dealer or an authorized Pioneer Service Station.

B

Please connect the microphone for measurement. When finished, please push HOME key. The microphone is not connected. Plug the optional microphone securely into the jack. Error. Please check xxxx speaker. The microphone cannot pick up the measuring tone of a speaker. Confirm that the speakers are connected correctly. Correct the input level setting of the power amp connected to the speakers. Plug the microphone securely into the jack.

USB connection was temporarily disabled for device protection. Do not connect this USB device to the unit. To restart USB, restart the unit.

Error. Please check noise. The surrounding noise level is too high. Stop your car in a place that is quiet, and switch off the engine, air conditioner and heater. Set the microphone correctly.

There is an over current error. Do not use this USB storage device. Turn the ignition switch OFF and then to ACC or ON. If the error message is still displayed after performing the above action, please contact your dealer or an authorized Pioneer Service Station.

Error. Please check battery. Power is not being supplied from the battery to this unit. Connect the battery correctly. Check the battery voltage.

C

D

E

F

66

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

5.5 CONNECTOR FUNCTION DESCRIPTION FM/AM ANTENNA INPUT

AUDIO INPUT

A

USB IF

B

C

REARVIEW FRONT CAMERA INPUT REAR SUBWOOFER PRE-OUT

AUX INPUT

REAR VIDEO WIRED MONITOR INPUT REMOTE VIDEO CONTROL OUTPUT

D

POWER SUPPLY

NAVI INTERFACE 26

2 16 14 12 10 8 6 4 2 15 13 11 9 7 5 3 1

1 : CCR 2 : CCG 3 : CCB 4 : CSYNC 5 : GNDSIG 6 : HSYNC 7 : GNDD 8 : VSYNC 9 : ASENBO

9. P. BRAKE 10. MUTE 11. B.REM 12. ILM 13. BGSENS 14. ACC 15. GND 16. B.UP

1. FR2. RR3. FR+ 4. RR+ 5. FL6. RL7. FL+ 8. RL+

25

1

10 : CCAUL 11 : CCAUR 12 : GNDAU 13 : ONSEI+ 14 : ONSEI15 : IPSDA 16 : IPSCL 17 : NC 18 : NC (VCLK)

19 : GNDD (DSEN) 20 : TVON 21 : GUIDE ON 22 : MONON 23 : IP5V 24 : SYS_TO_NAVI 25 : NAVI_TO SYS 26 : GNDD

E

F

AVH-X1600DVD/XNUC 5

6

7

8

67

1

2

3

4

5.6 EEPROM OPERATION EXPLANATION FOR iPhone 5 A

Operation Description of EEPROM for iPhone 5 The operation of EEPROM that provides a video output setting value to the iPhone 5 upon connection to the iPhone 5 is described below. 2013 AVH models 2012 AVH models (AVH-X1600DVD, X2600BT, X3600***, (AVH-X1500DVD, X2500BT, X3500***, X4600DVD, X5600BT series) X4500DVD, X5500BT series) EEPROM embedded in the product

IC3661 EEP ROM

B

EEPROM embedded in the cable

EEP ROM

Changed C

Lightning to VGA Adapter (Apple Inc. products) (sold separately)

D

Lightning to VGA Adapter (Apple Inc. products) (sold separately)

iPhone 5

iPhone 5

E

Operation flow of 2013 AVH models after connecting to the iPhone 5

EEPROM [IC3661]

iPhone 5 Supplies 5V to IC3661 of the product

Turned on upon reception of 5V from the iPhone 5 Initial communication

Initial communication

Provides a video output setting value to the iPhone 5

F

68

Outputs a video signal to the product upon reception of the video output setting value

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

6. SERVICE MODE

6.1 MONITOR TEST MODE MONITOR TEST MODE MENU SCREEN

A

Method for Mode IN While pressing [Mute] + [Reverse] key, restart the system.

Display specification

B

Operational description Selection cursor up movement Selection cursor down movement Menu enter

Remote controller key Up Down Band C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

69

1

2

3

4

3

4

1. Version Information Method for Mode IN

A

While pressing [Mute] + [Reverse] key, restart the system. Choose “1. Version Information” among the Monitor Test Menu screen.

Display specification Page: 1

B

When Navi is connected : Connect When Navi is not connected : <EEPRM> When set value initialization is performed normally : Init OK When set value initialization is not performed normally : <Eject Lock> When Eject Lock is on : ON When Eject Lock is canceled : OFF

C

Operational description Return to test mode menu Page up Page down

D

Remote controller key RETURN NEXT PREV

Page: 2

Page: 3

Page: 4

Page: 5

E

F

70

AVH-X1600DVD/XNUC 1

2

5

6

7

8

2. Touch Panel Test Method for Mode IN

A

While pressing [Mute] + [Reverse] key, restart the system. Choose “2. Touch Panel Test” among the Monitor Test Menu screen.

Display specification Top menu

B

Condition that the mark meaning adjustment is completed, (*) is lit (the mark is lit when any of one condition is satisfied) Outermost circle check -1 When “Outermost circle check of line calibration-1” is finished normally When “Outermost circle check of line calibration-2” is finished normally -> Since “Outermost circle check of line calibration-2” includes “Outermost circle check of line calibration-1.” Outermost circle check -2 When “Outermost circle check of line calibration-2” is finished normally Calibration check When “Calibration check of line calibration” is finished normally

C

Condition that the mark meaning adjustment is completed, (*) is extinguished (the mark is extinguished when any of one condition is satisfied) Outermost circle check -1 When “conditions that the mark is lit” are not satisfied When “Data Initialize is executed” When “EEPROM initialize is executed” Outermost circle check -2 When “conditions that the mark is lit” are not satisfied When “Outermost circle check of line calibration-1” is finished abnormally -> Since “Outermost circle check of line calibration-2” includes “Outermost circle check of line calibration-1.” When “Data Initialize is executed” When “EEPROM initialize is executed” Calibration check When “conditions that the mark is lit” are not satisfied When “Data Initialize is executed” When “EEPROM initialize is executed” Operational description Return to test mode menu Selection cursor up movement Selection cursor down movement Menu enter

D

E

Remote controller key RETURN Up Down Band

F

AVH-X1600DVD/XNUC 5

6

7

8

71

1

2

3

4

1. Effective Area Calibration - 1 Outermost circle check screen

A

First point

Second point

B

Operational description Check is interrupted

Remote controller key Band

Outermost circle check result screen Finished normally

Finished abnormally

C

Operational description Check is finished

D

Remote controller key Band

2. Effective Area Calibration - 2 Outermost circle check screen First point

Second point

E

F

72

AVH-X1600DVD/XNUC 1

2

3

4

5

6

3rd point

7

8

4th point A

Operational description Check is interrupted

Remote controller key Band

B

Outermost circle check result screen Finished normally

Finished abnormally

C

Operational description Check is finished

Remote controller key Band

3. 16 Point Calibration

D

Calibration check screen

E

Touch the cursor [+] displayed on the screen. By touching it correctly, it disappears and another cursor appears. By repeating this action 16 times, obtain calibration value of each [+]. When touching the last 17th cursor, calibration values at 16 points and information of normal finish in 17 bytes are written in EEPROM and the screen returns to TOP menu by pressing a key.

F

AVH-X1600DVD/XNUC 5

6

7

8

73

1

2

3

4

A

Operational description Return to top menu

B

Remote controller key Band

Calibration check result screen

C

Operational description Return to top menu

Remote controller key Band

4. Touch Panel Coordinates Test D

[+] is displayed at a touched place. (Two [+] are displayed by touching two places.)

E

Operational description Return to top menu

Remote controller key RETURN

F

74

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

5. Calibration Test Calibration confirmation screen

A

B

Touch the cursor [+] displayed on the screen. By touching it correctly, it disappears and another cursor appears. Otherwise, the cursor is displayed in red. Repeating this action for 4 points and by pressing the last 4th point, “O.K.” is displayed.

C

Operational description Return to top menu

Remote controller key RETURN

Calibration confirmation result screen D

E

Operational description Return to top menu

Remote controller key RETURN

F

AVH-X1600DVD/XNUC 5

6

7

8

75

1

2

3

4

6. Data Initialize A

B

Condition that the mark meaning adjustment is completed, (*) is lit (the mark is lit when any of one condition is satisfied) Outermost circle check When “Outermost circle check of line calibration-1” is finished normally When “Outermost circle check of line calibration-2” is finished normally Calibration check When “Calibration check of line calibration” is finished normally Outermost circle check of user calibration When “Outermost circle check of user calibration” is finished normally User calibration check When “Calibration check of user calibration” is finished normally

C

Condition that the mark meaning adjustment is completed, (*) is extinguished (the mark is extinguished when any of one condition is satisfied) Outermost circle check When “conditions that the mark is lit” are not satisfied When “Data Initialize is executed” When “EEPROM initialize is executed” Calibration check When “conditions that the mark is lit” are not satisfied When “Data Initialize is executed” When “EEPROM initialize is executed” Outermost circle check of user calibration When “conditions that the mark is lit” are not satisfied When “Data initialize is executed” When “EEPROM initialize is executed” When Outermost circle check of line calibration or 16-point adjustment is finished normally after Outermost circle check of user calibration is finished normally User calibration check When “conditions that the mark is lit” are not satisfied When “Data initialize is executed” When “EEPROM initialize is executed” When Outermost circle check of line calibration or 16-point adjustment is finished normally after 16-point adjustment of user calibration is finished normally

D

E

Operational description Return to test mode menu Selection cursor up movement Selection cursor down movement Menu enter

Remote controller key RETURN Up Down Band

F

76

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

3. EEPROM Adjustment Method for Mode IN

A

Choose “3. EEPROM Adjustment” among the Monitor Test Menu screen.

Display specification Top menu

B

Operational description Return to test mode menu Selection cursor up movement Selection cursor down movement Menu enter

Remote controller key RETURN Up Down Band C

1. Flicker Adjustment 1 dot stripe image of black and gray (50% white) will appear. Adjust the number to minimize the flicker. < Flicker Adjustment >

Flicker adjustment image (lattice) D

COM DC

Operational description Return to top menu -1 +1

Remote controller key RETURN REV FF E

Following items in EEPROM Adjustment menu are not used on service.

F

AVH-X1600DVD/XNUC 5

6

7

8

77

1

2

3

4

3

4

4. EEPROM Initialize Method for Mode IN

A

Choose “4. EEPROM Initialize” among the Monitor Test Menu screen.

Display specification Confirmation screen

B

Operational description Return to test mode menu Selection cursor left movement Selection cursor right movement Menu enter

Remote controller key RETURN REV FF Band

C

D

E

F

78

AVH-X1600DVD/XNUC 1

2

5

6

7

8

5. Display Test Method for Mode IN

A

Choose “5. Display Test” among the Monitor Test Menu screen.

Display specification Top menu

B

Operational description Return to test mode menu Selection cursor up movement Selection cursor down movement Menu enter

Remote controller key RETURN Up Down Band C

1. RGB RGB is plotted in the following pattern: R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Magenta:100% -> Magenta:50% -> Cyan:100% -> Cyan:50% -> Yellow:100% -> Yellow:50% -> Black -> Gray -> White -> Green & Magenta dot signal (The display of the screen will be changed in 1 second.) R: 100% D

Operational description Return to test mode menu Stop / restart of auto display

E

Remote controller key RETURN Band

F

AVH-X1600DVD/XNUC 5

6

7

8

79

1

2

3

4

3

4

2. Monochrome Stripe Display of monochrome stripe signals.

A

Monochrome stripe (Vertical)

B

Operational description Return to test mode menu Pattern change

Remote controller key RETURN Band

3. Color Bar Display of color bar signals.

C

Color bar (Vertical)

D

Operational description Return to test mode menu Pattern change

Remote controller key RETURN Band

E

F

80

AVH-X1600DVD/XNUC 1

2

5

6

7

8

4. Ramp & 10step Display of step signals and signals for alpha blend check.

A

Right-white 64step

Alpha blend set value (in hexadecimal)

B

Operational description Return to test mode menu (+0x10) Alpha blend Up (-0x10) Alpha blend Down (+0x01) Alpha blend Up (-0x01) Alpha blend Down Pattern change

Remote controller key RETURN Up Down FF REV Band C

5. Raster Signal Display of signals for step confirmation. White 0%

D

Operational description Return to test mode menu Pattern change

Remote controller key RETURN Band E

F

AVH-X1600DVD/XNUC 5

6

7

8

81

1

2

3

4

3

4

6. Contrast Display of Black / White signals.

A

Black

B

Operational description Return to test mode menu Pattern change

Remote controller key RETURN Band

7. Center Marker Display of signal for screen central location setting.

C

Center marker

D

Operational description Return to test mode menu

Remote controller key RETURN

E

F

82

AVH-X1600DVD/XNUC 1

2

5

6

7

8

6. Rear Video Output Test Method for Mode IN

A

Choose “6. Rear Video Output Test” among the Monitor Test Menu screen.

Display specification On this Rear Video Output Test mode, test signals appear only on the rear video output terminal. Top menu

B

Operational description Return to test mode menu Selection cursor up movement Selection cursor down movement Menu enter

Remote controller key RETURN Up Down Band

C

1. RGB RGB is plotted in the following pattern: R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Black -> Gray -> White signal (The display of the screen will be changed in 1 second.) R: 100% D

E

Operational description Return to test mode menu Stop / restart of auto display

Remote controller key RETURN Band

F

AVH-X1600DVD/XNUC 5

6

7

8

83

1

2

3

4

3

4

2. Color bar Display of color bar signals.

A

Color bar (Vertical)

B

Operational description Return to test mode menu

Remote controller key RETURN

3. Ramp & 10step C

Display of step signals and signals for alpha blend check. Right-white 64step

D

Operational description Return to test mode menu (+0x10) Alpha blend Up (-0x10) Alpha blend Down (+0x01) Alpha blend Up (-0x01) Alpha blend Down Pattern change

E

Remote controller key RETURN Up Down FF REV Band

F

84

AVH-X1600DVD/XNUC 1

2

5

6

7

8

4. Raster Signal Display of signals for step confirmation.

A

White 0%

B

Operational description Return to test mode menu Pattern change

Remote controller key RETURN Band

5. Center Marker

C

Display of signal for screen central location setting. Center marker

D

Operational description Return to test mode menu

Remote controller key RETURN

E

F

AVH-X1600DVD/XNUC 5

6

7

8

85

1

2

3

4

3

4

6. Multiburst Display of multiburst signal.

A

Multiburst

B

White 94dot

Gray 30dot

Stripe 9dot width

Gray 30dot

Stripe 4dot width

Gray 30dot

Operational description Return to test mode menu

Stripe 3dot width

Gray 30dot

Stripe 2dot width

Gray 30dot

Stripe 1dot width

Gray 30dot

Remote controller key RETURN

C

D

E

F

86

AVH-X1600DVD/XNUC 1

2

5

6

7

8

6.2 DVD TEST MODE The service test mode is used to check functions in fault diagnosis by a serviceman in case of any defect found in the DVD mecha. This mode is enabled only when the test mode is activated. At this time, no normal operation is executed.

A

1. Outline The service test mode is used to check functions in fault diagnosis by a serviceman in case of any defect found in the DVD mecha. No general user goes into this mode. The mode is implemented mainly to check the FE part. It is originally the test mode at the FE part implemented in the PC communication, which is modified to allow implementation in the HOST communication. The command for the test mode received in the HOST communication is interpreted by the application part, converted to the PC communication command and transferred to the OS. The OS transfers this command to the PC task as if it received the command in the PC communication. The execution result is noticed to the application part by an e-mail instead of the PC communication. The application part then transmits the result in the HOST communication to display OSD.

B

2. Conditions for operation (1) This service test mode is enabled only when the test mode is activated. At this time, no normal operation is executed.

3. To enter the test mode. (1) [MUTE] key + [FORWARD] key -> Turn on BUP and ACC. (2) DVD SOURCE -> ON (3) Execute the test mode using each key.

Display on function flow (0) (1) (2) (3) (4) (5) (6) (7) (8) UP DOWN EJECT SOURCE

C

Operation Key + MUTE MENU TOP MENU AUDIO SUB TITLE ANGLE RETURN

D

EJECT SRC

E

F

AVH-X1600DVD/XNUC 5

6

7

8

87

1

2

3

4

Image of the test mode. Legend:

A

… Key operation … Operation state … The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication.

Start of the test mode. TEST

[Note] Higher level 4 characters only. Lower level 4 characters are spaces.

(1)

(2)

(3)

FE test selection

EDC1 test selection

Hereafter, to FE test mode image.

Hereafter, to EDC1 test mode image.

(4)

(5)

LD power on time mode selection

EDC2 test selection

Hereafter, to EDC2 test mode image.

Simple FE test mode

Hereafter, to simple FE test mode.

Hereafter, to LD power on time mode image.

[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.

B

Legend:

Image of the front end test mode.

… Key operation … Operation state … The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication.

FE test mode

0X00 0000 (1) Power on 0FFF 0000

C

(2)

FE offset coefficient TE offset coefficient AS offset coefficient ENV offset coefficient TG offset coefficient DBAL coefficient VIN1 offset cancel value VIN2 offset cancel value VIN3 offset cancel value VIN4 offset cancel value VIN5 offset cancel value VIN6 offset cancel value VIN7 offset cancel value VIN8 offset cancel value VIN9 offset cancel value

(3)

(4)

Disc type DVD2 layer

Disc type DVD1 layer

0100 0000

0000 0000

(5)

Disc type CD

0200 0000

EJECT

Disc type CD-RW

EJECT

0300 0000

1X00 0000

(2) F search

1FFF 0000

1A00 0000

(6)

(5)

(3),(4)

(1) F close

CRG+/-

LD-ON/OFF

(7)

CRG_HOME

CRG_OUTSIDER

1D00 0000

1E00 0000

(8) Power_OFF

S curve measurement When LO-ON : 1100 0000 When LD-OFF : 1000 0000

Activates while the key is being pressed. 1B00 0000 : CRG+ 1C00 0000 : CRG-

(2) F search STOP

[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically. If F close is selected during LD-OFF, it will become an error. During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds. In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again before F close.

D 1100 0000

Focus close state FEMAX level FEMIN level ASMAX level ENVMAX level FE normalization coefficient Spindle gain coefficient TEMAX level indication TEMIN level indication

(2) 2x00 0000 (1) Tracking balance

2FFF 0000

E

(3),(4)

(2) Focus Jump

(8)

CRG+/-

When L0 layer : 2000 0000 When L1 layer : 2100 0000 TBAL coefficient (layer 0) TBAL coefficient (layer 1) TE normalization coefficient (layer 0) TE normalization coefficient (layer 1) Off track adjustment result

Power_OFF

It operates while the key is being pressed. 2B00 0000 : CRG+ 2C00 0000 : CRG-

3000 0000

(1) Tracking close

3FFF 0000

(5)

(3),(4) CRG+/It operates while the key is being pressed. 3B00 0000 : CRG+ 3C00 0000 : CRG-

3FFF 0000 Tracking close state

F

A 88

(8) Power_OFF

RF level value

FBAL coefficient (layer 0) FBAL coefficient (layer 1) Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0)

C

B AVH-X1600DVD/XNUC

1

2

3

4

5

6

7

8

B

A

C A

5000 0000 (1) RF level value indication start

RF level is informed every 500msec. (1) RF level value indication end

Tracking close state

(2)

(7)

Error rate measurement

T.OPEN

Error rate Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0) AS normalization adjustment value (layer 1)

(8) Power_OFF

To (2)

FBAL coefficient (layer 0) FBAL coefficient (layer 1) Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0)

B

4000 0000

4x00 0000

(1) Error rate measurement

(2) Playback speed switching

Error rate Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0) AS normalization adjustment value (layer 1)

DVDX1.3 1.6CAV CDX4CLV: 4x00 0000

(5)

(6) ID Search

Focus Jump

When L0 layer : 4x00 0000 When L1 layer : 4x00 0000

4A00 0000 (1)-(4) ID designation ID display

Error occurrence

Error display (8)

L0 layer L0 layer L1 layer L1 layer L0 layer L0 layer L1 layer L1 layer

DVD X CAV,CD X 2CLV DVD X 1CLV,CD X 1CLV DVD X CAV DVD X 1CLV Change V V DVD X 1.3 - 1.6CAV, CD X 4CLV DVD X 1CLV DVD X 1.3 - 1.6CAV DVD X 1CLV

:4000 0000 :4200 0000 :4100 0000 :4300 0000 :4000 0000 :4200 0000 :4100 0000 :4300 0000

Power_OFF

(5) Search start

(3),(4)

(7)

T.Jump+/-

T.OPEN

Jump+ : 4B00 0000 Jump- : 4C00 0000

(8) Power_OFF

To (2)

(3) Track number designation Track number indication (5) Jump start

The higher 2 digits of the designated ID are the value showing the test state. The lower 6 digits show the ID. Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.

C

The number for designation of the track number shall be selected from the track numbers previously prepared. Switch to cyclic by (3). Fix by (4). For CD: Tracks 1, 4, 10, 11 and 32 For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100 Change the method for ID address designation. Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).

Error occurrence at Power_OFF [Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again. Error display

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

89

1

2

3

Legend:

EDC. Image of the test mode

4

… Key operation … Operational state

A

… The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication. EDC1/2 test mode

[Note] Image is the same for both EDC1 and EDC2.

0000 0000

(1)

(2)

[Note] Eject can be effected any time during the EDC test mode.

EJECT operation

Layer 0 selection

Layer 1 selection

0000 0000

0100 0000

1003 0000

1103 0000

Eject

B

Test mode Eject

After completion of EJECT operation

(1)-(4) ID designation Layer 0:10** **** Layer 1:11** **** [Note] ** **** is the ID designation value (5) EDC1/2 start Layer 0:20** **** Layer 1:21** **** [Note] ** **** is the present ID designation value

C

**** **** [Note] **** **** is the present ID designation value

[Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.

Image of the LD power on time mode. Legend:

… Key operation … Operational state

D

LD power on time mode

… The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication.

0000 0000

(1) CD LD power on time indication

10** **** [Note] ** **** is the CD LD power on time.

(6)

(5)

(2)

CD LD power on time setting

DVD LD power on time indication

20** **** [Note] ** **** is the DVD LD power on time.

DVD LD power on time setting

40** **** [Note] ** **** is the setting time.

30** **** [Note] ** **** is the setting time.

(1)-(4) Setting time designation

(1)-(4) Setting time designation

(8)

(5)

(5)

E

(8)

Setting time registration

Setting time registration

10** **** [Note] ** **** is the CD LD power on time.

20** **** [Note] ** **** is the DVD LD power on time.

[Method of setting time designation] Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Cancel by command (8). [Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours. [Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.

F

90

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Simple test mode The selection of the figure of each screen can be selected by "Key command for the test".

A

TEST MODE 1: LD ON 2: ASMAX 3: Skew Adjustment 4: Error Rate 5: CRG Move Outer 6: Eject Please Input Number

LD ON

1 select

1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return

5 Return select

LD ON

Please Input Number

Now Running

ASMAX

2 select

1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return

5 Return select

ASMAX

5 Return select

ASMAX

ASMAX value set

Now Running

Skew Adjustment

Now Running

select

1: Inner Measurement 2: Outer Measurement 3: Middle Measurement

5: Return

RF Level display Update 500 msec.

Please Input Number

*1 Error Rate - Inner

Error Rate

DVD select

3: CD

Please Input Number

Search ID 0x00100000

Error Rate - Inner

Error Rate set

select

5: Return

5 Return select

Search ID inner : 0x00040000 outer : 0x00200000

Now Running

1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return

5 Return select

CRG Move Outer

Error Rate - CD

*1 : The position in which select was done is displayed. Error Rate -CD DVD Inner DVD Outer DVD Middle CD CD

*1

Please Input Number

Now Running

Error Rate display

D

Search CRG home position

CRG Move Outer

CRG Move Completion

select

select

Please Input Number

Now Running

CRG Move Outer

*1

1: Power OFF

Error Rate : 000000

Please Input Number

CD select

5 select

C

1: Power OFF

RF Level : 000000

Error Rate

5 Return select

select ASMAX Level display

Skew Adjustment

value set RF Level

select

Please Input Number

1: DVD Single Layer

1: Power OFF

Please Input Number

5: Return

4 select

select

ASMAX Level : 000000

Skew Adjustment 1: DVD Single Layer

B

1: Power OFF

Please Input Number

select

Please Input Number

3 select

LD ON

LD ON Completion

select

1: Power OFF

Please Input Number

select CRG moves to the most outer

<Error> ERROR 1: Power OFF

E

select

Code : 00000000 Please Input Number

<Error : Power OFF> ERROR

Code : 00000000 Please Reset

F

AVH-X1600DVD/XNUC 5

6

7

8

91

1

2

3

4

7. DISASSEMBLY A

While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.

Removing the Monitor Assy (Fig.1)

1

Remove the four screws (5 mm length).

2

Release the six latches.

3

Disconnect the connector and then remove the Monitor Assy.

B

1

1

1

1

Monitor Assy 2

2 3

2

2

C

2

2 Fig.1

Service Unit (Monitor)

Removing the Service Unit (Monitor) (Fig. 2)

2

2

1

Disconnect the four connectors.

2

Remove the four screws and then remove the Service Unit (Monitor).

D

1

1

2

1

2

1

Fig.2

Holder(1)

Removing the Service Unit (Keyboard) (Fig.3)

E

Service Unit (Keyboard)

Remove the the Holder(1).

1

Release the seven latches and then remove the Holder(2).

1

1

Remove the Service Unit (Keyboard).

1 Note) With this model, the Cushion of Touch Panel was attached using a jig in the factory line.

F

1 1

1

1

Holder(2) Fig.3

92

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Removing the DVD Mechanism Module (Fig.4)

1

Remove the four screws (6 mm length).

2

Disconnect the connector and then remove the DVD Mechanism Module.

A

DVD Mechanism Module 1

DVD Mechanism Module

1

B

1

1

Bracket 2

Attention at assembly) When installing the DVD Mechanism Module, pulling the side Bracket to the DVD Mechanism Module, tighten the screws. Put the dowels of the DVD Mechanism Module in the slits of the side Bracket securely.

C

Attention of removing Don’t remove this screws excluding the dismantlement of the DVD Mechanism Module. Fig.4

D

Removing the Heat Sink and the Holder (Fig.5) Heat Sink

1

Remove the two screws.

2

Remove the two screws (6 mm length) and then remove the Heat Sink and the Holder.

Holder

2

2

1

E

1

F

Fig.5 AVH-X1600DVD/XNUC 5

6

7

8

93

1

2

3

4

Removing the Service Unit (Mother I/F) (Fig.6)

A

1

Service Unit (Mother I/F)

Remove the two screws (6 mm length).

1

1 B

2

Loose the four screws (5 mm length).

3

Remove the three screws (5 mm length) and then remove the Service Unit (Mother I/F).

C

3

2

3

3

2

2

2

Service Unit Holder

Service Unit Holder

D

Note) Remove the Service Unit Holder with tweezers. If forcefully removed, it may be deformed.

Attention at assembly) E

When you assemble the Service Unit Holder and the Bracket, the Claw enters the hole. They are hardly separated, so pay attention to the deformation.

The Service Unit Holder should contact the Bracket.

F

Fig.6

94

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Removing the Interface PCB and the Mother PCB (Fig.7)

1

Disconnect the connector.

2

Remove the three screws and then remove the Interface PCB.

3 4

A

Interface PCB

Straighten the tab at location indicated.

2 2

2

1

Remove the three screws and then remove the Mother PCB.

4

B

4

3

4

Mother PCB C

Fig.7

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

95

1

2

3

4

8. EACH SETTING AND ADJUSTMENT 8.1 DVD ADJUSTMENT A

This product uses 5 V and 3.3 V as standard voltages. The electrical potential that is the reference for signals, is not GND, but VREF (approximately 2.2 V) and VHALF (approximately 1.65 V) . During product adjustments, if the reference voltage is mistakenly taken as GND, and a grounding contact is made, not only would it be impossible to measure the accurate electrical potential, but also the servo motor would malfunction, resulting in the application of a strong impact on the pick up. The following precautionary measures should be strictly adhered to, in order to avoid such problems. The reference voltage and GND should not be confused when using the minus probe of a measurement device. When an oscilloscope is being used special care should be taken to make sure that the reference voltage is not connected to the probe of ch1 (on the minus side), while the probe of ch2 (on the minus side), is connected to GND. Further, since the body frame of most measurement devices have the same electrical potential as the minus side of the probe, the body frame of the measurement device should be set to floating ground. If the reference voltage is connected to GND by mistake, turn the regulator OFF immediately, or turn the power OFF.

B

Remove the filters and wires used for measurements only after the regulator has been turned OFF. After the power supply is turned on, regulator ON the following adjustment and measurement are promptly done. Whenever the product is in the test mode, the software will not take any protective action. For this reason, special care should be taken to make sure that no mechanical or electrical shock could be applied to the product when taking measurements in the test mode. Whenever the EJECT key is pressed to eject the disk, no other keys, other than the EJECT key, should be pressed until the disk eject action has been completed. Press the EJECT key only after the disk has stopped completely. If the product hangs up turn the power OFF immediately. Don't touch the volume for laser power adjustment other than the time of POWER adjustment. (Laser diode may be damaged.)

C

D

E

F

96

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

- Power Adjustment A

Power Adjustment To turn VR of the circuit for Power adjustment and adjust the optical output level of PU laser diode to make the level of signal (RF signal) read from the media appropriate level during the reproduction of media, CD and DVD. It has been decided that Power adjustment circuit (circuit from IMON to CDMP, DVDMP) which adjusts the optical output level of PU laser diode should be installed on DVD Core Unit in the DVD mecha module. Therefore, in the replacement of CRG mecha (with PU unit) and DVD Core Unit, Power adjustment should be implemented. The Power adjustment method of mecha module is shown below.

Items to be Prepared Measuring instrument: Oscilloscope (digital or analog) Frequency band of oscilloscope in DVD whose frequency is higher than CD Adjustable 10 MHz and higher (enough to check the level) (In LS2, DVD (x 1.5CLV) MAX RF 6.55 MHz / DVD (x 1.5CLV) MIN RF 1.40 MHz) DISC: DVD TEST DISC (TDV-582 or TDV-520) Almedio CD TEST DISC (TCD-782 or TCD-792) Almedio Adjustment screwdriver : crosshead, No.0, nonmetal (ceramic screwdriver for adjustment)

B

Line Locating The following line locating is required. 1 2

RF VREF1

Power adjustment Power adjustment

C

Connection Diagram : Checking terminal for oscilloscope The figure in parentheses of resistor / capacitor is constant.

Universal board

RF

VREF1 D

Enlarged E

For CDt For DVDt

F

AVH-X1600DVD/XNUC 5

6

7

8

97

1

2

3

4

Method of Power Adjustment 1. Monitor RF by using the analog oscilloscope. (line locating of RF and VREF1) 2. Turn VR1101 and VR1102 to set the PP value of RF at the value shown in the right lower table.

A

RF waveform after F-ON / before T-ON (waveform measured by analog oscilloscope)

Adjust VR in order that this width is within the range of target RF level adjustment value.

Power adjustment standard RF level adjustment value (F-ON STEP 10, 24)

B

DVD CD

200 mV to 1200 mV 200 mV to 1200 mV

RF waveform after the completion of all adjustment (waveform measured by analog oscilloscope) Adjust VR in order that this width is within the range of target FR level adjustment value.

C

Power adjustment standard RF level adjustment value (The setup is completed. STEP 12, 26) 848 mV to 892 mV 658 mV to 702 mV

DVD CD

D

E

F

98

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

Procedure of Power Adjustment Flow 1. DVD Power adjustment in the state where F is ON 2. DVD Power adjustment in the state where the setup is completed 3. CD Power adjustment in the state where F is ON 4. CD Power adjustment in the state where the setup is completed

A

Procedure of Adjustment STEP No.

1. Set the mecha to clockwise. 2. Turn on power. 3. Test Mode In

Refer to FE test mode function flow.

B

4. Insert DVD TDV-582 (or TDV-520). 5. Set the mecha to counterclockwise. 6. Adjustment of the initial position of VR for Power adjustment 1st CD (VR1101) DVD (VR1102)

-30°

2nd -30° -45°

Adjust the angle at the D cut position to the initial position (initial position shown in Fig.1).

3rd 0°

-90°

CD VR (VR1101) Adjustment of the initial position -30° - 1st, 2nd, 3rd is the same, too

C

3rd - -90° 2nd - -45° DVD VR (VR1102) Adjustment of the initial position 1st - -30°

7. Set DISC TYPE to DVD single layer.

0° Fig.1

8. Power on.

Refer to FE test mode function flow.

9. LD-ON.

Refer to FE test mode function flow.

10. Execute until Focus close state is reached.

Refer to FE test mode function flow.

D

If the waveform is similar to RF waveform after F-ON and before T-ON (waveform measured by analog oscilloscope), Focus Close is reached. Go to STEP 9. If the RF waveform does not appear, Focus Close is not reached. Return to STEP 7 and change the angle of initial position of DVD VR (VR 1102). If Focus Close is not reached after the 3rd VR adjustment, replace the whole CRG mecha (including PU unit) and start again from STEP 1.

DVD

200 mV to 1200 mV

11. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.) DVD

848 mV to 892 mV

12. Execute until Tracking Close is reached. E

13. Conduct Power adjustment. (Conduct the adjustment in the state of Tracking Close.) DVD

2.0E – 4 and under

14. Check the ERR rate after Power adjustment. DVD DVD

820 mV to 917 mV 2.0E – 4 and under

15. Power off. 16. Return the state of mecha to clockwise. 17. Set up again (state of mecha to clockwise / setting of DVD single layer) and conduct the final check of RF level and ERR rate. (Check in the state of Tracking Close)

F

18. Eject.

AVH-X1600DVD/XNUC 5

6

7

8

99

1

2

3

4

19. Take out DVD TDV-582 (or TDV-520). Insert CD TCD-782 (or TCD-792). A

20. Set the mecha counterclockwise. 21. Adjustment of the initial position of VR for Power adjustment CD (VR1101) DVD (VR1102)

Adjust the angle at the D cut position to the initial position (initial position shown in Fig.2).

3rd 2nd 1st -45° -90° -30° As the adjustment is completed, never change.

CD VR (VR1101) Adjustment of the initial position 1st - 30°

0°

2nd - -45° 3rd - -90°

B DVD VR (VR1102) As the adjustment is completed, never change.

0° Fig.2

22. Set DISC TYPE to CD.

Refer to FE test mode function flow.

23. Power on.

Refer to FE test mode function flow.

Refer to FE test mode function flow. If the waveform is similar to RF waveform after F-ON and before T-ON (waveform measured by analog oscilloscope), Focus Close is reached. Go to STEP 20. If the RF waveform does not appear, Focus Close is not reached. Return to STEP 21 and change the angle of initial position of CD VR (VR1101). If Focus Close is not reached after the 3rd VR adjustment, replace the whole CRG mecha (including PU unit) and start again from STEP 1.

24. Execute until Focus Close 1 is reached.

C

25. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.) CD

200 mV to 1200 mV

26. Execute until Tracking Close is reached.

Refer to FE test mode function flow.

27. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.) CD

658 mV to 702 mV

28. Check ERR rate. D

CD

Refer to FE test mode function flow.

1.0E – 2 and under

29. Power off.

Refer to FE test mode function flow.

30. Return the state of mecha to clockwise. 31. Set up again (state of mecha to clockwise / setting of CD layer), and conduct the final check of RF level and ERR rate. (Check in the state of Tracking Close) CD CD

528 mV to 832 mV 1.0E – 2 and under

Refer to FE test mode function flow.

32. Eject.

E

Refer to FE test mode function flow.

33. Take out CD TCD-782 (or TCD-792). 34. Power off.

F

100

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

8.2 PCL OUTPUT CONFIRMATION A

- PCL Output With the TESTIN (72 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started. The clock signal is output from the CLKOUT terminal IC601 (Pin 78). The frequency of the clock signal is 9.375 MHz(± 375 Hz). If the clock signal out of the range, the X’tal (X601) should be replaced with new one.

B

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

101

1

2

3

4

9. EXPLODED VIEWS AND PARTS LIST NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.

The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)

A

"

9.1 PACKING RC, RD, RI, ID

B

C

D

RC, RI

EW5

E

UC, RC, RD RI, ID EW5, UW5

UC, RC, RD, RI, ID F

UC, EW5 UW5 102

EW5, UW5, RI AVH-X1600DVD/XNUC

1

2

3

4

5

6

7

8

(1) PACKING SECTION PARTS LIST Mark No.

Description

Mark No.

Part No.

Description

1

Cord Assy

See Contrast table (2)

12

Panel

2

USB Extended Cable

CDP1585

13

IM CD-ROM

3

Polyethylene Bag

CEG1160

4

Screw

See Contrast table (2)

5

Screw

TRZ50P080FTC

6

Handle

See Contrast table (2)

*

Part No. See Contrast table (2) See Contrast table (2)

14-1 Owner's Manual

See Contrast table (2)

14-2 Warranty Card

See Contrast table (2)

14-3 Quick Start Guide

See Contrast table (2)

14-4 Installation Manual

See Contrast table (2)

7

Cover

See Contrast table (2)

*

14-5 Caution Card

See Contrast table (2)

8

Unit Box

See Contrast table (2)

*

14-6 Caution Card

See Contrast table (2)

9

Contain Box

See Contrast table (2)

*

14-7 Service Network

See Contrast table (2)

10

Protector

See Contrast table (2)

11

Card Remote Control Unit

See Contrast table (2)

15

Cord Assy

A

See Contrast table (2) B

(2) CONTRAST TABLE AVH-X1600DVD/XNUC, AVH-X1600DVD/XNEW5, AVH-X1600DVD/XNUW5, AVH-X1650DVD/XNRC, AVHX1650DVD/XNRD, AVH-X1650DVD/XNRI and AVH-X1690DVD/XNID are constructed the same except for the following: Mark

*

* * *

No.

*

AVH-X1600DVD/ XNUC

AVH-X1600DVD/ XNEW5

AVH-X1600DVD/ XNUW5

AVH-X1650DVD/ XNRC

1 4 6 7 8

Cord Assy Screw Handle Cover Unit Box

CDP1668 CRZ50P090FTC Not used CEG1359 CHG8426

CDP1436 CRZ50P090FTC CND6289 CEG1356 CHG8434

CDP1436 CRZ50P090FTC CND6289 CEG1356 CHG8435

CDP1668 Not used Not used CEG1356 CHG8427

9 10 11

CHL8426 CHP4598 CXE5116

CHL8434 CHP4599 Not used

CHL8435 CHP4599 Not used

CHL8427 CHP4598 CXE5116

12 13

Contain Box Protector Card Remote Control Unit Panel IM CD-ROM

Not used Not used

Not used CPJ1471

Not used Not used

CNS9475 Not used

14-1 14-2 14-3 14-4 14-5

Owner's Manual Warranty Card Quick Start Guide Installation Manual Caution Card

CRD4758 QRY3001 Not used Not used Not used

Not used CRY1376 CRD4756 CRD4757 CRP1436

CRB4290 CRY1330 Not used Not used Not used

CRD4759 Not used Not used Not used Not used

14-6 14-7 15

Caution Card Service Network Cord Assy

Not used Not used Not used

CRP1441 Not used Not used

Not used Not used Not used

Not used Not used CDP1655

Mark

*

Description

No.

Description

AVH-X1650DVD/ XNRD

AVH-X1650DVD/ XNRI

Cord Assy Screw Handle Cover Unit Box

CDP1668 Not used Not used CEG1356 CHG8428

CDP1668 Not used CND6289 CEG1356 CHG8436

CDP1668 Not used Not used CEG1356 CHG8429

9 10 11

CHL8428 CHP4598 CXE5116

CHL8436 CHP4599 CXE5116

CHL8429 CHP4598 CXE5116

12 13

Contain Box Protector Card Remote Control Unit Panel IM CD-ROM

CNS9475 Not used

CNS9475 Not used

CNS9475 Not used

14-1 14-2 14-3 14-4 14-5

Owner's Manual Warranty Card Installation Manual Installation Manual Caution Card

CRD4760 Not used Not used Not used Not used

CRD4761 Not used Not used Not used Not used

CRB4291 CRY1304 Not used Not used Not used

AVH-X1600DVD/XNUC 6

D

AVH-X1690DVD/ XNID

1 4 6 7 8

5

C

7

E

F

8

103

1

Mark

A

* *

No. 14-6 14-7 15

2

Description Caution Card Service Network Cord Assy

3

AVH-X1650DVD/ XNRD Not used Not used Not used

AVH-X1650DVD/ XNRI Not used Not used CDP1655

4

AVH-X1690DVD/ XNID Not used CRY1305 Not used

Owner's Manual,Installation Manual Part No.

B

Language

CRD4758

English, French, Spanish(Espanol)

CRD4756

English, French, Italian, Spanish(Espanol), German, Dutch

CRD4757

English, French, Italian, Spanish(Espanol), German, Dutch

CRB4290

Russian

CRD4759

English, Traditional Chinese

CRD4760

English, Spanish(Espanol), Portuguese(B)

CRD4761

English, Arabic, Persian

CRB4291

English

CONTENTS OF CD-ROM (Operation Manual), CPJ1471 Part No.

C

D

Language

* CRB4277

English

* CRB4278

French

* CRB4279

Italian

* CRB4280

Spanish(Espanol)

* CRB4281

German

* CRB4282

Dutch

* CRB4283

Swedish

* CRB4284

Norwegian

* CRB4285

Finnish

* CRB4286

Danish

* CRB4287

Portuguese

* CRB4288

Greek

* CRB4289

Turkish

All operation manuals are supplied in PDF files by the CD-ROM. Regarding the availability of paper manual, contact Pioneer Service representative in your region.

E

F

104

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

B

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

105

1

2

3

4

9.2 EXTERIOR (1) A

A

D

B

B

D A

E

C

EW5, UW5, RI

D

EW5, UW5, RI

C

E

F

C

106

B

D

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

(1) EXTERIOR (1) SECTION PARTS LIST Mark No.

Description

Mark No.

Part No.

Description

Part No.

1

Screw

BSZ26P050FTC

17

Cushion

CNN4274

2

Screw

BSZ26P120FTC

18

Touch Panel

CSX1184

3

Screw

BSZ26P060FTC

19

Lighting Conductor

CNW2588

4

FFC

CDE9765

20

Lighting Conductor

CNW2589

5

FFC

CDE9767 21

Holder

CNW2590

6

Holder

YND5148

22

TFT LCD

CWX4218

7

Heat Sink

CNR2147

23

Grille Assy

See Contrast table (2)

8

Screw

ASZ26P050FTC

24

Button

CAI3844

9

Button (HOME)

CAI3845

25

Plate

CNN4709

10

FFC

CDE9768 26

Grille

See Contrast table (2)

11

Holder

CND6527

27

DVD Mechanism Module (LS2) CXK8003

12

Cover

CNN2628

28

•••••

13

Cushion

CNN4186

29

Service Unit (Monitor)

CXX6055

14

Sheet

CNN4187

30

Service Unit (Keyboard)

CXX6059

15

Service Unit (Touch Panel)

CXX6233 31

Holder

See Contrast table (2)

16

Cushion

CNN4273

32

Panel

See Contrast table (2)

A

B

(2) CONTRAST TABLE AVH-X1600DVD/XNUC, AVH-X1600DVD/XNEW5, AVH-X1600DVD/XNUW5, AVH-X1650DVD/XNRC, AVHX1650DVD/XNRD, AVH-X1650DVD/XNRI and AVH-X1690DVD/XNID are constructed the same except for the following: Mark

No.

Description

23 26 31 32

Mark

Grille Assy Grille Holder Panel

No.

Description

23 26 31 32

Grille Assy Grille Holder Panel

AVH-X1600DVD/ XNUC CXE6859 CNU2542 Not used Not used

AVH-X1600DVD/ XNUW5

CXE6858 CNU2541 CND6288 CNS9952

AVH-X1650DVD/ XNRD CXE6860 CNU2543 Not used Not used

AVH-X1600DVD/ XNEW5

CXE6858 CNU2541 CND6288 CNS9952

AVH-X1650DVD/ XNRI

C

AVH-X1650DVD/ XNRC CXE6860 CNU2543 Not used Not used

AVH-X1690DVD/ XNID

CXE6860 CNU2543 CND6288 CNS9952

CXE6861 CNU2544 Not used Not used

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

107

1

2

3

4

9.3 EXTERIOR (2) A

UC, RC, RD, RI, ID

B

UC, RC, RD, RI, ID

EW5, UW5

B

C

B

A

D

A

B

E

A

F

108

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

(1) EXTERIOR (2) SECTION PARTS LIST Mark No.

Description

Mark No.

Part No.

Description

Part No.

10

Screw

See Contrast table (2)

11

•••••

Card Remote Control Unit

See Contrast table (2)

12

Screw

Battery Cover

See Contrast table (2)

13

Screw

BPZ26P080FTC

14

FFC

CDE9766

15

Holder

CND6555

16

Fuse (10 A)

YEK5001

17

Service Unit (Mother I/F)

See Contrast table (2)

1

Screw

ASZ26P050FTC

2

Screw

BSZ26P050FTC

3

Cord Assy

4 5 6

Chassis

CNA3210

7

Bracket

CND6336

8

Holder

CND6530

9

Bracket

CND6635

>

BSZ26P060FTC A

ASZ26P050FTC

(2) CONTRAST TABLE AVH-X1600DVD/XNUC, AVH-X1600DVD/XNEW5, AVH-X1600DVD/XNUW5, AVH-X1650DVD/XNRC, AVHX1650DVD/XNRD, AVH-X1650DVD/XNRI and AVH-X1690DVD/XNID are constructed the same except for the following: Mark

No.

Description

3 4

Cord Assy Card Remote Control Unit Battery Cover Service Unit (Mother I/F)

5 17

Mark

No.

Description

3 4

Cord Assy Card Remote Control Unit Battery Cover Service Unit (Mother I/F)

5 17

AVH-X1600DVD/ XNUC

AVH-X1600DVD/ XNEW5

AVH-X1600DVD/ XNUW5

AVH-X1650DVD/ XNRC

CDP1668 CXE5116

CDP1436 Not used

CDP1436 Not used

CDP1668 CXE5116

CNU1624 CXX6037

Not used CXX6035

Not used CXX6036

CNU1624 CXX6038

AVH-X1650DVD/ XNRD

AVH-X1650DVD/ XNRI

AVH-X1690DVD/ XNID

CDP1668 CXE5116

CDP1668 CXE5116

CDP1668 CXE5116

CNU1624 CXX6039

CNU1624 CXX6040

CNU1624 CXX6041

B

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

109

1

2

3

4

9.4 DVD MECHANISM MODULE (1) A

B A

B

(C)

(A)

C

(C)

C

D (A) (NOTE)

C

D

(C)

(C)

D

(NOTE) (A) (C)

(A)

(A)

(B) (A) (NOTE) (A)

(A)(NOTE)

E

E

C E

B A (C)

(C)

(A) : GEM1045 F

(B) : GEM1038 (C) : GEM1024

110

(NOTE) Apply grease to the whole part.

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

DVD MECHANISM MODULE (1) SECTION PARTS LIST Mark No.

Description

Mark No.

Part No.

Description

Part No.

35

Gear

CNW1186

CBA1835

36

Gear

CNW1187

Washer

CBF1038

37

Clamper

CNW1190

Spring

CBH2855

38

Arm

CNW1192

39

Holder

CNW1193

40

Holder

CNW1194

1

Screw

BSZ20P040FTC

2

Screw

BSZ26P060FTC

3

Screw (M2 x 4)

4 5 6

Spring

CBH2860

7

Spring

CBH3010

8

Spring

CBH3011

41

Damper

CNW2439

9

Spring

CBH3014

42

Damper

CNW2440

10

Spring

CBH3015

43

Arm

CNW1726

44

Guide

CNW2240

45

Arm

CNW2241

11

Spring

CBH3016

12

Spring

CBH3017

13

Spring

CBH3019

46

Rack

CNW2265

14

Spring

CBH3086

47

Gear

CNW2287

15

Spring

CBH3095

48

Motor Unit(M1)(CRG(L/E))

CXC4026

49

Screw Unit

CXC8894

50

Chassis Unit

CXE6044

16

Spring

CBH3096 CBL1824

*

17

Plate Spring

18

•••••

51

•••••

19

Case

CNB3763

*

52

Support Wheel

CNW2052

20

Bracket

CND4553

*

53

Spindle Motor(M2)(SPINDLE)

EXM2002

54

Arm Assy

CXE6232

55

Washer

CBF1037 CBF1038

21

Lever

CND5398

22

Bracket

CND5710

23

Bracket

CND6127

56

Washer

24

Arm

CND6406

57

Arm

CND6242

25

Sheet

CNN3678

58

Roller

CNW2500

59

Collar

CNW2444

26

Roller

CNW1172

60

Gear Unit

CXC6225

27

Roller

CNW1175

28

Arm

CNW1177

61

Washer

YE15FTC

29

Arm

CNW1178

62

Screw

JFZ20P025FTC

30

Gear

CNW1180

63

Screw

JGZ17P020FTC

64

Screw (M2 x 5)

EBA1028

31

Gear

CNW1181

65

DVD Core Unit

YWX5032

32

Gear

CNW1183

33

Rack

CNW1184

66

Mechanism Unit(Service)

CXX4548

34

Gear

CNW1185

A

B

C

D

(NOTE) Pickup, Spindle Motor and Support Wheel are not available as service parts, because they need adjustment by special equipment after replacing. E

F

AVH-X1600DVD/XNUC 5

6

7

8

111

1

2

3

4

9.5 DVD MECHANISM MODULE (2) A

(C)

(C) (C) B

(A)

(B) C

D

(A) : GEM1045 (B) : GEM1038 (C) : GEM1024 E

F

112

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

B

C

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

113

1

2

3

4

10. SCHEMATIC DIAGRAM

10.1 MOTHER PCB (ANALOG BLOCK) Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".

BTANAR

FR

RR

RCAMUTE

GNDA

100p/50 C281

C252

54

NC9

NC8

0

NM

R264 1608 C285

1u/10

R265

1000p/50 C282

42

C286

0.1u/16

CCG1192-A

2125 10u

C283

NM 3216

1608

1608

40

1608 C272 1u/10

39

C268 NM

AV_ROUT1

38 C273

37 36

O

GNDA

NM C274 NM

PCHANG

BUSR+ BUS-

SYS+B

C277

0.1u/10

SPEED

EVMUTE

47k

R255

32

C276

CLK DATA STB 31

DGND

C271

35 NC7 DVCC 34 MUTE 33

30

29

SACLK

SAOUT

28

1u/10

43

NM

GND

SA_TEST_OUT

27 R253

CCG1192-A 10u 25 C287 26

C267 2125 100p/50

C270

44

1000p/50

CREF

NC6

VCC

24

23

NC5

22

1000p/50 C262

CCG1192-A 10u 2125 C114

45

S 1608

41

IN3R

IN4R-

1u/10

RL

10p/50

IN2R

46

C275

PML020A

C269

RR

CCG1192-A 2125 10u

IN1R

C266

NM

R262 NM TOUT_RR SVIN_PRE

IC251

100p/50

R263

100p/50 52 PRE_SWR 51 REAR_R FRONT_R 50 NC10 49

NC11

55

56

53

VP

PREF

NC12

C278 1608 1000p/50

CCG1192-A 10u 10V 2125 C280 NM

58

57 PGND

NC13

PRE_SWL

59

REAR_L

1u/10 1608 62

60

FRONT_L

GNDA 47

FL FR

48

TOUT_PRE

TEST_OUT MIC_IN DC_FILTER 20

19

1608 C264 0.1u/16 C265

NM

CCG1192-A 0.47u/10 2125 10u C289

GNDV

1608 C263

only E

1u/10 GNDA

3216 C288

C292

0 2125

SVIN_FR TOUT_FR SVIN_RR

MAO

CCG1218-A-T 2.2u/10 1608

2200p/50

C201

NM

18

17 C203

1.8k

0 R261

IN4R+

GNDA

R202 C291

A 2125 R260

TOUT_FL SVIN_FL NC14

2125 0.22u/50 C254

SYS+B

FM/AM(30%) (except B, C): -6.9 dBs FM/AM(30%) (B, C): -2.9 dBs TV:+9.3 dBs AUX:+9.3 dBs VCR:+9.3 dBs USB(LS2 Decode):+9.2 dBs USB(SH Decode):+9.3 dBs DVD/CD(LS2):+9.2 dBs Navi Guide: -12.5 dBs

61

C279 63

64 2

MIC_AMP_OUT

C290 0.01u/16

E.VOL Output

1

1u/10

21

C251 0

R201

R251 1.6k

1608 C253

SVIN_RL 3 TOUT_RL NC1 4 APF_2 C255 5 APF_1 0.22u/50 6 NC2 2125 7 GNDA IN1L C256 1608 1u/10 8 IN2L C257 9 IN3L NM 10 NC3 C258 11 IN4L+ NM C259 12 IN4LNM 13 NC4 1u/10 C260 14 1608 IN5L C261 15 IN5G IN5R 1u/10 16 1608

E.VOL Input FM/AM(30%) (except B, C): -15.0 dBs FM/AM(30%) (B, C): -11.0 dBs TV:+2.2 dBs AUX:+2.2 dBs VCR:+2.2 dBs USB(LS2 Decode):+5.1 dBs USB(SH Decode):+2.2 dBs DVD/CD(LS2):+5.1 dBs Navi Guide:+8.6 dBs

10p/50

GNDA

E. VOL IC INPUT 1 2 AV SEL 3 BT TEL AUDIO 4 SXI 5 NAVI/app GUIDE 6 M

C284

EV12

SYS+B

RCA_FR

RCA_RR

RCA_SWR

RCA_FL

RCA_RL

RCA_SWL

FL

2125 R258 0 R259 0 2125

R256 NM R257 NM

E.VOL

C

RL

AV_LOUT1

ANA-TUN BUS

B

ANA-SYS BUS

A 2/6

INNER BUS

BTANAL

BUS-

AEQMICIN

A 6/6

iNAVI

ANA-I/O BUS

A 5/6

BUSL+

101 - : AV.SEL 201 - : AEQ 251 - : E.VOL 301 - : PWAMP 801 - : SENS AUX_L

A

GNDA

EVSEL EVSDA

GNDA

EVSCK

C113

EVSACLK

GNDA

0.1u/10

D

T

EVSAOUT

GNDA

AVSCL

AV SELECTOR

AVSDA

0.1u/10

C131

13

MONVBS

GNDV

F

40

41

42

39 GND2 RIN2 38 VSS1 37

C136 C119 C120 C121 C122 C123 C124 C125 C126 C127

R108

1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10 1608 1u/10

SH_R iTV_L

iTV_R

GNDA

GNDA

LS_L

R119 1608 R120 1608

56

R121 1608

56 56

56

LS_R

GNDA VCR_L

R109 1 100 2

8

VCR_GND

7

VCR_R

3

6

AUX_L

4

5

AUX_AGND

R110 1 100 2

8

AUX_R

3

6

4

5

(TUN AGND) TUNAG

TUN_R

NM

C139 1000p/50

GNDA

FM/AM(30%) (except B, C): -15.0 dBs FM/AM(30%) (B, C): -11.0 dBs TV:+2.2 dBs AUX:+2.2 dBs VCR:+2.2 dBs USB(LS2 Decode):+5.1 dBs USB(SH Decode):+2.2 dBs DVD/CD(LS2):+5.1 dBs

ANA-I/O BUS INNER BUS ANA-SH BUS

AVH-X1600DVD/XNUC 2

3

A

TUN_L

7

ANA-SYS BUS

1

P

AV SELECTOR Input

R106 NM 1608

A 1/6 114

SH_L

1608

R107

CCG1192-A 10u

C117 1608 0.1u/16 C118 2125 AV_LOUT1

D102

C116 CCG1192-A 2125 10u AV_ROUT1

75

47 75 D%

0.1u/10

C112

NM NM

RCA_V

NM 1608

D101

C135

SYS+B

GNDV R103 C110 2125 CCG1192-A

SYS+B

GNDA

VOUT2 VOUT1 VR1

0.1u/10 C130 0.1u/10 C109 0.1u/10 NM

R111 NM

R118

GNDV

AK4223VQ

C134

35 LIN3 GND3 34 RIN3 33 LIN4 32 GND4 31 RIN4 30 LIN5 29 GND5 28 RIN5 27 LIN6 GND6 26 RIN6 25

24

0.1u/10

C108

23

C107

5

36

LOUT2 ROUT1 LOUT1

6

4 R102 100

IC101

22

7

3

C111

ANA-SH BUS

iCOMP

2

VCR_V

RIN1

0.1u/10

AUX_V VCR_VGND

LIN2

0.1u/10

C106

ROUT2

C105

RVDD

8

21

5

1

AUX_VGND

20

4

0.1u/10

GND1

0.1u/10

C104

LIN1

C103

AVDD

6

VIN6 3 VGND5 VIN5 4 VGND4 5 VIN4 6 VGND3 7 VIN3 8 VGND2 9 VIN2 10 VGND1 11 VIN1 VR2 12

VVDD

3

2

VGND6 VSS2 SCL

0.1u/10

REGV

0.1u/10

C102

16

C101

7

15

8

2

14

1

BCAM_IN LS2_VGND

R112 100 R116 100 R113 100 R114 100 R117 100 R115 100

B

1

BC_VGND

LS_V

GNDV

GNDV

19

-

43

CH6

18

TUN

1608 C115 0.1u/16

BC

CH6

45

LS-2

CH5

VCOM

CH4

AUX

RSTN

VCR

CH5

46

CH4

44

AUX

SDA

VCR

CH3

17

CH2

LS-2

AVSRST

iTV

CH3

47

CH2

R101 100

E

iCOMP

48

CH1

R104

A 3/6

SH

R105

CH1

VIDEO CH

0.1u/10 C140 270p/50 R122

AUDIO CH

C129 1608 1u/10 C137 1608 1u/10 C128 1608 1u/10 C132 1608 1u/10 C138 1608 1u/10 1608 C133 1u/10

4

B

BGSENS1

5

6

7

8

BUP_1

A

AMP

4 STBY 3 C2

B2 5

2 B1

C1 6

1 E1

NM

1608 0.22u C341 CCG1313-A 1608 0.22u C342 CCG1313-A

6 VCC1/2

NM C353

FL-

CCG1291-A 4.7u 50V C350

FL+

3216

CCG1291-A 4.7u 50V

3216

C347 NM R323

68k

68k

3

4

10k

R306

NM 1608

NM

D882

C881

NM 1608

FR+

22

MUTE

23

FR-

24

PW.GND4

25

H-SW

10p/50

C

FR-

NM

RR-

R871

NM

RL-

FL+

FL+

RL+

RL+

47k

NM

UDZV7R5(B)

MUTE BREM ILM

GNDD

GNDD

BGSN

NM

ACC

GNDD

NM

R802

BGSENS1

10k

NM

GNDD

SERVICE UNIT(MOTHER Consists of MOTHER PCB INTERFACE PCB

6

BUP1

BUP2

FR-

2

RR-

3

FR+

4

RR+

5

FL-

6

RL-

7

FL+

8

RL+

9

P.B.

10

MUTE

11

B.REM

12

ILM

13

BGSENS

14

ACC

15

GND

16

B.UP

E

YEK5001 10 A

>

FM/AM(30%) (except B, C):+19.1 dBs FM/AM(30%) (B, C):+23.1 dBs TV:+35.3 dBs AUX:+35.3 dBs VCR:+35.3 dBs USB(LS2 Decode):+35.2 dBs USB(SH Decode):+35.3 dBs DVD/CD(LS2):+35.2 dBs I/F) Navi Guide:+13.5 dBs

F

: The power supply is shown with the marked box.

A 1/6

NM : No Mount

AVH-X1600DVD/XNUC 5

L831

Q801 NM

NOTE : GNDD Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.

600uH

FUSE

1SR154-400

R834 R833

L801 CTH1221-A

GND1

JA801

1

NM

D831 DZ2J056M0

C832

C831

NM

R831

NM

R801

3.4V

0.1u/50 1608

Q831 LTC014EEB SOC33_1

BGSENS-App

1k 3216

100k

R832

GNDD

BGSENS0

14.4V

D802

GNDD VDD33 3.4V

1SR154-400

1k 3216

105

DA2J101

BGSENS-AVH

GND3 D801

10k

R842

D841

BUP_1

R841

C801 3300u/16

C841

1u/10 1608

Q841 LTC014EEB

GND2

NM 1608

ISENS

C842

ISENS

D303

FL-

FL-

PBK

100k

D872

RR+

RR+

D873 R879

NM

R877

NM 1608

R876

FR+

FR+

1k 3216

BSN2

RR-

D

CKM1376-A

FR-

RL-

R878 Q872 NM

0.1u/50

L821 1608 C821

R821

NM C305

NM 1608 GNDD GNDA

GNDD

R880

C871

3.9k

B.REM

NM 1608

C861

D821

BSENS 47k

VCC3/4

21

TELMUTE

GNDD

10k R875

FL-

20

C306

GNDD

D871 UDZV6R2(B)

R874

HN1C01FU(YGR)

6 C1 5 B2 4 E2 Q871 1 E1 2 B1 3 C2

PW.GND3

19

POWER SUPPLY

ASENS

FL+

18

D304 NM

15k

LS_R

ACGND

17

NM

10k DAN202UM

DAN202UM

LS_L

RLIN

16

L852

ASENS

NM

RRIN

15

NM 1608

R881

NM C882

R882

NM 1608

NM 1608 C884

D881

22k

R873

S-GND

14

0.1u/16 1608

R866

47k

R872

FRIN

13

GNDD D853

R863

BSENS

100p/50 C308

C352

VDD33 1k

SH_R

PCNG

Q881 NM

R865

GNDD

12

GNDD

R305

NM

NM

NM

R884 NM

NM

0.1u/50 1608 C862

R868

PBSENS

R883

NM

NM 1608

AVSDA SH_L

FLIN

NM

(Rb=Rbe=10k)

C860

R861

AVSCL

47k

1k

SVR

11

PBSENS

Q854 1 6 E1 C1 R864 2 5 B1 B2 3 4 47k C2 E2 HN1A01FU(YGR)

R867

TELMUTE

EVSAOUT

C885

VDD33

GNDD

EVSCK

SPEED-App

C883

R894

EVSEL

NM

GND

NM NM

5

IC881 NM

3

R889 R890

R888 NM

R895 NM

EVSACLK

6

NM

4

R886

7

NM

(Rb=10K,Rbe=10k)

EVSDA

R892

NM

2

R885

VCC 8

1

NM

D883

IC881 NM

NM

R891

R887

GNDD Q882 NM

C886 NM

R893

R896

NM

C887

DD5

EVMUTE

RR-

GNDA

PCHANG

NM 1608

AMMUTE

B

10

RN1903

GNDA

OFFSET

RR+

100

DZ2J082M0 47k

100k Q301 LSCR523UB

C321

2

D302

R303

1.5k

RL-

R324

R322

5

10k

GNDA

NM

SYS+B

C346 NM

C340 NM

C345 NM

R321

RL+

0.1u/16 1608 C307

T1

6

R302

R304

C301

DA2J101

NM

D301

1

CCG1192-A 2125 10u

R301

OFFMUTE

9.0V

CCG1325-A C348

AMPMUTE Q321

C349 1u

2125

CCG1201-A 2125 4.7u

SYS+B

SYSMUTE

9 RL+

GNDA

NM

D311

NM R311

RL

7 RL8 PW.GND1

1608 0.22u C343 CCG1313-A 1608 0.22u C344 CCG1313-A

RR

5 RR+

FR+ C351

GNDA

AMPPW

FR

3 RR-

FR-

E2 4

1k

GNDA

FL

1 OFFSET 2 PW.GND2

Q331

R332

1k

SYS+B

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

IC341 PA2032A

47k R333

D

AVH-X1600DVD/XNUC AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC

PCB A 1/6 MOTHER (ANALOG BLOCK) NM

6 C1 RN4987

A B C

R331

R312 5 B2

E1 1

C311

B1 2

TE

D312 4 E2

100u/16 105

Q311 C2 3

DA2J101

A-SYS BUS

7

8

115

1

2

3

4

10.2 MOTHER PCB (SYSTEM BLOCK) (GUIDE PAGE) A

A-a 2/6

Large size SCH diagram

A-b

SYS+B

A-a

SYS-TUN BUS 6

5

4

CN751

1k

R759

VD8

9.0V

LS2 CKS6025-A

XRESET

B

C CN1952

GND

GNDD

AMTE

SYS-POWER BUS R752

470

R753

1k

1

8

2

7

SYSTOLS

3

6

LSTOSYS

9

IRQPWR

10

HSTCMD

11

SLVSTS

12

STANBY

13

AGND

14

ANA_R_OUT

15

AGND

16

ANA_L_OUT

17

AGND

18

MOVBS

19

VIDEO_GND

20

WAKEUP

21

D-

22

D+

23

DGND

24

LS2TX

S LS2

SRX

XRST

/XRST

IRQPW

IRQPW

STNBY

5

4

AMUTE

AMUTE

INNER BUS

8

RN4982

AMUTE

SYS-I/O BUS

1

7

Q752

6

VD5

PGND

Detailed page

A-b

3

5

PGND

DGND

A-a

2

PGND

PGD PGND

VD5

4

NM

PGND

NM

3

C753

2

VD8

CCG1192-A 10u 10V 2125 C757

1

VD8

CCG1192-A 10u 10V 2125 C755

VD8

C751 0.1u/10

Guide page

C754

A-b

NM C752

A-a

8.0V

SYS-SH BUS

STANBY

SYS-ANA BUS

C758 R751 220

NM LS_ROUT

GNDD

LS_R

LS_L

LS_LOUT R754 GNDA

0

LS_V

R757

25

DGND

26

SCL

27

SDA

28

CPRST

29

CPRDY

30

4.7k

R758

IECOUT

USB(LS2 Decode):+5.1 dBs DVD/CD(LS2):+5.1 dBs

4.7k Q751 6 1 C1 E1 5 2 B1 B2 4 3 E2 C2 HN1C01FU(YGR)

GNDV

GNDA

DGND GNDD

USB SW

C

R707

DM

100k

DP SOC33

IC751 BD11600NUX 1 1D+ 1D2D+ 2D-

2 3 4

11 FIN

5

GND

0 1608

R750

ASENBO

S CH MEDIA

WIREDPU

CONNECTED DEVICE

AVSDA

1D

Audio

TO SH Hi SPEED

H 2D

Video

TO LS2 FULL SPEED

L 10 VCC 9 S 8 D+ 7 D6 OE

AVSRST USB_SW

AVSCL

R700 R692

220 R612

R601

220

D+

R603 100k

D-

*

R605 100k 100k

0.1u/10

C756

R607

100

BSENS ASENS R622

REMIN

100 R609

GNDD

NM

WIRED D6 DB2J31

WIREDAD COMDC EVSAOUT

*

0

POS

R601

R602

R603

R604

R605

A

NM

NM

NM

NM

NM

B C D

100k 100k

NM

100k 100k

NM

100k

NM TEMPSENS

NM

NM

NM

NM C605

100k

E

100k 100k

F G

NM

NM 100k 100k NM NM NM 100k 100k NM 100k 100k NM 100k

NM

100k 100k

NM

KDT1 KDT0

NM

NM

NM

100k

CN601 NM

E

VDD

1

NC

2

GND

3

NRST

4

NDMOD

5

GND

6

SCL

7

GND

8

SDA

9

GND

10

RESET OSMD

OSCK

OSDA

GNDD

SYS-ANA BUS

SYS-SH BUS

601 - : SYSTEM 751 - : LS2

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

SYS-POWER BUS

SYS-I/O BUS CHIP SIZE LEGEND 1608 2125 3216

SYS-TUN BUS

F INNER BUS

A 2/6 116

AVH-X1600DVD/XNUC 1

2

C603

ANTSENS

R606

VDD33

D

R626

3

4

5

6

7

8

A

A-b 2/6 PCB A 2/6 MOTHER (SYSTEM BLOCK) SYS-TUN BUS

A 6/6

SYSPW

DDCCLK

VDCNT5

VDCNT8

BEEP

LCDPW

MOT0

AMPPW

TELMUTE

SHIRQ

ISENS

PBSENS

BGSENS0

YS-ANA BUS

A 5/6

SYS-POWER BUS

A 4/6

SYS-SH BUS

A 3/6

SYS-ANA BUS

A 1/6

A B C D

AVH-X1600DVD/XNUC AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

SHRST

SHMUTE

S

HIOUTCLK

MOTPW2

MOT1

B_PWM

R_PWM

G_PWM

SYS-I/O BUS

B

C690 NM

220

VDD33

2.7k

1k

R690

NM

R693

NM

R691

R694 NM

47k

R689

R695

100k

R687

NM R625

NM C618

C616

C617

NM

NM

NM

R697

R683

8.2k

47k

100k R698

R699

R681

R682

220

220

R705

GNDD

0.01u/16 C615

CCG1321-A 0.1u 50V 1608

C621

1000p/50 C614

TELMUTE

65

66

67

68

69

70

72

71

73

74

75

77

76

79

80

78

81

82

83

84

86

85

87

88

89

90

91

92

93

94

110

/BSENS

111

/ASENS

112

REMIN

113

NC

114

MODEL4/NC

115

NC

SYSPW

DDCCLK

BEEP

AMPPW

VDCNT5

VDCNT8

NC

LCDPW

TESTIN

TELMUTEIN

PBSENS

/BGSENS

/ISENS

CLKOUT

NC

NC

NC

NC

VSS

VDD50

FLAPLESS

HIOUTCLK

MOT0

MOT1

43 42

120

SAIN

121

POS

RXHD/NC

40

122

SXISENS/ANTSENS

TXHD/NC

39

/STB TXSOC RXSOC EVLMUTE

38

/SOCSTB

37

ATRST

SXIPWEN R702 NM

SXTOS

NM

NM

STOSX BLEND

R680

ANTPW

NM

TU3VON TU1VON

BTMIX AUTOANT R668

10k R619 R664

10k

1k

R666

TUNCLK

1k 100k

TUNRST

R665

TUNDATA

0

R703 NM

DTUNtoSYS STDT

R663

SMTE 47k

SACLK

R662

EVSEL

35

R661

EVSCK

34

R660

33

R659

D

SYStoDTUN C604

SYSMUTE R638

36

0.1u/10

SHSTBY

1k

EVSACLK

0 EVSEL 0 EVSCK 0 EVSDA 0

32

31

30

29

VSS

28

27

R701

47k R621

R658

NRST

VDD50

VOUT18

XO

SYSTOBT R672

41

SYSMUTE

EVSDA

100k

47k

NM

R649

C612 1000p/50

0.1u/10 VDD33

1k

R644

R645

TCK 4.7k R637

TSI 4.7k R636

26

25

C608

24

23

XI 22

21

DCH1246-A-T C619 1u/10

VSS

OSCI 20

TSO LTS

NM

R635

NM

R656

1k R633 STL

4.7k

R655

R631 100k

NM

R651 R630 47k

BTTOSYS

UGD

1 0.1u/10

0

NM C602

OSCO

VREFH

19

KDT0

R629

KDT1

1k

AVDD

NOCDMOD

127

AMUTE

126

470

BTRST

NM NM

R667

NC

IRQPW

470

128 R628

44

TUNDATA

18

R614

TUNCLK /TUNRST

17

R616

AUTOANT

45

COMDC

16

R613 4.7k R615 4.7k

46

WIREDAD

TEMPSEN

R673

47

119

125

NM

48

BTMIX

118

124

R675 NM R674 NM

R669

NM

WIRED

OSMD

0.1u/10

NM

50

NC

AVSS

R678

R676

51

117

123

FAN_PWM

NM R677

BTRT

49

NC

(OCD_SCL)

47k

C601

HDPWR11/NC

(OCD_SDA)

NM

R627

PDB118A8

TCK

NM

except A

R704 BTMD

R706

116

15

R679

NM

HDPWR33/NC

14

330p/50 D604

SXIPW/ANTPW

PDB117A8

13

R626

IC601

only A

OSCK

10k

57

BLEND

OSDA

R624

B_PWM

52

TSI

10k

R_PWM

53

TXSXI/NC

TSO

R623

A, B, C : J% D, E, F, G : D%

C605

54

RXSXI/NC

MODEL3/NC

12

D602 DB2J31400

C603

SXIPWREN/NC

MODEL2/NC

109

11

100k D601 RB501VM-40

0

MODEL1/NC

108

R610

NM

VSAOUT

107

/H&OSW

R609

55

10

100

56

BTTX

/BTRST

/XRST

R622

BTRX

MODEL0/NC

RXDVD

100k

58

AVSCK

9

R618

59

BTTESTIN

/AVSRST

8

SENS

100k

AEQAUXSW

60

FAN_PWM BTTESTMD

106

TXDVD

SENS

R617

62

105

MICSEN

R608

C

DDCERR

63

61 /DDCERR VSS AEQAUXSW NC

7

NM

100k

64

104

6

100k

100k

AVSDATA

5

R606

R605 100k

R607

WREMCONT

470

100k

TXIE/NC

102

R654

100k

R604

101

103

4

R602

ASENBO

470

*

R601 R603 100k

100

R653

220

GNDD

offset /GUIDEON /RGBARI TXNAVI RXNAVI

10k

R611

R612

NC

3

VSCL

100k

R692

NC

2

VSRST

10k

R620

R700

NC

MOTPWR2

99

G_PWM

98

SOCTESTIN SOCAMUTE1 SOCIRQPW /SOCXRST

97

100k

220

95

96

CLKOUT

NM

TESTIN

R707

VSDA

TESTIN1

47k

R688

PBSN

0.1u/10

C613

220

220 R686

220 R685

R684

L601

NM

NM D603

R650

NC1

E

SYS-TUN BUS

SYS-I/O BUS

SYS-POWER BUS

SYS-SH BUS

NM

SHtoSYS

SYStoSH RESET

F

RESET

STANBY

OSMD

AMUTE

IRQPW

OSDA

OSCK

LSTOSYS

XRST

H/OSW

MICSENSR

S

SYSTOLS

4 VSS

SYS-ANA BUS

CSS1839-A

N_TO_S

3

120

2 GND1

12.500MHz

S_TO_N

GNDD

EVMUTE

OFFSET

NM

C609 R646

1

R648

X2

GND2

3

R657

120

X601

X1

NM C611

C610

VDD

NM

4

RGBARI

5 NC2

2

0.1u/10

1u/10 DCH1246-A-T C620

47k

GUIDEON

IC602 1 OUT

R652

SYS-ANA BUS

100k

8p/50

R647

RST

C606

47k

R642

47k

R634

47k

R632

Q601 LSCR523UB

C607 10p/50

A 2/6 AVH-X1600DVD/XNUC 5

6

7

8

117

4

D602

NM

R609

100k

100k

NM

100k

100k

100k

D601 RB501VM-40

100k

R610

R608

R606

R604

R602

100k

R624

10k

10k

100k

R618

R623

100k

10k

10k

R617

R611

R620

99

98

97

117

116

115

114

113

112

111

110

109

108

107

106

105

104

103

102

101

100

TESTIN

SHMUTE

220

SHIRQ

WIRED

NC

NC

MODEL4/NC

NC

REMIN

/ASENS

/BSENS

MODEL3/NC

MODEL2/NC

MODEL1/NC

MODEL0/NC

AVSCK

/AVSRST

AVSDATA

WREMCONT

SHRST

93

R681

100k R698

95

TXIE/NC

47k

R683

220

C617

220

R682

94

ASENBO

NC

NC

C616

NM

R_PWM NM 89

G_PWM

R684

92

MOT1

90

MOTPW2

R697

NM

G_PWM

B_PWM

R_PWM

220 R685

91

MOTPWR2

C618 220 R686 88

MOT1

R687

HIOUTCLK 86

MOT0 220 87 MOT0

NM R625 HIOUTCLK

C613 85 FLAPLESS

R699

96

NC

only A except A

ISENS

PDB118A8

PDB117A8

IC601

83 NC

CLKOUT 82 VSS

VDCNT5 69

VDCNT8 70

/DDCERR VSS AEQAUXSW NC

AMPPW 68

SYSPW

FAN_PWM

2.7k

NC

TUNCLK

AUTOANT

BTMIX

HDPWR11/NC

HDPWR33/NC

SXIPW/ANTPW

BLEND

TXSXI/NC

RXSXI/NC

SXIPWREN/NC

BTTX

BTRX

/BTRST

BTTESTIN

BTTESTMD

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

8.2k

R705

NM

GNDD

AUTOANT

BTRT

BTMD

C690

A-a A-b

R667

NM

R706

10k

NM

C621

NM

R704

NM

R680

R669

R675 NM R674 NM

R677

0.01u/16 C615

R666

NM

R672

R673

R678

GNDD

NM

NM

NM

NM

L601

R668

NM

R702

NM

R676

SYS-ANA BUS

SYS-SH BUS

A 1/6

A 3/6

A 4/6

SYS-POWER BUS

A 6/6 A 5/6

VDD33

SYS-I/O BUS

SYS-TUN BUS

TU1VON

TU3VON

ANTPW

FAN_PWM

DDCERR

BTMIX

STOSX

SXTOS

SXIPWEN

SYSTOBT

BTTOSYS

BTRST

AEQAUXSW

TUNCLK

BLEND

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

A AVH-X1600DVD/XNUC B AVH-X1600DVD/XNEW5 C AVH-X1600DVD/XNUW5 D AVH-X1650DVD/XNRC

PCB A 2/6 MOTHER (SYSTEM BLOCK)

3

100k

100k

00k

R707

A-b 2/6

81 NC

NM B_PWM

SOCTESTIN SOCAMUTE1 SOCIRQPW /SOCXRST

80 NC

0.1u/10

79 NC

100k 84 VDD50

R688 77

78 CLKOUT

BGSENS0

/ISENS

PBSENS R695 PBSN 75 PBSENS

47k 76 /BGSENS

TELMUTE TELMUTE 74

LCDPW R694 NM TELMUTEIN

NM R689

73 LCDPW

TESTIN1 72 TESTIN

47k 71 NC

3 VDCNT8

AVH-X1600DVD/XNUC VDCNT5

BEEP R691 67

1k R693

2 66

DDCCLK R690

1 NM

118 AMPPW

1000p/50 C614

F 65

D BEEP

C

SYSPW

E 2

DDCCLK

B

CCG1321-A 0.1u 50V 1608

1 4

A

100k

R610

R613 4.7k R615 4.7k

10k

R624

R628

470

470

0.1u/10

NM C602

R614

R616

128

127

126

125

124

123

47k

0.1u/10

C601

NM

R627

122

121

120

119

118

117

116

115

114

113

112

R679

A, B, C : J% D, E, F, G : D%

10k

R623

A-b 2/6

NM

330p/50 D604

NM

D601 RB501VM-40

D602 2J31400

NM

R609

OFFSET

VREFH

KDT0

KDT1

AVDD

TEMPSEN

AVSS

SXISENS/ANTSENS

POS

SAIN

COMDC

WIREDAD

WIRED

NC

NC

MODEL4/NC

NC

REMIN

/ASENS

47k

R652

only A except A

(OCD_SCL)

111

TXDVD

R618

4

470

PDB118A8

PDB117A8

IC601

NOCDMOD

/BSENS

1

GUIDEON

2

R651

R630 47k

RGBARI

3

NM

Q601 LSCR523UB

5

470

R654

N_TO_S

R653

R631 100k

R632

S_TO_N

R655

47k

TSO 11

offset /GUIDEON /RGBARI TXNAVI RXNAVI 4.7k

RXDVD 47k

MICSEN

6

1k

R633

MICSENSR

7 STL R634 SYSTOLS

8 LTS LSTOSYS

/XRST 9 R635 XRST

/H&OSW 10 R656 H/OSW

TSI 12

TSO NM NM

TSI 4.7k R636

(OCD_SDA) 14 OSDA OSDA

TCK 13 TCK 4.7k R637

OSCO 19 R629

MODEL3/NC

OSCK

IRQPW 16 IRQPW

C607

1

4

X601

CSS1839-A

GND1

X2

12.500MHz

X1

GND2

8p/50

C606

10p/50

2

3

ATRST

110

R644

18 OSMD OSMD

15 R642 OSCK

XI 22

DCH1246-A-T C619 1u/10

21

AMUTE 17 47k AMUTE

OSCI 20 0

1k

VSS

XO 23 C608

UGD

VDD50 24 0.1u/10 VDD33

1u/10 DCH1246-A-T C620

VOUT18 25 C610

VSS 27 1k

NRST 26

C612 1000p/50 R645 RST 0.1u/10

NC

EVSDA

EVSCK

EVSEL

SACLK

/SOCSTB

SYSMUTE

TXHD/NC

RXHD/NC

NC

TUNDATA

/TUNRST

TUNCLK

AUTOANT

BTMIX

HDPWR11/NC

HDPWR33/NC

SXIPW/ANTPW

BLEND

TXSXI/NC

32

/STB TXSOC RXSOC EVLMUTE 29 100k

28 R701 R658 RESET

31 47k

100k

NM NM

100k

120 R646

47k R621 STANBY

30 R647 SYStoSH

AUTOANT

R660 R659

34 33

A-a A-b

R661

35

NM

R703

R662

R663

R664

36

37

38

39

40

41

42

43

44

45

46

47

48

R667

NM

50 49

R706

51

0

0

0

0

47k

10k

10k

SMTE

STDT

1k

R619

NM

R680

R666

NM

GNDD

0.1u/10

C604

100k

1k

R638

0

R665

1k

R668

R650 C609

R617

3

2

1

VSS

VDD

NM

IC602 OUT

NC1

NC2 4

5

EVSDA

EVSCK

EVSEL

EVSACLK

SYSMUTE SHSTBY

TU1VON

TU3VON

ANTPW

BTMIX

STOSX

SYStoDTUN

DTUNtoSYS

TUNDATA

TUNRST

TUNCLK

BLEND

6

AVH-X1600DVD/XNUC

7 RESET

R649 120 R648 SHtoSYS

100k R657 EVMUTE

NM

NM D603

6 NM

NM

SYS-POWER BUS

R608

SYS-TUN BUS

100k

SYS-ANA BUS

5 NM C611

5 7 8

A

B

C

D

8 E

119

F

SYS-I/O BUS

SYS-SH BUS

A-a 2/6

2

CN1952

C

F

3

3

4

5

6

7

8

9

10

11

12

13

VD8

PGND

PGND

PGND

VD5

AMUTE

XRESET

IRQPWR

HSTCMD

SLVSTS

STANBY

22

23

24

D-

D+

DGND

30

CPRDY

28

SDA

29

27

SCL

CPRST

26

DGND

25

21

WAKEUP

IECOUT

20

18

AGND

19

17

ANA_L_OUT

MOVBS

16

AGND

VIDEO_GND

15

ANA_R_OUT

14

2

VD8

AGND

1

VD8

GND

PGD

GNDD

GNDV

GNDA

LS_LOUT

LS_ROUT

SRX

LS2TX

DGND

LS2

S

GNDD

DGND

PGND

PGND

8.0V

0

R754

NM

C758

VD5

AVH-X1600DVD/XNUC

4

GNDD

GND

5

4

3

2

FIN

11

IC751 BD11600NUX

SYS+B R759

6 5

4

7

3

2

SOC33

10 VCC 9 S 8 D+ 7 D6 OE

1D

H 2D

L Video

Audio

S CH MEDIA

STNBY

TO LS2 FULL SPEED

TO SH Hi SPEED

CONNECTED DEVICE

GNDA

STANBY

LSTOSYS

SYSTOLS

XRST IRQPW

IRQPW

8

R757

1

AMUTE

D-

D+

WIRED

REMIN

WIREDPU

ASENBO

USB_SW

DP

DM

LS_V

LS_L

LS_R

ASENS

BSENS

AVSCL

AVSRST

AVSDA

100

R622

220

R612

220

R700

SYS-ANA BUS

SYS-SH BUS

SYS-POWER BUS

SYS-I/O BUS

SYS-TUN BUS

*

R607

NM

100k

100k

100k

D601 RB501VM-40

100k

R610

R608

R606

R604

R602

100k

D602

NM

R609

100k

100k

R605 100k

R603 100k

R601

R692

100k

R707

R62

R62

R6

R6

R

R6

A-b 2/6

3

2D-

2D+

1D-

1D+

1

USB SW

2

/XRST

AMUTE

6

1k

R751 220

470

5

R753

R752

USB(LS2 Decode):+5.1 dBs DVD/CD(LS2):+5.1 dBs

GNDD

C751 0.1u/10

AMTE

C753

C754

NM C752

VD8 CCG1192-A 10u 10V 2125 C757 CCG1192-A 10u 10V 2125 C755

CKS6025-A

R750

CN751

9.0V

C

0 1608

B

C756

2

0.1u/10

LS2

NM NM

1k 4

1 3

A-a A-b

RN4982

120 4.7k 4.7k Q751 6 1 C1 E1 5 2 B1 B2 4 3 E2 C2 HN1C01FU(YGR)

E Q752

D 1

A

R758

1 4

INNER BUS

5

F G

E NM

NM

100k 100k

NM

100k NM

NM

NM

R605

NM

NM

R604

100k

NM

NM

R606

NM

NM

6

AVH-X1600DVD/XNUC 2 3 4 5 6 7 8 9 10

NC GND NRST NDMOD GND SCL GND SDA GND

A-a A-b

1

VDD

NM

CN601

VDD33

GNDD

OSDA

OSCK

OSMD

RESET

7

C605

C603

100k

R610

R608

NM

R613 4.7k R615 4.7k

R628

C6

R6

A D, E

R62

R62

R6

R6

A-b 2/6

NM

330p/50 D604 NM

D601 RB501VM-40 D602 DB2J31400

NM

R609

100k

7

INNER BUS

SYS-TUN BUS

0

R626

SYS-ANA BUS

EVSAOUT

SYS-SH BUS

SYS-POWER BUS

ANTSENS

SYS-I/O BUS

KDT0

KDT1

TEMPSENS

POS

COMDC

WIREDAD

WIRED

100

R622

R607

6

CHIP SIZE LEGEND 1608 2125 3216

601 - : SYSTEM 751 - : LS2

100k

NM 100k 100k NM NM NM 100k 100k NM 100k 100k NM 100k NM

NM

NM

100k 100k

B C D 100k 100k

NM

NM

NM

A 100k 100k

R603

R602

C756

R601

0.1u/10

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

*

GNDD

REMIN

ASENS

BSENS

5 8

A-a 2/6

8

121

A

B

C

D

E

F

1

2

3

4

10.3 MOTHER PCB (SH BLOCK) (GUIDE PAGE) A

A-a 3/6 RGB VIDEO ISOLATOR DD5

Vcc15

227

PF21/SD_CMD_0/SCK3/MMC_CMD

VDEC_D3

228

PF22/SD_D3_0/RxD3/MMC_D3

VDEC_D2

229

PF23/SD_D2_0/TxD3/MMC_D2

230

PD0/D0/PWM1A

231

PVcc19

232

PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7

233

Vss21

D1

234

PD1/D1/PWM1B

D2

235

PD2/D2/PWM1C

D3

236

8

1

5

4

6

3

7

2

8

1

R1105 470

C1105 0.1u/10

NC1 A11 A9 A8 A7 A6 A5 A4 VSS1

D8

1 UDQM

470 L1107 CTF1645-A C1108

40 39 38

47p/50

R1112

37 R1110

470

35

5

4

34

6

3

33

7

2

32

8

1

31

5

4

30

6

3

29

7

2

28

8

1

36

R1111 470

SDCK

470 R1113 NM

CKE

A9

B4

VDEC_D5

B3

C1366

C1363 56p/50

L1413 100 VTL1126-A L1411 100 VTL1126-A L1409 100 VTL1126-A L1407 100 VTL1126-A

VTL1126-A

R1406 167

0.1u/10

C1346

R1410

R1408 168

100 C1345

0.1u/10

C1344

A8

170

171

PB6/A6/TIOC1B L1315

SH-SYS BUS

A5 A4

SH-I/O BUS

M12L128168A-5TG2N

WE

A 3/6 AVH-X1600DVD/XNUC 2

3

4

27

PB5/A5/TIOC1A

PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC

PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD 24

23

Vcc2

PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK 22

Vss2

PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7

PVcc3

PB4/A4/TIOC0D 20

19

21

DAMT18

PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6

17

A7 A6

166

PG13/D29/LCD_DATA13/PINT5

PG14/D30/LCD_DATA14/PINT6

PG15/D31/LCD_DATA15/PINT7

PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0

PVcc13

PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F

172

173 PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G

PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175 Vss15 174

177

178

179

176 Vcc13

PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H

180 PG18/DV_DATA4/LCD_DATA18/SPDIF_IN/SCK4

PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5

PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5

PB2/A2/TIOC0B

PB1/A1/TIOC0A

PB3/A3/TIOC0C

SH-POWER BUS

INNER BUS

1

16

SH-TUN BUS

A12 A11

C1315

D9

2 220 R1106

100

8

0.22u/16

7

0.1u/10

41

R1418

C1107

42

C1399

43

D10

0.1u/10

3

C1314

6

100k

44

GNDD

122

L1313

4

L1312 VTL1127-A

5

USBCNT

CKE

D11

45

100k

CLK

R1109

46

R1319

NC2 UDQM

1

220

47

0.1u/10 R1318

VSS2

8

D12

C1313

DQ8

MD_CLK0

MDCLK

NM

D13

4.7k

VDDQ3

256

R1301

D14

26

F

7

2

DQ9

2

A5

A3

3

DQ10

3

7

25

A2

6

0.1u/10

4

6

A4

A1

4

48

5

DIMMER

A0

1

DQ11

PD15/D15/NAF7/PWM2H

A3

A10

R1104 8 470 5

49

C1106

VDDQ4 DQ12

255

DACMUTE

BA1

2

50

VSSQ3

D15 D15

51 DQ14 DQ13

PD14/D14/NAF6/PWM2G

PD13/D13/NAF5/PWM2F

USBFLG

BA0

3

7

52 VSSQ4

Vss23

254

A1

SDCS

4

6

R1108

253

D14

A2

RAS

53

PD12/D12/NAF4/PWM2E

D13

A0

CAS

0.1u/10

VSS3 DQ15

SDCS

WE

R1103 470 5

54

VDD1 2 DQ0 3 VDDQ1 4 DQ1 5 DQ2 6 VSSQ1 7 DQ3 8 DQ4 9 VDDQ2 10 DQ5 11 DQ6 12 VSSQ2 13 DQ7 14 VDD2 15 LDQM 16 WE 17 CAS 18 RAS 19 CS 20 BA0 21 BA1 22 A10_AP 23 A0 24 A1 25 A2 26 A3 27 VDD3

C1312

LDQM

251

0.1u/10

C1104

PVcc21

0.1u/10

PD9/D9/NAF1/PWM2B

R1315

1

250

CKE

220

C1308

PD8/D8/NAF0/PWM2A

CAS

8

PD11/D11/NAF3/PWM2D

C1311

2

7

PD10/D10/NAF2/PWM2C

249

4.7k

3

248

D11

R1313 4.7k

6

D10

R1312 4.7k

C1103 0.1u/10

247

R1314 4.7k

D7

1

4

246

D9

RAS

D6

220 R1102

5

PD7/D7/FWE/PWM1H

D8

UDQM

D5

245

LDQM

8

D4

0.1u/10

D7

1

2

PD6/D6/FALE/PWM1G

L1311

3

7

PD4/D4/FRE/PWM1E PD5/D5/FCLE/PWM1F

244

252

1

Vss22

242 243

C1310

4

6

NM

R1346

D3

5

241

47k

D2

0.1u/10

R1307

R1101

D0 D1

PVcc20

D6

D12

IC1101 0.1u/10 C1102

240

15

SDRAM

CTF1786-A

L1101

SOC33

C1101

PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7

C1307

0.1u/10

C1069

0.1u/10

0.1u/10

C1068

47k

R1054

C1066

0.1u/10

C1061

0.1u/10

0.1u/10

C1059

GNDD

PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7

PJ27/SGOUT_3/TIOC1A/CTS7

D5

D4

GNDD

PD3/D3/PWM1D

239

R1423 2.2k R1430

237 238

SDO BLSYNC

HSYNC

E

SDO

13

SDI

VDECSTUS

VSYNC

0.1u/10

SDI

14

560

L1305 VTL1126-A

VDEC_FLD

4.7k

VDEC_HD

220

PC7/CKE/RxD7/CRx1/CRx0/CRx1/IRQ1

SSCK

SSCK

PC8/CS3/TxD7/CTx1/CTx0&CTx1

VDEC_VD

0.1u/10

Vcc1

C1306

PC6/CAS/SCK7/CTx0/CTx0&CTx1&CTx2

220

VDEC_D0

PVcc2

390

D0

VTL1127-A 12

0.1u/10

PF20

11

VDEC_D4

VDEC_D1

390

B2

C1364 56p/50 C1365 56p/50

PF20/SD_CLK_0/SSIDATA3/MMC_CLK

226

VDEC_D5

560

C1086

R1412

Vss20

225

R1345 47k C1305

GNDD

GNDV

B1

B0

PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0

224

120

Vss1

390

L1415

223

VDEC_D6

390

R1414

PVcc18

0.1u/10

R1305

R1306

USB_SW

BLEN

390

0.1u/10

222

NM

VDEC_D7

390

181

PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5

C1304

R1304

MTCHRST

VDECCLK

100k

390

PVcc14

PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7

221

PJ11

NM

9

R1070

VTL1127-A

PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6

220

R1375

8

R1069

33

0

PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1

219

NM

10

34

C1343

PF17/SD_WP_0/FRB/IRQ5

218

PCHANG

VDCRST

L1051 CTF1740-A

390

182

PF16/SD_CD_0/FCE/IRQ4/MMC_CD

217

R1374

PC5/RAS/CRx0/CRx0/CRx1/CRx2/IRQ0

R1068

L1306

Vss19

216

PC4/WE1/WE/DQMLU/TxD6

R1067

0

PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5

215

PC3/WE0/DQMLL/RxD6

R1066

R1427

PVcc17

214

NM

NM

7

R1064 R1065

R1416

213

R1421

6

R1063

0

PF15/A0/SSIDATA2/WDTOVF/TxD2/UBCTRG

C1303 0.1u/10

R1072

0.1u/10

R1062

R1379

PF14/A25/SSIWS2/RxD2

212

C1074

R1061

0.1u/10

PF13/A24/SSISCK2/SCK2

211

R1368

SHTOBT

0.1u/10

R1060

184

210

NM R1377 BTTOSH

only A, E

C1073

183

PF12/SSIDATA1/DV_DATA3/TxD1/MMC_D7

4

100

185

PF11/SSIWS1/DV_DATA2/RxD1/MMC_D6

209

R1317 NM

R1074 2.2k R1075 2.2k

PF10/CS1/SSISCK1/DV_DATA1/SCK1/MMC_D5

208

R1373

BGSENS1

100

PVcc16

R5S7269* PC1/RD 2 PVcc PVcc1 3 PC2/RD/WR/SCK6

0

R1076

0 CCG1192-A 10u

C1076

10u C1072

CCG1192-A

NM

PF10

Vss18

4

1

R1399

0.1u/10

205

207

32

31

30

DATA_BT

C1302

4

1

3 3 X1051 CSS1818-A C1070

2

2

R1056

R1055

STATUS DVDD_C3 DGND3 DVDD_IO2 DE 29

28

SLEEP

DGND2

27

TEST3

TEST2

DVDD_C2 25

24

26

R1394

NM

SHIRQ

R1073

Vss16

PF9/BS/DV_DATA0/SCK0/MMC_D4/RTS1

LRCLK

47k C1075

C1085 5p/50

Vcc14

PF8/A23/TxD0

204

PF9

R1397

R1071

0.01u/16

PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4

203

R1310

NM

GNDD

PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2

PF7/SSIRxD0/RxD0/SGOUT_3/CTS1

27k

NM

VDEC_FLD

R1057

GNDV

0

202

SHtoSYS

R1309

V_SCL0 V_SDA0

5p/50

470 R1058 1M

100

100 R1059

0

4.7k

R1053

C1064 0.1u/10

CCG1192-A

75 C1062

C1063 10u

1000p/50 C1060

0.01u/16

R1051

C1079 1u/10

VSI

R1082

75 R1090

NM NM

R1091

R1081 75

C1081 1000p/50 C1080 0.01u/16

47

RESETN 46 CLKO DVDD_IO3 45 DGND4 44 DVDD_C4 43 DO7 42 DO6 41 DO5 40 DO4 39 DO3 38 DO2 DO1 37 DO0 VSYNC_L 36 HSYNC_L FID 35

ML86V7675TBZA3A

TEST1

C1078 1u/10

GNDV

48

L1377 VTL1126-A

PF6/CE2A/SSITxD0/SGOUT_2

SYStoSH

100 R1302

NM

NM

C1071 5p/50

IC1051

23

0.47u/6.3

0.01u/16

21

0.47u/6.3 C1052

19

C1053 0.47u/6.3

D

C1056

20

C1051

C1082 1u/10

GIN1 3 GIN2 AVDD1 4 AGND1 5 BIN1 6 BIN2 7 REF 8 REFP 9 REFN 10 AGND2 11 TAOUT 12 RIN1 13 RIN2 14 AVDD3 15 AGND3 16 CSYNC_A

DVDD_C1 DGND1 DVDD_IO1 CHSI

NM

R1089

R1084 75

C1055 1000p/50

2

18

C1054 0.01u/16

17

NM

R1085

R1088 75

1

22

C1083 1u/10

0

PF5/SSIWS0/SGOUT_1

201

56p/50

R1308

206

32.000MHz

63 AGND4 AVDD4 62 CVBS4 61 CVBS3 60 CVBS2 59 CVBS1 58 PGND_A 57 PVDD_A 56 DVDD_IO4 55 SAS 54 DGND5 53 DVDD_C5 52 SCL 51 SDA XOSCO 50 XOSCI 49

C1058 64

R1083

0 CCG1192-A

10u C1057

GNDV

1u/10 R1052

VDEC15 VDEC33

C1360 47p/50

PF4/CS5/CE1A/SSISCK0/SGOUT_0

200

NM

DATA

R1077

C1067

0.1u/10

C1065

NM

R1086

NM

NM

Q1051 NM

189

PF3/CS2/QMI_1/QIO1_1/MISO1/TIOC4D/AUDIO_XOUT/SPBMI_1/SPBIO1_1

199

LRCK

BCLK

186

PF2/WAIT/QMO_1/QIO0_1/MOSI1/TIOC4C/TEND0/SPBMO_1/SPBIO0_1

198

C1361 R1390

BCK

0.1u/10

0 C1077

NM R1079 NM R1087 NM

R1080

R1078

C1084

187

Vss17

197

FIO1_1

GNDD

188

PVcc15

PF1/BACK/QSSL_1/SSL10/TIOC4B/DACK0

FIO0_1

NM

PF0/BREQ/QSPCLK_1/RSPCK1/TIOC4A/DREQ0/AUDCK

194 195 196

FCS1

0.1u/10

FLCS_1

VDEC15 VDEC33

PG24/LCD_CLK

C1301

PG23/LCD_DATA23/LCD_TCON6/TxD5/AUDATA3

193

FLCLK_1

VIDEO DECODER

PG22/LCD_DATA22/LCD_TCON5/RxD5/AUDSYNC

GNDV

L1052

100k C1342

PG18 PG19

MONVBS

GNDV

0 R1426 0 R1425 330 R1365

ANG

1u/10

0.1u/10 R1316

N_G

BH7673G

PG19/DV_DATA5/LCD_DATA19/SPDIF_OUT/SCK5

4

VCC

GNDSIG

VTL1127-A

0.1u/10

GND

1u/10 C1018

5

3 C1009 0.1u/10

NM

C1017

R1311

GNDV

L1009

only A, E

5

190

2

PG25/LCD_TCON0

1

100

PG26/LCD_TCON1

R1009

ANB

1u/10

IC1004

R1393 100 R1342

N_B

BH7673G

CTF1545-A Q1004 LSCR523UB

1u/10 C1016

4

VCC

192

L1003

GND

GNDSIG

C1390

0.1u/10

3 C1008 0.1u/10

NM

C1015

5

2

GNDV

L1008

iCOMP

1u/10

10p/50

IC1003 1

GNDV

ANR

1u/10 C1014

100 iPodVideo 26pim

R1376

N_R R1013

BH7673G

100

Q1001 LSCR523UB

1u/10 C1013

4

VCC

191

GND

NM GNDSIG

PG27/LCD_TCON2/LCD_EXTCLK

3 C1007 0.1u/10

NM

R1010

2

GNDV

L1007

GNDV

C

GNDD

C1381 C1012

5

169

SH-ANA BUS

56p/50

SH-TUN BUS

6p/50

C1383

CSYNC

1u/10

IC1002 1

L1002

C1003

1u/10 C1011

L1378 NM

N_CSYNC

CTF1545-A

C1004

4

BH7673G

NM

C1002

GND VCC

0.1u/10

B

3 C1005 0.1u/10

NM

100

2

GNDV

L1006

R1012 Q1002 LSCR523UB

GNDSIG

R1378

L1004 CTF1545-A

C1010

C1378 NM

5

C1362

GNDD

IC1001 1

VDEC_D6

VDCRST DIO

LOAD

CLK

SH-POWER BUS

GNDV

VDEC_D7

DEEM POL

VCLK

C1382

GNDV

0

C1001

0.1u/10

15p/50

SH-SYS BUS R1381

100

Q1003 LSCR523UB

10u 2520

L1005 C1006

R1011

SH-I/O BUS

10u 10V CCG1192-A

L1001 CTF1545-A

INNER BUS

5

6 C1332

0.1u/10

R1391 C1385 NM C1384 1u/10

PLLVss1 86

XTAL 85 R1328

EXTAL 84 1k

2.2k

L1302 C1333

CTF1545-A

0.1u/10 R1329

79

NMI C1335 R1330

CPPW

PE5/SDA2/RxD5/DV_HSYNC 75 PE4/SCL2/RxD4/DV_VSYNC 74 R1334

R1333 47k

R1324

DCH1246-A-T

R1338 100k

47k

100k R1387

47k 4.7k

NM

0

100k R1332

100

GNDUSB

0.1u/10 R1340

R1339

AVH-X1600DVD/XNUC R1424

7

0.1u/10 CPRST

DP

12p/50

VDEC_HD CPPW

VDEC_VD

PE3/SDA1/TCLKD/ADTRG/DV_HSYNC 73 72 PE2/SCL1/TCLKC/IOIS16/DV_VSYNC 71 R1383

C1391 CP_SCL

V_SCL0 V_SDA0

C1392 NM

27k CPRST

LPSYNC FLSIO1

MTCH_SDA0 MTCH_SCL0 FLCS

R1348 100 R1337 100

GNDD

SHRST

NM

SH-SYS BUS

GNDUSB

47

CP_SDA

11

FLSIO2 R1258 47

FLSIO3 R1260

ASEMDJ

R1281

TDOJ

R1282

ASEBRKJ

R1283

TRSTJ

R1284

TMSJ

R1285

TDIJ

R1286

TCKJ

R1287

FIO0_1

GNDD

100

CP_SCL R1205

CP_SDA R1206

DM

R1327

except P-V

C1340

SHMUTE

47

VDECCLK

TAGGING

NM

NM

NM

NM

NM

R1288

A, D CXX5989

B, C, E, F, G CXX5991

FLCK R1251 22 16

FLSIO0 R1257

*

15

14

13

12

10

SHSTBY R1259 9

220

CPPW

SCK

SI

DNU2 VIO

DNU4

DNU3

SOC33_1

10

11

12

8

7

IC1202 337S3959

9

1

2

GND

SDA

0.1u/10 CCG1192-A 10u

C1154

C1153

8

9

10

11

12

13

820

R1152

GNDA

MCK

DACMUTE

GNDA

100 2.2k

VSS NC 5 RFU 6

WP CS 7 SO 8

1

SOC33

2

MDMP

3

TDO

4

ASEBRE

5

TRST

6

TMS

NM

7

TDI

NM

8

TCK

9

A_RST

R1203

R1201 2.2k

12p/50

FLASH

13.3333MHz

V D5

820

R1151

SOC12

C1156

ASEMDJ

IC1251

HOLD 1

0.1u/10

10p/50 VCC

48.000MHz

NC1

R1422 NM

3

BCK

RST

PAD

LRCK

6

4

VDECSTUS

SCL

5

10p/50 NC2

100k

CCG1192-A 10u

R1435

NM C1152

14

1800p/50

R1202 18k C1201

C1328 NC3

R1434 100k C1151

GNDD IC1151 WM8761BGED

0.1u/10

1 LRCIN MCLK 2 DIN FORMAT 3 BCKIN DEEMPH 4 NC1 NC2 5 CAP MUTE 6 VOUTR VOUTL 7 GND VDD

0.01u/16

C1358 VTL1129-A

CCG1192-A 10u

SH_R

SH_L

TCKJ

TRSTJ

ASEBRKJ

TDOJ

TDIJ

TMSJ

7

8 0.1u/10

C1331

DEEM

CTF1786-A

0.1u/10

C1357 CCG1192-A 10u

L1303

C1251

RTC_X2 90 RTC_X1 89 F%

330p/50 C1355

VTL1129-A

LSAR523UB Q1201

104

USB5

5.6k 2

NM

48.00MHz

GNDD

NM

96 GND1 X1 CSS1760-A

SOC33_1

NM

97

USBDVcc 1

R1411

A 1/6

R1254

USBDVss

SH-ANA BUS

GND4

98

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

L1251

REFRIN

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

C1252

99

1000p/50 C1356

SH-TUN BUS

R1262 NM R1261 NM

USBAPVss SOC33

C1330 0.1u/10

0.01u/16

R5

R4

R3

D

AVH-X1600DVD/XNUC AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC

NM

VBUS 95 DP 94

330p/50 C1386

C1380 56p/50

56p/50

C1379

C1377 56p/50

6

C1287

NMI C1324

13.3333MHz

C1329 0.1u/10

100

1u/10 DCH1246-A-T

101

2

USBAVcc

USBAPVcc

GND1 X1 CSS1840-A

5 4

L1381 VTL1126-A

L1383 VTL1126-A

VDEC_D0

VDEC_D1

VDEC_D2

VDEC_D3

VDEC_D4

VDEC_D5

VDEC_D6

VDEC_D7

A B C

0

PVcc8 78 PE7/SDA3/RxD7 77 PE6/SCL3/RxD6 76 C1327

1

DM 93 USBDPVss 92 USBDPVcc 91

A 5/6 A 2/6 A 4/6

0 R1253

Vcc8 82 ASEMD 81 Vss8 80 0.1u/10 680

C1387

1000p/50 C1389

6 3

100

100

56p/50

C1376

R0 R1 R2

G5

G4

G3

G2

G1

G0

B5

B4

B3

B2

B1

B0

INNER BUS

MX25L8006EM2I-12G

83 R1326

R1256

C1326

0.1u/10

7 R1349 HOLD 0 6 SCLK 4 GND 5 SI/SIO0

111

3 WP

112

VDAVcc

X2 3

VDAVss

2 SO/SIO1

PLLVcc

C1388

7 2

47k

R1352 8 1

1k

R1351

R1380

R1382

C1353 12p/50

100 L1384 VTL1126-A

A 6/6

0

USB_X2 106 USB_X1 105 X1301

R1336 NM BLR R1431 100k PH0/AN0/PINT0 118 R1325 BIAS 117 R1401 24k F% VRB 116 R1403 NM VRT 115 R1405 NM VIN2 114 NM R1407 VIN1 113 119

100k

GND2

R1432

4

PH2/AN2/PINT2 120

C1336

100k

R1331 10k

121

R1419

RES 88 PLLVss2 87

X2 3

PH3/AN3/PINT3

X1302

102 NM

GND2

USBAVss R1433

4

103 R1409

8

USBUVcc C1325

0.1u/10

0.1u/10

USBUVss NM

VCC

107 100k

IC1301

108

PVcc9 R1436

1 CS

129

C1354 0.1u/10

R1385

12p/50

56p/50 56p/50

C1375

C1373 56p/50

C1369 56p/50 C1370 56p/50

C1364 56p/50 C1365 56p/50

C1374

C1372 56p/50

56p/50

C1371

56p/50

C1368

56p/50

C1367

56p/50

C1366

C1363 56p/50

56p/50

SH-SYS BUS

FIO1_1

FLCS_1

C1341

TRST

C1352 0.1u/10

100 VTL1126-A

L1397

L1401 100 VTL1126-A L1399 100 VTL1126-A

L1403 100 VTL1126-A

L1394 100 VTL1126-A L1393 R1392 100 VTL1126-A R1389 L1391 100 L1390 VTL1126-A R1388 L1387 100 VTL1126-A VTL1126-A R1386 100 C1351 R1395

R1396

R1398

R1400

R1402

L1405 100 VTL1126-A

L1413 100 VTL1126-A L1411 100 VTL1126-A L1409 100 VTL1126-A L1407 100 VTL1126-A

VTL1126-A

C1362

SH-POWER BUS

0

R1335

131

132

133

1.5k

R1350

0.1u/10

C1350

0.1u/10

C1349

0.1u/10

C1348

0.1u/10

C1347

R1404

R1406

R1408

100

L1415

SH-I/O BUS

NM

PH5/AN5/PINT5/LCD_EXTCLK 123 PH4/AN4/PINT4 122

C1394

109

VIDEO_X1

C1334 0.1u/10

PH6/AN6/PINT6 125 AVss 124

ASEBRKAK/ASEBRK 130

TDO

TDI

TMS

PG0/D16/LCD_DATA0/IRQ0/TIOC0A 136 135 Vss10 TCK 134

PG1/D17/LCD_DATA1/IRQ1/TIOC0B 138 Vcc9 137

PVcc10 141 PG2/D18/LCD_DATA2/IRQ2/TIOC0C 140 Vss11 139

AUDIO_X1 143 AUDIO_X2 142

128 AVref PH7/AN7/PINT7 127 AVcc 126

NM

PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK

100 PE0/SCL0/TCLKA/LCD_EXTCLK 70 R1323 100 69 PJ31/DV_CLK 68 R1384 PJ30/SSIDATA5/TIOC2B/IETxD 1k 67 PJ29/SSIWS5/TIOC2A/IERxD TP1301 66 PJ28/SSISCK5/TIOC1B/RTS7 65 PA1/MD_BOOT1

PA0/MD_BOOT0

Vcc7 VIDEO_X2

NM

64

63

Vss9 110

C1393

L1323

VTL1127-A

PVcc7

Vss7

CKIO

PH1/AN1/PINT1

C1395

NM

100k

PB22/A22/CTx2/IETxD/CS4

PC0/CS0/MD_BOOT2

R5S72690RW266FP

0.1u/10

C1323

R1321

62

61

60

59

58

Vcc6

PB21/A21/CRx2/IERxD

Vss6

PB20/A20/QMI_0/QIO1_0/MISO0/SPBMI_0/SPBIO1_0

PB19/A19/QMO_0/QIO0_0/MOSI0/SPBMO_0/SPBIO0_0

PB18/A18/QSSL_0/SSL00/SPBSSL

Vcc5

PB17/A17/QSPCLK_0/RSPCK0/SPBCLK

IC1302

NM C1396

NM

VTL1127-A

PB22

NM C1397

C1322

PB21

0.1u/10

L1322

56

57

PB16/A16/QIO3_0/SPBIO3_0

Vss5

146

147

148

PG3/D19/LCD_DATA3/IRQ3/TIOC0D 145 Vss12 144

Vcc10

PG4/D20/LCD_DATA4/IRQ4/TIOC1A

PG5/D21/LCD_DATA5/IRQ5/TIOC1B

149

C1346 0.1u/10

R1410

R1412

4

55

54

53

52

51

50

49

PVcc6

PB15/A15/QIO2_0/SPBIO2_0

PB14/A14/QIO3_1/SPBIO3_1

PG6/D22/LCD_DATA6/IRQ6/TIOC2A

PJ0/DV_DATA0/LCD_DATA0/SD_CD_1/PWM1A 151 PG7/D23/LCD_DATA7/IRQ7/TIOC2B 150

C1345 0.1u/10

1

0.1u/10 R1320 100k

46

45

47 MT10 48

PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1

PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1

155

156

157

158

159

160

161

162

163

164

165

166

167

168

169

Vss13 154 PJ1/DV_DATA1/LCD_DATA1/SD_WP_1/PWM1B 153 PVcc11 152

PG8/D24/LCD_DATA8/PINT0/TIOC3A

Vcc11

PJ2/DV_DATA2/LCD_DATA2/SD_D1_1/PWM1C

PJ3/DV_DATA3/LCD_DATA3/SD_D0_1/PWM1D

PJ4/DV_DATA4/LCD_DATA4/SD_CLK_1/PWM1E

PG9/D25/LCD_DATA9/PINT1/TIOC3B

PG10/D26/LCD_DATA10/PINT2/TIOC3C

PVcc12

PG11/D27/LCD_DATA11/PINT3/TIOC3D

Vss14

PG12/D28/LCD_DATA12/PINT4

Vcc12

PG13/D29/LCD_DATA13/PINT5

PG14/D30/LCD_DATA14/PINT6

PG15/D31/LCD_DATA15/PINT7

PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0

170

171

172

173

GND2

C1359 C1398

R1344 15

L1319

VTL1127-A

44

PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2

Vcc4

PB13/A13/QIO2_1/SPBIO2_1

Vss4

PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2

PVcc5

PJ19/DV_DATA19/LCD_DATA19/MISO0/TIOC0D/SIOFRxD/AUDIO_XOUT

PB12/A12/TIOC3D

PVcc13

PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G

PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F

R1414

X1

C1321

47k

0.1u/10 R1322

C1320

0.1u/10

42

41

40

TPIRQ 43

VTL1127-A

39

SCS 38

L1318

VTL1127-A

37

36

35

PB11/A11/TIOC3C

PB10/A10/TIOC3B

PB9/A9/TIOC3A

Vcc3

PB8/A8/TIOC2B

Vss3

PB7/A7/TIOC2A

PVcc4

PB6/A6/TIOC1B

PB5/A5/TIOC1A

PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD

PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC

PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK

Vcc2

PB4/A4/TIOC0D

Vss2

C1344 0.1u/10

16.9344MHz

SDCK

100k

C1319

R1341

0.1u/10

C1318

0.1u/10

L1317

34

33

32

31

30

29

28

27

26

25

24

23

22

177

Vcc13 176 PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175 Vss15 174

GND1

FLSIO1

0 R1356 0

R1347

SCS

C1317

20

19

21

_

X1303 CSS1794-A

FLSIO0

0

0

NM

NM

0

0

0

NM

0

L1301

CTF1786-A

VTL1127-A

L1316

VTL1127-A

L1315

100

R1418

_ PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H

3 X2

FLCS

R1360

R1359

R1358

R1357

R1429

R1428

R1355

R1354

R1353

47p/50

C1309

0.1u/10

C1316

0.1u/10

C1315

0.22u/16

C1399

0.1u/10

C1314

100k

PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7

PVcc3

PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6

2

FLCK

FLSIO3

FLSIO2

BA1

OEV

STV2

TPIRQN

0

R1303

USBCNT

100k

R1319

16

17 DAMT18 GNDD

BA0

BA1

A12

BA0

MCK

A11

A10

A9

A8

A7

A6

A5

A4

DIMMER

L1305 VTL1126-A

PBIO1_1

A3

NM

C1313

0.1u/10 R1318

O0_1

DACMUTE

USBFLG

5 8

A-b 3/6 A

PCB A 3/6 MOTHER (SH BLOCK) 1001 - : RGB VIDEO ISO 1051 - : VIDEO DECODER 1101 - : SDRAM 1151 - : DAC 1201 - : IPOD CP 1251 - : FLASH 1281 - : JTAG 1301 - : SH PART CHIP SIZE LEGEND 1608 2125 3216

B

SC33 L1304 SOC33

USB(SH Decode):+2.2 dBs

DAC 1800p/50

C1155

CTF1786-A

L1151

DATA

C1157 NM

C

BLERR GNDD

C1337

ipod CP

C1338

R1209 C1202 1000p/50

L1201 GNDD

NM

D

C1339 SHRST GNDD

*

SOC33

47k

VCC 2 RESET 3 DNU1 4

CXX5989

47

E

R1252

FLCLK_1

47

to JTAG JIG

GNDD

CN1281

NM

SOCRST

GNDD

GND

GND

SH-I/O BUS

F

INNER BUS

A 3/6

123

3

4 IC1302

R5S72690RW266FP

164

Vss14

165

PG12/D28/LCD_DATA12/PINT4

166

Vcc12

167

PG13/D29/LCD_DATA13/PINT5

168

PG14/D30/LCD_DATA14/PINT6

169

PG15/D31/LCD_DATA15/PINT7

170

PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0

171

PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F

172

PVcc13

173

PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G

157

158

PJ3/DV_DATA3/LCD_DATA3/SD_D0_1/PWM1D

159

PJ4/DV_DATA4/LCD_DATA4/SD_CLK_1/PWM1E

160

PG9/D25/LCD_DATA9/PINT1/TIOC3B

161

PG10/D26/LCD_DATA10/PINT2/TIOC3C

149

PG6/D22/LCD_DATA6/IRQ6/TIOC2A

VDEC_D7 C1344 0.1u/10

R1414 100

L1415 VTL1126-A

GNDD

163

156

Vcc11

PJ2/DV_DATA2/LCD_DATA2/SD_D1_1/PWM1C

148

B0 C1362 56p/50

VDEC_D6

C1345 0.1u/10

VDEC_D5 R1412

C1363 56p/50

L1413 100 VTL1126-A L1411 100 VTL1126-A L1409 100 VTL1126-A L1407 100 VTL1126-A

R1410 R1408 R1406 C1346 0.1u/10

R1404

R1398

B3 B4

B5

C1367 56p/50

L1403 100 VTL1126-A

R1400

B1 B2 C1364 56p/50 C1365 56p/50

C1366 56p/50

L1405 100 VTL1126-A

R1402 C1347 0.1u/10

G0

C1368 56p/50

L1401 100 VTL1126-A L1399 100 VTL1126-A

G1 C1369 56p/50 C1370 56p/50

G2 VDEC_D4 VDEC_D3 VDEC_D2

C1348 0.1u/10

L1397

R1396

G3

100 VTL1126-A

C1371 56p/50

VDEC_D1

C1349 0.1u/10

C1350

VDEC_D0 L1394 R1395 100 VTL1126-A R1392 L1393 100 VTL1126-A R1389 L1391 100 L1390 VTL1126-A R1388 L1387 100 VTL1126-A VTL1126-A R1386 100 C1351

0.1u/10

GND1

GND2

C1352

X1

1.5k

X1303 CSS1794-A

3 X2

2

12p/50

R1350

4

1

0.1u/10

C1353 12p/50

C1372 56p/50

G4 G5 C1373 56p/50

56p/50

C1376

56p/50

C1375

56p/50

C1374

16.9344MHz C1377 56p/50

C1354

100

R1382

100 L1384 VTL1126-A

R1385

100

R0 R1 R2

R3 R4

C1379

L1383 VTL1126-A

0.1u/10 R1380

56p/50

L1381 VTL1126-A

R5

TCKJ

TDIJ TDOJ

REFRIN

USBDVss

USBAPVss

USBAPVcc

USBAVcc

USBAVss

USBUVcc

USBUVss

97 5.6k F%

R1327

100

98

C1330 0.1u/10

101

99

0.1u/10

C1329 0.1u/10

102

C1328

C1327

0.1u/10 R1326 680

103

104

107

108

0.1u/10

109

110

NM

C1326

NM

111

R1407

112

R1405 NM

24k F%

R1325

C1338

10p/50

10p/50

GNDD

C1337

48.000MHz

GNDUSB

GNDD

VTL1129-A

L1304

VTL1129-A

L1303

SOC33

A 1/6

BLERR VDECSTUS

CPRST

BCK

DATA

LRCK

MCK

220

except P-V

DAC

ipod CP

R1209

DACMUTE

DEEM

USB(SH Decode):+2.2 dBs

GNDA

C1156

GNDD

L1201

NM

C1202 1000p/50

C1157

C1155

1800p/50

GNDA

1800p/50

CHIP SIZE LEGEND 1608 2125 3216

820

GNDD

L1151

CTF1786-A

1001 - : RGB VIDEO ISO 1051 - : VIDEO DECODER 1101 - : SDRAM 1151 - : DAC 1201 - : IPOD CP 1251 - : FLASH 1281 - : JTAG 1301 - : SH PART

PCB A 3/6 MOTHER (SH BLOCK)

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

A AVH-X1600DVD/XNUC B AVH-X1600DVD/XNEW5 C AVH-X1600DVD/XNUW5 D AVH-X1650DVD/XNRC

SH_R

SH-ANA BUS

SOC33_1

R1422 NM

SC33

A 6/6

R1336 NM

R1434 100k

100k

0.1u/10

R1435

R1403 NM

R1401

113

114

USB_X2 106 USB_X1 105

PVcc9

VIDEO_X1

Vss9

VDAVcc

VIDEO_X2

VDAVss

VIN1

VIN2

VRB 116 VRT 115

100k

R1432

120

119

100k

R1433

NM

R1409

C1325

C1324

0.1u/10

NM

100k

A 5/6 A 2/6 A 4/6

R1436

R1411

121

128

BLR R1431 100k PH0/AN0/PINT0 118 BIAS 117

PH1/AN1/PINT1

PH2/AN2/PINT2

AVref

SH-TUN BUS

PH3/AN3/PINT3

TRSTJ

SH_L

SH-POWER BUS

PH6/AN6/PINT6 125 AVss 124

1k

820

R1152

9

0.1u/10 C1154

SH-SYS BUS

PH5/AN5/PINT5/LCD_EXTCLK 123 PH4/AN4/PINT4 122

TMSJ

132

ASEBRKJ R1351

129

7

2

C1358

14 13 12 11 10

8

C1153

SH-I/O BUS

PH7/AN7/PINT7 127 AVcc 126

TRST

6

3

47k

1000p/50 C1356 0.01u/16

C1387

CCG1192-A 10u

330p/50 C1355 0.01u/16

LRCIN MCLK DIN FORMAT BCKIN DEEMPH NC1 NC2 CAP MUTE VOUTR VOUTL GND VDD

GND

C1380 56p/50

TMS

TDI

TDO 131 ASEBRKAK/ASEBRK 130

R1352 8 1

5

4

C1388 330p/50 C1386

1000p/50 C1389

6 7

SDA

2

INNER BUS

2

NC2 4

NC1

3 9

R1151

A-a A-b

X1301

X2 3

GND2

48.00MHz

SOC12

IC1151 WM8761BGED

4

NM C1152

NC3 5

PAD

6 7

VDCRST

177

Vcc13 176 PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175 Vss15 174

162

PVcc12

PG11/D27/LCD_DATA11/PINT3/TIOC3D

155

PG8/D24/LCD_DATA8/PINT0/TIOC3A

Vss13 154 PJ1/DV_DATA1/LCD_DATA1/SD_WP_1/PWM1B 153 PVcc11 152 PJ0/DV_DATA0/LCD_DATA0/SD_CD_1/PWM1A 151 PG7/D23/LCD_DATA7/IRQ7/TIOC2B 150

147

PG4/D20/LCD_DATA4/IRQ4/TIOC1A

PG5/D21/LCD_DATA5/IRQ5/TIOC1B

Vcc10 146 PG3/D19/LCD_DATA3/IRQ3/TIOC0D 145 Vss12 144 AUDIO_X1 143 AUDIO_X2 142 PVcc10 141 PG2/D18/LCD_DATA2/IRQ2/TIOC0C 140 Vss11 139 PG1/D17/LCD_DATA1/IRQ1/TIOC0B 138 Vcc9 137 PG0/D16/LCD_DATA0/IRQ0/TIOC0A 136 135 Vss10 TCK 134 133

4

1

GND1 X1 CSS1760-A

C1357 CCG1192-A 10u

SOC33

1 2 3 C1151

5

CCG1192-A 10u

LSAR523UB Q1201

SCL RST

CCG1192-A 10u

A-b 3/6

PBIO1_1

O0_1

PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5 PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H

AVH-X1600DVD/XNUC

VCC

2

1

1

IC1202 337S3959

124

8

F E D C B A

V D5

1

2

3

4

8

125

USBFLG

7 A2

R1317 NM

A-b 3/6

C1313

AVH-X1600DVD/XNUC PB3/A3/TIOC0C L1305 VTL1126-A

0.1u/10

100k

C1314

R1319

C1399

16 17 DAMT18

0.1u/10 R1318

DACMUTE

100k A3

DIMMER

R1418 100

0.22u/16

USBCNT

PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6 PVcc3

Vcc2

21

PB4/A4/TIOC0D

20

Vss2

19

25

A4

VTL1127-A

PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7

PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK

22 23 24

26

A5 L1315

C1315 0.1u/10

A6

A7 L1316

PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD PB5/A5/TIOC1A PB6/A6/TIOC1B

PB7/A7/TIOC2A

28

PVcc4

27

PB8/A8/TIOC2B

30

Vss3

29

33

A9

PB9/A9/TIOC3A

32

A8

Vcc3

31

VTL1127-A

0.1u/10

L1301 C1309

CTF1786-A SCS

36 L1317

C1317

VTL1127-A

0.1u/10

37 SCS 38

40 NM

R1357

BA0

0

R1347 0 R1356 0

L1318

C1318

41 42

TPIRQ 43

R1341 100k

44

0

45

NM

46

NM

L1319

C1319

47 MT10 48

PB10/A10/TIOC3B PB11/A11/TIOC3C PB12/A12/TIOC3D PJ19/DV_DATA19/LCD_DATA19/MISO0/TIOC0D/SIOFRxD/AUDIO_XOUT PVcc5 PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2 Vss4 PB13/A13/QIO2_1/SPBIO2_1 Vcc4 PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2 PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1 PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1 PB14/A14/QIO3_1/SPBIO3_1 PB15/A15/QIO2_0/SPBIO2_0 PVcc6 PB16/A16/QIO3_0/SPBIO3_0

50

Vss5

49

PB18/A18/QSSL_0/SSL00/SPBSSL

Vcc5

51

C1320

54

PB19/A19/QMO_0/QIO0_0/MOSI0/SPBMO_0/SPBIO0_0 PB20/A20/QMI_0/QIO1_0/MISO0/SPBMI_0/SPBIO1_0

PB21 PB22

Vcc6

PB21/A21/CRx2/IERxD

56

Vss6

55

PC0/CS0/MD_BOOT2

61

PVcc7

Vss7

PVcc8

NMI

CPPW

NMI

CTF1545-A

L1302

1k

R1391

A-a A-b

78

79

82

83

84

85

86

87

ASEMD 81 Vss8 80

Vcc8

PLLVcc

EXTAL

XTAL

PLLVss1

PLLVss2

RTC_X1 89 RES 88

USBDPVcc 91 RTC_X2 90

DM 93 USBDPVss 92

96

97

98

99

100

101

102

103

VBUS 95 DP 94

USBDVcc

USBDVss

REFRIN

USBAPVss

USBAPVcc

USBAVcc

USBAVss

USBUVcc

USBUVss

C1334 0.1u/10

104

PE7/SDA3/RxD7 77

PA0/MD_BOOT0 Vcc7

NM

NM

USB_X2 106 USB_X1 105

PE3/SDA1/TCLKD/ADTRG/DV_HSYNC 73 72 PE2/SCL1/TCLKC/IOIS16/DV_VSYNC 71 R1383 PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK 100 PE0/SCL0/TCLKA/LCD_EXTCLK 70 R1323 100 69 PJ31/DV_CLK 68 R1384 PJ30/SSIDATA5/TIOC2B/IETxD 1k 67 PJ29/SSIWS5/TIOC2A/IERxD TP1301 66 PJ28/SSISCK5/TIOC1B/RTS7 PA1/MD_BOOT1 65

PB22/A22/CTx2/IETxD/CS4

58

57

59 60

64

VTL1127-A

NM C1396

C1395

C1393 NM

PE6/SCL3/RxD6 76 PE5/SDA2/RxD5/DV_HSYNC 75 PE4/SCL2/RxD4/DV_VSYNC 74

VTL1127-A

0.1u/10

63 L1323

0.1u/10

IC1302

34

A10 R1303 0

R1353

BA0

39

0

VTL1127-A

0.1u/10

R1355 R1428

STV2

R1358

BA1

0

VTL1127-A

0.1u/10

0

PB17/A17/QSPCLK_0/RSPCK0/SPBCLK

52

0.1u/10 R1322 47k

SDCK

CKIO

62 R1321

100k

C1323

R5S72690RW266FP

C1316

35

A11 MCK

47p/50

R1354

A12 BA1

0

TPIRQN

R1429

OEV

R1359

FLSIO2

R1360

FLSIO3

FLCK

FLCS

53

FLSIO0 FLSIO1

C1321 0.1u/10 R1320 100k L1322

C1322 R1344 15 NM

C1359 C1398

6

F E D

NM C1397

5

C1394

100k

R1324

NM

R1331 10k

4.7k

C1336

4

G

1 X1 C

USB5

SHRST

FIO0_1

FLCLK_1

CPRST

VDECCLK

V_SCL0

V_SDA0

CP_SCL

CP_SDA

VDEC_VD

CPPW

VDEC_HD

R1284

R1285

R1286

R1287

TRSTJ

TMSJ

TDIJ

TCKJ

GNDD

R1283

ASEBRKJ

NM

R1282

R1288

R1281

TDOJ

47

R1252

47

R1259

ASEMDJ

FLCS

FLSIO1

R1260

47

R1258 47

FLSIO3

47

R1257

R1251 22

R1206

R1205

GNDD

NM

NM

NM

NM

NM

NM

NM

SOC33_1

12 GND

GND

TCK

8

SOCRST

TDI

7

11

TMS

6

A_RST

TRST

5

9

ASEBRE

4

10

TDO

3

NM

MDMP

SOC33

SOC33

GNDD

R1202 18k C1201

VCC

5 6 7 8 I 33

GNDD

CN1281

2

1

CS 7 SO 8

NC 5 RFU 6

RESET 3 DNU1 4

2.2k

2.2k

HOLD 1 VCC 2

CXX5989

VSS

WP

DNU3

DNU2

DNU4

VIO

SI

RST

NM

IC1251

SCK

R1203

R1201

GND4

L1201

L1251 CTF1786-A C1251

C1202 1000p/50

to JTAG JIG

GNDD

9

10

11

12

13

14

15

16

FLASH

*

CXX5991

100

100

CXX5989

except P-V

FLSIO2

FLSIO0

FLCK

A, D

B, C, E, F, G

*

CP_SDA

CP_SCL

CPPW 220

SOC33

R1209

R1262 NM R1261 NM

LSAR523UB Q1201

NC3 SCL

C1252 NM

R1254 NM

CPRST

NM

ASEMDJ

INNER BUS

R1348 100 R1337 100

LPSYNC

MTCH_SDA0 MTCH_SCL0

SH-I/O BUS

SHSTBY

DM

DP

SHMUTE

0

SHRST

SH-SYS BUS

C1392 NM

C1340

12p/50

C1339

12p/50

1u/10 DCH1246-A-T

2

100

13.3333MHz

R1387

X2 3

GND2

GND1 X1 CSS1840-A

R1332

TAGGING

R1339

0

GNDUSB

X1302 4

1

GNDUSB

R1424

27k

GNDD

R1333 47k

C1391

R1334 47k

47k

47k

100k

0.1u/10 R1340

C1335

R1330

0.1u/10 R1329

C1333

2.2k

R1328

R1338 100k

DCH1246-A-T

C1332

0.1u/10

C1385 NM C1384 1u/10

0.1u/10

F%

C1331

5.6k

R1327

C1330 0.1u/10

0.1u/10

0

C1328

8 7 R1349 6

13.3333MHz

C1338

3

R1256 0 R1253

10p/50

0

5

C1329 0.1u/10

0 C1341 0.1u/10 IC1301 1

FLCS_1

2

R1419

FIO1_1

4

CS VCC SO/SIO1 HOLD WP SCLK GND SI/SIO0

MX25L8006EM2I-12G

C1287

0.1u/10 R1326 680

NM R1335

C B A

0.1u/10

0.1u/10

5

6

7

8

R1088 75

84 5

R1085

89

NM

M

0.1u/10

L1002

L1003

CTF1545-A

GNDV

C1002

CTF1545-A

GNDV

C1003

GNDV

NM

NM

C1082 1u/10

C1055 1000p/50

C1054 0.01u/16

C1083 1u/10

R1083

VDEC33

R1078

GNDV

C1084

R1080

C1001

0.1u/10

0.1u/10

0.1u/10

GIN1 3 GIN2 AVDD1 4 AGND1 5 BIN1 6 BIN2

2

1

GNDV

Q1051 NM

NM

100

R1009

100

R1010

VDEC15

NM

L1009

NM

L1008

NM

L1007

NM

100

L1052

Q1004 LSCR523UB

Q1001 LSCR523UB

Q1002 LSCR523UB

L1006

R1012

3

2

1

3

2

1

3

2

1

3

2

BH7673G

VCC

GND

IC1004

BH7673G

VCC

GND

IC1003

BH7673G

VCC

GND

IC1002

BH7673G

VCC

GND

IC1001

GNDD

VIDEO DECODER

C1009 0.1u/10

GNDV

C1008 0.1u/10

GNDV

C1007 0.1u/10

GNDV

C1005 0.1u/10

GNDV

1

C1058

C1004

10u C1057

C1065

1000p/50 C1060

CTF1545-A

75 C1062

GNDV

4.7k

64

0 C1077

0

CCG1192-A

NM

L1005 C1006 C1067

L1004

0.1u/10 R1053

NM R1079 NM R1087 NM

R1086

10u 2520 10u 10V CCG1192-A

GNDV

100 R1059

100

0.1u/10 R1055

C1071 5p/50

32.000MHz

RESETN 46 CLKO DVDD_IO3 45 DGND4 44 DVDD_C4 43 DO7

47

48

N_G

N_B

VDEC15 VDEC33

4

5

4

5

N_R

N_CSYNC

100 iPodVideo 26pim

R1013

4

5

4

5

100

R1073

GNDD

R1060

0.1u/10

C1074

0.1u/10

C1073

C1085 5p/50

0.01u/16

47k C1075

R1071

1u/10

1u/10 C1018

C1017

1u/10

1u/10 C1016

C1015

1u/10

1u/10 C1014

1u/10 C1013

C1012

1u/10

1u/10 C1011

C1010

A-a A-b

VDCRST VDECCLK

VDEC_D7

L1051 CTF1740-A

100

R1072

only A, E

V_SCL0 V_SDA0

BCLK

NM

PF9

196

195

194

193

BCK

VDEC_FLD

DATA

LRCK

BLEN

MTCHRST USB_SW

NM

R1306

R1304

100k

NM

PCHANG

BGSENS1

R1421 SHTOBT

NM

NM

R1368

SHIRQ

R1399

BTTOSH

DATA_BT

LRCLK

R1394

NM

NM

120 0.1u/10

C1304

R1305

NM

R1375

R1374

0.1u/10

C1303

NM

NM R1377

R1373

0.1u/10

C1302

27k R1397

SHtoSYS

R1310

NM R1309

SYStoSH

56p/50

100 R1302

NM

NM

R1308

PJ11

PF10

224

223

222

221

220

219

218

217

216

215

214

213

212

211

210

209

208

207

206

205

204

203

202

201

200

199

198 C1361

FCS1

FIO1_1

0.1u/10

C1301

only A, E

197 R1390

MONVBS

iCOMP

SH-ANA BUS

SH-TUN BUS

SH-POWER BUS

FIO0_1

FLCS_1

FLCLK_1

ANG

GNDSIG

ANB

GNDSIG

ANR

GNDSIG

CSYNC

GNDSIG

SH-SYS BUS

SH-I/O BUS

INNER BUS DEEM

NM

C1381

GNDD

C1382

15p/50

DIO

CLK

PG18 PG19

VDCRST

A-b 3/6

Vss20

PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0

PVcc18

PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5

PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7

PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6

PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1

PF17/SD_WP_0/FRB/IRQ5

PF16/SD_CD_0/FCE/IRQ4/MMC_CD

Vss19

PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5

PVcc17

PF15/A0/SSIDATA2/WDTOVF/TxD2/UBCTRG

PF14/A25/SSIWS2/RxD2

PF13/A24/SSISCK2/SCK2

PF12/SSIDATA1/DV_DATA3/TxD1/MMC_D7

PF11/SSIWS1/DV_DATA2/RxD1/MMC_D6

Vss18

PF10/CS1/SSISCK1/DV_DATA1/SCK1/MMC_D5

PVcc16

PF9/BS/DV_DATA0/SCK0/MMC_D4/RTS1

PF8/A23/TxD0

PF7/SSIRxD0/RxD0/SGOUT_3/CTS1

PF6/CE2A/SSITxD0/SGOUT_2

PF5/SSIWS0/SGOUT_1

PF4/CS5/CE1A/SSISCK0/SGOUT_0

PF3/CS2/QMI_1/QIO1_1/MISO1/TIOC4D/AUDIO_XOUT/SPBMI_1/SPBIO1_1

PF2/WAIT/QMO_1/QIO0_1/MOSI1/TIOC4C/TEND0/SPBMO_1/SPBIO0_1

Vss17

PF1/BACK/QSSL_1/SSL10/TIOC4B/DACK0

PVcc15

PF0/BREQ/QSPCLK_1/RSPCK1/TIOC4A/DREQ0/AUDCK

C1390

R1011

1

R1425 R1365

Q1003 LSCR523UB

1

POL 191

CTF1545-A

R1051 0.01u/16

0 C1064 0.1u/10

10u C1072 4 4

190

0 0

DD5

0

VDEC_D7 177

RGB VIDEO ISOLATOR

100 R1056

R1076 CCG1192-A

6p/50 0.1u/10

L1001

C1063 10u

1u/10 R1052 CCG1192-A

470 R1058 1M

4 2

AVH-X1600DVD/XNUC

63 AGND4 AVDD4 62 CVBS4 61 CVBS3 60 CVBS2 59 CVBS1 58 PGND_A 57 PVDD_A 56 DVDD_IO4 55 SAS 54 DGND5 53 DVDD_C5 52 SCL 51 SDA XOSCO 50 XOSCI 49

F 2

VDEC_D6

GNDD

3

5p/50

E C1070

0

R1077 C1076

3 CCG1192-A 10u

2

3 3 X1051 CSS1818-A

R1074 2.2k R1075 2.2k

10p/50 192 PG27/LCD_TCON2/LCD_EXTCLK

VCLK R1376

330 PG26/LCD_TCON1

C1378 NM L1377 VTL1126-A

R1381 R1378 189 PG24/LCD_CLK

R1427 R1379

0 R1426 0 0 PG25/LCD_TCON0

0 0

L1306 R1416

C1383 VTL1127-A 0 C1343

LOAD 185

C1360 47p/50 R1393 100 R1342 188 PG23/LCD_DATA23/LCD_TCON6/TxD5/AUDATA3

100k C1342 186 Vcc14

187 PG22/LCD_DATA22/LCD_TCON5/RxD5/AUDSYNC

C1344

Vcc13 176 PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1 175 Vss15 174

L1378 NM 0.1u/10 PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2

184 Vss16

183 PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4

182 PVcc14

181 PG19/DV_DATA5/LCD_DATA19/SPDIF_OUT/SCK5

180 PG18/DV_DATA4/LCD_DATA18/SPDIF_IN/SCK4

179 PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5

178 PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5

L1415 R1414

C1362 VTL1126-A 100

B0 0.1u/10

56p/50 173

C1345 172 PVcc13

2

PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G

B1 C1363 56p/50 L1413 100 VTL1126 A

1

VDEC_D5 0.1u/10

126 R1412

A-a 3/6 171

D 170

C PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F

B PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H

A PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0

1 4

GNDV

0.47u/6.3

0.47u/6.3 C1052

C1051

R1088 75

R1084 75

A3

A2

A1

A0

A10

BA1

BA0

SDCS

RAS

CAS

WE

LDQM

D7

D6

D5

D4

D3

D2

D1

D0

GNDV

0.1u/10

C1086

C1079 1u/10

C1081 1000p/50 C1080 0.01u/16

C1078 1u/10

0.01u/16

C1056

3

2

1

6

7

8

3

2

1

6

7

8

2

1

4

3

2

1

4

3

2

1

7

R1104 8 470 5

6

7

8

5

6

7

8

R1105 470

3

6

220

4

5

R1102

220

4

5

R1101

4

GNDD

GIN1 3 GIN2 AVDD1 4 AGND1 5 BIN1 6 BIN2 7 REF 8 REFP 9 REFN 10 AGND2 11 TAOUT 12 RIN1 13 RIN2 14 AVDD3 15 AGND3 16 CSYNC_A

2

R1103 470 5

CCG

C1082 1u/10

C1055 1000p/50

C1054 0.01u/16

C

ML86V7675TBZA3A

IC1051

0.1u/10

C1105

0.1u/10

C1104

0.1u/10

C1103

0.1u/10

0.1u/10 C1102

C1101

SOC33

27

26

25

24

23

22

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

47

48

VSS1

A4

A5

A6

A7

A8

A9

A11

NC1

CKE

CLK

UDQM

NC2

VSS2

DQ8

VDDQ3

DQ9

DQ10

VSSQ3

DQ11

DQ12

VDDQ4

DQ13

DQ14

VSSQ4

VSS3 DQ15

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

0.1u/10

C1107

0.1u/10

C1106

GNDD

SDRAM

560

R1057

5

8

7

6

5

8

7

6

5

1

2

3

4

1

2

3

4

R1111 470

NM

1

2

3

4

1

2

A-a A-b

A4

A5

A6

A7

A8

A9

A11

A12

470 R1113

4 3

CKE

R1112

SDCK

UDQM

D8

D9

D10

D11

D12

D13

D14

D15

VDECSTUS

VDEC_FLD

VDEC_HD

VDEC_VD

VDEC_D0

VDEC_D1

VDEC_D2

VDEC_D3

VDEC_D4

VDEC_D5

VDEC_D6

VDEC_D7

470

47p/50

VDCRST VDECCLK

L1051 CTF1740-A

100

R1072

GNDD

220

220

390

390

390

390

390

390

390

390

0.1u/10

470 L1107 CTF1645-A C1108

220 R1106

R1109

220

R1110

8

7

6

5

8

7

6

R1108

560

R1070

R1068

R1067

R1066

R1065

R1064

R1063

R1062

R1061

R1060

C1074

0.1u/10

C1073

C1085 5p/50

33

100

R1073

GNDD

R1069

C1070

34

RESETN 46 CLKO DVDD_IO3 45 DGND4 44 DVDD_C4 43 DO7 42 DO6 41 DO5 40 DO4 39 DO3 38 DO2 DO1 37 DO0 VSYNC_L 36 HSYNC_L FID 35

M12L128168A-5TG2N

VDD3

A3

A2

A1

A0

A10_AP

BA1

BA0

CS

RAS

CAS

WE

LDQM

VDD2

DQ7

VSSQ2

DQ6

DQ5

VDDQ2

DQ4

DQ3

VSSQ1

DQ2

DQ1

VDDQ1

VDD1 DQ0

IC1101

2 2

1 C

GNDV GNDD

R1082

R1081 75

1

17

C1059

NM

C

18

R1085

0.01

20

NM

1000 C

19

C1061

0.1u/10

VSI 21

TEST1 22

R1089

CCG TEST2 23

C1053 0.47u/6.3

NM

75 R1090

C 0.1 C1066

DVDD_C1 DGND1 DVDD_IO1 CHSI

0.1u/10

NM

4

25

33 CS 5p/50

R 26

DGND2 27 R1054

0.1u/10

SLEEP 28 47k

DVDD_C2

29 C1068

TEST3 24 L1101

R1091

R1056 30 0.1u/10

CTF1786-A

31 C1069

STATUS DVDD_C3 DGND3 DVDD_IO2 DE

64

R1055

63 AGND4 AVDD4 62 CVBS4 61 CVBS3 60 CVBS2 59 CVBS1 58 PGND_A 57 PVDD_A 56 DVDD_IO4 55 SAS 54 DGND5 53 DVDD_C5 52 SCL 51 SDA XOSCO 50 XOSCI

R 49 32 0.1u/10

HSYNC

VSYNC

NM

2.2k R1430

R1423

100k

NM

SH-TUN BUS

SDO

SDI

SSCK

R1306

R1304

SH-POWER BUS SH-SYS BUS

USB_SW

SH-I/O BUS

BLSYNC

INNER BUS

D15

D14

D13

D12

D11

D10

D9

D8

D7

D6

D5

D4

D3

D2

D1

D0

BLEN

MTCHRST 120

SSCK

NM

R1301

256

255

254

253

252

251 0.1u/10

249

248

247

246

245

244

243

242

241

240

239

238

237

250

MDCLK

SDO

SDI

236

235

234

233

232

231

230

229

228

227

226

225

C1308

0.1u/10

C1307

0.1u/10

C1306

0.1u/10

R1345 47k C1305

224

223

0.1u/10

221

220

219

222

PF20

PJ11

218

217

C1304

R1305

NM

NM

47k

R1375

PD14/D14/NAF6/PWM2G

PD13/D13/NAF5/PWM2F

Vss23

PD12/D12/NAF4/PWM2E

PVcc21

PD11/D11/NAF3/PWM2D

PD10/D10/NAF2/PWM2C

PD9/D9/NAF1/PWM2B

PD8/D8/NAF0/PWM2A

PD7/D7/FWE/PWM1H

PD6/D6/FALE/PWM1G

PD5/D5/FCLE/PWM1F

PD4/D4/FRE/PWM1E

Vss22

PVcc20

PJ27/SGOUT_3/TIOC1A/CTS7

PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7

PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7

PD3/D3/PWM1D

PD2/D2/PWM1C

PD1/D1/PWM1B

Vss21

PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7

PVcc19

PD0/D0/PWM1A

PF23/SD_D2_0/TxD3/MMC_D2

PF22/SD_D3_0/RxD3/MMC_D3

PF21/SD_CMD_0/SCK3/MMC_CMD

Vcc15

PF20/SD_CLK_0/SSIDATA3/MMC_CLK

Vss20

PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0

PVcc18

PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5

PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7

PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6

PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1

PF17/SD_WP_0/FRB/IRQ5

PF16/SD_CD_0/FCE/IRQ4/MMC_CD

MD_CLK0

PD15/D15/NAF7/PWM2H

C1310

PCHANG

0.1u/10

BGSENS1

PC2/RD/WR/SCK6

3

only A, E

PVcc2

0.01u/16

6

C1083 1u/10

R1307

Vss19

PC6/CAS/SCK7/CTx0/CTx0&CTx1&CTx2 8

216

9

215

Vcc1

R1374

L1311 NM

PC8/CS3/TxD7/CTx1/CTx0&CTx1

SHIRQ

R5S7269* 1 PC1/RD 2 PVcc PVcc1 R1346

PB3/A3/TIOC0C 15

R1071

PC3/WE0/DQMLL/RxD6

4 4.7k R1312 4.7k LDQM

VTL1127-A R1311 WE

PC4/WE1/WE/DQMLU/TxD6 5

R1313 4.7k UDQM

PC5/RAS/CRx0/CRx0/CRx1/CRx2/IRQ0 RAS

7 C1311 R1314 4.7k

L1312 VTL1127-A 0.1u/10 CAS

Vss1 R1315

PC7/CKE/RxD7/CRx1/CRx0/CRx1/IRQ1 10 4.7k CKE

11 L1313 C1312

PB2/A2/TIOC0B 14 4.7k A1

VTL1127-A 12 0.1u/10 R1316 SDCS

PB1/A1/TIOC0A 13 A0

PVcc3

7

A-b 3/6

C1313

Vcc2

47k C1075

0.1u/10 R1318

PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6 16 R1317 NM A2

PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7 17 DAMT18 L1305 VTL1126-A USBFLG

7

DACMUTE

Vss2 19 100k

PB4/A4/TIOC0D 20 A3

PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK 21 C1314 R1319

PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC 23 100

22 R1418

6

C1399

5

0.1u/10

AVH-X1600DVD/XNUC

100k

6

DIMMER

5 8

A-a 3/6

8

127

A

B

C

D

E

F

1

2

3

4

1

NM

R1858

NM

3

NM

NM

R1836

R1831

GNDA

VIN

CONT 1

GND

VOUT

NC

TUN5

2

3

4

VIN

GND

CONT

TU5

1

2

5

3

NC

1 Vin

TUN5

R1903

1u/10

C1902

C1901

CCG1192-A

1u/10

NM

CRG03

NM

GNDD

R1902

0

GNDD

L1901

D1902

D1901

NM

10u

NM

C1912

NC

2.2u/10

4

TU33

NM

CRG03

C1911 CCG1218-A-T

4.7u

ON/OFF

D1921

5

NM D1922

VSS2

TUN33

IC1901 NJM2886DL3-05 5.0V

D1911

6

NM

VSS1

3

TUPW VIN

C1923

10V

2

CCG1201-A 4.7u 10V

VOUT

C1922

1

C1924

IC1921

TU11

3 Vout 2 GND

TUN12

VOUT

IC1911 NM

TUN33 IC1922 NM

5

3.3V

TUN12

4

1.2V

GNDRF

0

R1901

NM

RFVCC33

IC1931

NM (0.5A)

1u/10

5

NC2 EN

2 3

VOUT

VIN

VSS1

VSS2

ON/OFF

NC

(1A)

P1951

1 2 CEK1381-A

6 5 4

NM

NM

R2002

BD00IA5WEFJ

8.1V

R2024

DD8

3.3V

VDEC15 2

TPN33

NJM2878F3-15

3 2 1

NM

NM

CONT

NM R2021

C2021 NM

5

VIN

R2023

0

NC

NM

NC

3

VOUT

GND

C2022

1u/10

1u/10 C2032

C2031

VOUT

2

1k

CCG1192-A 10u R2022

CONT

VIN

1 R2031

4

1 2 CEK1382-A

0.1u/10

NM

(0.75A)

VDC33

GND 4

Fast acting Fuse P2071

VD5

C2071

L2071

VDEC33

IC2031

VDC15

>

VD5

IC2021

1.5V

VDEC15

C2023

NM

C1957

TPN33

For LS2 Mecha

1 2 CEK1380-A

GNDD

2

5

VD5

Fast acting Fuse P2081

0.1u/10

EN

NC3

NM

R2051

NM

NM

1

P2052

>

NM C2083

NC

6

VCC

GNDD

5.18V

C2081

NC

FIN

7

GNDD

5.2V

NM C2082

4

47k

1

PVI

GND

NC

P2051

NM

PWRVI

3

GND

VCC

FIN 9

FB

0

CONT

VIN

IC2051 NM

NM

C2052

C2051

C2062

1u/10

CCG1201-A

4.7u C2061

D2052

PWRVI

VO

2

NC1

1

2

VOUT

GND 3

4

NC 5

BT33

GNDD

FB

1

R2013

BT33

D2051

NM

4.7k 22k C2011

R2011 R2012

0

BT33

1

VIN

3

4

5

BT18

2

VO

NC

BT18

GND

BT18

VO

0 IC2001

8

NM

1k

R1905

GNDRF

3.3V

CONTROL

1.8V

1

R2003

SOC33

IC2011

SC12

R2052

>

3.3V

SOC33

SOC12 SOC12

IC2061 NM

2

NM

NM (2.5A)

1.25V

R2001

NM

1

CRG03

C2001

4

NC

P1911

D1904

NM

NM

5

NM

ON/OFF

L1902

6

C2002

VSS2

C2003

VIN

VSS1

1u/10

3

VOUT

CCG1201-A 4.7u

C

2

C1904

C1905

CCG1201-A 4.7u

1

R1904

RFVCC33

3.3V

NM

DAB33

C2012

C1921 CCG1201-A

NM

GNDHI

4 RN1907

D

NM

GNDFA

6

GNDA 2

10k

B

Q1855 NM

C1833

4

C1831

3

BR/CTL

Out

2

NM

Vcc

R1863 NM (D)

GND

NM

R1861

NM

C1857

SCP

C1861 NM

5

S

1

EaIn

OSC

C1860

6

NM

7

NM

G

FB

C1859

8

NM

R1862

NM

NM (D)

R1859

NM

IC1851 C1858

5 R1868

FAN

NM

Q1854 D NM

R1860

GNDA

10

R1866

GNDA

NM

NM

NM (D)

C1853

6

27k

R1854

NM

R1852 22k

C1856

68k

C1855 CCG1244-A-T 10u/6.3

NM

R1857

680

RN4982

5 1 Q1852 HN1B04FU(YGR)

DD5

6

1

2

R1864

L1851

D1852

14.1V

5

4

3

NM

D1851

DZ2J130M0 C1852

0.1u/16

R1865

R1851

D1853

DA2J101 C1851

4

2

Q1856 GNDA

NM

V18

3

270k

Q1851 LSCR523UB

CN1831

V18HI

R1853

C1832

18.0V Q1853

12.3V

EV12

C1854

EV12

A

2

1

10.4 MOTHER PCB (POWER SUPPLY BLOCK)

GNDD

(1.25A)

GNDD

GNDD GNDD D2162 1SR154-400

5.0V R2179

D2161 RB060M-30 CTF1793-A

NM L2162

IC2161

33k (D) 0

R2178 R2167

1.5k 470p/50

C2168 R2166

C2170 27p/50 R2169 C2169 7.5k

2200p/50

GNDD

128

GNDD

0.1u/16 R2176 R2165

8.1V

18 17

NM

ILL8

47k (D)

365.8/413.9kHz

16 15

C2165

14

R2164

13

C2166

ILMB

1000p/50

Fast acting fuse P2152 1 2 CEK1383-A

(1.5A)

NM

GNDD

220k 4700p/25

1u/10

200k

390k

GNDD

only A, E C2152 1000p/50

GNDD

AVH-X1600DVD/XNUC 1

2

3

4

120 R2133 22

0.1u/10

19

>

47k D2131 DZ2J062M0

C2167

R2174 R2173

C2164

ILMB

0.1u/16

20

1u/10

GNDD C2161

21

D2132 NM R2132

R2131

22

0 8.2k (D)

R2168 R2177

A 4/6

Q2131 2SD1760F5(QR)

(2.5A)

23

AN33014UA

F

MTV

C2133

GNDD

0.1u/16

0

C2173

R2172

BT 4 PVCC1 BTVCC 5 PVCC2 TL 6 VCC FLAG 7 NC3 RADJ 8 RSIN SYNC 9 VREG EN 10 SGND CT 11 COMP RT 12 FB SS

MOTV

1 2 CEK1385-A

100u/16 C2132

47u/16 105

C2162

10u/35 C2172

3 NC2

MOTV

Fast acting fuse P2151

C2131

PGND

M8V

C2151

2 RSO

LX

24

6.4V

>

VD8

8.1V

0.1u/16

1 NC1

GNDD

For LS2 Mecha

VD8

NM

C2175 R2175

ACN7160-A 0.056

C2186

0.1u/16

105

C2185

100u/16

USB5

L2161 CTH1524-A 10u

NM R2171

C2163

1k

R2163 1k

R2161 1k

R2162

E

R2170 1k

USB5

DCH1256-A 22u

USB5

Q21 LTC

6

7

8

2

USBFLG

A 3/6 MOTPW2

VDCNT5

A 2/6

FAN_PWM

VDCNT8

DDCERR

DDCCLK

TU3VON

ANTSENS

SYSPW

USBCNT

ANTPW

1000u/16 105

C1804

0.1u/50

C1803

C1802

0.1u/10

105

47u/16

NM

15k

C1801

C1805

10k 82k R1824

PWR-SH BUS

PWR-SYS BUS HIOUTCLK

D1801 1SR154-400

A 5/6

TU1VON

B UP _ 1 VDIN

PWR-I/O BUS

B

GNDD

R1821

GNDA

NM

BT18ON

VD33

3 VIN

1 VOUT 2 GND

VDD33

GND

VADJ

VOUT

CONT

IC1801 NJW4181U3-33B

3.3V

5

4

1

1u/16 R1822 R1823

C1822

C1821

100u/16 105

910 0.1u/16

R1911 D1903

DZ2J160M0 C1903

2.2k 1/4W

R1907

R1906 10k

(F) 100k

R1909 C1907

NM R1910 (D) 18k

NM

C1906

PCB A 4/6 MOTHER (POWER SUPPLY BLOCK)

SYB

Q1903 2SD2114K(VW)

Q1902 LTC014EEB

2

VIN

SYS+B

VDD33

IC1821 NJM2387ADL3

9.0V

3

2

P1901 1

SYS+B

GNDFAN Q1901 2SA1577(QR)

A

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

FSMD020-R

BUP_1 DABSX12

2

D

NM

NM R1831

NM

R1836

NM

NM

NM C1832

C1833

3 2 3 1 NM 2 2 R1832 1 1 NM

1

Q1831 4 4 5 5 6 6

C1831

(1.0A) P1831

AVH-X1600DVD/XNUC AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC

A B C

B UP _ 1

8.1V DD8

FAN

Fast acting (0.75A) P1902 Fuse CEK1380-A

1

5

NM

D1953 RB080L-30

NM

C1982

10uH 3300u/16 105

C1979

C1977

10u/35

DDC 5/8

C1975

2 NM Slow Blow Fuse (4.5A)

1000p/50

(1A)

L1953 CTH1486-A

DDIN

P1952 1

Fast acting Fuse

P1951

>

1 2 CEK1381-A

GNDD

C

GNDD

47k (D)

6800p/25

5

BST

0.01u/16

EN

0.1u/10

10u/35

10u/35

CCG1236-A-T

C1980

C1981

E

0

SYNC

10u/35 C2108

FIN

VCC C2106

0.01u/16

NM

6

FB

C2105

C2104

7

3 4

R2105

8 9

BD9876EFJ GNDD

2.2k

3.6k (D)

R2103

NM R2101 R2102

VC

22k (D) R2104

GNDD

GND

2

C2107

RB056L-40

D2101

C2102

10u/35

0.01u/16

105 C2101

C2109 47u/16

IC2101 1 LX

C2103

1000p/50

C2134

22

GNDD

365.8/413.9kHz

L2101 CTH1524-A 10u

120 R2133

C1976

3225size C1974

R1969

DDC33 DDC33

(2A)

CEK1384-A

Fast acting Fuse P2131 1 2

NM R2132

D

NM

200k

3.3V

D2132

1000p/50

47u 10V CCG1229-A-T

CCG1236-A-T

NM RB056L-40

4.3k (D)

33k (D)

D1952

560 470p/50 R1953

DD5

15u

3.6k (D)

220k

14

R1955 R1954

1u/10

15

5.2V

R1961

DDC33

D2131 DZ2J062M0

C1951 R1952

16

13

L1952 CTH1519-A

12k

0.01u/16

C1972

17

8p/50

18

390k

C2133

C1952 R1956

19

R1960

NM

0.1u/10

D 2

20

C1978

R1962 CCN1321-A 0.012

21 C1970 0.1u/16

AN33012UA

R1951

Q2131 60F5(QR)

3 S

1 G

R1963

NM

10k R1958

0.1u/10 R1957

10k (D)

300 1.1k (D) (D) C1966

510 1000p/50 R1967

Q1952 RSD140P06

22

0.1u/10

8p/50

0.1u/16

0.01u/16

C1956

R1966 R1965

RB056L-40

C1955

C1954

4.7k

R1968

D1951

C1961

R1964

D 2

L1951 CTH1446-A

3225size

C1960

C1959

C1957

GNDD C1969

23

C1953

1 G

24

C1971

HSD1

NM

C1958

VCC_S2 2 VCC_S1 RS2 3 RS1 HSD2 4 HSD1 SS2 5 SS1 PGND 6 COMP1 COMP2 7 FB1 FB2 8 EN1 VREG 9 EN2 SGND 10 CT RT 11 TL_CTRL TL 12 FLAG SYNC

0.011

Q1951 S 3 RSD140P06

10uH

NM R2021

R1959 CCN1341-A

47u 10V

10u/35 CCG1236-A-T

CCG1236-A-T

0.1u/10

DD8

1000p/50

8.1V

CCG1229-A-T

10u/35

IC1951 1 VCC

C1973

10u/35

C1967

10u/35 C1968

C1965

10u/35

C1964

1000p/50

0.047u/50

NM

C1963

C2001

NM

C1962

GNDD

365.8/413.9kHz

GNDD Q2132 LTC014EEB

1801 - : VDD33 1821 - : SYS+B 1851 - : EV12 1901 - : TUN 1951 - : DDC 5/8 2001 - : SOC 2051 - : BT 2101 - : DDC33 2161 - : USB5

GNDD

CHIP SIZE LEGEND 1608 2125 3216

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.

AVH-X1600DVD/XNUC 5

6

F

A 4/6 7

8

129

130

1

F

NM

GNDD

2

GNDD

NM

BT IF

3 5 B2 6 C1

B1 2 E1 1 RN4984

4 E2

C2 3

C1661 470p/50

D1661

DZ2J039M0 1.2k

R1663 SYS+B

1 24

MIC2_N

1k POL

A 5/6

AVH-X1600DVD/XNUC

4

WIREDAD WIREDPU G5

Q1731 RN4982

4 3

6

NM

R1744 C1737

GNDD 27k

R1742

NM

2.2u/10

6

10k

5

5

B0

BTANAL

R1711

R1702 2.2k C2 3 5.6k R1703 B1 3.3k 2 E1 1

R1717

R1718

P1701

2

470 D%

1k 47k R1713

R1714

NM

R1712

BUSRM

BUSRP

ASBO

0

AUVG R1764

FSMD075-24R

1

47k

NM

DD5

B1

E2 4 B2 5 C1 6 UMF23N

5.1V Q1701

R1701

Q1711

B2

BTMICP

BTMICN

2

B3

BUSL+

BUS-

BUSR+

AUX_V

AUX_VGND

AUX_L

AUX_AGND

AUX_R

4

B4

B5

G0

G1

G2

G3

BTMIX

WIRED

G4

SXIPWEN

ASENBO

N_TO_S

S_TO_N

GUIDEON

RGBARI

R0

COMDC

AEQAUXSW

R1

R2

R3

R4

R5

LOAD

CLK

STV2

OEV

VCLK

VSYNC

HSYNC

CSYNC

ANB

ANG

ANR

GNDSIG

BEEP

PESD0402-140

PESD0402-140 D1601

D1602

C1601 0.1u/50

NM

2

4 GND

LCDGND 28

2 23

27

R1680

B0

1u/10

26

MIC2_P

25

0

24

R1683

23

MIC_BIAS

NM

B1

C1678

B2

C1679

MIC1_P

B3

MIC1_N

B4

L1671

22

5 20

CTF1786-A BBOT

G0 21

VSS 1

B5

BOOTS Q1661 2SD2114K(VW)

3

G1 20

I2S_MCLK 6 C1

G2 19

CN1671 12

BCG

AUV

AUL

AUAG

AUR

BCI

NM

R1601

R1602 NM

GNDD

G3 18

6 19 NM

14.4V

G4 17

7 18 BCAM_IN

BUP_1

G5 16

8 17 AEQMICIN

R1704

3 3

2 2

GNDD

R0 15

9 16 5 B2

R1 14

4 21

I2S_SYNC BTMICP

CTF1713-A

L1601

SOC33_1

R2 13

LINEOUT_R

I2S_CLK BC_VGND

SPEED

BTMICN

44

11

GNDD

R3 12

VSS

10 15

R1690 RN4984

GNDD

R5 10

LINEOUT_L

11 14

USB_DUSB_D+ USBGND

3 4

HSYNC

DTVR TVON

27

ONSEI+

SYSTON

SXL

1

2

3

4

5

WIREDAD

WIRED

GNDSX

GNDSX

SXEN

6 SXPWR

7 SXPWR

8

9 GNDA

10 SXR

11 ASENBO

12 GND

13 STOSX

14 SXTOS

15 GNDD

16 GNDD

17 GNDD

18 BTMICP

19 BTMICN

20 GND

21 NTOSYS

22

23 GND

24 ONSEI-

25

26 GUIDEON

28

29 DTVAG

30 DTVL

31 GND

32 VSYNC

33

34 CSYNC

35 APPPUP

36 ANB

37 GNDSIG

38 ANG

39 GNDSIG

40 ANR

41 GNDSIG

42 AUXV

43 AUXVGND

44 AUXL

45 AUXAGND

46 AUXR

47 AUXAGND

48 BEEP

49 BCAMIN

50 BCAMGND

RT2 Shield2

RT1 Shield1

USB5V

1 2

3

R4 11

BT18V

I2S_IN E1 1

9

BT18_EN

I2S_OUT B1 2

LD

BT18V

12 13 C2 3

8

GNDA 1.5k

LCDGND

DUMMY R1664

10k

AEQMIN

7

BT33V C1686 VD5 1800p/50

HCLK

UART_AT_RX 8 R1662

I/O-SH BUS

6

NM AUX_AGND

BTANAL

I/O-ANA BUS

LCDGND

7 GNDA 820

BTANAR

INNER BUS

5

6 R1684

D+

D-

GNDD

STV2

5

Q1663

4

FORMAT BCKIN DEEMPH NC1 NC2 CAP MUTE VOUTR VOUTL GND VDD

100p/50

3 MCLK L1672 CTF1786-A

LRCLK

SYSTOBT

C GNDD

2

nRESET DIN 14

CCG1192-A 10u

IC1671

180 C1671

NM

BCLK

0

R1762

4

UART_DBG_TX 2

C1685

GNDA

R1763

3

GNDD DD5

B

POL

NM

A-a 5/6

OEV

UART_DBG_RX LRCIN

0.1u/10 C1682

820

NM

R1687

USB

VCLK

R1672 R1696

R1695

DATA_BT

SHTOBT

BTTOSH

A

COMDC 1

UART_AT_TX 1

R1693 0

R1685

NM

2

1u/10

R1673 CCG1192-A 10u C1683 1800p/50

C1707

BT18

IF

NM

DBGR NM

NM

BTRST BTTOSYS

GNDD

R1681

DBGT 100p/50

R1689 R1694

R1688

0

I/O-SYS BUS

NM C1687

C1684

R1686

B

0.1u/10 C1688

BT18ON

I/O-POWER BUS

C1689

NM

R1671

USB5

R1692 0 R1697

100

100

CKN1091-A

R1678 1k R1679 1k C1674 NM C1675 NM C1676 220u/4

R1677

R1674

JA1601

NM

NM

USB IF

NM R1675

0.1u/16

NM

CCG1192-A 10u

BT33

R1676

C1681

C1673

GNDD

R1682

A 4/6

0.01u/16

C1677

RT2

A 3/6

NM

A 2/6

C1680

U1671 NM RT1

E RT2

D

RT1

A 1/6

10u

C1672 CCG1192-A

1 4

10.5 MOTHER PCB (IN/OUT BLOCK) (GUIDE PAGE)

CN3601

DABSX12

CKS6535-A

CN1701

10k

GNDSX

A, B, C : J% D, E, F, G : D%

2

3

GNDD

1

only D, E,

Q1712 HN1B04FU(YG

GNDD

1 I/O1

2 O/I1

3 CT1

IC1732

O/

V

I/O

C

1 NM

GNDA

RGB in:VGA se &Mixing on other

MIC SENS

(3.9V)

GNDA Q1662

4 E2

13

11

10 GNDA

9

GNDA

GNDD

R1691 GNDA

NM

0

C1690

NM

BT33

3 22

only E

GNDD

D

5

6

7

8

A

WIREDAD

WIRED

GNDSX

A-b 5/6

PCB A 5/6 MOTHER (IN/OUT BLOCK)

CN1701

1

3

2

CKS6535-A

SYS+B

C1733

2 NM

1

NM P1631

C1638

C1637 820

NM

R1650 NM

R1643

RCA_RL

RCA_RR

MOT0

MOT1

POS

H/OSW

STOSX

MICSENSR

D

BLERR

DIMMER

BLEN

BLSYNC

TPIRQN

MTCH_SDA0

MTCH_SCL0

RESET

REMIN

LPSYNC

MTCHRST

KDT1

KDT0

B_PWM

R_PWM

G_PWM

TEMPSENS

SXTOS

L

LCDPW

820

R1649 RCA_FL

RCAMUTE

RCA_FR

RCA_SWL

RCA_SWR AEQMICIN

VCR_R

VCR_L

VCR_V

VCR_VGND

iTV_R

iTV_L

iNAVI

BTANAR

VCR_GND

FM/AM(30%) (except B, C): -6.9 dBs FM/AM(30%) (B, C): -2.9 dBs TV:+9.3 dBs AUX:+9.3 dBs VCR:+9.3 dBs USB(LS2 Decode):+9.2 dBs USB(SH Decode):+9.3 dBs DVD/CD(LS2):+9.2 dBs Navi Guide: -12.5 dBs

H

DIO

B0

B1

B2

B3

4.7k

C

BTMIX B4

B5

G0

G1

G2

G3

R1646

4.7k

0.1u/10

BTMIX

other

R1645

R1648

22k

22k

C1636

22k

4.7k

GNDA R1647

CCG1201-A 4.7u

R1623

R1640

4.7k

C1635

R1622

R1639

4.7k

GNDRF GNDA GNDA

C1612 27p/50

Q1633 2C 2E 3 4 2B 1B 2 5 1E 1C 1 6 HN1C01FU(YGR)

CCG1201-A 4.7u

GNDV

R1635

4.7k

820

1

GNDD 2

R1633

CCG1201-A 4.7u

P1623

2

75

2

22k

2C 2E 3 4 2B 1B 2 5 1E 1C 1 6 HN1C01FU(YGR)

2C 2E 3 4 2B 1B 2 5 1E 1C 1 6 HN1C01FU(YGR)

R1642

NM

FSMD075-24R

NM P1622

1

R1644

22k Q1632

C1634

5

22k

C1611 27p/50

GNDA R1641

820

R1737 15k R1738 15k

6

NJM4565V

RGB in:VGA select &Mixing on

FSMD075-24R

RLOUT

8 GNDA

RROUT

7 GNDA

5

4 FLOUT

3 FROUT

2 SWLOUT

6 GNDA1

RLO

RRO

1 SWROUT

SWLO

SWRO

VOUT

VCR_RG

VCR_RIN

1

VCRG

2

VOUT_G

VCR_LG 5

4

3 VCRI

VCVO

VCLG

VOVG

VCR_LIN

VCR_VG

VCR_VIN 1

15k

7

GNDA BTANAL

R1621

R1739

GNDA

NM

B

15k

C1739

NM 1

8

FOR SERVICE P1621

RCA_V

47k

5 6

R1736

5

I/O2

C1734 100p/50

1 A_OUTPUT V+ 2 A-INPUT B_OUTPUT 3 A+INPUT B-INPUT 4 VB+INPUT

6 O/I2

4 GND

6

NM GNDD

2.2u/10

R1638

22k Q1631

820

GND OUT_Y

R1634

22k

R1637

2.2u/10

R1735

CT2

3 CT1

2

D1621 NM D1622 DZ2S180C D1623 DZ2S180C D1624 DZ2S180C C1622 0.1u/50 C1623 NM C1621 0.1u/50 C1624 0.1u/50

4

R1636

2.2u/10

C1731

15k

7

7

8

R1632

5

C1632

VCC

IN_A

CCG1201-A 4.7u C1633

G

C1610 27p/50

CCG1201-A 4.7u

3

C1609 27p/50

GNDA

820

2

C1608 27p/50

R1631

NM

1

C1607 27p/50

NM

15k

R1765

0.1u/10

R1726 100p/50

IC1741

GNDA

C1732

IC1731

0.1u/10

3

10k

4

R1744

2 O/I1

Q1731 RN4982

XKB7001-B

VDD33

C1631

27k 27k

8

JA1631

VCR:+8.2 dBs SOC33_1

R1732

VCC

JA1621 CKB1110-A

CCG1201-A 4.7u

15k

C1724

C1725

C1735

R1740

IC1732 1 I/O1

VCLI

VCVI

NM

C1751

NM

C1752 15k

4

VCVG

NM

R1751 R1743 27k C1738 2.2u/10

OUTY

NM

PREOUT

GNDD

C1736

27k

R1742 C1737

2.2u/10

GND

only A, E

NJM4565V

R1733

5

INA

R1724

R1731

8 V+ 7 2 A-INPUT B_OUTPUT 6 3 A+INPUT B-INPUT 4 V5 B+INPUT

VCC

INB

1 A_OUTPUT

only D, E, F, G

R1734

15k

NM

1u/10

DZ2J051M0

C1723 1u/10

R1728

D1721

4.7k C1722

R1730 C1721 R1723

R1721

R1722

R1725

IC1721

GNDD

6

1k

15k

15k

15k

15k

15k

100p/50

1k

Q1712 HN1B04FU(YGR)

5

M

R1729

GNDA

R1716

6

R1727

R1717

R1718

5 1

2 3

1k R1715

4

3 2

4

IC1751 1

Q1721 LSCR523UB

VDD33

470 D%

1k 47k

R1713

R1714 47k

DD5

11

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

RCA V IN OUT

A, B, C : J% D, E, F, G : D%

FRO

D

DD5

AVH-X1600DVD/XNUC AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC

FLO

A B C

GNDSX

DZ2S180C

D1663

DZ2S180C

0.1u/10 R1651

NM

C1604

R1652

0.1u/16 NM

C1603

R1653

D1662

C1602

680

C1651

CHIP SIZE LEGEND 1608 2125 3216

47k

MOTV

47k VDD33

C1605 0.1u/16

C1652

GNDD

NM

C1606 0.1u/16 D1603 NM GNDD GNDA

NM

MOTV 1

MOTV 2

GNDD 3

GNDD 4

MOT0 5

MOT1 6

7 POS

8

GNDD 9

JA1661

VDD33

H/O SW 10

1 3 2

GNDD

CN1651 NM

E

: USB IF : OPT : VCR IN/OUT : PREOUT : AUTO FLAP : MIC SENS,Auto EQ MIC : BT : TO IF : TO MONITOR

ILMB

0.1u/10

C1703

60

59 ILMB

ILMB

58 ILMB

BLGND 57

BLGND 56

54

53

BLGND 55

BLERR

DIMMER

51

BLEN 52

BLSYNC

50

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

0.1u/16

BLGND

TPN33

C1704 47

KEYGND 48

TPIRQN

TOUCHGND 49

MTCHDA 46

MTCHCK 45

44

43 REMIN

RST 42

DZ2S180C

D1782

0

R1782

GNDD TPN33

LCDGND

40

41 KDT0

KDT1

PWM_B 39

PWM_R 38

PWM_G 37

NM

PWRVI 470p/50

C1702 0.1u/10 36

35 PWRVI

LCDGND 34

TMPSENS

33 V18HI

D1781 DZ2S180C

V18HI NM C1701

R1781 LPSYNC

32

C1705

NM C1706 29 DIO

LCDPW 31

LCDGND 30

LCDGND 28

27

25

24

26 B1

B2

B3

22

23 B4

B5

G0 21

G1 20

G2 19

G3 18

B0

D

1601 1611 1621 1631 1651 1661 1671 1701 1781 -

TEMP

LPSNC

LCDPW

NM

CN1751

F

CKS6536-A

CN5401

A 5/6 AVH-X1600DVD/XNUC 5

6

7

8

131

731 982

6

1

2

3

1k

6

5

only D, E, F, G

GNDD

Q1712 HN1B04FU(YGR)

1

4

GNDA

NM

CT2

I/O2

4

other

RGB in:VGA select &Mixing on

4 GND

3 CT1

2 O/I1

VCC

O/I2

IC1732

1 I/O1

5

6

7

8

R1725

15k

R1727

L

H

C1731

C1732

C1735

IC1731

15k

R1732

27k

27k

15k

15k

C1733

0.1u/10

NJM4565V

1 A_OUTPUT V+ 2 A-INPUT B_OUTPUT 3 A+INPUT B-INPUT 4 VB+INPUT

GNDA

BTMIX

47k

R1736

R1734

R1733

R1740

5

6

7

8

2.2u/10

2.2u/10

2.2u/10

NJM4565V

8 V+ 7 2 A-INPUT B_OUTPUT 6 3 A+INPUT B-INPUT 4 V5 B+INPUT

IC1721

1u/10

1 A_OUTPUT

GNDA

1k

R1729

R1737 15k R1738 15k

15k

R1739

C1734 100p/50

GNDA

C1736

NM

GNDD

R1751

3

2

1

NM NM

C1752

IC1741 VCC

NM

OUTY

VCC

4

5

SOC33_1

NM

GND

INA

INB

GND OUT_Y

IN_A

G

GNDD

3

2

1

IC1751

4

5

VDD33

DD5

C1751

1

1

NM

NM P1622

GNDV

2

2

FOR SERVICE P1621

VCR_VIN

RCA V IN OUT VCR_LG

STOSX

WIREDAD

5

4

3

2

NM

Q1721 LSCR523UB

SYS+B

22k

R1622

VOUT 4

1

DD5

R1714

47k

R1718

R1744

470 D%

R1713

27k

2.2u/10

VCR_RIN

22k

R1623

only A, E

GNDD

D1621 NM D1622 DZ2S180C D1623 DZ2S180C D1624 DZ2S180C C1622 0.1u/50 C1623 NM C1621 0.1u/50 C1624 0.1u/50

VCR:+8.2 dBs

JA1621 CKB1110-A

GNDA

Q1631

22k

R1634

R1635 4.7k

R1633 4.7k

2C 2E 3 4 2B 1B 2 5 1C 1E 6 1 HN1C01FU(YGR)

22k

R1632

C1608 27p/50

C1607 27p/50

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

A AVH-X1600DVD/XNUC B AVH-X1600DVD/XNEW5 C AVH-X1600DVD/XNUW5 D AVH-X1650DVD/XNRC

PREOUT

C1609

C1610

Q1632

22k

GNDA R1641

27p/50

4.7k

R1639

4.7k

R1640

2C 2E 3 4 2B 1B 2 5 1C 1E 6 1 HN1C01FU(YGR)

22k

R1638

27p/50

C1612

Q1633

22k

GNDA R1647

27p/50

4.7k

R1646

FSMD075-24R NM P1631

2

GNDRF GNDA GNDA

NM

FM/AM(30%) (except B, C): -6.9 dBs FM/AM(30%) (B, C): -2.9 dBs TV:+9.3 dBs AUX:+9.3 dBs VCR:+9.3 dBs USB(LS2 Decode):+9.2 dBs USB(SH Decode):+9.3 dBs DVD/CD(LS2):+9.2 dBs Navi Guide: -12.5 dBs

4.7k

R1645

2C 2E 3 4 2B 1B 2 5 1C 1E 6 1 HN1C01FU(YGR)

22k

R1644

27p/50

C1611

XKB7001-B

JA1631

PCB A 5/6 MOTHER (IN/OUT BLOCK)

3

BTMIX

VDD33

1k

R1716

R1743 27k

15k

R1722

47k

R1717

R1742

C1737

10k

BTANAL

15k

G_PWM

C1738 2.2u/10

C1739

BTANAR

15k

R1721

TEMPSENS

1k R1715

0.1u/10

LCDPW

100p/50

C1721 R1723

R_PWM

VCR_RG 1

A, B, C : J% D, E, F, G : D%

KDT0

R1731 R1726 100p/50

4.7k C1722

KDT1

NM

R1730

B_PWM

DZ2J051M0 C1725 R1735

NM R1765

15k R1724 15k

D1721 iTV_R

0.1u/10 C1724 15k

VCLG

VCR_VG VCLI

VCR_LIN 6 VCR_L

8 VCVG 75

7 VCR_VGND

VCVI R1621 VCR_V

2 P1623 1

5 VCVO RCA_V

VOVG

VOUT_G 3 VCRI FSMD075-24R VCR_R

2 SWLOUT

CKS6535-A

MOT1

C1723 1u/10 iNAVI RESET

820 CCG1201-A 4.7u

RROUT

CN1701

AEQMICIN

R1631 C1631 RCA_SWR

SWRO R1637 820

CCG1201-A 4.7u C1633

RLOUT

5

A-a A-b

MOT0

R1728 iTV_L REMIN

R1650 NM

A-b 5/6

RCAMUTE

FRO

FROUT 3 FLO

FLOUT 4 RRO

GNDA 6 RLO

GNDA GNDA1

7

820

2 VCRG VCR_GND MICSENSR

R1636 C1632 RCA_SWL H/OSW

820

SWLO 820

1 SWROUT CCG1201-A 4.7u POS

R1649 CCG1201-A 4.7u

NM R1643

8 R1642 C1634 RCA_FL

3

C1635

AVH-X1600DVD/XNUC

CCG1201-A 4.7u

2

RCA_RR

820

1 C1637

132 R1648

E C1636

D CCG1201-A 4.7u

C RCA_RL

A C1638

F 2

RCA_FR

B 1

1 4

SXTOS

15k

5

6

AVH-X1600DVD/XNUC

7

8

133

G1

G1 20

G0

G0 21

D

A-b 5/6

F

26

B1

25

B2

24

B3

23

B4

22

B5

B0

B5 B4

BTM

B3 B2 B1 B0

27

LCDGND 28 DIO

DIO

29

CN5401

LCDGND 30 LCDPW 31

33

V18HI

32

LPSYNC

LCDGND 34

36

TMPSENS

35

PWRVI

C1706 NM C1705 NM C1701 470p/50

R1781

LCDPW LCDPW LPSNC

LPSYNC

V18HI

NM PWRVI TEMP

C1702 0.1u/10

TEMPSENS G_PWM

PWM_G 37

R_PWM

PWM_R 38

B_PWM

PWM_B 39

41

KDT0

40

KDT1

KDT1 KDT0 RESET

RST 42

E

44

LCDGND

43

REMIN

R1782

REMIN MTCHRST

0

MTCH_SCL0

MTCHCK 45

MTCH_SDA0

MTCHDA 46 TPIRQN

TPIRQN

47

KEYGND 48

52

BLEN

51

BLSYNC

50

TPN33

D1781 DZ2S180C C1704 0.1u/10

D1782

GNDD

53

DIMMER

DZ2S180C

BLSYNC BLEN DIMMER

STO

BLERR

SXT

BLGND

BLGND 55 BLGND 56

TPN33

TOUCHGND 49

54

BLERR

BLGND 57 58

ILMB

C1703

59

ILMB

0.1u/16

60

ILMB

ILMB

CKS6536-A

CN1751

CHIP SIZE LEGEND 1608 2125 3216

D A-a A-b

GNDA MICSENSR

NM NM

JA1661

NM

0.1u/16

C1606 0.1u/16 D1603

C1605

GNDD

DZ2S180C

DZ2S180C

0.1u/16 NM

NM

C1604

C1603

C1602

D1663

1 3 2

D1662

C

GNDD NM

H/OSW

H/O SW 10

VDD33

GNDD 9

: USB IF : OPT : VCR IN/OUT : PREOUT : AUTO FLAP : MIC SENS,Auto EQ MIC : BT : TO IF : TO MONITOR

VDD33

8

6

MOT1

7

POS

MOT0

R1653

POS

680

MOT1 MOT0

5

GNDD 4

GNDD

GNDD 3 MOTV 2 MOTV 1

MOTV

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

1601 1611 1621 1631 1651 1661 1671 1701 1781 -

47k

47k

C1652

R1652

R1651

C1651

0.1u/10

B

NM

CN1651

A 5

6

7

8

2

3

4

AVH-X1600DVD/XNUC

A 2/6

A 1/6

I/O-SYS BUS

I/O-ANA BUS

INNER BUS

USB IF

GNDD

C1601

USB5

L1601

R1601

0.1u/50

1 2

USB5V USB_D-

GNDD

USBGND

4

USB_D+

3

USB

2 2

11 D-

NM

D+ R1602 NM

CKN1091-A

BTRST BTTOSYS 0 SYSTOBT 0

3 3

44

D1602

CTF1713-A

BTANAR

JA1601

1686

1

1687

134

A-a 5/6 F E

RT1 Shield1

GNDD

PESD0402-140 D1601

RT2 Shield2

PESD0402-140

IF

BTANAL

DD5

NM

R1762

10k

R1763

R1704

SOC33_1

BTMICN BTMICP

SPEED

D

NM BC_VGND

AUX_AGND

BCG 50 BCAMGND

BCI

A-a A-b

BCAM_IN

AEQMICIN

49 BCAMIN

BEEP

48 BEEP 47 AUXAGND

AUR

AUX_R

46 AUXR

AUAG

AUX_AGND

45 AUXAGND

AUL

AUX_L

44 AUXL

AUVG R1764

AUX_VGND

43 AUXVGND

AUV

0

AUX_V

42 AUXV

IG

41 GNDSIG 40 ANR 39 GNDSIG 38 ANG 37 GNDSIG 36 ANB 35 APPPUP

C

C

34 CSYNC

C

33

C

HSYNC

32 VSYNC

GNDD

AEQAUXSW

31 GND 30 DTVL 29 DTVAG

TVON

27

DTVR

28

B

RGBARI GUIDEON

ONSEI+

GNDD

23 GND 22

SYSTON

21 NTOSYS

CN3601

26 GUIDEON 25

24 ONSEIS_TO_N N_TO_S COMDC

20 GND BTMICN

19 BTMICN

BTMICP

GNDD

1

P1701

18 BTMICP 2

17 GNDD

FSMD075-24R

16 GNDD

R1701

15 GNDD

GNDD

14 SXTOS

BUP_1

13 STOSX

GNDD

R1702 2.2k C2 3 5.6k R1703 B1 3.3k 2 E1 1

14.4V

ASENBO

5.1V Q1701 E2 4 B2 5 C1 6 UMF23N

ASBO

12 GND 11 ASENBO

BUSRP

BUSR+

10 SXR

BUSRM

BUS-

DABSX12

BUSL+ SXIPWEN NM

R1711

1

3

2

GNDD

WIRED WIREDAD WIREDPU

R1712

6

5

4

DD5

Q1731 RN4982

NM

5

6

4

NM

GNDSX

Q1711

NM

SXL

8

GNDA

9

7 SXPWR 6 SXPWR

WIREDAD

1

WIRED

2

GNDSX

3

GNDSX

4

SXEN

5

1

2

3

NM O

3

othe

RGB in:VGA &Mixing on

GNDA

4 GND

3 CT1

2 O/I1

IC1732

1 I/O1

only D, E

Q1712 HN1B04FU(Y

1

3

2

R1713

A, B, C : J D, E, F, G : D

GNDD

1k

47k

R1717

CKS6535-A

27k

CN1701

R1742

R1714

47k

R1718

R1744 C1737 2.2u/10

470 D%

A-b 5/6

BTMIX

10k

2

BTANAL

B A

1

4

7

8

135

NM

GNDD

NM

R1672

GNDD

DUMMY

R1673

BT33

NM

BT18

A 4/6 I/O-POWER BUS

I/O-SH BUS

U1671 NM RT1

RT1

R1674

A 3/6

RT2

RT2

0.1u/16 BT18ON

NM

BTRST

100

R1686

DBGT

DBGR

R1671

SYSTOBT

R1687 NM

0

BTTOSH SHTOBT

D-

DATA_BT

D+

BCLK NM

R1696

820

7

6

5

4

3

2

1

NM

1 24

2 23

3 22

4 21

5 20

6 19

7 18

8 17

9 16

10 15

11 14

12 13

LRCLK NM

MIC2_N

MIC2_P

MIC_BIAS

MIC1_P

MIC1_N

VSS

BOOTS

I2S_MCLK

I2S_SYNC

I2S_CLK

I2S_IN

1u/10

C1678 NM

L1671

L1672 CTF1786-A

GNDD

NM

1k

R1680

0

BT IF

R1683

C1690

GNDA

0

R1690

C1679

C1685 0.1u/10 C1682 CCG1192-A 10u

C1686 VD5 1800p/50

CTF1786-A BBOT

GNDA

8

9

10

11

12

13

14

I2S_OUT

NM

R1691

NM

MCLK

FORMAT BCKIN DEEMPH NC1 NC2 CAP MUTE VOUTR VOUTL GND VDD

DIN

LRCIN

IC1671

GNDA

CN1671

VSS

LINEOUT_R

LINEOUT_L

BT18_EN

BT18V

BT18V

nRESET

BT33V

UART_DBG_TX

UART_DBG_RX

NM NM

R1685

C1683 1800p/50

UART_AT_TX

UART_AT_RX

GNDD

GNDD

C1684

R1689 R1694

NM C1687

0.1u/10 C1688

R1695

CCG1192-A 10u

100p/50

R1693 0 R1692 0 R1697 180 C1671

BTTOSYS 0

NM

R1677 100

R1678 1k R1679 1k C1674 NM C1675 NM C1676 220u/4

100p/50

I/O-SYS BUS

10u NM

C1681 C1673

CCG1192-A 10u R1682

0.01u/16 R1676 NM R1675

R1688 C1689

NM

E

R1684 820

BT33

R1681

A 2/6

C1672 CCG1192-A

C1680

6

A-a 5/6 F

C1677

5

AVH-X1600DVD/XNUC

D

NM

A-a A-b

AEQMIN

BEE

GNDA

1.5k

5 B2

6 C1

B1 2

E1 1

R1663

DZ2J039M0

SYS+B

GNDSIG

Q1662

RN4984 4 E2

C2 3

GNDA

1.2k

D1661

GNDA

(3.9V)

MIC SENS

Q1661 2SD2114K(VW)

R1664

R1662 10k

C1661

ANR

ANG

ANB

470p/50

Q1663

C

C2 3

4 E2

GNDA

6 C1

E1 1

5 B2

B1 2

CSYNC HSYNC VSYNC

RN4984

AEQAUXSW

RGB GUI

GNDD

only E

C1707 1u/10

COMDC 1

B

4

OEV

3

VCLK

2

POL

7

HCLK

6

LCDGND

5

STV2

9

LD

8

LCDGND

S_T N_T COMDC POL VCLK OEV STV2

CLK ASE LOAD R5

R5 10

R4

R4 11

R3

R3 12

R2

R2 13

D

25

B2

24

B3

WIR WIR WIR

G5 G4 G3 G2 G1

B5 B4

BTM

B3 B2 B1 B0

6

7

A-b 5/6

22

B5

26

B1

SXIP

R1

R1 14

R0

R0 15 G5 16 G4 17 G3 18 G2 19 G1 20

G0

G0 21

23

B4

27

B0

LCDGND 28

5

A

8

1

2

3

4

10.6 MOTHER PCB (TUNER BLOCK) A

AV AV AV AV

A B C D

TUN-SH BUS

E AV F AV G AV

A 3/6

5

4 R408

RFGND1

ADO

0

7

220

6

L403

5

NM

4 3

DABANT

ADI 0

2 3 4 5

7

R521

750

CTF1806-A

0.01u/16

C522 0.01u/16

C523

CCG1192-A GNDRF

except A,

L505

L519

1.5k

0.01u/50

CTF1389-A

10n

L507 22u

D503

GNDD

L451

R5

R522

C512

NM

10u

C524 0.022u/16

1M

R520 DABSX12

1

C518 0.01u/16

GNDRF

TUNAG

GNDRF

3

L504

C521

0.1u/10 TUNAG

9

JA452

C519

8

2

10

2

CTF1786-A

GNDRF

6

1

E

0.01u/16

C454

NM GNDRF L503

1

L5

only A, 1M

3 R409

C528

R523

6

AWS

1u/10

3p/50

2

GNDRF

C529 10u

7

RFVCC33

8

1

C520

RFGND2

9

NM

ACLK

8

C525

TUNAG orRFGND

NM

FMAMANT

C526 NM C527

GNDRF L506 CTF1794-A

0.01u/16

33p/50

C511

RFVCC5

10 GNDD

CN401

NM

RFGND3

TUN33

R404

C406

RCH

TUDAT

C403 NM

AGND

D

GNDD

12 11

LCH

L502 0.27u

14

13

RDSINT

D502

C509 TUCLK

DGND1

NM

P451

only A, E

RN731VN

NM

I2C0_SCL I2C0_SDA

C455

TUN33 NM

L401

L402

16

0

NM

28

17

15

DTUNtoSYS

TUN12

18

C516

29

SYStoDTUN

0

C517

30

R406

C514

31

0

R405

19

0.1u/10

32

0

20

C515

5

22p

TUNRST

0.1u/10

BBD1 4

R407

C513 0.01u/16

6

33

GNDD

220

BBD0 3

34

C5

21

6p/50

7

only *4

22

NM

BBWS 2

35

SCS

1

0

R519

8

2

8

D501

C

R402 1

7

23

only A, E

GNDRF

RN731VN

BBCLK

24

SDI SSCK

C510

36

SSCK BLEND/SCK SCS DGND6 DGND4 DVCC33_2 DVCC33_1 BB_CLK RESET BB_WS RX BB_DII TX BB_DIQ/REF_CLK GPIO DVCC11_2 DVCC11_1 I2C1_SCL DGND3 I2C1_SDA DGND2

3

L501 0.15u

37

4

6

CCG1192-A

38

0

5

2p/50

39

NM

5

4

40

NM

6

SDO

C404

3

ADO

RFG1

R403

1k C401

ADI

41

R410

7

NM

2

NM

AWS

U401 X-2062 NM A_CLK DGND5 27 A_WS SDI 26 A_DI SDO 25 A_DO

C405

8

C402

R401 ACLK 1

3

3p/50 D452

1

2

IMSA-6803-01Y900

B

FM/AM ANTENNA

JA451 YKS5041-A

RFG2

only A, E NM

C462

NM

C453

NM

NM D451

VA451

NM 4

R455 NM C458

GNDRF

NM

R456

5p/50

GNDRF

C459

R457

5p/50

F

C456 GNDD

4p/50 C460

R454

4p/50

0

0

C461 GNDRF

GNDRF

TUNAG

NM NM

except A

C457

only A

GNDRF

R451 NM

GNDRF

A 6/6 136

only A, E

AVH-X1600DVD/XNUC 1

2

3

NM GNDD

4p/50 TUNAG

R452

4

GNDRF

5

6

7

PCB A 6/6 MOTHER (TUNER BLOCK)

AVH-X1600DVD/XNUC AVH-X1600DVD/XNEW5 AVH-X1600DVD/XNUW5 AVH-X1650DVD/XNRC

D

TUN-ANA BUS TUN_R

E AVH-X1650DVD/XNRD F AVH-X1650DVD/XNRI G AVH-X1690DVD/XNID

FM/AM(30%) (except B, C): -15.0 dBs FM/AM(30%) (B, C): -11.0 dBs

TUN_L

A B C

8

TUN-SYS BUS

only A, E

10p/50

TUNER

C563

A 2/6

TUN5

C562 4700p/25

A 1/6

TUNRST

C561

TUNDATA

BLEND

10p/50

TUNCLK

C560

A

B

4700p/25

7

GPIO1

GND1V2

TDA7706

CK_SEL

TCAM2 PINDDEC PINDIN

41

R534

40

R535

39

R536

38

R537

37

R538

GPIO7 GPIO8

22p/50 C574

BBWS

NM

BBCLK

NM

ADO

NM

ADI

NM

AWS

NM NM

31

VREG3V3 RSTN RDSINT 30

29

27

REG1V2

VCCREG1V2

VDIG

GNDSLINK

AMMIXIN2 26

AMMIXIN1 25

LNADEC2 24

LNAOUT2

C555 0.1u/10

34

0.1u/10

GNDD

33 L518 NM R539 1k

100p/50

C544 2.2u/10 CCG1218 C545 GNDD

R530 L510

C553

22p/50

C554 1000p/50

E

only A, E GNDD

5.6

CTF1786-A 0.1u/10

5.6

C550

R529

5.6

0.1u/10

NM C547

C546 1/4W R528

C543 0.1u/10

C542

82p/50

680

47u R527

L509

C540

D

ACLK

GNDRF

only A, E

GNDRF

CHIP SIZE LEGEND 1608 2125 3216

401 - : HD TUNER UNIT 451 - : ANT PART R452

BBD0

NM

35

23

LNAIN2 21

20

only A, E GNDRF

22p/50

2.2u/10

R533

BBD1

NM

36

0.01u/16

only A, E

R525

3p/50

C531

1M

R523

3p/50

42

NM

GND3V3

C541

only A, E

0.1u/10

L508 68n

470

L507 22u

R526

1.5k

R532

C CCG1218-A-T 2.2u/10

L511 CTF1786-A

C539

0

C530 CCG1192-A

R524

10u

except A, E R522

18

F

17

C524 0.022u/16

C538

16

LNAOUT

GNDLNA LNAIN LNADEC

10u

19

CCG1192-A

15

22

14 0.01u/16

33

VCCVCO

100p/50

LF1 13

28

12

C522

R531

43

GPIO6 VDD3V3 I2CSCL I2CSDA

LFREF

0.01u/16

R501

44

GPIO5

C548

10

45

32

9

NM

0.1u/10

GPIO4

IC501

0.1u/10

C528

C573

46

GPIO2

8

C521

C523

49

50

51 OSCIN

VCC-REF VDDIO1V2 VDDPLL1V2

VDD_CORE

47

GPIO3

VCCRF

CCG1218 C569

NM

R540 53 GND-REF

GPIO0

GNDVCO

/10

48

TEST

11 9

NM L514 CTF1786-A C571

0.1u/10 C549

1u/10

52

0.1u/10 54

R541

OSCOUT

C565 55

L515 NM L516 NM

FMMIXDEC

TCAM

L517

TUN33

GNDRF

C525

GNDD

CTF1786-A

VREFDEC

GND-ADC_DAC

56 DACOUTL

DACOUTR

57

58

FMPINDRV FMPINDDEC

0.1u/10 C568

GND1

only A, E

CSS1805-A

FMMIXIN2 FMMIXIN1

C566 10p/50

2

5 6

C567

1

3

TUNAG

NM C570

10p/50

C564

CTF1786-A

CTF1786-A L513

L512

X2

GND2

1u/10 59

60

4

0.01u/16

UNAG rRFGND

VCC-ADC_DAC

C526 NM C527

4

X1

VCC-PLL

3

GND-PLL

2

GNDRF 506 794-A

61

TVDAC TCFM PLLTEST

1

62

64

22p/50

63

C557

C556

36.48MHz X501

0.22u/16

only *4 A, E

C559

C558

0.22u/6.3

NM

TUNAG

501 - : HIT2 PART

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

F

NM GNDD

GNDRF

GNDRF

AVH-X1600DVD/XNUC 5

6

A 6/6 7

8

137

1

2

3

4

10.7 INTERFACE PCB

JA3621

BZ R3621

1

1

AUX GND

NM

GNDSIG

9 10

AUXR 1

VIDEO

AUX:+2.2 dBs

ANR 11 GND

12

GNDSIG

AUXL

5

AUXV

3

6

R3648 NM

4

4

R3643 75

8

AUXVGND

NM

GND

7

R3647 22k

DZ2S180C

R3642

DZ2S180C

AUXL

7

22k

D3643

6

D3642

5

NM

R3646

CKN1106-A

2

C3642

AUXR AUXAGND

JA3641

NM

R3645

R3641

0.1u/50

4

D3641 DZ2S180C

3

0.1u/50 C3641

B

BEEP AUXAGND

3

2

8

BCAMIN

R3644

2

GND BZ3631 CPV1062-A 1

NM

D3621 NM

CKS6605-A-TBB

C3621

75

2

BCAMGND

B.

2

1 2

CN3601

CKB1106-A

R3661 1

A

ANG 13 14

GNDSIG

ANB 15

APPPUP 1000p/50

16

APPPUP

C3722 CSYNC 17 HSYNC 18 2.2u/10

C3601

VSYNC 19

A 5/6 CN1701

C

GND 20

C3602

2.2u/10

C3603

2.2u/10

C3604

2.2u/10

C3605

2.2u/10

DTVL 21 DTVAG 22 C3724

DTVR 23 TVON 24 GUIDEON

25

ONSEI+

26

ONSEI-

27

C3723 1000p/50

1000p/50

IC3661 1 NC_1

VCC

2 NC_2

NTOSYS 30

3 NC_3

BTMICN

32

BTMICP

33

6 SCL

4 GND

5 SDA

GND 31

D

7 VCLK

C3725 18p/50 C3726 18p/50

SYSTON 29

R3682

GND 28

8

NM GND GNDD

GNDD 34 GNDD 35 GNDD 36 SXTOS

37

STOSX

38

GNDD C3721

1000p/50

GND 39 ASENBO 40

GND

SXR 41 GNDA 42 SXPWR C3606

SXL 43 SXPWR 44

E

NM

SXPWR 45

GND

SXEN 46

CKS6437-A

NM

D3732 NM

C3732 NM D3731

NM

C3731

VA3692 NM

NM

NM

R3694

2 3 1

NM

R3693 WIREDAD WIRED GND

JA3691 1 3 2

VA3691 NM

NM 1k

JA3731 0.1u/10

R3731 R3732

BT MIC R3692 NM NM

50

NM

C3692

WIREDAD

WIRED REMOTE

GNDSX

C3691

49

NM

GNDSX 48 WIREDD

R3691

GNDSX 47

GND

F GND

B 138

1

GNDD

M2R6TP_GND

AVH-X1600DVD/XNUC 1

2

1

GN

KN3601 KN360

3

4

M2R6TP_GND

5

6

7

8

A

JA3621 1

CKB1106-A

B

B.CAMERA INPUT

2

INTERFACE PCB

CN3661 D3666 NM D3667 NM D3668 NM

1

CCR

2

CCG

3

CCB

4

CCSYNC

D3669 NM D3670 NM D3671 NM

5

GNDSIG

6

HSYNC

7

GNDD

5

6

7

75

R3685 NM

4

3

2

R3661 1

8

CKS4497-A

GNDD

NM

NM

GND R3674

NM GND

8

VSYNC

9

ASENBO

NAVI/DTV INTERFACE

R3686 D3665

B

R3662

22k

R3675

NM

10

CCAUL

R3663

22k

R3676

NM

11

CCAUR

12

GNDAU

13

ONSEI+

14

ONSEI-

15

IPSDA

16

IPSCL

17

NC

18

NC

19

DSEN

20

TVON

21

GUIDEON

22

MONON

23

IP5V

24

SYS_TO_NAVI

25

NAVI_TO_SYS

26

GNDD

2.7k

R3677

R3664 5.6k

R3678

2.7k

R3684

NM NM

R3683

R3687

R3680 NM

IC3661 1 NC_1

VCC

2 NC_2

R3679

8 7

R3665

1k

R3666

1k

APPPUP

NM

VCLK 3 NC_3

R3681 NM

NM

6

R3668

470

R3669

470

C3743 D3673 NM

NM GND

GND

NM

NM

NM

D3664

C3661

NM

R3682 NM

NM

D3663

D3672 NM

D3662

5 SDA

D3661

4 GND

NM

SCL

IF-Mother Connector part : 3601 - 3620 Back Camera part : 3621 - 3630 Buzzer part : 3631 - 3640 AUX part : 3641 - 3660

C

NAVI part : 3661 - 3690 BT mic part : 3691 - 3700 SXi part : 3701 - 3730 Wired remote part : 3731 - 3740 GND to GND : 3741 -

CHIP SIZE LEGEND 1608 2125 3216

TV:+2.2 dBs Navi Guide:+14.5 dBs

GNDD

D

GND R3706

8.2k

R3707

470

SXPWR

JA3701 R3712

NM

NM

R3704

C3702 0.1u/25

D3704 NM

NM

D3705 NM

D3706

9

SXPWR

8

GNDSX

7

GND

6

SXRX

5

GNDA

4

SXR

SXi

3 2

SXTX

1

SXL

E

NM NM

D3701

NM

180

NM R3710

NM

R3705

C3701

22k

NM R3709

D3703

470

180

22k R3703

NM

R3701

R3711 NM

GND

R3708

D3702

R3702

100k

R3713

10 PWEN

GNDSX

GND C3744

1u/10

NM

C3742 NM R3741 NM

SERVICE UNIT(MOTHER I/F) Consists of MOTHER PCB INTERFACE PCB

TP3741 C3741 NM 1

1

GND

601 KN3602 _GND

F

B

M2R6TP_GND

AVH-X1600DVD/XNUC 5

6

7

8

139

1

2

3

4

10.8 DVD CORE UNIT (GUIDE PAGE) A

167

MDQ3

168

MDQ11

169

MDQ4

170

MDQ10

171

MDQ5

172 173

MDQ9

C1505

174

0.1u/10

175

MDQ6

176

MDQ8

177

MDQ7

178

DQM0

179

DQM1

180

XWE

181 182

MCK

R1512

L1501

47

CTF1743-A

183 C1506

184

0.1u/10

185

XCAS

100k

R1538

186 C1503

187

0.1u/10

188

XRAS

189

XCSM

190

STANDBY

191

MA11

192

BA0

193

MA9

194 195

BA1

C1507

196

0.1u/10

197

MA8

198

MA10

199

MA7

200

MA0

201

MA6

202

MA1

203 204

MA5

C1508

205

0.1u/10

206

MA2

207

MA4

208

MA3

209 210 C1509

211

0.1u/10

212 213 214 215

TEMP

TD

FD R1601

12k

R1672

(D) C1674

(D)

24k (D)

12k

R1602

100p/50 R1671

C1601

TEMP

C1606

0.1u/10

1u/10

C1673 0.1u/10

10k (D) (1608)

C1676

GNDA

30k (D)

R1603 R1674

24 (F) (1608)

R1983 100

0.1u/10 0.1u/10

0 R1987

R1950

R1508 220 GNDD5 100 R1507

0.1u/10

100 R1506

0.1u/10

C1514

0.1u/10

C1511 166

0.1u/10

GNDD

R1670 10k

0.01u/16 AD2

MDQ13 MDQ2 VSS_11 VDD33_7 MDQ12 MDQ3 MDQ11 MDQ4 MDQ10 MDQ5 VSS_12 VDD33_8 MDQ9 MDQ6 MDQ8 MDQ7 DQM0 DQM1 NWE VSS_13 MCK VDD33_9 MCKI VSS_14 VDD12_5 NCAS

IC1501 MN2DS0018MA

NRAS NCSM STANDBY DQM3 BA0 MA9 VSS_15 VDD33_10 BA1 MA8 MA10 MA7 MA0 MA6 MA1 VSS_16 VDD33_11 MA5 MA2 MA4 MA3 VSS_17 VDD12_6 EXADT0 NEXCE NEXOE EXDT0 EXDT8

2

1

216

VCC33

3 EXDT1 EXDT9 4 EXDT2 EXDT10 5 VSS_1 6 VDD33_1 7 EXDT3 8 EXDT11 9 EXDT4 10 EXDT12 11 EXDT5 12 EXDT13 13 EXDT6 14 EXDT14 15 VSS_2 16 VDD33_2 17 EXDT7 18 EXDT15 19 VSS_3 20 VDD12_1 21 EXADR16 22 EXADT15 23 EXADT14 24 EXADT13 25 EXADT12 26 EXADT11 27 EXADT10 28 EXADT9 29 EXADT8 30 EXADR19 31 NEXWE 32 VSS_4 33 VDD33_3 34 EXADR18 35 EXADR17 36 EXADT7 37 EXADT6 38 EXADT5 39 EXADT4 40 EXADT3 41 EXADT2 42 EXADT1 43 VSS_5 44 VDD12_2 45

165 C1504

R1954 15k

MDQ1 MDQ14 160 MDQ0 159 MDQ15 158 VDD12_4 157 VSS_10 156 OSCO 155 OSCI 154 VDD33_6 153 VSS_9 152 IECOUT 151 ADOUT 150 LRCK 149 SRCK 148 DACCK 147 AVDDI 146 ROUT 145 AVSSI 144 LOUT 143 AVSSG 142 AVDDG 141 AVDDE 140 AVSSE 139 DAC5OUT 138 COMPOSITE 137 AVSSF 136 COMP2 135 IREF1 134 VREF 133 COMP1 132 AVDDF 131 DAC1OUT 130 DAC2OUT 129 DAC3OUT 128 AVDDH 127 FD 126 TD 125 AVSSH 124 AD4 123 AD2 122 TEMP 121 VDSENS 120 VIN1 119 VIN2 118

164

MDQ12

D

161

162

10u (2125)

10u (2125)

C1501 CCG1192-A

C1502 CCG1192-A

163

MDQ2

VTL1126-A L1511 R1505 100

MDQ0

MDQ14

68p/50 C1603

R1955 15k

C1515

1M

MDQ15

VCC12

C1605

RSB6R8SM D1902

R1503

MDQ1

200 (D)

100p/50

10p/50 GNDD

VCC33

68p/50 C1602

C1671

1.2k

R1501

10p/50

C1604

GNDV D1901 RSB6R8SM

2

NC1 C1512

X1 C1510

MHz

24 (F) (1608)

1

C1809

0.1u/10

0.1u/10 C1805

B

GNDD

X1501 27.000 CSS1823-A X2 3 NC2

R1951

4

GNDAU

C

COMPOSITE

IC1801

BCK 1

820

VCC5_AU

MDQ13

D-

LTDAC

D+

SCKDAC

IECOUT

SDODAC

DATA

12

ML 15 SCK 16

LRCK

2

11

VCOM 10

MD 13

DGND

3

4

VCC

AGND 9

VOUTR

VOUTL

6

R1804

4.7u (2125)

IEC

C1802 CCG1201-A

ADAC

R1504 120

LOUT

8

GNDAU1

NC

(2125)

5

C1806 CCG1192-A 10u

820

PCM1753DBQ

R1803

7

C1803

1800p/50

100k 100k

C1804

R1801 R1802

4.7u (2125)

1800p/50

C1801 CCG1201-A

ROUT

MC 14

C-a

1

MDQ5

5

4

MDQ6

6

MDQ7

7

3 R1481 56 2

8

1

C1482 0.1u/10

C1484 0.1u/10

DQM0 5

4

XCAS

6

XRAS

7

3 R1482 56 2

XCSM

8

1

BA0

5

4

BA1

6

MA10

7

3 R1483 56 2

MA0

8

1

MA1

5

4

MA2

6

MA3

7

3 R1484 56 2

8

1

XWE

F

C1485 0.1u/10

2

8

1

MDQ14

A12

MDQ13

A11

MDQ12

A10 A9 A8

R1486 56 4

5

3

6

3

C1487

7

2

0.1u/10

8

1

MDQ11

A19

MDQ10

XWR1

MDQ9

FRES

MDQ8

C1410

R1489

DQM1

56

MCK

5

4

R1487 6 56 7

3 2

8

1

R1488 5 56 6

4

7

2

8

1

3

MA11 MA9

MA8

A13 VSS2 4 A12 DQ15/A-1 5 A11 DQ7 6 A10 DQ14 7 A9 DQ6 8 A8 DQ13 9 DQ5 XWR1 10 A19 NC1 DQ12 11 DQ4 WE 12 %RESET VCC 13 NC2

14

15 0.1u/16 NRES GNDD 16 A18 A17

17

A7

18

A6

19

A5

20

A4

21

A3

22

A2

23

MA6

A1

24

MA5

A0

MA7

MA4

BYTE

WP RY/BY

DQ11

DQ3

48 47

IC1402

46

C1404 CCG1201-A 4.7u (2125)

45

A18

DQ2

A17

DQ9

A7

DQ1

A6

DQ8

A5

DQ0

A4

OE

A3

VSS1

A2

CE

A1

A0

A15

1

A14

2

A13

3

D15

A12

44

D7

A11

43

D14

A10

42

D6

41

D13

A9 A8

40

D5

A19

39

D12

A20

38

D4

37

C1403

36

0.1u/10

XWR1 FRES

D11

35 34

DQ10

A16

14

D10

15

D2

A18

16

32

D9

A17

17

31

D1

A7

18

30

D8

A6

19

29

D0

A5

20

XRD

A4

21

A3

22

A2

23

A1

24

DGND1

26 25

XCSF1 100k R1402

CWW5043

BYTE

NC2

D3

27

A16

A14

A13 VSS2 4 A12 DQ15/A-1 5 A11 DQ7 6 A10 DQ14 7 A9 DQ6 8 A8 DQ13 9 A19 DQ5 10 NC1 DQ12 11 WE DQ4 12 %RESET VCC 13

33

28

0 1u/10

C1519

R1547 A20

A1

A2

A3

A4

A5

A6

A7

A17

A18

XWR1

A19

A8

A9

A10

VCC33

A15

WP RY/BY

DQ11

DQ3

48 47

C1409 CCG1201-A

46

4.7u (2125)

45

D15

44

D7

43

D14

42

D6

41

D13

40

D5

39

D12

38 37 36

D4 C1408 0.1u/10

35

A18

DQ2

A17

DQ9

A7

DQ1

A6

DQ8

A5

DQ0

A4

OE

A3

VSS1

A2

CE

A1

A0

33

D2

32

D9

31

D1

30

D8

29

D0

28

DGND2

27 26 25

CWW5044

VHALF VHALF IC1251

2 TD2 TD

TD1

4 FD

XCSF2 R1405 100k

R1251 R1252

33k FD2 FD1

47k R1253 R1254

33k

D10

A0 GNDD

D11 D3

34 DQ10

A16

47k

1 VR PreVcc 2 OPIN2+ 3 OPIN2-OPIN3+ OPIN34 OPOUT2 OPOUT3 5 OPIN1+ OPINSL 6 OPIN1OPOUTSL 7 OPOUT1 LDIN 29

CONT2

CNT2

R1257

220

C1254

XRD FOP

FOP2

FOM

FOM2

TOM

TOM2

TOP

TOP2

0.1u/16

R1406

FIN1

FIN2

8 GND1 CNT 9 MUTE GND2 10 PowVcc1 PowVcc2 11 VO1- VO412 VO1+ VO4+ 13 VO2- VO314 VO2+ VO3+

28 C1524 0.047u/16

27 26

MD1 MD2 R1255

25

18k

24 23

CRGDRV R1256

GNDD3

GNDD

GNDP5

2

C1523 0.22u/6.3 30

R1258

21

19

C1255

18

0.1u/16

17 16 15

GNDP4

MOTOR DRIVER

4

220

20

GNDP

3

7.5k

22

BA5839FP

4.7k

AVH-X1600DVD/XNUC 1

A11

A12

A13

A14

A15

A16

D15

D7

D14

D6

D13

D5

D12

D4

D11

D3

D10

D2

D9

D1

D8

D0

XRD

XCSF2

A0 CCG1192-A 10u (2125)

C1489

1000p/50

3

7

0.1u/10

A13

A16

A14

GNDD

C

0.1u/10

C1518

0.1u/10

C1517

0.1u/10

C1516

C1513

GNDD4

9 12

8 13

6 15

5 16

7 14

SDATA

4 17

10 11

R1979 NM

6 C1488

MDQ15

FLASH 16M VCC33

A15

M12L64164A-5TG2Y

SDRAM

140

4

2

4.7u (2125) C1251

8

5

1

A14

C1253 0.1u/16

3 R1480 56 2

10

R1527 6.8 R1546 6.8

C1252 CCG1222-A

7

MDQ4

IC1401 A15

220

4

6

MDQ3

FLASH 16M R1485 56

C1401

5

MDQ2

54 GND3 53 DQ15 52 GNDQ4 51 DQ14 50 DQ13 49 VDDQ4 48 DQ12 47 DQ11 46 GNDQ3 45 DQ10 44 DQ9 43 VDDQ3 42 DQ8 41 GND2 40 NC2 39 UDQM 38 CLK 37 CKE 36 NC1 35 A11 34 A9 33 A8 32 A7 31 A6 30 A5 29 A4 28 GND1

0.1u/16

0.1u/10

MDQ1

IC1480

2 VDD1 DQ0 3 VDDQ1 4 DQ1 5 DQ2 6 GNDQ1 7 DQ3 8 DQ4 9 VDDQ2 10 DQ5 11 DQ6 12 GNDQ2 13 DQ7 14 VDD2 15 LDQM 16 WE 17 CAS 18 RAS 19 CS 20 BA0 21 BA1 22 A10 23 A0 24 A1 25 A2 26 A3 27 VDD3

R1401

C1481

56

1

C1490

C1480 0.1u/10

R1542

VCC33

L1904

R1490

NM

R1528 10k R1530 10k

CTF1528-A

MDQ0

R1539 100 R1533

R1517 10k R1529 10k R1531 10k R1518 10k

GNDD

SCLOCK

R1977 NM R1978 NM EXTRG0

3 18

2 19

1 20

E

TRCCLK

R1975 NM R1976 NM TRCDATA0

R1973 NM R1974 NM TRCDATA1

TRCDATA3

TRCST

R1971 NM R1972 NM

NM

TRCDATA2

CN1951

0.1u/10

DEBUG GNDD

5

6

7

8

A

E+G_E+F

C

IC1004 NJM2855DL1-33

12k

R1602

05 VCC33

VDSENS

1u/10 (1608)

GNDD

VSS

(2125)

6

2

7

5

3

4

NC1

VIN NC2 ON/OFF

1u/10

1 VOUT

VCC12

C1953

VREF

VREF2 C1623

0.01u/16 AD2

VCC12

VCC33 C1607 CCG1192-A 10u

1u/10

4.7u

C1954

C1608 (2125) CCG1201-A

VREF1

GNDA3

TEMP

C1606

0.1u/10

10k (D) C1601

IC1953 S-1135D12-A6

1u/10

C1010

VHALF

R1603

B

VD5 2.2u/10

VCC33

50 71 k

C1011

0 03

DVD CORE UNIT

1 Vin

50

2 GND

12k

R1601

04 0 02

:POWER SUPPLY :PU :ACT+SPDL :FLASH :SDRAM :DV5(SYS) :DV5(FE) :DV5(BE) :VIDEO :AUDIO (ANALOG) :AUDIO (DIGITAL) :OUTSIDE I/F :USB

1000->1049 1100->1199 1200->1299 1400->1449 1480->1499 1500->1599 1600->1669 1670->1699 1700->1749 1800->1849 1850->1899 1900->1950 1950->1999

3 Vout

FE1

F+H_G+H

FE2

TEMP

TD

FD

C-b

1M R1605 1M

R1604 0.1u/10

D

C1616

0.1u/10

RF

C1617

0.1u/10

1

CTF1487-A

VCC5_AU

IC1003 5

VCC5_AU C1001 1u/10

ANAMONI1 C1625 0.1u/10 C1618 100p/50

VOUT

VIN VSS

(1608)

ANAMONI2

4

NC ON/OFF

1

GNDP

2 3

S-1200B50-M5

R1043

0.22u/6.3

0.22u/6.3

C1622

0.033u/16

C1624

0.1u/10 C1521

VCC5

GNDAU

C1002

2 VSS 1 NC

VOUT5 C1004

0.1u/16

CCG1201-A 4.7u (2125)

C1003

VCC5

GNDA1 GNDA2

0.1u/10 GNDA TRCST

TRCST 1

VD5

TRCDATA1

F1002 DTL1106-A

TRCDATA0

NM (3216)

VD8_P2

AMUTE

EXTRG0

SCLOCK R1523

C1526

0.1u/10 R1513 10k R1514 18k

220

AMUTE

IRQPWR

IRQPWR

CMDCOMN

CMDCOMN

STSCOMN

STSCOMN R1025

STANDBY

NRES

R1522 100k R1516 100k R1510 1k R1509 1k R1524 4.7k

C1522

STANBY

100 RO

ROUT CRGDRV

LO

LOUT

MD HOME CONT2

R1027

COMPOSITE

COMPOSITE

100

CONT1 LDIN CP_RESET

R1532

CP_RST

100

D-

D-

D+

D+

XCSF1 SCKDAC

IECOUT

SDA

CP_RST

CP_RST

R1004

47k

6.8k C1018

0.1u/10

VSENS STSCOMN

R1007

CMDCOMN

220

R1534

IRQPWR

220 C1528 470p/50 R1536 100k

1000p/50

VDSENS C1016

1k

10k

R1535

VD8

R1526

10k R1525

R1537

220

GNDAU2

I2C_SDA

GNDAU3

12EJ

100k

55

100k

SCL

08EJ

FOP

I2C_SDA

TOM

FOP1

R1953

2 3

IC1951

VREF

TC7SZU04FU

2

C1952

GND1 X1 CSS1760-A

C1108 0.01u/16

10p/50

1

VCC5_PU

48.000 MHz C1951

48MHz

OUT_Y GND

1M

1

NC IN_A

X2 3

10p/50

R1952

0.1u/10

X1950 4 GND2

820

C1950

VCC

F+H_G+H

F+H_G+H

E+G_E+F

E+G_E+F

C1110

0.01u/16

CDLD0

CDLDO

DVDLD0

DVDLDO GNDD

2 C1223

GNDP

SPDLP

BLK

D

D

FE1

FE1

FE2

FE2 VR1101 CCP1447-A 2

CDMPD

M2 EXM2002 SPINDLE MOTOR

GNDA4

RED

DVDMPD

1

(1608*4)

3.9

RF

RF

CDLDO

C1111

R1117

3.3

(1608) C1109 0.22u/16

R1114

DGND

24

VD5

23

AMUTE

22

XRESET

21

IRQPWR HSTCMD

19

SLVSTS

18

STANBY

17

AGND

16

ANALOG ROUT

15

AGND

14

ANALOG LOUT

13

AGND

12

COMPOSIT

11

VIDEO GND

10

DGND

9

D-

8

D+

7

DGND

6

IECOUT

5

DGND

4

SCL

3

SDA

2

RESET

1

DGND

A 2/6 CN751

D

CN1101 1

T+

2

F-

2

3

IMON

F+

4

T-

5

GND

6

TEMP

7

TEMP GND

8

Vref

9

VCC

10

F+H/G+H

11

E+G/E+F

12

SW

13

78LD

14

65LD

15

LD GND

16

B

17

A

18

C

19

D

20

FE1

21

FE2

22

IMON

23

RF

E PU UNIT (DP11)

1 8.2k 6.8k(B)

3 1 VR1102 CCP1449-A 15k(B)

DVDLD2

DVDLD1

GNDA

R1115

3.3 2.7 (1608*4) R1111 R1116

3.3 Q1103 2SB1132(QR)

Q1101 LSCR523UB

LPCO1

M

C1104 0.1u/10

M1 CXC4026 CRG(L/E) MOTOR

GREEN

SPDLP

C

F

2.7 DVDLDO

C1106 0.01u/16

C

GNDA

AVH-X1600DVD/XNUC 5

PGND

25

0.22u/16 (1608)

CDLD1 CDLD2

(2125)

430

C1105 0.1u/10

22u

(F) R1105

C1112 DCH1256-A

560

C1101 CCG1192-A

3.3

(2125)

M

22u

3 LECRGP SPDLM

SPDLM

1

100u/16

4.7u (2125) C1251

C1253 0.1u/16

GNDP4

C1252 CCG1222-A

DP5

LECRGP

PGND

26

C1107 0.01u/16

R1109 WHITE

430

SPDLM VD8

C

3.9

3.9

R1112

LECRGM

LECRGM

A

DVDMPD

R1118

Q1104 2SB1132(QR)

Q1102 LSCR523UB

C1113 DCH1256-A

SPDLP

LPCO2

3

LECRGP LECRGM

BA5839FP

3.3 10u (2125)

12EJ GNDD SWITCHES: DVD CORE UNIT S1:HOME SWITCH.........ON-OFF S3:12EJ SWITCH............ON-OFF The underlined indicates the switch position.

100k (F) R1106

CONT1

0.1u/16

R1110

(F) R1103

220

C1255

A

R1982

R1102

CNT1 R1258

B

CDMPD R1113

VCC5

NM

LDIN C1523 0.22u/6.3

30

B

S3 CSN1081-A

C1225

100k (F) R1104

LDIN

12EJ

470

NM

R1101

7.5k

22

21 CNT MUTE GND2 20 19 PowVcc1 PowVcc2 18 VO1- VO417 VO1+ VO4+ 16 VO2- VO315 VO2+ VO3+

R1225

1

CRGDRV R1256

12EJ CRGDRV

1

18k

GND1

NM

MD R1255

24

S2

C1224

NM

MD1 MD2

25

23

NM 08EJ

1

FIN2

C1524 0.047u/16

27 26

R1224

C1955 0.1u/16

FIN1

08EJ

C1210 0.1u/16

PreVcc OPIN2+ OPIN3+ OPIN2OPIN3OPOUT2 OPOUT3 OPIN1+ OPINSL OPIN1OPOUTSL OPOUT1 LDIN

2

28

VR

2

IC1251

510

560

4 31

HOME

S1

4 31

R1223

HOME CSN1080-A

4 31

HOME

27

3 VCC5

I2C_SCL TEMP

A20

A1

A2

A3

A4

A5

A6

A7

A17

A18

R1544 180 R1543 180

4

VD8

CKS6331-A

10k

5

VD8

28

GNDD GNDAU GNDV TOP1

TOP

R1527 6.8k R1546 6.8k

VD8

29

GNDV1 GNDV2

SDODAC I2C_SCL

30

20

FOM R1542

VD5_1

NRES

100

NRES

SDATA

SCLOCK

GNDD2 VD5_2

CKS6025-A

VD8_P1

C1015 1000p/50 VD8_A

GNDD1

R1019

GNDD

CN1952

L1903 CTF1558-A

AMUTE

SDATA

GNDP

GNDA

3

LTDAC

R1541

R1045

2

TRCCLK

C

270p/50

TRCDATA3 TRCDATA2

NM (3216) GNDV C1041

GNDAU IC1002 S-1133B50-U5 VIN 4 3 ON/OFF

0.1u/16

C1621

C1040 820p/50

C1619 5600p/25 C1620

L1902

3 2

GNDP3

C

GNDP2

0.1u/10

C1615

GNDP1

C1614

VD8

(1608)

A

C1005

B

0.1u/10

1u/16

0.1u/10

C1613

R1519

VSS_6 VDD33_4 CMDCOMN STSCOMN

F1001 DTF1106-A C1612

54

53

52 C1520

LPCO1

NM

R1547

0.1u/10

0.1u/10

C1519

0.1u/10

C1518

NM

CDMPD

DVDMPD

56

R1540

R1539 100k R1533

GNDD

LPCO2

0.01u/16

F+H_G+H E+G_E+F 111 VHALF 110 VREFH 109

112 51

114

115

116

117

118

113 VIN5

108

107 AVSSB 106 AVDDB LPCO2 105 CDMPD 104 LPCO1 103 DVDMPD 102 VREFL5 101 VREFH5 100 VIN3RF 99 VIN4RF 98 VIN2RF 97 VIN1RF 96 RFINP 95 RFINN 94 ANAMONI2 93 ANAMONI1 92 AVDDC 91 CDATA 90 CCAPA 89 AVSSC 88 VREFL7 87 AVSSD 86 VREFH7 85 PLFIL1 84 AVDDD 83 VDD12_3 82 VSS_8 81 TRCST 80 TRCDATA3 79 TRCDATA2 78 TRCDATA1 77 TRCDATA0 76 TRCCLK 75 EXTRG1 74 EXTRG0 73 SDATA 72 SCLOCK 71 FG 70 NRES 69 VDD33_5 68 VSS_7 67 CRGDRV 66 MD 65 HOME 64 CONT2 63 CONT1 62 LDIN 61 CP_Reset P13 60 XCSSR 59 SCKDAC SDODAC 58 LTDAC 12EJ 57

USB_CLOCK

50

49

08EJ

IRQPWR

48

VIN6

VIN7

VIN3

VIN4

VIN2

VIN8 I2C_SCL

VDD12_2

A20

I2C_SDA

47

46

45

121

119 44

122

120 VIN1

AD2

TEMP

VDSENS

VSS_5

EXADT2

EXADT3

EXADT1

43

41

42

123

AD4 EXADT4

40

AVSSH EXADT5

124 39

125

127

128

129

126 EXADT6

38

37

36

EXADT7

TD

FD

AVDDH

DAC3OUT

DAC2OUT VDD33_3

EXADR17

EXADR18 34

33

35

130

GND C1609 0.1u/10

6

7

8

141

TEMP

u/16 AD2

01

k (D)

E+G_E+F

F+H_G+H

FE1

FE2

TEMP

108

0.1u/10

0.1u/10

0.1u/10

0.1u/10

0.1u/10

0.1u/10

VREF

C1522

SCLOCK

SDATA

TRCST

0.1u/10

0.1u/10 C1521

0.033u/16

0.22u/6.3

0.22u/6.3

0.1u/10 R1513 10k R1514 18k

C1624

C1622

C1621

C1620

ANAMONI1 C1625 0.1u/10 C1618 100p/50 C1619 5600p/25

ANAMONI2

C1617

C1616

C1615

C1614

C1613

C1612

C1609 0.1u/10

1u/10 (1608)

VREF2 C1623

107 AVSSB 106 AVDDB LPCO2 105 CDMPD 104 LPCO1 103 DVDMPD 102 VREFL5 101 VREFH5 100 VIN3RF 99 VIN4RF 98 VIN2RF 97 VIN1RF 96 RFINP 95 RFINN 94 ANAMONI2 93 ANAMONI1 92 AVDDC 91 CDATA 90 CCAPA 89 AVSSC 88 VREFL7 87 AVSSD 86 VREFH7 85 PLFIL1 84 AVDDD 83 VDD12_3 82 VSS_8 81 TRCST 80 TRCDATA3 79 TRCDATA2 78 TRCDATA1 77 TRCDATA0 76 TRCCLK 75 EXTRG1 74 EXTRG0 73 SDATA 72 SCLOCK 71 FG 70 NRES 69 VDD33_5 68 VSS_7 67 CRGDRV 66 MD

123 AD2 122 TEMP 121 VDSENS 120 VIN1 119 VIN2 118 VIN4 117 VIN3 116 VIN8 115 VIN7 114 VIN6 113 VIN5 112 F+H_G+H E+G_E+F 111 VHALF VREFH 110 109

C1608 (2125) VREF1 CCG1201-A 4.7u

R1604

GNDA3

VCC33

220

R1523

(2125)

C1607 CCG1192-A 10u

1M R1605 1M

03

VCC5_AU

NC ON/OFF

VSS

VIN

1

VCC5

F1002 DTL1106-A

VCC5

3

2

1

SDATA

MD

CRGDRV

NRES

SCLOCK

3

2

1

2

VCC33

ON/OFF

NC2

VIN

GNDP

2

3

2 VSS 1 NC

L1902

LOUT

ROUT

STANDBY

STSCOMN

100

R1025

LO

RO

STANBY

STSCOMN

CMDCOMN CMDCOMN

NRES 100 IRQPWR

AMUTE

VD5_2

GNDD2

C1040

VD5_1

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

ANALOG LOUT

AGND

ANALOG ROUT

AGND

STANBY

SLVSTS

HSTCMD

IRQPWR

XRESET

AMUTE

VD5

DGND

PGND

PGND

VD8

VD8

VD8

CKS6025-A

GNDP

NM (3216)

R1045

CN1952

270p/50

NM (3216) GNDV C1041

R1043

820p/50

GNDD

VD5

CN751

A 2/6

DVD CORE UNIT

VD8_P1

GNDA

GNDAU

GNDD

C1015 1000p/50 VD8_A

L1903 CTF1558-A

GNDD1

2 GND

IC1004 NJM2855DL1-33

C

VD8_P2

VCC33

CTF1487-A

R1019

GNDA

GNDA1 GNDA2

VOUT5

1u/10

GNDD

IC1002 S-1133B50-U5 VIN 4 3 ON/OFF

1

F1001 DTF1106-A

4

5

6 C1953

IRQPWR

3

GND

7

IC1953 S-1135D12-A6

C1002

0.1u/16

NC1

VSS

VOUT

NRES

VD5

GNDAU

IC1003 VOUT

S-1200B50-M5

4

5

VD8

1u/10

EXTRG0

VCC5_AU

VCC12

VCC12

C1954

AMUTE

D

AMUTE

TRCCLK

TRCDATA0

TRCDATA1

TRCDATA2

TRCDATA3

TRCST

RF

D

C

A

B

DVDMPD

LPCO1

CDMPD

LPCO2

VDSENS

C1001 1u/10

VHALF

C1526

:POWER SUPPLY :PU :ACT+SPDL :FLASH :SDRAM :DV5(SYS) :DV5(FE) :DV5(BE) :VIDEO :AUDIO (ANALOG) :AUDIO (DIGITAL) :OUTSIDE I/F :USB

(1608)

1000->1049 1100->1199 1200->1299 1400->1449 1480->1499 1500->1599 1600->1669 1670->1699 1700->1749 1800->1849 1850->1899 1900->1950 1950->1999

C1005

3 Vout C1010

C-a C-b

(1608) 1u/16 C1004

C-b

0.01u/16

4 R1522 100k R1516 100k R1510 1k

AVH-X1600DVD/XNUC 1k R1509

3

4.7k R1524

C1003

3

0.1u/16

2 CCG1201-A 4.7u (2125)

E GNDP3

C GNDP2

1 Vin

1 1u/10

142 2.2u/10

F C1011

B 2

GNDP1

1 4

A

EXADT2

41

10k R1527 6.8k R1546 6.8k

18k

220

C1523 0.22u/6.3

7.5k

R1255

C1524 0.047u/16

0.1u/16

C1255

R1258

NM

R1542

RGDRV R1256

D1 MD2

42

I2C_SDA

I2C_SCL

MD

LDIN

IN_A

NC

C1224

NM

470

R1225

NM 08EJ

R1224

SPDLP

SPDLM

LECRGP

LECRGM

SPDLP

SPDLM

LECRGP

3

LECRGM

3

NM

C1225

12EJ

NM

C1223

HOME

3

2

1

560

R1223

TC7SZU04FU

IC1951

OUT_Y GND

VCC

220

CP_RESET

0.1u/10 R1513 10k R1514 18k

C1522

SCLOCK

SDATA

S1

C1951

48.000 MHz

X1 CSS1760-A

GNDD

S2

S3 CSN1081-A

NM

2

X2 3

220

R1523

GND1

X1950 GND2

HOME CSN1080-A

1

4

C1526

RED

BLK

GREEN

WHITE

M

M

M2 EXM2002 SPINDLE MOTOR

M1 CXC4026 CRG(L/E) MOTOR

12EJ GNDD SWITCHES: DVD CORE UNIT S1:HOME SWITCH.........ON-OFF S3:12EJ SWITCH............ON-OFF The underlined indicates the switch position.

12EJ

08EJ

HOME

4

5

0.1u/10

C1950

R1544 180 R1543 180

R1534 220 C1528 470p/50 R1536 100k

R1541

220

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

R1540

CP_Reset P13 XCSSR SCKDAC SDODAC LTDAC 12EJ

LDIN

CONT1

CONT2

HOME

MD

CRGDRV

VSS_7

VDD33_5

NRES

FG

SCLOCK

SDATA

54

73

100k

74

0.01u/16

75

C1952

EXTRG0

R1522 100k R1516 100k R1510 1k 10p/50

1k R1509

4.7k R1524

EXTRG1

100

R1532

AMUTE

VCC5

I2C_SCL

I2C_SDA

08EJ

IRQPWR

CMDCOMN

STSCOMN

12EJ

LTDAC

SDODAC

SCKDAC

XCSF1

CP_RST

LDIN

CONT1

CONT2

HOME

MD

CRGDRV

NRES

SCLOCK

SDATA

EXTRG0

8

10u (2125)

GNDA

GNDA4

LPCO1

LPCO2

3.3

R1110

Q1102 LSCR523UB

3.3

R1109

Q1101 LSCR523UB

3.9

3.9

C1106 0.01u/16

2.7

R1111 R1116 3.3 Q1103 2SB1132(QR)

DVDLDO

CDLDO

C-a C-b

R1115

3.9

R1117

3.3 2.7 (1608*4)

R1112

C1107 0.01u/16

Q1104 2SB1132(QR)

3.3

R1114

(1608*4)

R1118

R1113

RF

DVDMPD

CDMPD

FE2

FE1

D

C

A

B

DVDLDO

CDLDO

E+G_E+F

F+H_G+H

TEMP

TOM

FOP

FOM

TOP

VDSENS

CP_RST

I2C_SDA

I2C_SCL

IECOUT

D+

D-

COMPOSITE

LOUT

ROUT

STANDBY

STSCOMN

CMDCOMN

IRQPWR

NRES

AMUTE

RF

1

DVDMPD

CDMPD

FE2

FE1

D

C

A

B

DVDLD0

CDLD0

E+G_E+F

F+H_G+H

FOP1

TOP1

100

VD8

CP_RST

SDA

SCL

D+

D-

COMPOSITE

LO

RO

STANBY

STSCOMN

CMDCOMN

1000p/50

R1982

IMON

VCC5_PU

VREF

GNDA

1 8.2k 6.8k(B)

VR1101 CCP1447-A 2 3

GNDV1 GNDV2

GNDD GNDAU GNDV

C1016

0.01u/16

3 1 VR1102 CCP1449-A 15k(B)

2

C1110

C1108 0.01u/16

VCC5

VSENS

R1027

100

R1025

NRES

100 IRQPWR

AMUTE

R1019

AGND

D+ DGND IECOUT DGND

8 7 6 5

RESET DGND

2 1

VCC F+H/G+H E+G/E+F SW 78LD 65LD LD GND B A

9 10 11 12 13 14 15 16 17

IMON RF

FE2 22 23

FE1 21

D 20

19

C

Vref

8

18

TEMP GND

7

TEMP

T-

4

GND

F+

3

6

F-

2

5

T+

1

CKS6331-A

CN1101

SDA

3

SCL

D-

9

4

DGND

10

VIDEO GND

COMPOSIT

11

AGND

12

ANALOG LOUT

AGND

13

14

15

ANALOG ROUT

STANBY

16

17

SLVSTS

HSTCMD

IRQPWR

XRESET

AMUTE

18

19

20

21

22

23

A 2/6

PU UNIT (DP11)

CN751

7

C-b

VD8

SPDLM

SPDLP

LECRGM

LECRGP

CONT1

CNT1

LDIN

CRGDRV

47

IRQPWR

48

08EJ

49

USB_CLOCK

50

EXADT3

40

A3

52

VDD12_2

44

R1539 100k R1533

51

VSS_6 VDD33_4 CMDCOMN STSCOMN

53

C1520

VSS_5

43

C1252 CCG1222-A

R1537

EXADT1

A1

45

0.1u/10

C1519

R1547

4.7u (2125) C1251

R1007

A20

A20

46

NM

100u/16

1k

10k

R1525

2

2

2

R1004 6.8k C1018

100k

48MHz

R1519

R1952

R1953

R1535

1M

820

4 31

4 31

4 31

47k 0.1u/10

10k R1526 10p/50

0.1u/10

C1955 0.1u/16

C1210 0.1u/16

C1101 CCG1192-A

A2

C1253 0.1u/16

1

430 560 430 510

1

1

1

R1102 R1101

(2125) 22u (2125) 22u

(F) R1105 100k (F) R1106 (F) R1103 100k (F) R1104

C1112 DCH1256-A C1113 DCH1256-A

CDLD1 CDLD2 DVDLD2

7 DVDLD1

AVH-X1600DVD/XNUC C1105 0.1u/10 C1104 0.1u/10

6 (1608) C1109 0.22u/16

GNDAU2 GNDAU3

5

6

0.22u/16 (1608)

5 8

A

B

C1111

C

D

E

143

F

100k 100k

R1801

3 185

0.1u/10

E

F

AVH-X1600DVD/XNUC

4

192 193 194

MA11

MA9

201 202 203

MA0 MA6 MA1

0 1 /10

C1508

200 MA7

205

204

199 MA10

197

0.1u/10

198

196

C1507

MA8

BA1

191

STANDBY

BA0

LTDAC

DQM3

STANDBY

NCSM

NRAS

NCAS

VDD12_5

VSS_14

MCKI

VDD33_9

MCK

VSS_13

NWE

DQM1

DQM0

MDQ7

MDQ8

MDQ6

MDQ9

VDD33_8

VSS_12

MDQ5

MDQ10

MDQ4

MDQ11

MDQ3

MDQ12

MDQ13 MDQ2 VSS_11 VDD33_7

VDD33_11

VSS_16

MA1

MA6

MA0

MA7

MA10

MA8

BA1

VDD33_10

VSS_15

MA9

BA0

1M

R1503

MHz GNDV

COMPOSITE 200 (D)

GNDA

GNDD

R1954 15k

R1955 15k

RSB6R8SM D1902

D1901 RSB6R8SM

0.1u/10

(D) C1674

R1670 10k

(D)

R1983 100

C1604

24k (D)

100p/50 R1671

68p/50 C1603

C1605

100p/50

68p/50 C1602

IC1501 MN2DS0018MA

0.01u/16 AD2

C1601

10k (D)

R1603

3

195

190

188

0.1u/10

XCSM

187

C1503

186

184

C1506

183

182

181

180

179

178

177

189

CTF1743-A

175

0.1u/10 176

174

C1505

XRAS

XCAS

MCK

XWE

DQM1

DQM0

MDQ7

MDQ8

MDQ6

47

172

MDQ5

MDQ9

171

MDQ10

10p/50 GNDD

NC1 C1512

X1 C1510

2

X1501 27.000 CSS1823-A X2 3 NC2

IC1801

10p/50

1

4

ADAC

C-b

2

173

170

167

0.1u/10

MDQ4

166

C1504

165

164

163

GNDD

169

L1501

GNDAU

168

R1512

(2125) 11

MDQ11

VCC12

820

R1804

820 12

MDQ3

MDQ12

MDQ2

MDQ13

MDQ1

MDQ14

MDQ0

MDQ15

VCC5_AU

C1803 C1804

VCC33

4.7u (2125)

1800p/50 1800p/50

10u (2125)

R1802

C1802 CCG1201-A

C1502 CCG1192-A

LOUT

GNDAU1

4.7u (2125)

C1501 CCG1192-A

PCM1753DBQ 100k

AGND 9 8

VOUTR

VCOM 10 VOUTL 7

VCC 6

NC 5

SDODAC MD 13 0.1u/10

SCKDAC MC 14

DGND 4

LRCK 3

C1809

ML 15 SCK 16 DATA 1.2k

2 R1501 162

BCK 1

C1806 CCG1192-A 10u

100 R1506

R1803

24 (F) (1608)

C1801 CCG1201-A

0.1u/10 C1671

ROUT

140

TD 12k R1602

C-a C-b

0.1u/10 C1805 10u (2125) R1538

0.1u/10 157

C1511 161 MDQ1 MDQ14 160 MDQ0 159 MDQ15 158 VDD12_4

155

OSCO

0.1u/10

C1514 154

OSCI

156

VSS_10

(1608)

IECOUT IEC R1504 120 152

VTL1126-A L1511 R1505 100 VSS_9

153

VDD33_6

100 R1507

150 LRCK

149

SRCK

0 R1987 148

ADOUT

151

IECOUT

R1508 220 GNDD5 C1515 147 DACCK

R1674 135

1u/10 C1676

TEMP 122

D+ R1950 0.1u/10 146 AVDDI

24 (F) (1608) 145 ROUT

DR1951 AVSSI

144 LOUT

143 AVSSG

141 AVDDE

142 AVDDG

TEMP 121

R1672 AVSSE

139 DAC5OUT

138 COMPOSITE

137 AVSSF

136 COMP2

30k (D) IREF1

134 VREF

133 COMP1

C1673 0.1u/10 132 AVDDF

131 DAC1OUT

130 DAC2OUT

129 DAC3OUT

C1606 128

FD R1601 AVDDH

0.1u/10 127 FD

126 TD

12k 125 AVSSH

124 AD4

123 AD2

2

TEMP

1

120 VIN1

FE1 115

FE2 116 118

117

119

144 VDSENS

C-a VIN2

C VIN4

B VIN3

D VIN7

A VIN8

1 4

7

MA3

MA2

MA1

MA0

MA10

BA1

BA0

XCSM

XRAS

XCAS

XWE

DQM0

MDQ7

MDQ6

MDQ5

MDQ4

MDQ3

MDQ2

MDQ1

MDQ0

3 R1480 56 2

6

1

4

3 R1483 56 2

5

6

3 R1484 56 2

1

5

6

8

7

1

4

8

7

7

8

8

3 R1482 56 2

7

4

1

6

6

3 R1481 56 2

5

5

1

4

8

7

4

5

56

R1490

C1480

0.1u/10

C1485

0.1u/10

C1484

0.1u/10

C1482

0.1u/10

C1481

0.1u/10

NM

CN1951

2 19

1 20

IC1480

TRCDATA1

54

SDRAM

M12L64164A-5TG2Y

GND3 53 2 VDD1 DQ0 DQ15 52 3 VDDQ1 GNDQ4 51 4 DQ1 DQ14 50 5 DQ2 DQ13 49 6 GNDQ1 VDDQ4 48 7 DQ12 DQ3 47 8 DQ11 DQ4 46 9 VDDQ2 GNDQ3 45 10 DQ10 DQ5 44 11 DQ9 DQ6 43 12 GNDQ2 VDDQ3 42 13 DQ8 DQ7 41 14 GND2 VDD2 40 15 NC2 LDQM 39 16 UDQM WE 38 17 CLK CAS 37 18 CKE RAS 36 19 NC1 CS 35 20 A11 BA0 34 21 A9 BA1 33 22 A8 A10 32 23 A7 A0 31 24 A6 A1 25 30 A2 A5 26 29 A3 A4 27 28 VDD3 GND1

1

VCC33

2 1

7 8

C1488 0.1u/10

0.1u/10

C1487

3

2 1

7 8

3

R1487 6 56 7 1 4 3 2 1

8 R1488 5 56 6 7 8

2

4

5

MA4

MA5

MA6

MA7

MA8

MA9

MA11

MCK

DQM1

MDQ8

MDQ9

MDQ10

MDQ11

MDQ12

MDQ13

MDQ14

MDQ15

MA3

MA4

MA2

MA5

MA1

MA6

MA0

A0 0.1u/16

C1401

3

2

1 A14

A15 BYTE

A16

IC1401

A11

A12

D5 D12 D4

40 39 38

D9 D1 D8 D0 XRD

33 32 31 30 29 28

NEXCE NEXOE EXDT0 EXDT8

EXADT0

R1402 GNDD

A0

A1

A2 25

A3

A4

A5

A6

A7

A17

A18

FRES

XWR1

A20

A19

A8

A9

A10

A11

A12

A13

A14

A15

27

216

215

214

VDD12_6

VSS_17

MA3

MA4

MA2

MA5

VDD33_11

VSS_16

MA1

MA6

MA0

MA7

MA10

MA8

BA1

26

XCSF1 100k

D2

34

DGND1

D3 D10

35

D11

D13

41

36

D6

42

0.1u/10

D14

43

C1403

D7

37

D15

44

4.7u (2125)

C1404 CCG1201-A

VCC33 A16

212

0.1u/10 213

211

210

209

208

C1509

GNDD

GNDD4

45

46

47

48

XRD

C-a C-b

CWW5043

A13 VSS2 4 A12 DQ15/A-1 5 A11 DQ7 6 A10 A10 DQ14 7 A9 A9 DQ6 8 A8 DQ13 A8 9 A19 DQ5 XWR1 10 A19 XWR1 DQ12 NC1 11 FRES DQ4 WE 12 %RESET VCC 13 DQ11 NC2 C1410 14 DQ3 WP 15 RY/BY 0.1u/16 DQ10 NRES A18 GNDD 16 DQ2 A18 17 A17 DQ9 A17 18 A7 DQ1 A7 19 A6 A6 DQ8 20 A5 A5 DQ0 21 A4 OE A4 22 A3 VSS1 A3 23 A2 CE A2 24 A1 A0 A1 A0

A13

A14

A15

XCSF2

FLASH 16M

206

0.1u/10 207

205

C1508

204

203

202

201

200

199

1 D1

MA7

D8

VDD33_10

D9

198

D2

197

2 EXDT1 3 EXDT9 4 EXDT2 EXDT10

VDD33_1

A16 BYTE

A14

IC1402 A15

CWW5044

A13 VSS2 4 A12 DQ15/A-1 5 A11 DQ7 6 A10 DQ14 7 DQ6 A9 8 DQ13 A8 9 DQ5 A19 10 DQ12 NC1 11 DQ4 WE 12 %RESET VCC 13 DQ11 NC2 14 DQ3 WP 15 RY/BY DQ10 16 DQ2 A18 17 DQ9 A17 18 DQ1 A7 19 A6 DQ8 20 A5 DQ0 21 OE A4 22 VSS1 A3 23 CE A2 24 A0 A1

3

2

1

A16

D4

39 38

D9 D1 D8 D0 XRD

33 32 31 30 29 28

2

GNDD

4.7k

R1406

100k

FOM

FIN1

13 14 TOP2

20

21

GNDP4

BA5839FP

GNDP5

12

11

0.1u/16 FOM2

CNT

FIN2

30

22

23

24

25

26

27

28

GND2 19 PowVcc1 PowVcc2 18 VO1- VO417 VO1+ VO4+ 16 VO2- VO315 VO2+ VO3+

8 GND1 9 MUTE

29

10

220

47k

R1254

47k

R1252

C1254

R1257

33k

R1253

33k

R1251

IC1251 1 VR PreVcc 2 OPIN2+ OPIN3+ 3 OPIN2OPIN34 OPOUT2 OPOUT3 5 OPIN1+ OPINSL 6 OPIN1OPOUTSL 7 OPOUT1 LDIN

TOM2

FOP2

CNT2

FD2

TD2

VHALF VHALF

MOTOR DRIVER

TOP

TOM

FOP

27

25

FD1

TD1

CONT2

FD

4

TD

R1528 10k R1530 10k

R1531 10k R1518 10k

R1517 10k R1529 10k

26

XCSF2 R1405

D2

34

DGND2

D3 D10

35

D11

D12

40

0.1u/10

D5

41

36

D13

42

C1408

D6

43

37

D7 D14

44

D15

4.7u (2125)

C1409 CCG1201-A

VCC33

EXDT7

45

46

47

48

FLASH 16M

D10

196

5

EXDT3

6 C1513

VSS_1 7 0.1u/10 D3

EXDT11 8 D11

0.1u/10

GNDP

7.5k

220

C1523 0.22u/6.3

18k

R1255

C1524 0.047u/16

0.1u/16

C1255

R1258

NM

R1542 10k R1527 6.8k R1546 6.8k

CRGDRV R1256

MD1 MD2

VDD12_2

R1539 100k R1533

I2C_SCL

LDIN

8

C-b

VD8

SPDL

SPDL

LECRG

LECRG

CONT

CNT1

LDIN

CRGDR

M

7

GNDD

3

6

56

4

5

R1489

R1486 56

4

R1485 56

6

CCG1192-A 10u (2125)

5

GNDD3

CTF1528-A

L1904

R1971 NM

TRCST

4 17

TRCDATA3

5 16

R1972 NM R1973 NM

3 18

TRCDATA2

6 15

R1974 NM R1975 NM TRCDATA0 TRCCLK

8 13 SDATA

7 14

R1976 NM R1977 NM EXTRG0

9 12

R1978 NM R1979 NM SCLOCK C1490

GNDD

VCC33

C1489

DEBUG

10 11

1000p/50

10

EXDT4 9 D4

EXDT12 11

D12

EXDT6

D5

EXDT5 12 D13

C1507

15

EXDT13 13 D6

EXDT14 14 D14

VSS_2 16 C1516

VDD33_2 17 0.1u/10 D7

EXDT15 18 D15

VSS_3 19

VDD12_1 20

C1517

EXADR16 21

0.1u/10 A16

EXADT15 22 A15

EXADT14 23 A14

EXADT13 24 A13

MA10

220

25 A12

EXADT10

26 A11

EXADT12 27

EXADT11 28 A10

EXADT9

29 A9

NEXWE A8

EXADT8

30 A19

MA8

32

EXADR19

31 XWR1

VSS_4

33 C1518

VDD33_3

34 0.1u/10 A18

EXADT7 35 A17

EXADR18

36

EXADR17

37 A7

EXADT6

38 A6

EXADT3 A5

EXADT5

39 A4

EXADT4

40 A3

EXADT2 41 A2

BA1

R1401

D0

43

VSS_5

44

EXADT1 42 A1 C1253 0.1u/16

NM

A20 45 0.1u/10 C1519

R1547 A20

6

C1252 CCG1222-A

AVH-X1600DVD/XNUC

4.7u (2125) C1251

46

I2C_SDA

47

IRQPWR 48

5

6

100u/16

5 8

C-a

145

A

B

C

D

E

F

1

2

3

4

10.9 SERVICE UNIT (MONITOR) (GUIDE PAGE)

STV1

Vcom

Vcom 1

NC

NC

2

5

3

VDDG+18V 6

4

VEEG-6V

NC 7

NC

8

POL

XON(Hi)

9

GND

10

12

11

OEV(Low)

GND 13

UD(Low)

VCLK

16

14

STV2

15

GND

GND

17

GND 20

18

3.3V DIO2 21

19

33.3MHz HCLK

DVDD 22

9.2V GND

AVDD 26

GND

AVDD 27

24

L/R (Hi) 28

25

R4

LOAD

R3 32

29

R2 33

R5

R1 34

30

R0 35

31

G3

G5 36

G2

G4

39

37

G1 40

TFT LCD

38

B5

G0 41

B3

B4 43

42

44

B0

B2 45

VR10

B1

48

46

VR9

47

VR7

VR8

49

VR6 52

50

53

51

VR3

VR4

VR5

54

NC

VR2

55

56

DIO1

VR1 57

GND

59

58

60

D-a CN5001

23

A

CKS6536-A

TO LCD

R5028 47k

R5026

LCDGND

POL

VCLK

STV

47k

B

OEV

HCLK

R5024

LOAD

R5

R4

R3

R2

R1

R0

G5

G4

G3

G1

G2

G0

B4

B3

B5

B2

B1

B0

DIO

47k

47k

R5029

C5021 C5028 1000p/50 C5022 R5003

R5005

R5007

R5009

R5011

R5013

R5015

R5017

R5019

R5021

180 D%

47 D%

39 D%

100 D%

130 D%

100 D%

39 D%

47 D%

180 D%

33 D%

C5034 0.1u/16

1000p/50

0.1u/16

C5038

NM

C5033

NM C5029

NM C5023

C5035

C5030

10u/10V

1000p/50 C5026

C5040 0.33u/50

C5036 NM

C5032

C5037 2.2u/16

BTX1042-A

C5031 CCG1192-A-T

NM

2125 C5124

D5103

0.1u/10 3216 10u/35

CCG1236-A 3216

L5004

C5025

DTL1096-A

C5024 NM

2.4

L5003

R5022

L5002 DTL1096-A

NM C5018

NM C5017

NM C5016

NM C5015

2.2

L5001 CTF1635-A

R5020

0

NM

R5018

NM C5020

4.7

NM C5019

R5016

8.2

NM C5014

C5011

0.1u/16

R5014

1000p/50 C5012

0

1000p/50 C5010

NM

R5012

0.1u/16 C5013

8.2

C5009

R5010

4.7

NM C5007

NM C5005

NM C5004

NM C5002

R5008

0

NM C5008

R5006

2.2

NM C5003

C5001

NM

R5139

2125 C5119 NM

R5004

56 D%

4.7

NM C5006

R5002

R5001

10k Q5106 2SA1577(QR)

C5042 0.1u/16

0.1u/50 4.7u/16V

R5108

NM C5039

C5041 NM

C5027 NM

3216

DB3S308F0

LCDGND

-6V VM6 18V V18

R5023

100k D% C5140 9.1k D%

560p/50

R5142 R5143

91k D%

R5140

NM

C5122

CPGND

4.7k

0 120k D%

R5136 C5113

470p/50

R5134 R5135

3k D%

10u/35

NM

10u/35 C5112

R5113

NM

19

R5116

LCD POWER BLOCK COMDC

0

R5129

Q5104 NM

M2R6TP_GND

1

1

NM

R5105

GND R5112

100

LCDGND

1 R5114

0

R5128 NM

M2R6TP_GND

R5127

KN5001 KN5003

D

10u/35

C5115

6.8k

Q5103 LSAR523UB

M2R6TP_GND

C5114

KN5004

NM

0.1u/16

15k D%

R5117

C5110

1200p/50

100p/50

15k D% C5109

15k D% R5111

1u/10

R5109

C5106

100k R5104

C5104

0.012u/16 C5105

0.1u/10

1u/6.3

C5103

0

4.7k

GND

R5126

R5122

NM C5129

Q5101 LTC014EEB

R5125

R5121

20k

NM

L5102 LCTAW101J2520-T

R5103

1M

6800p/25 R5123

C5107

4.7k

R5124

R5106

R5110

NM

R5102

CPPGND

CPPGND

13 12

24

LX2 23 LX1 CPPSW 22 CPP CPVCC 21 CPN 20 EP 25

VFB SS 9 TST DTC 10 DELAY AMPOUT 11

6

7

C5102

1000p/50

2125 C5101

CCG1201-A 4.7u 10V

NM

18

17 CPGND CPPFB 16 CPPDLY CPNFB 15 CPNDLY RT 14

8

2 PGND1 3 PGND2 AGND 4 VIN VREF 5 CE

10k

R5101

0

L5103

C5108

0

22uH

R5144

D5101 RB162M-40

R5107

L5101 CTH1426-A IC5101 R1290K103A UVLO : 2.8V 1

C5111

0.1u/50

8.2k D%

CPGND

R5141

D5105 DB3S308F0

18k D%

C5123

1608

9.2V

1u/10

C

NM

DB3S308F0

C5051

2125 C5121

LCDGND

9.2V V92

2125 C5125 0.47u/25

D5104

1u/25

4.7u/16 3216

C5126 NM

1u/25

C5127

0.47u/25

2125 C5120

NM

R5115 BLGND

C5131

GND

NM

NM

3.3V GND

CPPGND LCD33

GND R5130

IC5201

BLGND

10 11 12 13 14

R5210

NM NM

R5209

NM

R5208

NM

10

9

8

K2

K3 7

6

K1 5

4

2

3

IC5102 MM3479A33P VTL1134-A

4

3

2 SDA

GND 1

7

8

NM NM

DIM

LPSNC

BLSYNC

R5321 NM

LPSYNC LCDGND

D AVH-X1600DVD/XNUC 4

R5315 NM

R5313 NM

BLEN BLERR DIMMER

NM

BLEN

R5314 NM

BLDGND

3

L5303

5 RST

NM

C5313 NM

PGND

2

SCL

NM

D5303

D5304

BLER

1

4.7u

NC 10 NC

NM

C5311

BLSYNC

146

C5116 CCG1201-A

NC

K2 6

9

K1 5

K3

NC 4 NC

K4

Anode 3 Anode

8

Anode 2 Anode

7

Anode

K4 NC

D5302

BLGND R5211

NM

NM

R5317

F

R5319 NM

C5310

100

NM

1

NM

D5301

C5312

R5207

R5215

CN5302

INT

0 BLDGND KEYGND

6

OUTH SYNC M2R6TP_GND 23 SHDETEN SW 22 GND 29VDISC R5224 21 PAD NM DGND PWM L5205 20 BLDGND OUTL FAIL1 VTL1128-A 19 PGND FAIL2 PGND R5206 18 R5205 LEDEN1 ISET D 100k 17 D150k BLGND LEDEN2 OVP 16 LED1 LED4 15 LED2 LED3 BD81A04EFV-M

BLGND

1

R5223

5

KN5002

BLGND

4

9

C5212

TEMPSENS

2.2u/10

24

NM

100k

R5219

8

150k

R5220

BLGND

XR

C5203

VREG

25

6

26

R5213

7 VREG

100p/50

27

VCC

BOOT

GND 7

6

RT

1

476.6/514.8kHz

CS EN VREG

GND 8

5

SS

3

27k

VCC

COMP

2

4

YB

YT

1

3

510

XL

KEYGND

C5309

2 R5203

NM

R5212

BLGND

R5202

CKS654

TOUCH PANEL

C5209 0.1u/10

D 360k

BLGND

0.1u/10

CN53

TH5201 CCX1058-A

D 24k

C5214 0.1u/16

NM

3216 C5201

C5204 C5206 0.1u/10

C5211

28

1

NM

NM

R5214

CCG1236-A 3216 10u/35

NM BLDGND

10u/35

3216 C5207

CKS6523-A NM 3216 C5208

R5221

CCG1236-A

R5225 2.2 2125

C5215 3300p/50

NM

C5205

3216 C5202

CN5202

D5201 RB060M-30

NM NM

DUMMY R5217 DUMMY R5218

NM

C5210

0.1u/16

C5213 NM

L5201

CCG1236-A 10u/35 3216

L5202 CTH1526-A 6.8u

NM

R5216

Anode

0 1608 R5222

L5204 NM NM 1608

R5201

BACK LIGHT L5203

E

C5130

NM

R5316 NM

723/1000kHz

ILMB

CN5201

10V

NM

TFT LCD (BACKLIGHT)

5

6

7

8

A

1

Vcom

D-b TO LCD

D

SERVICE UNIT(MONITOR)

5001 - : LCD 5101 - : LCD POWER 5201 - : BACK LIGHT 5301 - : TOUCH PANEL 5401 - : IN/OUT

LCDGND

CN5401 CKS6536-A COMDC

IC5001 NM NM

NM R5036

R5027

NM

NM R5037

11

OEV

R5030

NM

NM R5038

12

R5031

NM

NM R5039

13

HCLK

R5032

NM

NM R5040

14

LOAD

R5033

NM

NM R5041

15

R5

R5034

NM

NM R5042

16

R4

R5035

NM

NM R5043

17

STV C5042 0.1u/16

Y8 Y7

18 R5078 NM

NM

NM

C5043

19 C5044

LCD33

A8

Y6

A7

Y5

A6

Y4

A5

Y3

A4

Y2

A3

Y1

A2

OE2

A1

VCC

20

LPOL

GND

OE1

LVCLK 10

R5416

9

R5417

8

0 0

R5418

7

R5419

6

R5420

5

R5421

4

R5422

3

R5423

0 0 27 0 27

LPOL

LOEV

LVCLK

LSTV

LOEV LSTV

LD

1

LCDGND

LD

LR5

LR5

LR4

LR4

27

2

LHCLK

LHCLK

LR3 LR2

NM

R5025

VCLK

C5420

POL

LR1 LR0

LCDGND

IC5002 NM

R3

R5044

NM

NM R5052

R2

R5045

NM

NM R5053

11

R1

R5046

NM

NM R5054

12

R0

R5047

NM

NM R5055

13

G5

R5048

NM

NM R5056

14

G4

R5049

NM

NM R5057

15

G3

R5050

NM

NM R5058

16

G2

R5051

NM

NM R5059

17

R5023 R5079 NM

NM

C5046

C5045

A8 A7

Y5

A6

Y4

A5

Y3

A4 A3

Y1

19

NM

NM

C5051

LCD33

GND

20

A2

OE2

A1

VCC

OE1

LG3 10

R5424

9

R5425

8

R5426

7

R5427

6

R5428

5

R5429

4

R5430

3

27 27 27 27 27 27 27

R5431

LR3

LG2

LR2

LG1

LR1

LG0

LR0

LB5

LG5

LB4

LG4

LB3

LG3

LB2

LG2

LB1

27

2

COMDC

59

POL

58

VCLK

57

OEV STV2

55

LCDGND

54

HCLK

53

LCDGND

52

LD

51

R5

50

R4

49

R3

48

R2

47

R1

46

R0

45

G5

44

G4

43

G3

42

G2

41

G1

40

G0

39

B5

38

B4

37

B3

36

B2

35

LB0

1 LDIO

B

56

B1

34

B0

33

LCDGND

32

DIO

31

LCDGND

CPGND LCDGND

R5061

NM

B5

R5062

NM

B4

R5063

NM

B3

R5064

NM

G0

NM R5069

11

NM R5070

12

NM R5071

13

NM R5072

14

R5065

NM

NM R5073

15

B1

R5066

NM

NM R5074

16

B0

R5067

NM

NM R5075

17

B2

R5080 NM

NM

NM

C5048

C5047

LCD33

19 20

30

LPSYNC

Y8

GND

Y7

A8

Y6

A7

Y5

A6

Y4

A5

Y3

A4

Y2

A3

Y1

18

LCDGND

LCDPW

IC5003 NM NM R5068

NM

R5060

G1

A2

OE2

A1

VCC

OE1

V18HIOUT 10

R5432

9

R5433

8

R5434

7

R5435

6

R5436

5

R5437

4

R5438

3

R5439

PWRVI

LG1 27 27 27 27 27 27 27

LB5

TEMPSENS

LB4

PWM_G

LB3

PWM_R

LB2

PWM_B

LB1

KDT1

LB0

KDT0

27

2

REM LCDGND MTCH_SCL0

LCDGND

MTCH_SDA0 IC5004 NM R5076

DIO

TRIRQN

OUT

4

NM

GND IN

NM

C5050

NM

NM

LCD33

C5049

R5081 VCC

5

G

TPN33 R5440

3 2

C5401

LDIO

KEYGND

0.1u/10

0

1

TOUCHGND

BLSYNC BLEN

BLERR

LCDGND V18HIOUT

TEMPSENS

24

PWM_G

BLGND

C

PWM_R

22

PWM_B

21

KDT1

20

KDT0

19

RST

18

REMIN

17

LCDGND

16

MTCHCK

15

MTCHDA TPIRQN

13

KEYGND

12

TOUCHGND

11

TPN33

10

BLSYNC BLEN

8

DIMMER

7

BLERR

6

BLGND

5

ILMB

3.3V

PWRVI

25

9

DIMMER

LCDGND

26

14

R5077

NM

V18HI

23

RESET

1

LPSYNC

28 27

LCDGND

LG0

LCDPW

29

A 5/6 CN1751

NM

LG4

Y7

Y2

18

LCDGND

Y8

Y6

LG5

60

D

BLGND

4

BLGND

3

ILMB

2

ILMB

1

ILMB

PWRVI

LCD33

COMDC

LCD33

R5132 R5130

D5132 CRG03

NM

0.1u/10

C5118

KDT1

KEYGND RESET

8-A

3

KDT0

LEDB

LEDG

8

LEDB

9

TPN33

10k

10k

(BLUE) R5409 68

(GREEN)

KEYGND

R5410 56

R5405 68 R5406 56 R5407 NM

KDT1 LEDR

7

R5411 NM

R5401 68 R5402 56 R5403 NM

NM

R5404

ILMB

6

Q5402 LSCR523UB

R5415

NM

10k

R5414

R5408 NM

PWM_R

R5311 100

100

R5309

REM

11 KEYGND

F

KEYGND

MTCH_SCL0

100

KEYGND

2

10 RST

R5412

SDA

SCL

2

3

Q5401 HN1C01FU(YGR) 6 1 C1 E1 5 2 B1 B2 3 4 C2 E2

R5413

1

TVDD

PWM_G

TOUCHGND

TOUCHGND

MTCH_SDA0

TRIRQN

M

1

5 LEDR

LEDG

0.01u/16 C5308

0.01u/16

0.01u/16 C5306

0.01u/16 C5307

62

C5305

R5312

YN 14 VSS 15 TEST 16 CAD0

4.7k

4.7k

R5305

R5303

NM R5304

R5318

C5304

0.1u/10

C5302 CCG1192-A 10u 10V R5315 NM

R5316 NM

R5313 NM

R5314 NM

NM

R5317

TOUCHGND

E

0

R5310 180 11

R5308

620

10

12 YP

RYP

PWM_B

(RED)

21

RST

4

L5301 NM

NM

KDT0

9

NM

TOUCHGND

NM

TPN33

8

CN5403

RXP

9 R5307 4

NM NM

LEDB

7

11 KEYGND

17 EP

6 IN 5 NC

LEDG

6

0

R5306 C5303

0.1u/10

NM 10u 10V

C5314

NM

C5309

NM

0.1u/10

NM

NM

LEDR

10 REM

13

8 XN 7 VDD

PENIRQN

L5302 NM

R5319 NM

XP

TOUCHGND D5309

C5301 CCG1192-A

VTL1134-A

IC5301 AK4187VN NM

2 SDA

GND 1 8

7

L5303

3

4

5 RST

INT

SCL 6

4

3

5

6 VCC

GND 7

GND 8

M

2

1

2

TPN33

200

1

NM

YT

KEYGND

NM

2

NM R5302

3

XR

NM

YB

REM

D5306 D5307 D5308 D5305

4

R5301

0

XL

KDT1

4 5

KDT0

CKS6548-A

ILMB

3

CN4801

TO TOUCH PANEL

CN5301

KEYGND

2

E

NM

NM

NM

NM

1 LCDPW

D5401

R5131

LCDGND

TOUCH PANEL

CN5402 CKS6063-A

ILMB TPN33

C5130

D5402

0.1u/10

C5117

CCG1201-A 4.7u 10V

4

C5128

VOUT

VDD CS

CE

GND

3

2

1

4.7u

IC5102 MM3479A33P

C5116 CCG1201-A

10V

5

NM

T)

D AVH-X1600DVD/XNUC 5

6

7

8

147

AVH-X1600DVD/XNUC

4

NM

CPGND

NM

R5023

0.1u/16

C5042

LCDGND

R5065

R5066

R5067

B2

B1

B0

DIO

NM R5072

NM

R5064

B3

LCD33

LCD33

NM R5071

NM

R5063

B4

NM

R5076

NM R5075

NM R5074

NM

NM

R5077

LCDGND

LCDGND

R5081

NM

R5080

NM

NM

NM R5073

NM R5070

NM

R5062

B5

NM

12

NM R5069

NM

R5061

G0

5

4

20

19

18

17

16

15

14

13

11

NM R5068

NM

LCDGND

20

19

R5060

NM

R5079

18

17

G1

LCD33

NM R5059

NM

R5051

G2

16

NM R5057

NM

R5049

G4

NM R5058

15

NM R5056

NM

R5048

G5

NM

14

NM R5055

NM

R5047

R0

R5050

13

NM R5054

NM

R5046

R1

G3

12

NM R5053

NM

R5045

R2

11

NM R5052

NM

LCDGND

20

19

18

17

16

15

14

13

12

11

R5044

NM

R5078

NM

R3

LCD33

NM R5043

NM

R5035

R4

NM R5041

NM R5042

NM

NM

R5034

R5

R5033

NM R5040

NM

R5032

LOAD

NM R5039

NM

R5031

NM R5038

NM

R5030

OEV

STV

NM R5037

NM

R5027

VCLK

HCLK

NM R5036

NM

R5025

POL

C5043

C5045

C5047

C5051

NM

TO LCD

C5044

C5049

3 NM

D-b

NM NM

2 NM

1 C5046

E NM

148 A3 A2 A1 OE1

Y2 Y1 OE2 VCC

A2 A1 OE1

Y1 OE2 VCC

VCC

OUT

IC5004 NM

G

IN

GND

OE1

A1

OE2 VCC

A2

A3

A4

A5

A6

A7

A8

GND

Y1

Y2

Y3

Y4

Y5

Y6

Y7

Y8

A3

Y2

IC5003 NM

A4

A5

A6

A7

A8

GND

Y3

Y4

Y5

Y6

Y7

Y8

A4

Y3

IC5002 NM

A5

A6

A7

A8

GND

Y4

Y5

Y6

Y7

Y8

IC5001 NM

1

2

3

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

10

LCDGND

0

0

27

0

0

0

0

27

27

27

27

27

27

27

27

27

27

27

27

27

27

27

27

27

27

R5440

R5439

R5438

R5437

R5436

R5435

R5434

R5433

R5432

R5431

R5430

R5429

R5428

R5427

R5426

R5425

R5424

R5423

R5422

R5421

R5420

R5419

R5418

R5417

R5416

5001 - : LCD 5101 - : LCD POWER 5201 - : BACK LIGHT 5301 - : TOUCH PANEL 5401 - : IN/OUT

LDIO

LB0

LB1

LB2

LB3

LB4

LB5

LG0

LG1

LG2

LG3

LG4

LG5

LR0

LR1

LR2

LR3

LR4

LR5

LD

LHCLK

LSTV

LOEV

LVCLK

LPOL

BLERR

DIMMER

BLEN

BLSYNC

TRIRQN

MTCH_SDA0

MTCH_SCL0

LCDGND

REM

RESET

KDT0

KDT1

PWM_B

PWM_R

PWM_G

TEMPSENS

V18HIOUT

LPSYNC

LCDPW

LDIO

LB0

LB1

LB2

LB3

LB4

LB5

LG0

LG1

LG2

LG3

LG4

LG5

LR0

LR1

LR2

LR3

LR4

LR5

LD

LHCLK

LSTV

LOEV

LVCLK

LPOL

COMDC

D-a D-b

D

TPN33

0.1u/10

C5401

PWRVI

KEYGND TOUCHGND

LCDGND

LCDGND

LCDGND

SERVICE UNIT(MONITOR)

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

CN5401

BLERR

DIMMER

BLEN

BLSYNC

TPN33

TOUCHGND

KEYGND

TPIRQN

MTCHDA

MTCHCK

LCDGND

REMIN

RST

KDT0

KDT1

PWM_B

PWM_R

PWM_G

TEMPSENS

PWRVI

LCDGND

V18HI

LPSYNC

LCDPW

LCDGND

DIO

LCDGND

B0

B1

B2

B3

B4

B5

G0

G1

G2

G3

G4

G5

R0

R1

R2

R3

R4

R5

LD

LCDGND

HCLK

LCDGND

STV2

OEV

VCLK

POL

COMDC

CKS6536-A

A 5/6 CN1751

C5048

D 3

NM

B

NM

A

C5420

F 2

C5050

1 4

C

1

2

3

4

LCDGND

L5302 NM

TPN33

L5301 NM

NM

TOUCHGND D5309

TOUCHGND

TOUCHGND

NM

R5081

NM

PWRVI

5

4 VCC

OUT

6 IN 5 NC

8 XN 7 VDD 17 EP

14

13

VSS 15 TEST 16 CAD0

YN

G

IN

GND

TO TOUCH PANEL

CRG03

IC5301 AK4187VN

NM

LCDGND

D5132

R5131

NM

R5077

R5132

NM

R5076

R5312

IC5004 NM

1

2

3

0.01u/16 C5306

C5305

TOUCHGND

0.01u/16

0.01u/16 C5308

TOUCHGND

0

R5440

PWM_R

PWM_G

PWM_B

REM

RESET

KDT0

KDT1

BLERR

DIMMER

BLEN

BLSYNC

D-a D-b

LCDPW

COMDC

V18HIOUT

LDIO

TRIRQN

NM

MTCH_SDA0

MTCH_SCL0

D5401 NM

(RED)

10k

R5413

KEYGND

Q5401 HN1C01FU(YGR) 1 6 E1 C1 2 5 B1 B2 3 4 C2 E2

(GREEN)

10k

R5414

(BLUE)

10k

R5415

LEDB

KEYGND

Q5402 LSCR523UB

TPN33

TOUCHGND

TPN33

KEYGND

ILMB

BLGND

KEYGND

ILMB

0.1u/10

C5401

TPIRQN

14

ILMB ILMB

2 1

KDT0 RST

8 9

TPN33

8 9

11 KEYGND

10 RST

LEDG LEDB

7

KDT1 LEDR

ILMB 4

6

KDT0

3

5

REM

2

1 KEYGND

NM

CN5403

11 KEYGND

10 REM

LEDB

LEDG

TPN33

5

7

LEDR

4

6

ILMB KDT1 3

KEYGND 2

1

CN5402 CKS6063-A

BLGND

BLGND

5

ILMB

BLGND

6

3

BLERR

7

4

BLEN DIMMER

8

BLSYNC

10 9

TPN33

TOUCHGND

11

12

KEYGND

MTCHDA

15

13

MTCHCK

16

7

D-b

NM

R5319

YT

XR

YB

XL

CKS6548-A

NM

C5130

LCD33

CN5301

TOUCH PANEL

NM

R5130

GND 8

1

NM

4

VDD

5

VOUT

3.3V

LCD33

5

GND 7

2

GND

R5317

6

RST

VCC

3

R5314 NM

4

C5309

10V

4.7u

2

IC5102 MM3479A33P

L5303

C5116 CCG1201-A

4

INT

5

3

SDA

SCL

6

R5316 NM

GND 1

8

7

R5315 NM

GND

2

CS

3

CE

1

VTL1134-A

R5301

NM

10V

10u

D5306 D5307 D5308 D5305

0.1u/10

0.1u/10

LCD33

C5301 CCG1192-A

C5302 CCG1192-A 10u 10V

NM

C5314

C5128

NM

C5117

NM

C5303

0 620

CCG1201-A 4.7u 10V

NM R5302

C5304

200

R5303

C5118

C5049 4.7k

NM

R5313 NM

62

NM R5306 R5305 R5318

0.1u/10

0.1u/10

C5050

XP PENIRQN TRIRQN

0

DIO

NM R5304

NM 0.1u/10 R5308 10 RXP

9 R5307 4

TVDD 3 R5309 MTCH_SDA0

4.7k 100

R5310 180 11 RYP

12 YP SCL 1 R5311 100

SDA 2 100 MTCH_SCL0

NM LEDG

D5402

R5401 68 R5402 56 R5403 NM

LCDGND

R5404

LEDR R5405 68 R5406 56

7

R5407 NM

AVH-X1600DVD/XNUC

R5408 NM

6

NM

CN4801

R5409 68

5

E

R5410 56

6

R5411 NM

5 8

A

B

C

D

E

8

149

F

R5412

0.01u/16 C5307

NM

L5103

0

CPGND 1608

1u/10

C5122

1u/25

2125 C5121

1u/25

R5101

2125 C5120

C5102

R5144

2125 C5101 CCG1201-A 4.7u 10V

1000p/50

NM

NM

R5102

CPPGND 6

20k

R5103

0.1u/50

C5123

2125 C5125 0.47u/25

PGND1 3 PGND2 AGND 4 VIN VREF 5 CE

2

22uH

IC5101 R1290K103A UVLO : 2.8V 1

L5101

CTH1426-A

D5105 DB3S308F0

DB3S308F0

D5104

DB3S308F0

NM

2125 C5124

0.47u/25

24

LX2 23 LX1 CPPSW 22 CPP CPVCC 21 CPN

EP 25

D5103

R5139

20

4.7k

R5106

13

C5126 NM

19

18

17 CPGND CPPFB 16 CPPDLY CPNFB 15 CPNDLY RT 14

12

10k Q5106 2SA1577(QR)

11

C5107

R5140

18k D%

4.7u/16 3216

91k D%

R5002

56 D%

R5001

4.7

C5108

R5113

D5101 RB162M-40

9.1k D%

100k D% C5140

C5001 NM C5002

560p/50

DIO

18V V18

-6V VM6

9.2V V92

CPPGND

2.2

R5004

0

R5006

47 D%

R5005

4.7

R5008

39 D%

R5007

NM C5007

180 D%

NM C5003

10u/35

NM C5005 NM C5006

0

R5136

8.2

R5010

100 D%

NM

C5129

8.2

R5013

4.7k

R5122

0

R5018

47 D%

R5017

KN5004

NM

R5121

4.7

R5016

39 D%

R5015

LCD POWER BLOCK

R5014

R5012

0

100 D%

130 D%

R5011

B2 B3

2.2

R5020

180 D%

R5

LCDGND

2.4

R5022

33 D%

R5021

NM

LOAD

VR1

57

NC

58

DIO1

59

GND

60

VR6

52

VR5

53

VR4

54

VR3

55

VR2

56

VR9

49

VR8

50

VR7

51

B1

46

B0

47

VR10

48

G1

40

G0

41

B5

42

B4

43

B3

44

B2

45

G4

37

G3

38

G2

39

R0

35

G5

36

R3

32

R2

33

R1

34

LOAD

29

R5

30

R4

31

0

R5126

Q5104 NM

COMDC

NM

C5027

1000p/50 C5026

10u/35

CCG1236-A 3216

C5025

0.1u/16

C5024 NM

NM C5023

C5021

1000p/50 C5022

47k

R5024

GND

25

AVDD

26

AVDD

27

L/R (Hi)

28

DVDD

22

HCLK

23

GND

24

3216

3216

C5037

2.2u/16

NM

47k

47k

NM

C5036

4.7u/16V

C5035

C5033

C5034 0.1u/16

R5029

R5028

C5032

10u/10V

C5031 CCG1192-A-T

C5030

0.1u/10

1000p/50

NM C5029

C5028

L5102 LCTAW101J2520-T

GND

19

GND

20

DIO2

21

TFT LCD

R5019

R2 R3 R4

NM C5020

STV

POL

NM

47k

9.2V

33.3MHz 3.3V

VCLK

14

OEV(Low)

15

UD(Low)

16

STV2

17

GND

18

GND

12

GND

13

XON(Hi)

10

POL

11

NC

9

LCDGND

NM

C5041

C5040

0.1u/50

0.33u/50

NM

C5039

C5038

NC

3

STV1

4

NC

5

VDDG+18V

6

NC

7

VEEG-6V

8

Vcom

1

Vcom

2

2

CPGND

NM

R5023

C5042

0.1u/16

LCDGND

TO LCD

D-b

NM

D-a D-b

R5009

NM

R5003

10u/35 C5112

NM C5004

9.2V

R5134

R5135

CKS6536-A

R5142

R5143

8.2k D%

C5110

R5116

R5117

120k D%

C5113

NM C5008

B0 B1

C5011

B5 G0 G1 G2 G3 G4 G5 R0 R1

NM C5019

R5123 NM

R5125 6.8k

L5001 CTF1635-A

HCLK

L5002 DTL1096-A

OEV VCLK

L5003 DTL1096-A

R5026

L5004 BTX1042-A

C5051

CN5001

6800p/25

0

R5107

C5127 R5141

R5110

15k D% C5109

NM

NM

100p/50

C5111

1200p/50

3k D%

15k D%

4.7k

470p/50

C5009 1000p/50 C5010 0.1u/16

B4

1000p/50 C5012 0.1u/16 C5013 NM C5014 NM C5015 NM C5016 NM C5017

4

NM C5018

6 24 M Q5103 523UB

R5108

10k

7

.1u/10

100k 1u/10

R5109

2125 C5119

C5103 1u/6.3

C5104 0.012u/16 C5105

8 VFB SS 9 TST DTC 10 DELAY AMPOUT

4 06

4 15k D% R5111

3

AVH-X1600DVD/XNUC 9

2

C5115

1

10u/35

150

D-a F E D C B A

1

3

4

R5109 R5105

ILMB

NM

NM

R5216

R5215

BLGND

GND

1200p/50

BLGND

C5110

PGND

BLDGND

C5

0.1u/10

C5206

C5204

VREG

BLGND

NM

BOOT OUTH

RT

VREG

SYNC

COMP

CS EN

SS

23

24

25

26

27

28

GND

NM

VCC

7

BD81A04EFV-M

D-a D-b

BLGND

6

NM

R5115

L5203

IC5201

1 R5114

CPPGND

2.2u/10

C5203

L5202 CTH1526-A 6.8u

BLGND

D 100k

LCDGND

C5114

BLGND

VTL1128-A PGND R5206

NM L5205

R5224

KN5002 M2R6TP_GND

VREG

SHDETEN SW 22 GND 29VDISC 21 8 PAD DGND PWM 20 BLDGND 9 OUTL FAIL1 19 10 PGND FAIL2 18 R5205 11 LEDEN1 ISET 17 D150k 12 LEDEN2 OVP 16 13 LED4 LED1 14 15 LED2 LED3

5

4

510

27k

3

2

1

R5203

476.6/514.8kHz

R5202

0.1u/10

1

GND

0

1

M2R6TP_GND

KN5004

4.7k

R5123

C5104

NM

C5103

7

0.012u/16 C5105

8 V S 9 T D 10 D A 100k C5106

R5 R5117

BACK LIGHT

BLGND

R5112

GND

NM

M2R6TP_GND M2R6TP_GND

C5210

R5122

6.8k

NM NM

R5210 R5209 R5208

C5115

10u/35

NM

R5214

CKS6523-A

CN5202

NM

CN5201

100

R5128

Q5104 NM

NM NM

R5211

BLDGND KEYGND

0

R5223

BLDGND

NM

R5221

D5201 RB060M-30

0

R5126

0

R5110 15k D% R5111

BLGND

NM

C5131

NM 723/1000kHz

470 C5213

15k D%

GND

0.1u/16

KN5001 KN5003

NM

11

1u/10

R5104

0.1u/10

1u/6.3

100

R5102

12

Q5101 LTC014EEB

NM

C5129

C5205

NM 1M

R5124 R5225 2.2 2125

NM

R5127 10u/35

8.2k D% 15k D% C5109 0 R5201 L5201 3216 C5201

1608 R5222

100p/50 L5204 NM NM 1608 NM NM

C5214 0.1u/16

LPSNC

BLSYNC

DIM

BLER

BLEN

BLGND

Anode 1 Anode 1

R5121

NM C5211

L5102 LCTAW101J2520-T

LPSYNC

BLSYNC

DIMMER

BLERR

BLEN

TEMPSENS

NM

NM

NM

NM

NM

NM

LCDGND

NM

R5321

C5313 NM

D5304

C5312

D5303

C5311

D5302

C5310

NM

NM

D5301

CN5302

3.3V LCD33

KEYGND

C5209 0.1u/10

CCX1058-A

TH5201

TFT LCD (BACKLIGHT) NC 2 Anode 2

Anode

3 Anode 3

Anode

4 NC 4

20k

DUMMY R5217 DUMMY R5218

K1 5 K1 5

R5103

CCG1236-A 10u/35 3216

K3 6 K2 6

R5125 Q5103 LSAR523UB 3216 C5207

R5129 NM 3216 C5208 CCG1236-A

K2

7

COMDC

C5212 CCG1236-A 3216 10u/35

K4 8 K3 7

8

0.1u/16

C5215 3300p/50 100

3216 C5202 NM NM 1

100p/50 R5212 R5213

NC 9 K4 NC 9

C5107

D 360k D 24k

NC 10 NC 10

6800p/25

GND 8 1

4.7k

R5317

R5106

GND 7 NM

C TOUCH PANEL

NM

R5130

5 VCC 3

6

RST 4 NM

10V 4.7u 2 SDA SCL 6

CPPGND

100k 150k

R5219 R5220

7

R5207

D-b

6

R5313 NM

2 C5309

C5116 CCG1201-A 4 INT 5 R5314 NM

3

GND 1 8

6 7

5 R5316 NM

AVH-X1600DVD/XNUC

R5315 NM

5 7 8

D-a

8

151

A

B

C

D

E

F

CCG12 4.7u

C

2 C

1

2

3

4

10.10 SERVICE UNIT (KEYBOARD)

TPN33

A

3.3V

RST

D

C

CN5402

47

PNJ4833M

1 REM

REM 2

9

VCC 3

CCG1192-A 10u/10V

CKS6063-A KEYGND

GND 2

C4805

CN4801 11

1

NM

3.3V

10

IC4801 VO

C4804

R4801

ILMB

TPN33

B

3

8

KDT0

4

7

TPN33

5

6

LEDB

6

5

LEDG

7

4

LEDR

8

3

KDT1

9

2

ILMB

10

KEYGND

RESET KDT0 TPN33 LEDB1 LEDG1 LEDR1 KDT1

KEYGND 11

ILMB

1

D

8.0V

KEYGND D4801 1

6

2

5

3

4

SMLVN6RGB2UK(B)

E

C4801

NM

C4802

NM

C4803

NM

CH

F

E 152

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

SERVICE UNIT(KEYBOARD)

TPN33

E

3.3V

B

47

D C

R4801

4801

4833M

2

1 3

S4806

1

MUTE

RESET

VOL-

VOL+

CSG1155-A

4.7k

4

2

3

S4805 4

1

CSG1155-A

2

3

S4804 4

1

CSG1155-A

2

3

S4803

2.2k

EJECT

HOME

MODE

4

1

CSG1155-A

2 S4802

3

REVERSE

4

1

CSG1155-A

2

3

S4801 4

FORWARD

1.8k

1

12k

2

4.7k

R4807

3

2.2k

R4806

S4809

1.8k

R4805

C

4

R4804

CSG1155-A

R4803

1

R4802

2

R4808

x

HOME

MODE

3

REVERSE

S4808

FORWARD

x

4

x

x

CSG1155-A

KDT1

VOL-

4

VOL+

3

MUTE

3.0~3.3V

1

EJECT

2.4~3.0V

S4807

KDT0

1.8~2.4V

2

1.2~1.8V

CSG1155-A

0.5~1.2V

CSG1155-A

0.0~0.5V

D

KEYGND

KEYGND

E

CHIP SIZE LEGEND 1608 2125 3216

F

E AVH-X1600DVD/XNUC 5

6

7

8

153

1

2

3

4

10.11 WAVEFORMS - DVD Core Unit A

Note:1. The encircled number denote measuring points in the circuit diagram. 2. Reference voltage: 1.65 V(TD1,FD1)(=VHALF) 2.2 V(RF)(=VREF) In the waveform, it is seeing on the GND standard. Offset of 1.65 V or 2.2 V is put in.

1RF 0.2 V/div CDRF(x4CLV)

100 s/div

1RF 0.2 V/div DVDRF(x1.5CLV)

1RF 0.5 V/div DVDRF(BD1mm)

50 s/div

50 us/div

VREF1t

B

2TD1 0.5 V/div Interval FWD(DVD)

100 us/div

2TD1 0.5 V/div Interval REV(DVD)

2TD1 0.5 V/div Multi 32FWD(DVD)

100 us/div

500 us/div

C

VHALFt

VHALFt

VHALFt

2TD1 0.5 V/div Multi 32REV(DVD)

500 us/div

CH1 : 2TD1 0.5 V/div 10 ms/div CH2 : 3LECRGM-LECRGP 2.0 V/div 10 ms/div Traverse 1001FWD(short)(DVD)

CH1 : 2TD1 0.5 V/div 10 ms/div CH2 : 3LECRGM-LECRGP 2.0 V/div 10 ms/div Traverse 1001REV(short)(DVD)

D

VHALFt

VHALFt

VHALFt

GNDt

E

GNDt

CH1 : 2TD1 0.5 V/div 50 ms/div CH1 : 2TD1 0.5 V/div 50 ms/div CH2 : 3LECRGM-LECRGP 2.0 V/div 200 ms/div CH2 : 3LECRGM-LECRGP 2.0 V/div 50 ms/div CH2 : 3LECRGM-LECRGP 2.0 V/div 50 ms/div ID search Inside t Outside(DVD) Traverse 5001FWD(long)(DVD) Traverse 5001REV(long)(DVD)

VHALFt VHALFt

GNDt GNDt

GNDt

F

154

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

A

2TD1 0.5 V/div Play TD(DVD)

100 ms/div

VHALFt

4FD1 0.5 V/div Focus Close(DVD)

4FD1 0.5 V/div Play FD(DVD)

100 ms/div

500 us/div

VHALFt

VHALFt

B

4FD1 0.5 V/div Focus Jump L0tL1

500 us/div

4FD1 0.5 V/div 500 us/div Focus Jump L1tL0

C

VHALFt

VHALFt

D

E

F

AVH-X1600DVD/XNUC 5

6

7

8

155

1

2

3

4

11. PCB CONNECTION DIAGRAM 11.1 MOTHER PCB

A

PREOUT JA1631 7 3

C1611

C821

JA451

15

R1639 R1640

C1610

L821

100

C801

R863

R865

120

R683 R681 R699

1

20 35

R632 E R652 Q601

125

C601

R622

R655

R633 R654 R653 R651

R1402 R1406

R631

115

C606 R644

R637 R636

R630

110

R628

R

C1287

30 25 20 15 10 5 1

10

105

C884

R657 R649 R648 R646 C619 R701 C608 C620 C607 X601 R629 1

5

100

C883 C885

R666

95

CN401

D882

R662 R661 R660 R659

C602 R306

30

15

90

R697

D8

R647

85

R402

E

R R883

R638 C604

IC601

80

C613

Q881

R702

75

R688

1

40

C621

R1765 R664 R703 R663

R672 R674

R872 R677 R678

C614 R667

R871

C1801

R619

C566

R669

L517

D881

L601

X501

R676 R675

R533

R535

R534

R532 R531 R867 R501 L514

R536

R538

C571

C882

C615

C569

C573

TESTIN

C574

C881

Q871 1

C564 1

R673

55 50 45

R540

C1374

60

C561 C562

C559

C565

C568 R541 L516 C570 L515 C567

40

R881

L513

C518

C527

C526

C514

L506

C556

70

D

C1804

R521 C557 R519

65

R407 R405 R406

1

C517

R693 R689 R695

60

L801

D502

R861

C554

35

L511

C546

Q854

L512

L503 C525

C511 L504 C528 C522 C515

IC501

C555

C549 C548

R528

C553 R539

C544 C547

R529

10

C543 L510

1

50

1

R864

C558

L518 R537

R527

C550

R530

C521

30

70

2

3

L501 C516

C519

25

C545 R456

C523

R523

C538 R526 C542

5

L509

R404

4

5

C513

L502 C510

20

C539

C529

C540 C531

C530 R525 C541

80

6

7

C509

L519

R520 C524

R524

C453 C462

L451

C

R522 L508

D451

L507

JA452

D501

L505

C560 C563

C454

P451

D452 C455

C512

D503 C520

VA451

1

U401

8

9

1

R452

90

10

11

C862

D853

60

1

12

13

C861

1

1 D821

R821

55

CEK1381 CEK1382 CEK1380 CEK1385 CEK1383

15

Fuse 1 A Fuse 1.25 A Fuse 0.75 A Fuse 2.5 A Fuse 1.5 A

10

(A,45,37) (A,145,38) (A,23,20) (A,46,25) (A,49,27)

5

P 1951 P 2071 P 2081 P 2151 P 2152

1

> > > > >

14

C860

R1632

16

L852

R1644

R1634

Q1632 1

R1638

R1647

1 Q1631

JA801

C1609

R1635 R1633

SIDE B

C1608

1 R1646 R1645

C1637

FM/AM ANTENNA

C1638

Q1633

POWER SUPPLY

1

R1641

C1612

110

B

Chip Part

5 2

SIDE A

P.C.Board

4

R866

6

C1607

120

8

50

Capacitor

Connector

MOTHER PCB

45

1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams

40

NOTE FOR PCB DIAGRAMS

35

A

C R1053

R401

P1951

CN601 1 5 10

25

1

CN1751

40

30

E

1

5

10

15

20

25

30

35

40

45

50

R403

CN5401

1 P2081

20

P2152 C2151 D1904

P2151

P1911 C2131 C2132

C2081

C2083

CN751 1

5

10

15

20

25

C2082

10

C

P2131

R2131

D

CN1952

Y

F

0

X

A 156

10

20

30

40

50

60

AVH-X1600DVD/XNUC 1

2

3

4

70

30

5

6

7

8

A

SIDE A

B

CN3601

RCA V IN OUT JA1621 3 4

JA1601

6

2

R1602

D1953

D1601

D1602

IC1732 R1703 Q1701 C1739 1 R1702 C1725

R2162 R2161 R2170 R2163

C1982

1

1

C2163

1

C1738 P1621 1

R1728

R1723

C801

R1743

R1736 R1740

3

IC1721

C311

R2171

R1730

R1731

E

D2101

Q1721

L2101 1

C1722

L1851

C2101

R1865 R1851

C1851 Q1851

IC751

C1852

1 Q1951

C756

5

C1339

1 10

Q1952

R1324

R1252

1 C1974 1

R1258

R1356 R1347

R1429 R1428

C1976

C1960 C1959 C1980 C1981 C1399

L2071

C1313 L1305 R1317

C2071

L1313 C1312 C1311 L1312 R1314 C1310 R1346 L1311

R1686 R1687

R1688 R1671 R1677 R1689

C1958 C1957 C1672

R1673 R1676 R1675

5

10

1

CN1671

U1671

15

E

20

R1690 C1682

R1430

5

1

R1692

R1693

R1694

R1691 C1690 R1697

R1695

C1683

R1685

C1687

C1684

1

R1423

L1671 C1671

C1674

IC1671 10 C1676

R1684

P2051

JA1661

C1686

C1832 R1831 C1833 C1831

R1836

R1672

P2071

C1681 C1680

L1317 C1316 L1315

C1315 R1418 C1314

C1673

R1319

C2051 1

1

C1978

C1317

P1831 R1832

C1961

R1683

L1318 R1341 L1319

C1319 L1316 C1318

R1359

L1672

Q1831

D

R1679 R1678

C1322

L1952 1

R1259

L1322 R1320 R1257 R1322

55

60

C1323 R1321

L1951

R1251

50 45 40 35 30 25 20 15 10

D1952

C1308

C1307

C1306

C1305

L1323

R1424

R1384

D1951

C1335

R1323

R1334

1

30

R1375 R1374 R1304 C1304 R1306 R1305

R1373

R1377 R1368

C1302

R1421 C1303

R1419

R1337

C1973

C1340 R1383

R1328

1

C1333

R1338

X1302 R1391

C1332

C1327

R1325

C1326

R1403

C1330

C1384

R1332

R1331 C1337 R1401 R1326 C1336 R1431

IC1302

R1302

C292

1

R1339 X13011 R1434 R1433 R1407 R1405 R1432

C291

D102

R107

R1762 R1763

R893

1

R1712

R1376 R1426

5

D101

195 200 205 210 215 220 225 230 235 240 245 250 255

R1365

C1382 25

R1381 C1378 R1378 R1425

60

L1378

55

10

C1685

R1342 C1390

C1365

C1381

50

15

C1338

R1411 C1324 C1325

R1389

C1369

C1372

C1373

C1374

C1364 C1363 C1367 C1362 C1366

45

C1360 R1393

40

R1866

R1862

R1386

C

20

5

L1391

L1393 R1392 L1394 R1395 L1397 R1396 L1399 R1398 L1401 R1400 L1403 C1371 L1405 R1404 L1407 C1370 R1053 L1409 R1408 L1411 C1368 R1410 L1413 R1412 L1415 R1414 L1306 R1416 C1383 R1427 R1379 C1703 L1377

1751

20

R1351

L1387

C1353

C1375

R1388

R1348

R1402 R1406

L1390

C1376

R652 Q601

R1385

1

X1303

C1351

R1380

R1350

C1287 R1288

R1284 R1282 R1281 L1384

C1377

E

R631

R1382

C1380

C1379

R655 R632

L1381

L1383

25

R750

130 135 140 145 150 155 160 165 170 175 180 185 190

R1286

R1435

30

P1622 1

100 105 110 115 120 125

R1287 R1285

CN1281 10 1 5

C606 R644

35

E Q882 R1340 R1409

35

R896

1

C887

R1283

R648 R646 C619 R701 C608 C620 C607 X601 R629 1

R633 R654 R653 R651

R895

D882

D881

R885

R889 C886 R891

IC881

C1301

C884

C883 C885

R888 R882

R657 R649

R637 R636

R1860 R1859 R1858

R1863 C1861

R881

R886

R1352 1

R647

R630

5

40

P1701

1

95

D883

R892

R890

45 R1764

90

R887

50

Q1852

85

Q881

C1854

C1979

C2109

CN1701

R1852 R1853

Q1853 R1902 R1901 R1868 1 R1854 R894

Q1855

R884

30

C1859 1 C1853

C1858

1

C2152

80

E

C882

R1857

Q1856

C2102

C1855 C1856

75

IC1851 5

C881

C1857

1

70

R1861

D1851

E

Q1854 D1852

65

C1804

R883

1

R1729

D1853

C1860

R662 R661 R660 R659

L2161

R2179 1

CN1831

P2052

1

R1724 R1725

R1864

R1727

R1722 R1721

5

R1823

R1822

02

C2186

1 C1601 L1601

5 R1824

E

B C2172

C2185

L1953 1

R1701

D1721

1

C1821

C1737

C1733

C1822

R1732

1

1 Q1731

IC1821

IC1731

C1735

C1724 R1726 C1723

R260

C306

4

R1742

D303

R1734

R305

5

C1731

C349 R262

R1737

R258

R256

R1739

C343

C344

C341

C305

D304

R1821

Q331 R331

R257

C342 1

R259

R332 R333

R261

1

R263

2

C353

4 3

C350

6

R1738 R1735

25 C347 C346 C348

C351 C345 C340

5

8

20 IC341

R1744 C1721 C1732 R1733

10 1

C1734

PPLY

USB

7

5

2

R1601

1

R2051 C1675

1 1

F

FRONT 70

80

90

100

110

120

130

140

AVH-X1600DVD/XNUC 5

6

7

150

160

170

8

A 157

1

A

A

2

3

4

MOTHER PCB

1

R2166 R2167 R2168

C2166 R2164 C2165

C251

R301

15

15

20

60 55 50

10 5 1

10

R1072 C2032 R1060 R1061

15

IC20

C1341 51

5

C1074

C2021

4

IC2021

C2022

R R2024

R2022 R2023 R2021

D1661

1

C1056 C1051

R1062 R1063 R1064

R1065

IC1301

40

R1067

R1068 R1066

C2023

R1349

C2011

Q1662 C1661

C1605

D1663

C1603

C1606

D1603

C1689 C1688

C1052

35 R1069

R2011 R2012

R1664

C2012

R1084 C1082

C1069

1

R2013

E

1

L1004

30

1 C2052

IC1051

25

IC2051

L1007

20

C1343 C1342

C1357

R1394 R1399

5

IC2011 5

Q1661

R1662 1 IC2061

C1387

C1389

1

R1010

R1081

R1308

C1066 C1068

R1335 R1316 R1313 R1315 R1311

C1602

C1604

D1662

D2051

R1082 C1078

C1061

R1345

C1355 L1303

R1089

R1090

R1091

R1070

R1309

Q1663

C1679 R2052

R1013

L1001

E Q1001

R1397

D2052

C1015

R1012

R1681

R1680

C1678

R1312

E Q1201

C1003

Q1003 Q1002 C1079

1

R1104 R1105

C1002 E

R1301

C2062

C1014

C1012

L1006

1

C1361 R1310

R1103

R1307

R1696

C1013

C1011

C1010

25

C1347 C1346 R1054 R1057 C1345 C1344

L1201 1

C1397 R1101 R1102 1 1

5

R304

20

C1349 C1348

IC1202

15 C1104

C10

C1080 C1352 C1081 C1053 C1350 C1086 C1059

C1152 1

10 C1103

5

5 C1102

R1436

C1354

C1151

R1303 C1309 R1206 R1203 R1201 5 C1396 1 C1202 C1201 R1202 R1390

IC1101

1

R1422

IC1151

L1301

C1101

C1677

C1328

R2003

R1682

C282

30

C1105

R1674

C2061

1 R1111

R1205 R1209

IC2001

R1336 C1154

IC10 1

C1007

E

C1155 R1151 10

35

40

C1329 C1331

R1110

C1001

C1153

C1156

R1152 R1318

1

R1113 R1112

L1304

C2003

1

C2002

5

C1005

C1157

L1151

R1387

L1101

C2001

E

L1107

C1358

C1108

45

R1329 R1330

C1321 C1359 C1320 C1107

50

C1393

C1106

C1356

1

C1392

R1327 L1302 C1334

R1109 1

R1106

C1386

IC1002

1

R1011

R1355 R1358 R1354 R1357 R1353 R1344

C1398 C1395

C1388 R2002

R264 C286

C114 C113

R116 R113

R112

R1360

R1108 1

IC1001 L1005

C1391 C1394

15

R2001

E

IC1741

C1006

R1254 C1252

L1251

R1261 C1251

10

Q1902

R1333

IC1251 R1262

C285

C129

R114 R117

R115

C1971 R1963 C1966 R1957

R1961

1

C270

R1907

R1260 5

Q1903 E

R1704

C1385

R108 C134

R1953 C1951 R1954 R1955

C269

45

C137 C128

C132

C135

R1966

C1955 R1964 R1967 C1956 R1965

C136

R119

R1969 R1952

15

10

R1958 R1960

R1968

C1972

R1951

40

C119

R120

C1952 R1956

C138

C1953

IC1951

C120

R121

C133

C1954

35

20

5

C1969

IC101

C121

1 C1970

30

1

C271

C123 C122

C1964

C272

R109

R1962

C1962

C268

C124

25

R1959

C125

R1911

R1909

R118 R104 51 C109 C130 C1736 C131 R111 C108 C107 R102 C106 1 C105 C104 C103 C102 1 C101 R101

C126 1

C1968

D1903

C275

C140

C1967

P1902 P1901

R1906

R105

C117

D302

Q1901 E

C1906

C110 C116

C301

R1910 C1907

R122

C127

R110

C1963

C115

C118

C1965

45

C112 C111

R103

C

C139

C273

R255 C276

R106

C1977

D

C274

P1952

40

C321

R312

C1903 R265

C283

35

R2105

C1975

C280

30

C2106

C2104 R2103 R2102

R253

C284

D312

R303

C277 C2108

E C278

C252 C281

5

C279

IC251

25

C267

C266

C2107

C256

1

C287

IC2101

R324

1 R321 R322 R311 Q321 Q311 D301 1 R302 R323 Q301

C253

20

C262

C288

R2104 R2101 C2103

C257

C264

C263

C258

C289

C259

C265

C261

C2162

C2175 C2105

C260

R2175

R201

C290

1

C2161

10

5

20

R251 C201 C203 R202

D2162

D2161

L2162

D311 1

R1622

R2174 R2173

C1622

P1623

R1621

C2173 R2172

C254

R1623

C255

IC2161

D1621

D1622

5

10

15

R2176 C2167

C1623

D1623 C1624

D1624

R2169 C2169

5

C1621 C2170

1

R2178

C2168

R2177

R2165

B

1

C2164

R1663

1

F

170

A 158

160

150

140

130

120

110

100

AVH-X1600DVD/XNUC 1

2

3

4

90

8

5

6

7

8

A

SIDE B

D802

D801 C307 C308 C352

120 1

R1648

R1642 R1649 R1636 R1650 R1643

R1637

R1631

1

D311 1

R324

B

C1636

R879 R876 R877

D872

C1634

P1902

R834

Q872 E

C1632

R878

R312

D302

D871

D873

C1633

C301

C871

R323

R301

D312

R302

R875

D301

C1631

R322 R874 R873

1 Q311 1

C1635

1 R321 Q321

110

P1631

C321

R880

100 R457

P1901

1

3 R1911

Q1903

90

1906 E

C458

D1801

C1802

IC1801 1

Q1902

R455

R454

C461 C456

C1803

R842 C842

1

5

10

15

50

R608

R609

R610

L401

L1901

C1911

C401

R606

R607

D1921

D1902

R410

R605

C618

C1922

D1901

C404

R604

C405

L402

C402

R684 R602

R603

50

1

5

R698 R682 R686 R685

R613 R616 R614 R615

R601

D

IC1921

40

C1923 C1912 5

D1782 C1707

IC1911

1

IC1922

D1911 1 C1924

C1706

R1083

R1077

R1076

C1702 R1781 C1701

C1072

C1076

R1782 5

R408

R409

R1713

R620 R611

60

R1904 R1905

R690 C690 R705

R700

R679

R694

C616

C617

D1781

C1071

R1718

R617 R618

C603

C1921

Q1712

1

R1717

R707

R612

R627 C605 R634

55

C832

D601

R656

R1714

D602

R692

IC1901

1

D604

C1075

R1256 R1253

51

R1075

1 X1051

R1903

30

E

C757 C758 C1705

1 C2031 R2031 IC2021 R2024

C2022

R642

R1056

IC2031

1341

R623

R635

R1055 R1074

R1059 C1070

C1073

C1704

C1062

C1067

R1058 C1085 L1051

R1072 C2032 R1060 R1061

C2023 C2021

R1073

R625 R687

R1052

R1071 C1074

R1062 R1063 R1064

R1065

45

C1060

30 40

60

R1715

CLKOUT

R624 R626

C1063 C1064 C1065

25 R1067

R1068 R1066

C1058

20 35 R1069

C1057

C1056 C1051

Q1051

IC1051

C1069 070

E

C1904

C1902

R1716

C610

R1051

C1052

C1068

R1086

R1080 R1087

R1089 R1088

C457

R691 5

R1079 C1077

C1055

L831 R833

L1052

R1084 C1082

R1081

R1082 C1078

C1079 C1066

R1078

Q1004 R1085 C1083

Q1001

C1061

R650

5

C1901

TESTIN1

70

IC1931

L1902

R451

R704

R621 R645 C612

R658

Q1003 Q1002

R868

R680

C611 C609

1 D603

C1084

C1054

R802

C1004

C1003

R1090

R832

L1009

R665 R706

L1003

E

R1091

C1752 51 R668 IC1751 C1751

IC602

E

C1080 C1352 C1081 C1053 C1350 C1086 C1059

R831

C1009

E

E

C841 R841

D841

C1018

L1002

L1004

C1002

R1009 L1008

R1010

L1001

L1007

L1006

C1001

1 R1751

Q1711

1

C1008

C1007

C1905

R801

E Q801

1

IC1003 IC1004

80

C1805

D831

E

E

C

C831

Q831

R1711

1

R1012

011

C1017

R1013

1

C1005

C1016

C1015

IC1002

1

6

C1014

C1012

C1013

C1011

C1010

IC1001

Q841

C459

C406

C460

C403

L403

E

R751 R754

Q751

R2022

D1922

C2134

1 Q752 1

R753 R752

C753

C752

D2131 R2132

C2133 Q2132 E

D2132

R759

R758

R757

R2023 R2021

C754

R1653 1

Q2131

C755

20

C1651

R2133 R1652 R1651

1

C751

C1652

5

10

CN1651

E

10

Y 90

80

70

60

50

40

30

20

AVH-X1600DVD/XNUC 5

6

10

7

X

F

0

A 8

159

160

1

2

X

10

20

30

E

40

50

60

80

90

20

25

100

110

120

130

JA3691

1

2

15

D3663

R3669

C3606

NAVI/DTV INTERFACE

10

C3722

D3661

C3723

C3726

3

5

R3666

C3725

CN3661

1

D3670

D3669 D3671

70

2

D3666

D3667

R3679 D3668

3

Y

3

1

4

C3744

R3680 R3681

D3662

R3665

140

1

2

3

JA3731

R3711 R3707

R3713 R3706

150

WIRED REMOTE

4

160

5 8

1

6 10

2 9

A

170

7

3

JA3701

C3702

2

10

1

2

JA3641

AUX

C

JA3621

D C3661

R3682

C3743 C3724 R3668 D3664

20

F

BACK CAMERA

5

1 IC3661

B

30

0

B

40

BZ3631

B

50

1 3 4

11.2 INTERFACE PCB INTERFACE PCB SIDE A

D3705 D3706

R3741 C3742

AVH-X1600DVD/XNUC

4

KN3602 D3704 R3712

1

160

R3709

R3710 R3703

R3705

R3701

150

1

C3732

140

D3732

B D3731 C3731

R3731 R3732

R3693 VA3692

1

50 45

40

C3691 R3692 VA3691 R3694

130

35

CN1701 25

120

C3605

C3604

C3603

C3602

C3601

C3692

R3691

30

15

R3687

20

CN3601

A 10

5

1 R3661 1

D3672

C3741

100

D3665

D3673 C3721

C R3685 R3686 R3674 R3676 R3675 R3683 R3684 R3677 R3678

110

90

R3643

D3641

R3641 R3646 D3643 R3648 C3641 R3644

80

1

C3642

D

70

R3645

R3642 R3647 D3642

60

50

E

40

R3621

30

D3621

C3621

20

1

F

X

KN3601

10

Y

10

20

30

40

50

B

0

8

161

AVH-X1600DVD/XNUC

D3701

R3704 R3702

A

170

R3662 R3663 R3664

D3702 D3703

C3701 R3708

7

6

5

SIDE B

INTERFACE PCB

B

8 7 6 5

1

2

3

4

11.3 DVD CORE UNIT

C

DVD CORE UNIT

SIDE A

A

PU UNIT (DP11)

B

70 C1111

1 VR1101

20

R1982

CN1101

15

10

60

5

VR1102 1

C1110

1

C1108

1

C1109

C1950 IC1951

20

R1482 R1483

WHITE

15

C1484

RED

BLK

10

R1481

1

C1482 R1480

1 5

1

C1481 R1490

C1490

C1489

L1511

C1480

R1504

C1515

C1671 R1951

R1950

C1511 R1672 R1027

C1602

C1603 C1606 R1674 C1673

1

160

1

IC1480

L1501 R1489 1

R1484

25

1

R1512 R1485 R1486 C1488 C1487

205 210 215

R1488 R1487 R1538

C1505

165 170 175 180 185 190 195 200

1

C1503

C1504

R1544

R1543

R1533 C1605 C1604

C1608

R1604

C1601 R1602 R1601

R1953 R1952

C1524 R1255 R1256

50

C1523

45

R1522

40

C1607

35

10

30

5

C1507

50

1

25

15

1

45

105

20

C1508

C1485

40

100 140 145 150 155

GREEN

1

35

95

L1902

110 115 120 125 130 135

C1509

30

90

C1623

1

IC1501

85

C1612 C1609

80

R1605

M1 CRG(L/E) MOTOR

75

R1973 R1971 F1001

C1616 C1615 C1613 C1614

C1513

70

15 R1975

C1625

C1517 C1516 C1518

65

20

10 R1976

20

C1521 C1624 C1622

C1621 C1619 C1618

R1510 R1979 R1978

R1974 R1972

R1523 C1526 R1516

R1509

CN1951

D

R1513 C1522

C1255

R1977

30

R1514

C1519

60

R1258

C1254

R1525 R1519

R1526

C1520

R1540 R1541

R1532

30

29

40

R1537

M2 SPINDLE MOTOR

55

R1535

C1952

20

5

R1253 R1254

25

R1252

R1546 R1527

15

R1251

1 5

S1

10

1

C

50

HOME C1223 R1223

5

IC1251

1 X1950

1

C1951

L1904

10 CN1952 C1015 30

Y

E

25

20

15

10 R1954

5 R1955

A

1

CN751

0

X

10

20

30

40

50

60

70

80

F

C 162

AVH-X1600DVD/XNUC 1

2

3

4

5

C

6

7

8

DVD CORE UNIT

SIDE B A

70

B

C1106 R1111

Q1103

E

R1109

C1104

R1102

C1101

R1110 R1105

Q1102

C1113

R1106

E

R1115

60

R1112

R1104

R1118

R1101

E

R1534 C1528

C1112

50

C1251

20

C1252

C1403

C1404

30

15

35

40

IC1401

R1257

5

45

R1405

C1253

10

40

C1506

1

C1210 25

R1542

R1524 20

30

15

35 C1408

IC1402 10

40

R1528

R1530 R1224 C1224

C1620

R1518 R1531 C1410 R1401 C1401

C1409 IC1004

C

25

R1406

C1955

R1536

R1539 R1402

R1113

R1114 C1105

C1107

R1117

Q1104 E

R1116

Q1101

R1103

30

C1617

1

S2

D

R1547

C1010 1

5

45 R1517

X1501

C1802

R1804 R1803

C1803

R1801

C1005

R1802

R1043

IC1002

C1805 C1806

D1902 C1040

20

C1002

1

1

C1801

R1007 R1004

C1003

C1004

IC1003

C1001

D1901

C1018 R1045

10

R1505 R1506 C1804

R1603

R1529

5

C1510

C1954

C1016

C1953

L1903

1

R1983C1676 IC1801 R1671 R1508 C1809 R1507

15

1

R1670

1

IC1953

1

C1674

R1503 C1512

F1002

R1501

R1987

C1502

C1514

C1011 C1501

12EJ

C1041

1

S3

10

R1225 R1025

C1225

R1019

Y

E

0 80

70

60

50

40

30

20

10

X

F

C AVH-X1600DVD/XNUC 5

6

7

8

163

1

2

3

4

11.4 SERVICE UNIT (MONITOR)

D

A

SERVICE UNIT(MONITOR)

A

CN1751

80

60

25

R5121 R5122

5

10

15

20

25

R5125

30

35

45

50

55

C5049

R5076

60

IC5102 1 C5128

C5130

R5016

R5021

R5015 R5014 R5013 R5012 R5011 R5010 R5009 R5008 R5007 R5006 R5005 R5004 R5003

R5126

E Q5103

KN5004

R5001

20

TFT LCD

C5117

C5116

C5014 C5013 C5012 C5011 40

R5132

R5077

R5131

CN5001

E

C5050

R5081

R5020

R5075

R5074

R5055

R5070 R5071 R5069 R5072

R5130

5 R5080

R5068

D5132

R5019

1

R5022 C

C5010 C5009 C5008 C5007 C5006 C5005 C5004 C5003 C5002 C5001

10

TOUCH PA

Y 0

X 10

20

30

40

50

60

70

F

D 164

1 L52 R5

C5017 C5018 C5019 C5020

R5123

30

R5124 C5114

C5115

C5042 R5129

5

R5440

R5438

20

15

1

C5015 C5016

L5102

10

R5002

R5127 Q5104 E

15

C5401

IC5004

R5128

D

20

R5439

R5437

R5436 R5435 1

C5048

5 IC5003

C5047

R5431

R5434 R5433

R5432

R5427

R5423

R5425

R5429 10

R5073

R5033

C5023 C5022 C5021

30

R5079

R5060 R5051

C5030 C5029 C5028

C5038

C5040

L5004

C5039

C5034 C5033

C5041

1 20

R5058

R5050 R5049

40

R5025 R5027 R5030 R5031

C5035

R5034 R5035 R5043 R5045 R5044 R5053 R5046 R5048 R5047

L5003

C5027

35

R5018

15

40

R5017

20

R5040 R5042 R5052 R5054 R5041 R5056

R5039 R5032

C5037

C5036

R5036 R5037 R5038

5 IC5002

R5078

C5025

C5024

C5026

10

R5057 R5059

15 L5001

1

IC5001

R5062 R5063

5

C5031

R5061

10

50

C5044

L5002

C5043

C5032

R5430

C5420

C

R5428

R5422

C5106

R5426

C5131 C5129

C5045

Q5101

R5065 R5066 R5067

R5105

R5103

45

R5420 R5421

E

50

C5118

C5046

R5417

C5110

C5109

55

R5424

C5104

R5109

CN5401

D5105 C5123

R5064

R5117

R5102 R5101

R5106

C5107

R5104

R5135

R5136

R5116

C5105

60

C5120

R5110

C5113 R5134

R5141

10

C5111

1

R5140

R5419

5

C5103

R5416

C5112

C5140 R5142

R5143

15

1

C5102

R5418

C5126 IC5101

R5107

R5113 C5108

20

70

C5121

C5127

D5101

R5023

D5103 D5104 1 1 C5119

R5108

1

R5111

B

C5051

E L5101

KN5001

C5125

C5124

Q5106 R5139

C5122

C5101

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

SIDE A A

E

TFT LCD (BACKLIGHT)

CN4801

C5206

10

5

L5201

1

IC5201 R5215 15

20

B

KN5002 R5223 R5216

C5201

R5219 R5220

C5214

R5202 R5203 C5204

R5207

25

C5213 1

C5210

L5204 R5222

C5202

R5221

C5205

R5201

R5208 R5209

C5212

R5224

5

L5205

10 01

R5211 1

C5215

5

10

CN5201

C5211

C5207

D5201

C5208

1 L5202

R5210

R5214

R5225

L5203

C

D5132

CN5402

R5401 R5402 1 Q5401

R5020

KN5003

1

1

5

10

D R5021

CN5202 R5319

R5311 R5305 R5304

IC5301

10

1

CN5302

C5304 R5303

L5301 C5314

5 C5303

R5306 C5307

CN5403

1

1 C5301

L5302 L5303 C5209

D5307

5

C5309

R5307

1

R5308 R5312

R5022

C5302

C5019 C5020

R5408

C5128

0

R5405

R5407 R5406

IC5102 1

R5414

5

R5404

10

R5412 R5411

E

15

1

R5410 R5409

C5117

C5116

Q5402

R5415

R5413

R5132

R5403

130

5

10

CN5301

R5301

1

E

TH5201

TOUCH PANEL

70

80

90

100

110

120

130

140 F

D AVH-X1600DVD/XNUC 5

6

7

8

165

1

D

A

2

3

4

SERVICE UNIT(MONITOR)

B

R5206

C5203

R5213 R5212

R5205

R5218

R5217

C

D5401 D5402

D D5304 C5313 R5316

R5315 R5309

R5313

R5317

D5301

D5302

C5310

D5303

C5311

C5306

R5310

D5305

D5308

C5305

C5312

R5314 R5318

D5309

R5302

C5308

D5306

E

140

130

120

110

100

90

80

F

D 166

AVH-X1600DVD/XNUC 1

2

3

4

70

5

6

7

8

SIDE B A

80

R5112

B

R5321

R5114

70

R5115

R5144 L5103

60

C

50

40

R5024

R5029

R5026

D R5028

30

20

E

10

Y 0

X 70

60

50

40

30

20

10 F

D AVH-X1600DVD/XNUC 5

6

7

8

167

1

2

3

4

11.5 SERVICE UNIT (KEYBOARD)

E

SERVICE UNIT(KEYBOARD)

E

SIDE A

SERVICE UNIT(KEYBOARD)

SIDE B

A

S4809

S4805 1

1

90

C4805

90

RESET EJECT IC4801 1

VOL+ 1

80

B

80

C4804

S4807

R4801

R4807

VOL70

1

70

S4808

R4806 R4805

C

MUTE

60

1

60

S4806

50

50 1

C4803 C4801 D4801 5

D

S4804 1

1

D

CN5402

40

10

40

5

CN4801

HOME

C4802 R4804

MODE

30

1

30

S4803

E

FORWARD

20

20

1 S4801

R4808

R4803

R4802

REVERSE

10

10

1 S4802

Y

Y

F

0

X

E 168

10

20

20

10

0

X

AVH-X1600DVD/XNUC 1

2

3

4

5

6

7

8

12. ELECTRICAL PARTS LIST NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V The expression of the unit in this manual is shown by u instead of . Please do not make a mistake. Circuit Symbol and No.

Circuit Symbol and No.

Part No.

A:AVH-X1600DVD/XNUC B:AVH-X1600DVD/XNEW5 C:AVH-X1600DVD/XNUW5 D:AVH-X1650DVD/XNRC E:AVH-X1650DVD/XNRD F:AVH-X1650DVD/XNRI G:AVH-X1690DVD/XNID Unit Number : CXX6037(A) Unit Number : CXX6035(B) Unit Number : CXX6036(C) Unit Number : CXX6038(D) Unit Number : CXX6039(E) Unit Number : CXX6040(F) Unit Number : CXX6041(G) Unit Name : Service Unit(Mother I/F) Unit Number : YWX5032 Unit Name : DVD Core Unit Unit Number : CXX6055 Unit Name : Service Unit(Monitor) Unit Number : CXX6059 Unit Name : Service Unit(Keyboard)

Service Unit(Mother I/F) Consists of Mother PCB Interface PCB

6

B

Part No.

AB Unit Number : CXX6037(A) Unit Number : Unit Number : Unit Number : Unit Number : Unit Number : Unit Number : Unit Name :

CXX6035(B) CXX6036(C) CXX6038(D) CXX6039(E) CXX6040(F) CXX6041(G) Service Unit(Mother I/F)

C

MISCELLANEOUS IC 101 IC 251 IC 341 IC 501 IC 601

(B,132,74) IC (B,119,96) IC (A,97,121) IC (A,40,78) IC (A,56,55) IC(A) (A,56,55) IC(B,C,D,E,F,G)

AK4223VQ PML020A PA2032A TDA7706 PDB117A8 PDB118A8

IC 751 IC 1001 IC 1002 IC 1003 IC 1004

(A,132,67) IC (B,89,68) IC (B,86,68) IC (B,80,68) IC (B,77,68) IC

BD11600NUX BH7673G BH7673G BH7673G BH7673G

IC 1051 IC 1101 IC 1151 IC 1202 IC 1251

(B,82,41) LSI ML86V7675TBZA3A M12L128168A-5TG2N (B,123,41) RAM IC (B,104,49) IC WM8761BGED (B,105,40) IC 337S3959 (B,146,54) Flash ROM Unit(Service) (A,D) CXX5989 (B,146,54)Flash ROM Unit(Service)(B,C,E,F,G) CXX5991

IC 1301 IC 1302 IC 1721 IC 1731 IC 1801

(B,96,22) Serial Flash Memory (A,107,42) IC (A,126,100) IC (A,123,112) IC (B,60,83) Regulator IC

MX25L8006EM2I-12G R5S72690RW266FP NJM4565V NJM4565V NJW4181U3-33B

IC 1821 IC 1901 IC 1951 IC 2011 IC 2031

(A,91,101) IC (B,33,53) IC (B,158,68) IC (B,116,15) Regulator IC (B,78,24) Regulator IC

NJM2387ADL3 NJM2886DL3-05 AN33012UA BD00IA5WEFJ NJM2878F3-15

AVH-X1600DVD/XNUC 5

A

7

8

D

E

F

169

1

2

Circuit Symbol and No.

A

B

C

D

E

F

3

Part No.

IC 2101 IC 2161 Q 301 Q 311 Q 321

(B,164,96) Regulator IC (B,165,108) IC (B,93,101) Transistor (B,90,104) Transistor (B,88,106) Chip Transistor

BD9876EFJ AN33014UA LSCR523UB RN4987 RN1903

Q Q Q Q Q

601 751 752 831 841

(A,71,48) (B,65,18) (B,61,18) (B,65,77) (B,67,73)

Transistor Chip Transistor Chip Transistor Transistor Transistor

LSCR523UB HN1C01FU RN4982 LTC014EEB LTC014EEB

Q Q Q Q Q

854 871 1001 1002 1003

(A,53,98) (A,56,78) (B,82,58) (B,85,58) (B,88,58)

Chip Transistor Chip Transistor Transistor Transistor Transistor

HN1A01FU HN1C01FU LSCR523UB LSCR523UB LSCR523UB

Q Q Q Q Q

1004 1201 1631 1632 1633

(B,78,58) Transistor (B,110,32) Transistor (A,36,113) Chip Transistor (A,43,113) Chip Transistor (A,30,113) Chip Transistor

Q Q Q Q Q Q

1661 1662 1663 1701 1712 1721

(B,125,16) Chip Transistor 2SD2114K (B,128,14) Transistor RN4984 (B,129,19) Transistor RN4984 (A,135,105) Transistor UMF23N (B,46,54) Chip Transistor(D,E,F,G) HN1B04FU (A,136,97) Transistor LSCR523UB

Q Q D D D

1951 1952 301 302 312

(A,163,70) Power MOS FET (A,153,67) Power MOS FET (B,84,105) Diode (B,90,99) Diode (B,90,101) Diode

RSD140P06 RSD140P06 DA2J101 DZ2J082M0 DA2J101

D D D D D

501 502 601 602 801

(A,46,95) Diode (A,46,88) Diode (B,61,49) Diode (B,63,49) Diode (B,64,122) Diode

RN731VN RN731VN RB501VM-40 DB2J31400 1SR154-400

D D D D D

802 821 831 841 853

(B,60,122) Diode (A,48,101) Diode (B,63,76) Diode (B,70,76) Diode (A,51,102) Diode

1SR154-400 DAN202UM DZ2J056M0 DA2J101 DAN202UM

D D D D D

871 873 1601 1602 1622

(B,63,103) Diode (B,67,101) Diode (A,153,108) Diode (A,150,108) Diode (B,123,112) Diode

UDZV6R2(B) UDZV7R5(B) PESD0402-140 PESD0402-140 DZ2S180C

D D D D D

1623 1624 1661 1721 1781

(B,134,111) Diode (B,140,110) Diode (B,125,12) Diode (A,137,101) Diode (B,56,35) Diode

DZ2S180C DZ2S180C DZ2J039M0 DZ2J051M0 DZ2S180C

D D D D D

1782 1801 1902 1951 1952

(B,58,33) Diode (B,66,83) Diode (B,38,42) Diode (A,161,63) Diode (A,153,59) Diode

DZ2S180C 1SR154-400 CRG03 RB056L-40 RB056L-40

D D D D

1953 2101 2161 2162

(A,140,110) Diode (A,164,94) Diode (B,163,102) Diode (B,154,105) Diode

RB080L-30 RB056L-40 RB060M-30 1SR154-400

170

LSCR523UB LSAR523UB HN1C01FU HN1C01FU HN1C01FU

4

Circuit Symbol and No.

Part No.

D 3641 D 3642

(B,77,37) Diode (B,62,37) Diode

DZ2S180C DZ2S180C

D L L L L L L

3643 501 502 503 504 505 506

(B,77,41) (A,46,91) (A,43,90) (A,40,90) (A,38,89) (A,34,95) (A,43,88)

Diode Chip Coil Chip Coil Inductor SMD Ferrite Beads Inductor Inductor

DZ2S180C LCTAWR15J2520 LCTAWR27J2520 CTF1786 CTF1806 CTF1389 CTF1794

L L L L L

507 508 509 510 511

(A,32,89) (A,32,85) (A,29,79) (A,31,75) (A,35,70)

Inductor Inductor(A,E) Chip Coil Inductor Inductor

LCYC220K1608 LCYB68NJ1005 LCTAW470J2520 CTF1786 CTF1786

L L L L L

512 513 514 517 519

(A,50,83) (A,51,83) (A,44,68) (A,50,71) (A,33,93)

Inductor Inductor Inductor Inductor Inductor

CTF1786 CTF1786 CTF1786 CTF1786 LCYB10NJ1608

L L L L L

801 1001 1002 1003 1004

(A,63,92) (B,87,62) (B,80,62) (B,76,62) (B,83,62)

Choke Coil 600 uH Inductor Inductor Inductor Inductor

CTH1221 CTF1545 CTF1545 CTF1545 CTF1545

L L L L L

1005 1051 1101 1107 1151

(B,96,68) Chip Coil (B,77,34) Inductor (B,135,43) Inductor (B,119,50) Inductor (B,106,55) Inductor

LCTAW100J2520 CTF1740 CTF1786 CTF1645 CTF1786

L L L L L

1251 1301 1302 1303 1304

(B,138,55) (B,109,44) (B,110,57) (B,108,21) (B,138,43)

Inductor Inductor Inductor Chip Beads Chip Beads

CTF1786 CTF1786 CTF1545 VTL1129 VTL1129

L L L L L

1305 1306 1311 1312 1313

(A,127,37) Chip Beads (A,86,34) Chip Beads (A,124,29) Chip Beads (A,126,32) Chip Beads (A,124,35) Chip Beads

VTL1126 VTL1127 VTL1127 VTL1127 VTL1127

L L L L L

1315 1316 1317 1318 1319

(A,125,41) (A,124,43) (A,125,42) (A,125,46) (A,125,49)

Chip Beads Chip Beads Chip Beads Chip Beads Chip Beads

VTL1127 VTL1127 VTL1127 VTL1127 VTL1127

L L L L L

1322 1323 1377 1381 1383

(A,125,54) Chip Beads (A,125,58) Chip Beads (A,86,30) Chip Beads (A,87,54) Chip Beads (A,83,54) Chip Beads

VTL1127 VTL1127 VTL1126 VTL1126 VTL1126

L L L L L

1384 1387 1390 1391 1393

(A,85,52) (A,87,46) (A,83,46) (A,87,45) (A,83,44)

Chip Beads Chip Beads Chip Beads Chip Beads Chip Beads

VTL1126 VTL1126 VTL1126 VTL1126 VTL1126

L L L L L

1394 1397 1399 1401 1403

(A,87,44) (A,83,43) (A,87,43) (A,87,42) (A,84,41)

Chip Beads Chip Beads Chip Beads Chip Beads Chip Beads

VTL1126 VTL1126 VTL1126 VTL1126 VTL1126

(A,87,40) Chip Beads

VTL1126

L 1405

AVH-X1600DVD/XNUC 1

2

3

4

5

6

Circuit Symbol and No. L L L L

1407 1409 1411 1413

(A,84,39) (A,87,38) (A,87,37) (A,87,36)

L L L L L

1415 1601 1951 1952 1953

(A,86,35) Chip Beads (A,151,106) Inductor (A,164,55) Choke Coil 10 uH (A,151,54) Inductor (A,144,102) Choke Coil 10 uH

L L L X X

2101 2161 2162 501 601

X X X X P

1051 1301 1302 1303 451

P 1623 P 1631 P 1701 > P1951 > P2071

Chip Beads Chip Beads Chip Beads Chip Beads

7

Part No.

8

Circuit Symbol and No.

Part No.

VTL1126 VTL1126 VTL1126 VTL1126

R R R R

122 201 202 251

(B,125,80) (B,133,101) (B,129,102) (B,126,105)

RS1/16SS470J RS1/16SS0R0J RS1/16SS182J RS1/16SS162J

VTL1126 CTF1713 CTH1446 CTH1519 CTH1486

R R R R R

255 258 259 260 261

(B,124,88) (A,100,108) (A,96,108) (A,104,107) (A,92,108)

RS1/16SS473J RS1/8SQ0R0J RS1/8SQ0R0J RS1/8SQ0R0J RS1/8SQ0R0J

(A,158,94) Inductor CTH1524 (A,164,102) Inductor CTH1524 (B,167,102) Inductor CTF1793 (A,52,75) Resonator 36.48 MHz CSS1805 (A,71,56) Crystal Resonator 12.500 MHz CSS1839

R R R R R

265 302 303 304 306

(B,102,95) (B,87,104) (B,95,99) (B,96,99) (A,66,43)

RS1/16SS0R0J RS1/16SS103J RS1/16SS104J RS1/16SS473J RS1/16SS103J

(B,71,34) Crystal Resonator 32.000 MHz CSS1818 (A,102,65) Resonator 48.000 MHz CSS1760 (A,113,65)Crystal Resonator 13.333 3 MHz CSS1840 (A,86,50) Resonator 16.93 MHz CSS1794 (A,21,96) Surge Absorber IMSA-6803-01Y900

R R R R R

312 321 322 323 324

(B,85,100) (B,85,106) (B,83,106) (B,85,103) (B,88,109)

RS1/16SS102J RS1/16SS683J RS1/16SS152J RS1/16SS683J RS1/16SS101J

(B,130,108) Poly Switch (B,28,109) Poly Switch (A,121,77) Poly Switch (A,45,37) Fuse 1 A (A,145,38) Fuse 1.25 A

R R R R R R

332 333 454 457 519 520

(A,83,111) (A,83,110) (B,49,84) (B,C,D,E,F,G) (B,22,96) (A,47,86) (A,31,94)

RS1/16SS473J RS1/16SS102J RS1/8SQ0R0J RS1/10SR0R0J RS1/16SS221J RS1/16SS105J

R R R R R R

521 522 523 524 525 526

(A,47,87) (A,32,87) (A,33,85) (A,31,85) (B,C,D,F,G) (A,29,82) (A,31,81)

RS1/16SS751J RS1/16SS152J RS1/16SS105J RS1/16SS0R0J RS1/16SS471J RS1/16SS330J

R R R R R

527 528 529 530 539

(A,31,79) (A,28,71) (A,26,72) (A,26,75) (A,33,73)

RS1/16SS681J RS1/4SA5R6J RS1/4SA5R6J RS1/4SA5R6J RS1/16SS102J

R R R R R R

601 602 603 604 605 606

(B,51,41) (B,49,41) (B,51,40) (B,49,40) (B,51,39) (B,49,39)

R R R R R

607 610 611 612 613

(B,51,37) (B,49,36) (B,51,45) (B,55,50) (B,61,40)

RS1/16SS104J RS1/16SS104J RS1/16SS103J RS1/16SS221J RS1/16SS472J

R R R R R

614 615 616 617 618

(B,63,40) (B,64,40) (B,62,40) (B,55,45) (B,55,44)

RS1/16SS471J RS1/16SS472J RS1/16SS471J RS1/16SS104J RS1/16SS104J

R R R R R

619 620 621 622 623

(A,59,66) (B,50,45) (B,66,61) (A,55,42) (B,61,44) (A,B,C) (B,61,44) (D,E,F,G)

RS1/16SS102J RS1/16SS103J RS1/16SS473J RS1/16SS101J RS1/16SS104J RS1/16SS103J

(B,61,45) (A,B,C) (B,61,45) (D,E,F,G) (B,58,45)

RS1/16SS103J RS1/16SS1002D RS1/16SS0R0J

> P2081 (A,23,20) Fuse 0.75 A > P2151 (A,46,25) Fuse 2.5 A > P2152 (A,49,27) Fuse 1.5 A

FSMD075-24R FSMD075-24R FSMD075-24R CEK1381 CEK1382

BZ3631 CN751

(A,45,44) Buzzer (A,63,13) Connector

CEK1380 CEK1385 CEK1383 CPV1062 CKS6025

CN1701 CN1751 CN3601 CN3661 JA451

(A,119,85) Connector (A,67,27) Connector (B,119,49) Connector (A,111,25) Connector (A,14,111) Antenna Jack

CKS6535 CKS6536 CKS6605 CKS4497 YKS5041

JA801 JA1601 JA1621 JA1631 JA3621

(A,62,118) Plug (A,151,121) USB Jack (A,129,121) RCA Jack (A,35,120) Pin Jack (A,13,33) RCA Jack

CKM1376 CKN1091 CKB1110 XKB7001 CKB1106

JA3641 JA3731

(A,69,19) Jack (A,145,28) Jack

CKN1106 CKS6437

D

R R R R R

101 102 104 105 108

(B,122,71) (B,122,74) (B,125,78) (B,125,81) (B,141,66)

RAB4CQ101J RAB4CQ101J RS1/16SS75R0D RS1/16SS75R0F RS1/10SR560J

R R R R R

109 110 112 113 114

(B,143,74) (B,143,79) (B,129,63) (B,132,64) (B,134,64)

RAB4CQ101J RAB4CQ101J RS1/16SS101J RS1/16SS101J RS1/16SS101J

R R R R R

115 116 117 119 120

(B,136,63) (B,131,64) (B,135,64) (B,144,67) (B,143,69)

RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/10SR560J RS1/10SR560J

R 121

(B,144,71)

RS1/10SR560J

R 624 R 626

AVH-X1600DVD/XNUC 6

B

C

RESISTORS

5

A

7

(B,C,D,E) (F,G) (B,C,F,G) (D,E) (B,D,F) (C,E,G)

RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J

8

E

F

171

1

Circuit Symbol and No.

A

B

C

D

E

F

2

3

Part No.

Circuit Symbol and No.

4

Part No.

R 627 R 629 R 630

(B,62,45) (A,69,56) (A,69,45)

RS1/16SS473J RS1/16SS0R0J RS1/16SS473J

R 834 R 841 R 842

(B,55,103) (B,69,75) (B,72,79)

RS1/4SA102J RS1/16SS103J RS1/4SA102J

R R R R R

631 632 633 634 636

(A,70,46) (A,70,50) (A,68,50) (B,64,45) (A,68,52)

RS1/16SS104J RS1/16SS473J RS1/16SS102J RS1/16SS473J RS1/16SS472J

R R R R R

861 863 864 865 866

(A,44,63) (A,50,98) (A,55,97) (A,49,98) (A,51,105)

RS1/16SS473J RS1/16SS223J RS1/16SS473J RS1/16SS473J RS1/16SS103J

R R R R R

637 638 642 644 645

(A,68,53) (A,63,69) (B,65,52) (A,70,53) (B,66,60)

RS1/16SS472J RS1/16SS102J RS1/16SS473J RS1/16SS102J RS1/16SS102J

R R R R R

867 868 873 874 875

(A,43,63) (B,43,66) (B,66,103) (B,65,103) (B,60,103)

RS1/16SS102J RS1/16SS102J RS1/16SS103J RS1/16SS473J RS1/16SS392J

R R R R R

646 647 648 652 653

(A,68,62) (A,68,64) (A,68,63) (A,73,48) (A,68,48)

RS1/16SS121J RS1/16SS104J RS1/16SS121J RS1/16SS473J RS1/16SS471J

R R R R R

878 879 880 1009 1010

(B,62,101) (B,64,101) (B,55,100) (B,78,64) (B,81,64)

RS1/16SS104J RS1/16SS473J RS1/4SA102J RS1/16SS101J RS1/16SS101J

R R R R R

654 655 658 659 660

(A,68,49) (A,71,51) (B,68,59) (A,67,66) (A,67,67)

RS1/16SS471J RS1/16SS472J RS1/16SS104J RS1/16SS0R0J RS1/16SS0R0J

R R R R R

1011 1012 1013 1051 1052

(B,90,63) (B,86,64) (B,83,69) (B,71,49) (B,69,40)

RS1/16SS101J RS1/16SS101J RS1/10SR101J RS1/16SS750J RS1/10SR0R0J

R R R R R

661 662 663 664 665

(A,67,68) (A,67,69) (A,61,69) (A,59,69) (B,54,67)

RS1/16SS0R0J RS1/16SS0R0J RS1/16SS473J RS1/16SS103J RS1/16SS0R0J

R R R R R

1053 1054 1055 1056 1057

(A,76,40) (B,92,40) (B,71,39) (B,71,38) (B,92,39)

RS1/16SS472J RS1/16SS473J RS1/16SS101J RS1/16SS101J RS1/16SS561J

R R R R R

666 667 668 681 682

(A,59,72) (A,58,69) (B,56,67) (A,44,44) (B,43,44)

RS1/16SS104J RS1/16SS103J RS1/16SS102J RS1/16SS221J RS1/16SS221J

R R R R R

1058 1059 1060 1061 1062

(B,74,36) (B,72,37) (B,82,30) (B,83,30) (B,83,32)

RS1/16SS105J RS1/16SS471J RS1/16SS391J RS1/16SS391J RS1/16SS391J

R R R R R

683 684 685 686 687

(A,43,44) (B,47,44) (B,45,44) (B,44,44) (B,50,53)

RS1/16SS221J RS1/16SS221J RS1/16SS221J RS1/16SS221J RS1/16SS104J

R R R R R

1063 1064 1065 1066 1067

(B,84,30) (B,85,30) (B,86,31) (B,88,31) (B,86,32)

RS1/16SS391J RS1/16SS391J RS1/16SS391J RS1/16SS391J RS1/16SS391J

R R R R R

688 689 690 691 692

(A,44,56) (A,43,61) (B,46,62) (B,46,60) (B,53,46)

RS1/16SS473J RS1/16SS473J RS1/16SS272J RS1/16SS102J RS1/16SS104J

R R R R R

1068 1069 1070 1071 1072

(B,88,32) (B,87,34) (B,89,34) (B,74,33) (B,81,30)

RS1/16SS221J RS1/16SS221J RS1/16SS561J RS1/16SS473J RS1/16SS101J

R R R R R

698 699 700 701 705

(B,42,44) (A,45,44) (B,54,50) (A,68,61) (B,48,62)

RS1/16SS473J RS1/16SS104J RS1/16SS221J RS1/16SS473J RS1/16SS822J

R R R R R

1073 1074 1075 1076 1077

(B,77,33) (B,69,39) (B,69,37) (B,72,26) (B,70,26)

RS1/16SS101J RS1/16SS222J RS1/16SS222J RS1/10SR0R0J RS1/10SR0R0J

R R R R R

707 750 751 752 753

(B,50,50) (A,134,71) (B,59,23) (B,58,18) (B,58,19)

RS1/16SS104J RS1/10SR0R0J RAB4CQ221J RS1/16SS471J RS1/16SS102J

R R R R R

1080 1081 1082 1083 1084

(B,73,49) (B,87,54) (B,84,54) (B,69,26) (B,81,54)

RS1/16SS0R0J RS1/16SS750J RS1/16SS750J RS1/10SR0R0J RS1/16SS750J

R R R R R

754 757 758 759 821

(B,68,18) (B,64,16) (B,66,16) (B,61,16) (A,45,101)

RS1/16SS0R0J RS1/16SS472J RS1/16SS472J RS1/16SS102J RS1/16SS153J

R R R R R

1085 1101 1102 1103 1104

(B,78,55) (B,128,29) (B,125,29) (B,120,33) (B,116,33)

RS1/16SS750J RAB4CQ221J RAB4CQ221J RAB4CQ471J RAB4CQ471J

(B,65,75) (B,59,75)

RS1/16SS104J RS1/16SS103J

R 1105 R 1106

(B,113,33) (B,122,50)

RAB4CQ471J RS1/16SS471J

R 832 R 833

172

AVH-X1600DVD/XNUC 1

2

3

4

5

Circuit Symbol and No.

6

7

Part No.

Circuit Symbol and No.

8

Part No.

R 1108 R 1109 R 1110

(B,130,52) (B,126,52) (B,115,51)

RAB4CQ221J RAB4CQ221J RAB4CQ471J

R 1348 R 1349 R 1350

(A,94,25) (B,95,16) (A,90,50)

RS1/16SS101J RS1/16SS0R0J RS1/16SS152J

R R R R R

1111 1112 1151 1152 1201

(B,112,51) (B,118,51) (B,98,52) (B,109,52) (B,107,41)

RAB4CQ471J RS1/16SS471J RS1/16SS821J RS1/16SS821J RS1/16SS222J

R R R R R

1351 1352 1353 1355 1356

(A,92,60) (A,90,66) (B,118,54) (B,115,55) (A,129,47)

RS1/16SS102J RAB4CQ473J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J

R R R R R

1202 1203 1205 1206 1209

(B,109,37) (B,104,42) (B,108,41) (B,104,43) (B,109,41)

RS1/16SS183J RS1/16SS222J RS1/16SS101J RS1/16SS101J RS1/16SS221J

R R R R R

1359 1360 1365 1376 1378

(A,128,49) (B,122,56) (A,91,24) (A,91,27) (A,88,28)

RS1/16SS0R0J RS1/16SS0R0J RS1/16SS331J RS1/16SS0R0J RS1/16SS0R0J

R R R R R

1251 1252 1253 1256 1257

(A,126,50) (A,130,52) (B,76,30) (B,75,30) (A,128,52)

RS1/16SS220J RS1/16SS470J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS470J

R R R R R

1379 1380 1381 1382 1383

(A,87,32) (A,89,54) (A,88,26) (A,85,53) (A,117,61)

RS1/16SS0R0J RS1/16SS101J RS1/16SS0R0J RS1/16SS101J RS1/16SS101J

R R R R R

1258 1259 1260 1302 1303

(A,130,49) (A,129,56) (B,139,57) (A,97,22) (B,107,44)

RS1/16SS470J RS1/16SS470J RS1/16SS470J RS1/16SS273J RS1/16SS0R0J

R R R R R

1384 1385 1386 1387 1388

(A,120,61) (A,89,53) (A,88,46) (B,113,55) (A,84,46)

RS1/16SS102J RS1/16SS101J RS1/16SS101J RS1/16SS472J RS1/16SS101J

R R R R R

1305 1306 1307 1310 1311

(A,106,21) (A,106,19) (B,123,27) (B,102,32) (B,120,28)

RS1/16SS121J RS1/16SS104J RS1/16SS473J RS1/16SS101J RS1/16SS472J

R R R R R

1389 1391 1392 1393 1395

(A,88,45) (A,111,62) (A,84,44) (A,88,30) (A,88,44)

RS1/16SS101J RS1/16SS102J RS1/16SS101J RS1/16SS101J RS1/16SS101J

R R R R R

1312 1313 1314 1315 1316

(B,121,29) (B,118,28) (A,124,31) (B,119,28) (B,117,28)

RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS472J

R R R R R

1396 1398 1400 1402 1404

(A,85,43) (A,89,43) (A,89,42) (A,86,41) (A,89,40)

RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS101J

R R R R R

1318 1319 1320 1321 1322

(B,110,51) (A,128,43) (A,126,52) (A,126,56) (A,128,51)

RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS473J

R R R R R

1406 1408 1410 1412 1414

(A,86,40) (A,89,38) (A,89,37) (A,89,36) (A,87,35)

RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS101J

R R R R R

1323 1324 1325 1326 1327

(A,118,61) (A,123,57) (A,100,59) (A,103,61) (B,105,60)

RS1/16SS101J RS1/16SS104J RS1/16SS2402F RS1/16SS681J RS1/16SS5601F

R R R R R

1416 1418 1419 1423 1424

(A,87,34) (A,126,39) (A,97,25) (A,113,23) (A,123,59)

RS1/16SS0R0J RS1/16SS101J RS1/16SS0R0J RS1/16SS222J RS1/16SS0R0J

R R R R R

1328 1329 1330 1331 1332

(A,112,62) (B,113,57) (B,114,57) (A,106,64) (A,106,65)

RS1/16SS222J RS1/16SS473J RS1/16SS473J RS1/16SS103J RS1/16SS101J

R R R R R

1425 1426 1427 1428 1429

(A,89,24) (A,91,26) (A,85,32) (A,130,46) (A,130,47)

RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J

R R R R R

1333 1334 1335 1337 1338

(B,118,58) (A,114,62) (B,99,28) (A,96,23) (A,109,64)

RS1/16SS473J RS1/16SS473J RS1/16SS0R0J RS1/16SS101J RS1/16SS104J

R R R R R

1431 1432 1433 1434 1435

(A,100,61) (A,98,61) (A,98,64) (A,96,64) (A,91,63)

RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J

R R R R R

1339 1340 1341 1342 1344

(A,98,65) (A,93,66) (A,126,46) (A,89,30) (B,119,53)

RS1/16SS273J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS150J

R R R R R

1436 1621 1622 1623 1631

(B,92,54) (B,140,108) (B,134,106) (B,123,110) (B,45,110)

RS1/16SS104J RS1/16SS750J RS1/16SS223J RS1/16SS223J RS1/16SS821J

R 1345 R 1347

(B,103,29) (A,129,46)

RS1/16SS473J RS1/16SS0R0J

R 1632 R 1633

(A,45,113) (A,37,109)

RS1/16SS223J RS1/16SS472J

AVH-X1600DVD/XNUC 5

6

7

8

A

B

C

D

E

F

173

1

Circuit Symbol and No.

A

B

C

D

E

F

2

3

Part No.

R 1634 R 1635 R 1636

(A,34,113) (A,36,109) (B,39,110)

RS1/16SS223J RS1/16SS472J RS1/16SS821J

R R R R R

1637 1638 1639 1640 1641

(B,43,110) (A,40,113) (A,42,109) (A,43,109) (A,32,113)

RS1/16SS821J RS1/16SS223J RS1/16SS472J RS1/16SS472J RS1/16SS223J

R R R R R

1642 1643 1644 1645 1646

(B,37,110) (B,41,110) (A,38,113) (A,30,111) (A,29,111)

RS1/16SS821J RS1/16SS821J RS1/16SS223J RS1/16SS472J RS1/16SS472J

R R R R R

1647 1648 1662 1663 1664

(A,27,113) (B,35,110) (B,128,17) (B,126,10) (B,130,13)

RS1/16SS223J RS1/16SS821J RS1/16SS103J RS1/16SS122J RS1/16SS152J

R R R R R

1701 1702 1703 1713 1714

(A,138,104) (A,133,104) (A,133,105) (B,46,50) (D,E,F,G) (B,63,52) (A,B,C) (B,63,52) (D,E,F,G)

R R R R R

1715 1716 1717 1718 1721

R R R R R

Circuit Symbol and No.

4

Part No.

R R R R

1959 1960 1961 1962

(B,160,75) 0.011 ohm (B,163,64) (B,163,63) (B,154,75) 0.012 ohm

CCN1341 RS1/16SS204J RS1/16SS394J CCN1321

R R R R R

1963 1964 1965 1966 1967

(B,158,63) (B,165,67) (B,165,64) (B,167,64) (B,165,66)

RS1/16SS224J RS1/16SS472J RS1/16SS1101D RS1/16SS3000D RS1/16SS1002D

R R R R R

1968 2003 2011 2012 2013

(B,167,66) (B,145,39) (B,111,14) (B,112,13) (B,112,15)

RS1/16SS511J RS1/10SR0R0J RS1/16SS472J RS1/16SS223J RS1/16SS473J

R R R R R

2022 2024 2031 2101 2102

(B,82,18) (B,81,19) (B,79,22) (B,170,97) (B,168,97)

RS1/16SS0R0J RS1/10SR0R0J RS1/16SS102J RS1/16SS3601D RS1/16SS4702D

RS1/10SR222J RS1/16SS562J RS1/16SS332J RS1/16SS4700D RS1/16SS102J RS1/16SS1001D

R R R R R

2103 2104 2105 2161 2162

(B,168,98) (B,170,98) (B,158,90) (A,156,110) (A,156,111)

RS1/16SS2202D RS1/16SS222J RS1/8SQ0R0J RS1/16SS102J RS1/16SS102J

(B,46,56) (D,E,F,G) (B,47,57) (D,E,F,G) (B,48,51) (D,E,F,G) (B,48,50) (D,E,F,G) (A,122,98)

RS1/16SS102J RS1/16SS102J RS1/16SS473J RS1/16SS473J RS1/16SS153J

R R R R R

2163 2164 2165 2166 2167

(A,156,108) (B,171,113) (B,171,110) (B,164,115) (B,165,115)

RS1/16SS102J RS1/16SS224J RS1/16SS4702D RS1/16SS152J RS1/16SS3302D

1722 1723 1724 1725 1726

(A,121,99) (A,121,101) (A,131,98) (A,132,98) (A,132,100)

RS1/16SS153J RS1/16SS153J RS1/16SS153J RS1/16SS153J RS1/16SS153J

R R R R R

2168 2169 2170 2171 2172

(B,166,115) (B,157,110) (A,156,109) (A,158,103) 0.056 ohm (B,159,107)

RS1/16SS8201D RS1/16SS752J RS1/16SS102J ACN7160 RS1/16SS0R0J

R R R R R

1727 1729 1730 1731 1732

(A,123,97) (A,135,94) (A,134,98) (A,130,97) (A,128,112)

RS1/16SS153J RS1/16SS102J RS1/16SS472J RS1/16SS153J RS1/16SS153J

R R R R

2173 2174 2177 2178

(B,172,103) (B,171,104) (B,166,113) (B,164,113)

RS1/16SS394J RS1/16SS204J RS1/16SS0R0J RS1/16SS0R0J

R R R R R

1733 1734 1735 1736 1737

(A,124,107) (A,125,107) (A,119,114) (A,128,113) (A,118,110)

RS1/16SS273J RS1/16SS273J RS1/16SS153J RS1/16SS473J RS1/16SS153J

R R R R R

3621 3641 3642 3643 3661

(B,29,35) (B,81,42) (B,61,40) (B,86,38) (B,101,41)

RS1/16SS750J RS1/16SS223J RS1/16SS223J RS1/16SS750J RAB4CQ750J

R R R R R

1738 1739 1740 1763 1764

(A,118,114) (A,118,112) (A,121,108) (A,100,72) (A,109,80)

RS1/16SS153J RS1/16SS153J RS1/16SS153J RS1/16SS103J RS1/16SS0R0J

R R R R R

3662 3663 3664 3665 3666

(B,115,33) (B,114,32) (B,115,26) (A,115,43) (A,116,40)

RS1/16SS223J RS1/16SS223J RS1/16SS562J RS1/10SR102J RS1/10SR102J

R R R R R

1782 1822 1823 1824 1902

(B,78,26) (A,88,96) (A,90,96) (A,86,97) (A,93,76)

RS1/16SS0R0J RS1/16SS823J RS1/16SS103J RS1/16SS153J RS1/16SS0R0J

R R R R R

3668 3669 3677 3678 3732

(A,121,38) (A,122,39) (B,113,27) (B,113,26) (B,136,44)

RS1/10SR471J RS1/10SR471J RS1/16SS272J RS1/16SS272J RS1/10SR102J

R R R R R

1952 1953 1954 1955 1956

(B,149,66) (B,150,67) (B,150,65) (B,150,64) (B,150,68)

RS1/16SS561J RS1/16SS3302D RS1/16SS4301D RS1/16SS3601D RS1/16SS123J

R 1957

(B,160,63)

RS1/16SS103J

174

CAPACITORS C C C C C

101 102 103 104 105

(B,125,69) (B,125,70) (B,125,71) (B,125,72) (B,125,73)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

AVH-X1600DVD/XNUC 1

2

3

4

5

Circuit Symbol and No.

6

7

Part No.

8

Circuit Symbol and No.

Part No.

C C C C C

106 107 108 109 110

(B,125,74) (B,125,75) (B,125,76) (B,126,78) (B,127,81) 10 uF

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CCG1192

C C C C C

281 282 283 284 286

(B,111,95) (B,105,93) (B,109,93) 10 uF (B,108,98) 10 uF (B,103,94)

CCSSCH101J50 CCSRCH102J50 CCG1192 CCG1192 CKSSYB104K16

C C C C C

111 112 113 114 115

(B,126,83) (B,125,83) (B,128,66) 10 uF (B,126,67) (B,130,83)

CKSSYB104K10 CKSSYB104K10 CCG1192 CKSSYB104K10 CKSRYB104K16

C C C C C C

287 289 290 292 301 305

(B,127,96) (B,130,100) (B,124,106) (A,137,76) (E) (B,86,102) 10 uF (A,113,113)

CCSSCH102J50 CCSSCH102J50 CKSSYB103K16 CKSRYB105K10 CCG1192 CKSRYB104K16

C C C C C

116 117 118 119 120

(B,130,81) 10 uF (B,133,80) (B,134,81) 10 uF (B,140,70) (B,140,71)

CCG1192 CKSRYB104K16 CCG1192 CKSRYB105K10 CKSRYB105K10

C C C C C

307 308 311 321 341

(B,74,123) (B,74,122) (A,85,89) (B,85,108) 4.7 uF (A,95,111) 0.22 uF

CCSSCH101J50 CCSSCH100D50 XCEHVW101M16 CCG1201 CCG1313

C C C C C

121 122 123 124 125

(B,140,73) (B,140,74) (B,140,75) (B,140,77) (B,140,78)

CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10

C C C C C

342 343 344 349 350

(A,92,111) 0.22 uF (A,102,112) 0.22 uF (A,99,112) 0.22 uF (A,105,112) 1 uF (A,89,109) 4.7 uF

CCG1313 CCG1313 CCG1313 CCG1325 CCG1291

C C C C C

126 127 128 129 130

(B,140,79) (B,140,81) (B,132,66) (B,129,66) (B,122,77)

CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSSYB104K10

C C C C C

352 353 454 455 456

(B,74,121) (A,86,109) 4.7 uF (A,30,96) (A,E) (A,23,96) (A,E) (B,24,83) (A)

CKSRYB104K16 CCG1291 CCSSCK2R0C50 CCSSCJ3R0C50 CCSSCH5R0C50

C C C C C

131 132 133 134 135

(B,125,77) (B,133,66) (B,136,65) (B,139,67) (B,141,67)

CKSSYB104K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10

C C C C C

458 459 460 461 509

(B,35,88) (B,31,82) (B,33,82) (B,29,84) (A,43,93)

CCSSCH5R0C50 CCSSCH4R0C50 CCSSCH4R0C50 CCSSCH4R0C50 CCSSCH330J50

C C C C C

136 137 138 139 140

(B,140,69) (B,131,66) (B,135,66) (B,134,83) (B,124,80)

CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CCSSCH102J50 CKSSYB271K50

C C C C C

510 512 513 514 515

(A,45,93) (A,32,96) (A,48,93) (A,40,88) (A,37,87)

CCSSCH6R0D50 CKSRYB103K50 CKSSYB103K16 CKSSYB104K10 CKSSYB104K10

C C C C C

201 203 251 252 253

(B,129,103) (B,126,103) 2.2 uF (B,116,107) (B,110,94) (B,113,103)

CKSSYB222K50 CCG1218 CCSSCH100D50 CCSSCH101J50 CKSRYB105K10

C C C C C

517 518 519 520 521

(A,48,90) (A,46,85) (A,39,87) (A,33,90) (A,E) (A,39,86)

CKSSYB103K16 CKSSYB103K16 CKSSYB104K10 CCSSCJ3R0C50 CKSSYB103K16

C C C C C

254 255 256 260 261

(B,112,106) (B,114,106) (B,116,105) (B,122,105) (B,123,105)

CCSQCH223J50 CCSQCH223J50 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10

C C C C C

522 523 524 525 527

(A,36,87) (A,35,87) 10 uF (A,33,86) (A,41,90) (A,42,86)

CKSSYB103K16 CCG1192 CKSSYB223K16 CKSRYB105K10 CKSSYB103K16

C C C C C

262 263 264 265 266

(B,127,98) (B,130,99) (B,127,100) (B,135,98) 10 uF (B,126,96)

CCSSCH101J50 CKSRYB104K16 CKSRYB474K10 CCG1192 CCSSCH101J50

C C C C C

529 530 531 538 539

(A,38,92) 10 uF (A,30,83) 10 uF (A,33,83) (A,E) (A,31,82) (A,29,81)

CCG1192 CCG1192 CCSSCJ3R0C50 CKSSYB104K10 CCSSCH101J50

C C C C C

267 269 270 271 272

(B,129,95) 10 uF (B,113,87) (B,114,87) (B,116,87) (B,117,87)

CCG1192 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10

C C C C C

540 541 542 543 544

(A,35,85) (A,28,81) (A,32,79) (A,31,76) (A,E) (A,30,73) 2.2 uF

CKSSYB104K10 CKSSYB103K16 CCSSCH820J50 CKSSYB104K10 CCG1218

C C C C C

275 276 277 278 279

(B,117,85) (B,124,87) (B,130,92) 10 uF (B,108,100) (B,111,101)

CCSSCH100D50 CKSSYB104K10 CCG1192 CCSRCH102J50 CKSRYB105K10

C C C C

545 547 548 549

(A,32,77) (A,31,72) (A,34,70) (A,33,70)

CCSSCH101J50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

AVH-X1600DVD/XNUC 5

6

7

(A,E) (A,E) (A,E) (A,E)

8

A

B

C

D

E

F

175

1

Circuit Symbol and No.

A

B

C

D

E

F

2

3

Part No.

Circuit Symbol and No.

4

Part No.

C 550

(A,29,75)

CKSSYB104K10

C 1016

(B,79,71)

CKSRYB105K10

C C C C C

553 554 555 556 557

(A,32,72) (A,E) (A,34,73) (A,38,71) (A,48,83) (A,E) (A,52,85)

CCSSCH220J50 CKSSYB102K50 CKSSYB104K10 CCSSCH220J50 CKSRYB224K16

C C C C C

1017 1018 1051 1052 1053

(B,78,71) (B,76,71) (B,82,50) (B,83,50) (B,83,48)

CKSRYB105K10 CKSRYB105K10 CKSSYB474K6R3 CKSSYB474K6R3 CKSSYB474K6R3

C C C C C

558 559 560 561 562

(A,48,81) (A,51,82) (A,50,79) (A,E) (A,52,80) (A,E) (A,53,80)

CKSSYB224K6R3 CKSRYB105K10 CCSSCH100D50 CCSSCH100D50 CKSSYB472K25

C C C C C

1054 1055 1056 1057 1058

(B,79,50) (B,79,49) (B,81,50) (B,72,46) 10 uF (B,74,45)

CKSSYB103K16 CKSSYB102K50 CKSSYB103K16 CCG1192 CKSSYB102K50

C C C C C

563 564 565 566 568

(A,51,79) (A,52,78) (A,48,78) (A,52,73) (A,46,71) 2.2 uF

CKSSYB472K25 CCSSCH100D50 CKSSYB104K10 CCSSCH100D50 CCG1218

C C C C C

1059 1060 1061 1062 1063

(B,90,46) (B,73,45) (B,90,44) (B,70,46) (B,72,42) 10 uF

CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CKSRYB105K10 CCG1192

C C C C C

569 570 571 573 574

(A,46,72) (A,E) (A,46,70) (A,43,70) 2.2 uF (A,44,71) (A,48,75) (A,E)

CCSRCH220J50 CKSSYB104K10 CCG1218 CKSSYB104K10 CCSSCH220J50

C C C C C

1064 1065 1066 1067 1068

(B,74,42) (B,74,40) (B,90,40) (B,73,39) (B,90,38)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

601 602 603 604 606

(A,62,43) (A,65,43) (B,58,44) (A,63,68) (A,71,54)

CKSSYB104K10 CKSSYB104K10 CKSSYB331K50 CKSSYB104K10 CCSSCH8R0D50

C C C C C

1069 1070 1071 1072 1073

(B,89,36) (B,73,35) (B,68,35) (B,74,29) 10 uF (B,79,33)

CKSSYB104K10 CCSSCH5R0C50 CCSSCH5R0C50 CCG1192 CKSSYB104K10

C C C C C

607 608 610 612 613

(A,68,57) (A,68,60) (B,64,56) (B,65,59) (A,44,54)

CCSSCH100D50 CKSSYB104K10 CKSSYB104K10 CKSSYB102K50 CKSSYB104K10

C C C C C

1074 1075 1076 1078 1079

(B,81,33) (B,74,32) (B,71,29) 10 uF (B,86,54) (B,89,54)

CKSSYB104K10 CKSSYB103K16 CCG1192 CKSRYB105K10 CKSRYB105K10

C C C C C

614 615 619 620 621

(A,57,73) (A,57,74) 0.1 uF (A,73,63) 1 uF (A,68,59) 1 uF (A,57,72)

CKSSYB103K16 CCG1321 DCH1246 DCH1246 CCSSCH102J50

C C C C C

1080 1081 1082 1083 1085

(B,85,50) (B,85,49) (B,83,54) (B,79,55) (B,76,34) (A,E)

CKSSYB103K16 CKSSYB102K50 CKSRYB105K10 CKSRYB105K10 CCSSCH5R0C50

C C C C C

751 753 754 756 801

(B,49,22) (B,47,19) 10 uF (B,52,17) 10 uF (A,134,69) (A,76,98)

CKSSYB104K10 CCG1192 CCG1192 CKSSYB104K10 XCEHAT332M16

C C C C C

1086 1101 1102 1103 1104

(B,88,46) (B,135,38) (B,131,33) (B,127,33) (B,122,34)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

821 831 841 861 1001

(A,49,104) (B,63,78) (B,68,76) (A,54,102) (B,88,61)

CKSRYB104K50 CKSRYB104K50 CKSRYB105K10 CKSRYB104K50 CKSSYB104K10

C C C C C

1105 1106 1107 1108 1152

(B,110,38) (B,129,49) (B,125,49) (B,120,49) (B,98,49) 10 uF

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CCSSCH470J50 CCG1192

C C C C C

1002 1003 1004 1005 1006

(B,85,61) (B,81,61) (B,77,61) (B,89,65) (B,93,67) 10 uF

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CCG1192

C C C C C

1153 1154 1155 1156 1201

(B,104,55) (B,102,56) 10 uF (B,98,53) (B,109,54) (B,109,38)

CKSSYB104K10 CCG1192 CKSSYB182K50 CKSSYB182K50 CKSSYB104K10

C C C C C

1007 1008 1009 1010 1011

(B,85,65) (B,80,65) (B,76,65) (B,90,71) (B,88,71)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSRYB105K10 CKSRYB105K10

C C C C C

1202 1251 1301 1302 1303

(B,109,39) (B,139,53) (A,96,25) (A,100,25) (A,103,26)

CKSSYB102K50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C

1012 1013 1014 1015

(B,86,71) (B,85,71) (B,83,72) (B,81,71)

CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10

C C C C

1304 1305 1306 1307

(A,106,25) (A,108,24) (A,110,25) (A,114,25)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

176

AVH-X1600DVD/XNUC 1

2

3

4

5

Circuit Symbol and No.

6

7

Part No.

8

Circuit Symbol and No.

Part No.

C 1308

(A,117,25)

CKSSYB104K10

C 1369

(A,82,41)

CCSSCH560J50

C C C C C

1309 1310 1311 1312 1313

(B,109,43) (A,124,30) (A,124,32) (A,124,34) (A,125,36)

CCSSCH470J50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1370 1371 1372 1373 1374

(A,82,40) (A,80,41) (A,80,42) (A,79,42) (A,77,42)

CCSSCH560J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50

C C C C C

1314 1315 1316 1317 1318

(A,124,38) (A,124,40) (A,124,41) (A,125,43) (A,124,46)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1375 1376 1377 1379 1380

(A,81,46) (A,79,46) (A,81,50) (A,81,52) (A,81,54)

CCSSCH560J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50

C C C C C

1319 1320 1321 1322 1323

(A,124,49) (B,122,52) (B,122,53) (A,123,54) (A,125,57)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1382 1383 1384 1386 1387

(A,86,26) (A,86,33) (A,110,60) 1 uF (B,139,48) (B,108,26)

CCSSCH150J50 CCSSCH6R0D50 DCH1246 CCSRCH102J50 CCSRCH331J50

C C C C C

1324 1325 1326 1327 1328

(A,94,60) (A,96,60) (A,101,59) (A,102,60) (B,105,57)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1388 1389 1390 1399 1601

(B,136,48) (B,110,26) (A,90,30) (A,E) (A,128,39) (A,156,105)

CCSRCH331J50 CCSRCH102J50 CCSSCH100D50 CKSRYB224K16 CKSRYB104K50

C C C C C

1329 1330 1331 1332 1333

(B,106,57) (A,105,60) (B,107,57) (A,109,60) (A,113,60)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1607 1608 1609 1610 1611

(A,46,112) (A,36,115) (A,42,115) (A,32,111) (A,40,110)

CCSRCH270J50 CCSRCH270J50 CCSRCH270J50 CCSRCH270J50 CCSRCH270J50

C C C C C

1334 1335 1336 1337 1338

(B,111,57) (A,114,60) (A,106,63) 1 uF (A,103,63) (A,102,67)

CKSSYB104K10 CKSSYB104K10 DCH1246 CCSSCH100D50 CCSSCH100D50

C C C C C

1612 1621 1622 1624 1631

(A,27,115) (A,E) (B,139,111) (B,119,110) (B,131,111) (B,45,107) 4.7 uF

CCSRCH270J50 CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 CCG1201

C C C C C

1339 1340 1341 1342 1343

(A,110,64) (A,116,65) (B,93,22) (B,92,32) (B,92,33)

CCSSCH120J50 CCSSCH120J50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1632 1633 1634 1635 1636

(B,39,107) (B,43,107) (B,37,107) (B,41,107) (B,35,107)

CCG1201 CCG1201 CCG1201 CCG1201 CCG1201

C C C C C

1344 1345 1346 1347 1348

(B,92,37) (B,92,38) (B,92,41) (B,92,42) (B,92,45)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C C

1661 1701 1702 1703 1704 1707

(B,126,13) (B,65,25) (B,63,25) (A,83,32) (B,78,29) (B,51,34) (E)

CKSSYB471K50 CKSSYB471K50 CKSSYB104K10 CKSSYB104K16 CKSSYB104K10 CKSRYB105K10

C C C C C

1349 1350 1351 1352 1353

(B,92,46) (B,93,48) (A,84,49) (B,93,49) (A,89,50)

CKSSYB104K10 CKSSYB104K10 CCSSCH120J50 CKSSYB104K10 CCSSCH120J50

C C C C C

1721 1722 1723 1724 1725

(A,122,101) (A,130,93) (A,134,100) (A,131,100) (A,127,103)

CCSSCH101J50 CKSRYB105K10 CKSRYB105K10 CCSSCH101J50 CKSSYB104K10

C C C C C

1354 1355 1356 1357 1358

(B,93,51) (B,108,22) (B,138,46) (B,106,25) 10 uF (B,139,45) 10 uF

CKSSYB104K10 CKSSYB103K16 CKSSYB103K16 CCG1192 CCG1192

C C C C C

1731 1732 1733 1734 1735

(A,125,104) 2.2 uF (A,124,104) 2.2 uF (A,122,110) (A,119,112) (A,120,109) 2.2 uF

CCG1218 CCG1218 CKSSYB104K10 CCSSCH101J50 CCG1218

C C C C C

1360 1361 1362 1363 1364

(A,87,30) (B,101,34) (A,84,34) (A,83,35) (A,82,35)

CCSSCH470J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50

C C C C C

1801 1802 1803 1804 1821

(A,64,76) (B,57,85) (B,63,82) (A,75,86) (A,101,99)

XCEHVW470M16 CKSSYB104K10 CKSRYB104K50 XCEHAT102M16 XCEHVW101M16

C C C C

1365 1366 1367 1368

(A,86,37) (A,84,37) (A,83,38) (A,81,38)

CCSSCH560J50 CCSSCH560J50 CCSSCH560J50 CCSSCH560J50

(A,84,102) (B,35,62) 10 uF (B,32,61)

CKSRYB105K16 CCG1192 CKSRYB105K10

C 1822 C 1901 C 1902

AVH-X1600DVD/XNUC 5

6

7

(A,E) (A,E) (A,E) (A,E) (A,E)

4.7 uF 4.7 uF 4.7 uF 4.7 uF 4.7 uF

8

A

B

C

D

E

F

177

1

Circuit Symbol and No.

A

B

C

D

E

F

2

3

Part No.

C 1951 C 1952

(B,150,66) (B,150,69)

CCSSCH471J50 CKSSYB103K16

C C C C C

1953 1954 1955 1956 1957

(B,152,68) (B,164,68) (B,165,68) (B,165,65) (A,163,39)

CCSSCH8R0D50 CCSSCH8R0D50 CKSSYB103K16 CCSSCH102J50 CKSSYB102K50

C C C C C

1958 1959 1960 1961 1963

(A,163,40) (A,162,42) 10 uF (A,162,44) 10 uF (A,162,47) 47 uF (B,159,73)

CKSSYB104K10 CCG1236 CCG1236 CCG1229 CKSRYB473K50

C C C C C

1964 1965 1966 1967 1968

(B,156,73) (B,157,82) 10 uF (B,159,63) (B,157,79) 10 uF (B,157,77) 10 uF

CKSRYB102K50 CCG1236 CKSSYB104K10 CCG1236 CCG1236

C C C C C

1969 1970 1971 1972 1974

(B,164,69) (B,152,70) (B,157,63) (B,152,66) (A,152,48) 47 uF

CKSSYB104K16 CKSSYB104K16 CKSSYB104K10 CKSRYB105K10 CCG1229

C C C C C

1975 1976 1977 1978 1979

(B,158,86) (A,152,45) 10 uF (B,157,84) 10 uF (A,152,43) 10 uF (A,164,83)

CKSRYB102K50 CCG1236 CCG1236 CCG1236 XCEHAT332M16

C C C C C

1980 1981 2011 2012 2023

(A,151,41) (A,151,40) (B,109,15) (B,122,12) (B,85,25) 10 uF

CKSSYB104K10 CKSSYB102K50 CKSRYB105K10 CKSRYB105K10 CCG1192

C C C C C

2031 2032 2071 2083 2101

(B,76,23) (B,80,25) (A,147,37) (A,21,15) (A,157,90)

CKSRYB105K10 CKSRYB105K10 CKSSYB104K10 CKSSYB104K10 CKSSYB103K16

C C C C C

2102 2105 2106 2107 2108

(A,156,88) 10 uF (B,168,100) (B,163,91) (B,159,94) 10 uF (B,158,92)

CCG1236 CKSSYB682K25 CKSSYB103K16 CCG1236 CKSSYB103K16

C C C C C

2109 2151 2152 2161 2162

(A,154,82) (A,49,23) (A,140,85) (A,E) (B,170,103) (B,158,104) 10 uF

XCEHVW470M16 CKSRYB104K16 CKSSYB102K50 CKSSYB104K16 CCG1236

C C C C C

2163 2164 2165 2166 2167

(A,165,118) (B,167,113) (B,172,113) (B,170,113) (B,171,106)

XCEHVW101M16 CKSRYB105K10 CKSSYB102K50 CKSSYB472K25 CKSSYB104K16

C C C C C

2168 2169 2170 2172 2173

(B,163,113) (B,157,109) (B,158,109) (A,164,110) (B,160,108)

CCSSCH471J50 CKSSYB222K50 CCSSCH270J50 XCEHVW470M16 CKSSYB104K16

(A,156,107) (A,159,106) 22 uF (B,117,33) 2.2 uF

CKSSYB104K16 DCH1256 CCG1218

C 2185 C 2186 C 3601

178

4

Circuit Symbol and No. 2.2 uF 2.2 uF 2.2 uF 2.2 uF

Part No.

C C C C

3602 3603 3604 3605

(B,117,32) (B,117,30) (B,117,27) (B,117,25)

CCG1218 CCG1218 CCG1218 CCG1218

C C C C C

3641 3642 3721 3722 3723

(B,80,35) (B,70,21) (B,106,30) (A,118,35) (A,119,39)

CKSRYB104K50 CKSRYB104K50 CKSRYB102K50 CKSRYB102K50 CKSRYB102K50

C C C C

3724 3725 3726 3744

(A,117,43) (A,121,43) (A,125,43) (A,77,35)

CKSRYB102K50 CCSRCH180J50 CCSRCH180J50 CKSRYB105K10

C Unit Number : YWX5032 Unit Name

: DVD Core Unit

MISCELLANEOUS IC 1002 IC 1003 IC 1004 IC 1251 IC 1401

(B,15,13) (B,37,11) (B,64,28) (A,12,42) (B,27,41)

Regulator IC IC IC IC Flash ROM Unit

S-1133B50-U5 S-1200B50-M5 NJM2855DL1-33 BA5839FP CWW5043

IC 1402 IC 1480 IC 1501 IC 1801 IC 1951

(B,45,28) (A,64,30) (A,39,33) (B,34,16) (A,28,49)

Flash ROM Unit RAM IC IC D/A Converter Logic IC

CWW5044 M12L64164A-5TG2Y MN2DS0018MA PCM1753DBQ TC7SZU04FU

IC 1953 Q 1101 Q 1102 Q 1103 Q 1104

(B,57,17) (B,13,59) (B,13,56) (B,10,63) (B,22,54)

IC Transistor Transistor Transistor Transistor

S-1135D12-A6 LSCR523UB LSCR523UB 2SB1132 2SB1132

D D L L L

1901 1902 1501 1511 1902

(B,50,10) Diode (B,50,9) Diode (A,54,31) Inductor (A,48,17) Chip Beads (A,17,17) Inductor

L L X X F

1903 1904 1501 1950 1001

(B,63,16) (A,68,18) (B,48,18) (A,23,51) (A,14,19)

RSB6R8SM RSB6R8SM CTF1743 VTL1126 CTF1487

Inductor CTF1558 Ferrite Bead CTF1528 Oscillator 27.000 MHz CSS1823 Oscillator 48.000 MHz CSS1760 Chip EMI Filter DTF1106

F 1002 S 1 S 3 VR1101 VR1102

(B,63,18) Chip EMI Filter DTL1106 (A,47,55) Spring Switch(HOME) CSN1080 (B,25,13) Spring Switch(12EJ) CSN1081 (A,7,63) Semi-fixed 6.8 kohm(B) CCP1447 (A,7,60) Semi-fixed 15 kohm(B) CCP1449

CN1101 CN1952

(A,21,63) Connector (A,42,11) Connector

CKS6331 CKS6025

RESISTORS R R R R R

1004 1007 1019 1025 1027

(B,12,20) (B,12,21) (B,34,7) (B,36,6) (A,40,18)

RS1/16SS4702D RS1/16SS6801D RS1/16SS101J RS1/16SS101J RS1/16SS101J

AVH-X1600DVD/XNUC 1

2

3

4

5

Circuit Symbol and No.

6

7

Part No.

Circuit Symbol and No.

8

Part No.

R R R R R

1101 1102 1103 1104 1105

(B,15,57) (B,10,56) (B,14,61) (B,11,59) (B,17,54)

RS1/16SS104J RS1/16SS104J RS1/16SS4300F RS1/16SS5100F RS1/16SS4300F

R R R R R

1525 1526 1527 1528 1529

(A,24,44) (A,22,40) (A,35,49) (B,19,34) (B,35,21)

RS1/16SS103J RS1/16SS103J RS1/16SS682J RS1/16SS103J RS1/16SS103J

R R R R R

1106 1109 1110 1111 1112

(B,10,57) (B,6,57) (B,16,54) (B,6,63) (B,5,58)

RS1/16SS5600F RS1/16SS3R3J RS1/16SS3R3J RS1/10SR3R3J RS1/10SR3R3J

R R R R R

1530 1531 1532 1534 1535

(B,17,34) (B,33,30) (A,24,42) (B,29,48) (A,22,44)

RS1/16SS103J RS1/16SS103J RS1/16SS101J RS1/16SS221J RS1/16SS104J

R R R R R

1113 1114 1115 1116 1117

(B,15,59) (B,19,57) (B,6,61) (B,6,62) (B,17,59)

RS1/10SR3R9J RS1/10SR3R3J RS1/10SR2R7J RS1/10SR2R7J RS1/10SR3R9J

R R R R R

1536 1537 1538 1539 1540

(B,32,48) (A,24,46) (A,55,35) (B,33,48) (A,26,46)

RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS221J

R R R R R

1118 1223 1225 1251 1252

(B,16,59) (A,42,50) (B,29,8) (A,5,48) (A,5,47)

RS1/10SR3R9J RS1/16SS561J RS1/16SS471J RS1/16SS333J RS1/16SS473J

R R R R R

1541 1542 1543 1544 1546

(A,26,45) (B,26,34) (A,32,48) (A,36,48) (A,33,49)

RS1/16SS221J RS1/16SS103J RS1/16SS181J RS1/16SS181J RS1/16SS682J

R R R R R

1253 1254 1255 1256 1257

(A,5,46) (A,5,45) (A,21,48) (A,21,46) (B,8,37)

RS1/16SS333J RS1/16SS473J RS1/16SS183J RS1/16SS752J RS1/16SS221J

R R R R R

1601 1602 1603 1604 1605

(A,32,17) (A,32,18) (B,31,21) (A,23,21) (A,22,23)

RS1/16SS123J RS1/16SS123J RS1/16SS1002D RS1/16SS105J RS1/16SS105J

R R R R R

1258 1401 1402 1405 1406

(A,19,39) (B,34,28) (B,34,47) (B,55,35) (B,39,45)

RS1/16SS221J RS1/16SS221J RS1/16SS104J RS1/16SS104J RS1/16SS472J

R R R R R

1670 1671 1672 1674 1801

(B,40,21) (B,42,19) (A,39,18) (A,36,17) (B,41,8)

RS1/16SS1002D RS1/16SS2402D RS1/16SS2000D RS1/16SS3002D RS1/16SS104J

R R R R R

1480 1481 1482 1483 1484

(A,72,24) (A,72,28) (A,72,32) (A,72,35) (A,72,39)

RAB4CQ560J RAB4CQ560J RAB4CQ560J RAB4CQ560J RAB4CQ560J

R R R R R

1802 1803 1804 1950 1951

(B,43,8) (B,37,13) (B,39,14) (A,44,18) (A,42,18)

RS1/16SS104J RS1/16SS821J RS1/16SS821J RS1/10SR24R0F RS1/10SR24R0F

R R R R R

1485 1486 1487 1488 1489

(A,55,22) (A,55,28) (A,56,37) (A,55,40) (A,54,30)

RAB4CQ560J RAB4CQ560J RAB4CQ560J RAB4CQ560J RS1/16SS560J

R R R R R

1952 1953 1954 1955 1982

(A,26,50) (A,26,51) (A,48,5) (A,50,5) (A,10,62)

RS1/16SS105J RS1/16SS821J RS1/16SS153J RS1/16SS153J RS1/16SS822J

R R R R R

1490 1501 1503 1504 1505

(A,72,21) (B,48,21) (B,46,21) (A,50,17) (B,45,15)

RS1/16SS560J RS1/16SS122J RS1/16SS105J RS1/16SS121J RS1/16SS101J

R 1983 R 1987

(B,40,20) (B,43,21)

RS1/16SS1000D RS1/16SS0R0J

R R R R R

1506 1507 1508 1509 1510

(B,45,14) (B,43,17) (B,42,18) (A,20,34) (A,11,29)

RS1/16SS101J RS1/16SS101J RS1/16SS221J RS1/16SS102J RS1/16SS102J

R R R R R

1512 1513 1514 1516 1517

(A,55,32) (A,23,38) (A,24,40) (A,24,36) (B,57,22)

RS1/16SS470J RS1/16SS103J RS1/16SS183J RS1/16SS104J RS1/16SS103J

R R R R R

1518 1519 1522 1523 1524

(B,33,31) (A,24,43) (A,21,37) (A,22,37) (B,29,33)

RS1/16SS103J RS1/16SS102J RS1/16SS104J RS1/16SS221J RS1/16SS472J

A

B

C

D

CAPACITORS C C C C C

1001 1002 1003 1004 1005

(B,34,10) (B,12,17) (B,15,19) (B,15,17) 4.7 uF (B,40,11)

CKSRYB105K10 CKSSYB104K16 CKSSYB104K16 CCG1201 CKSRYB105K16

C C C C C

1010 1011 1015 1016 1018

(B,60,23) (B,64,22) (A,25,7) (B,64,15) (B,14,21)

CKSQYB225K10 CKSRYB105K10 CKSSYB102K50 CKSSYB102K50 CKSSYB104K10

C C C C C

1040 1041 1101 1104 1105

(B,51,7) (B,19,11) (B,14,53) 10 uF (B,7,57) (B,18,54)

CCSRCH821J50 CCSRCH271J50 CCG1192 CKSSYB104K10 CKSSYB104K10

AVH-X1600DVD/XNUC 5

6

7

8

E

F

179

1

Circuit Symbol and No.

A

B

C

2

3

Part No.

4

Circuit Symbol and No.

Part No.

C C C C C

1106 1107 1108 1109 1110

(B,8,66) (B,25,53) (A,19,57) (A,7,57) (A,17,58)

CKSSYB103K16 CKSSYB103K16 CKSSYB103K16 CKSRYB224K16 CKSSYB103K16

C C C C C

1606 1607 1608 1609 1612

(A,35,19) (A,20,24) 10 uF (A,28,18) 4.7 uF (A,26,22) (A,24,24)

CKSSYB104K10 CCG1192 CCG1201 CKSSYB104K10 CKSSYB104K10

C C C C C

1111 1112 1113 1210 1251

(A,9,66) (B,17,52) 22 uF (B,8,58) 22 uF (B,77,34) (B,12,41)

CKSRYB224K16 DCH1256 DCH1256 CKSSYB104K16 CEVW101M16

C C C C C

1613 1614 1615 1616 1617

(A,24,25) (A,22,24) (A,23,26) (A,24,27) (B,27,28)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1252 1253 1254 1255 1401

(B,7,41) 4.7 uF (B,7,39) (A,6,38) (A,18,37) (B,34,27)

CCG1222 CKSSYB104K16 CKSSYB104K16 CKSSYB104K16 CKSSYB104K16

C C C C C

1618 1619 1620 1621 1622

(A,22,29) (A,23,30) (B,27,30) (A,22,31) (A,24,31)

CCSSCH101J50 CKSSYB562K25 CKSSYB224K6R3 CKSSYB224K6R3 CKSSYB333K16

C C C C C

1403 1404 1408 1409 1410

(B,39,40) (B,40,40) 4.7 uF (B,57,27) (B,58,29) 4.7 uF (B,33,29)

CKSSYB104K10 CCG1201 CKSSYB104K10 CCG1201 CKSSYB104K16

C C C C C

1623 1624 1625 1671 1673

(A,27,20) (A,24,32) (A,24,29) (A,41,18) (A,37,19)

CKSRYB105K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1480 1481 1482 1484 1485

(A,71,19) (A,72,22) (A,72,26) (A,72,30) (A,72,41)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1674 1676 1801 1802 1803

(B,42,20) (B,38,21) (B,42,10) 4.7 uF (B,46,10) 4.7 uF (B,42,12)

CKSSYB104K10 CKSRYB105K10 CCG1201 CCG1201 CCSRCH182J50

C C C C C

1487 1488 1489 1490 1501

(A,57,29) (A,57,25) (A,64,17) 10 uF (A,66,18) (B,61,20) 10 uF

CKSSYB104K10 CKSSYB104K10 CCG1192 CKSSYB102K50 CCG1192

C C C C C

1804 1805 1806 1809 1950

(B,45,12) (B,34,13) (B,32,13) 10 uF (B,39,16) (A,27,51)

CCSRCH182J50 CKSSYB104K10 CCG1192 CKSSYB104K10 CKSSYB104K10

C C C C C

1502 1503 1504 1505 1506

(B,54,20) 10 uF (A,54,33) (A,53,24) (A,53,27) (B,52,35)

CCG1192 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1951 1952 1953 1954 1955

(A,23,54) (A,24,48) (B,60,17) (B,54,17) (B,77,40)

CCSSCH100D50 CCSSCH100D50 CKSRYB105K10 CKSRYB105K10 CKSSYB104K16

C C C C C

1507 1508 1509 1510 1511

(A,53,36) (A,53,39) (A,53,42) (B,51,18) (A,48,18)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CCSSCH100D50 CKSSYB104K10

C C C C C

1512 1513 1514 1515 1516

(B,45,18) (A,48,48) (B,45,21) (A,45,18) (A,43,48)

CCSSCH100D50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1517 1518 1519 1520 1521

(A,42,48) (A,38,48) (A,34,47) (A,27,47) (A,24,34)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

1522 1523 1524 1526 1528

(A,25,38) (A,20,46) (A,20,48) (A,24,37) (B,30,48)

CKSSYB104K10 CKSSYB224K6R3 CKSSYB473K16 CKSSYB103K16 CCSSCH471J50

C C C C C

1601 1602 1603 1604 1605

(A,32,19) (A,34,17) (A,33,18) (A,30,17) (A,30,18)

CKSSYB103K16 CCSSCH101J50 CCSSCH101J50 CCSSCH680J50 CCSSCH680J50

D

E

F

180

D Unit Number : CXX6055 Unit Name

: Service Unit(Monitor)

MISCELLANEOUS IC 5101 IC 5102 IC 5201 IC 5301 Q 5101 Q 5103

(A,25,67) IC (A,71,40) Regulator IC (A,110,69) IC (A,114,26) IC (A,30,61) Transistor (A,13,28) Transistor

R1290K103A MM3479A33P BD81A04EFV-M AK4187VN LTC014EEB LSAR523UB

Q Q Q D D D

5106 5401 5402 5101 5103 5104

(A,24,76) Transistor (A,101,42) Chip Transistor (A,99,45) Transistor (A,17,71) Diode (A,32,75) Diode (A,34,75) Diode

2SA1577 HN1C01FU LSCR523UB RB162M-40 DB3S308F0 DB3S308F0

D D D L L

5105 5132 5201 5001 5002

(A,34,67) Diode (A,72,49) Diode (A,111,56) Diode (A,9,46) Inductor (A,9,52) Chip Inductor

DB3S308F0 CRG03 RB060M-30 CTF1635 DTL1096

AVH-X1600DVD/XNUC 1

2

3

4

5

Circuit Symbol and No. L L L L L

5003 5004 5101 5102 5202

6

7

Part No.

Circuit Symbol and No.

(A,21,44) Chip Inductor (A,14,36) Chip Ferrite Bead (A,21,73) Choke Coil 22 uH (A,8,32) Inductor (A,106,58) Inductor

DTL1096 BTX1042 CTH1426 LCTAW101J2520 CTH1526

L 5205 L 5303 TH5201 CN5001 CN5202

(A,109,62) Chip Beads (A,112,18) Chip Beads (A,104,15) Thermistor (A,34,32) Connector (A,127,31) Connector

VTL1128 VTL1134 CCX1058 CKS6536 CKS6523

CN5301 CN5401 CN5402

(A,121,17) Connector (A,58,69) Connector (A,113,42) Connector

CKS6548 CKS6536 CKS6063

RESISTORS R R R R R R R

5001 5002 5003 5004 5005 5006 5007

(A,60,18) (A,62,18) (A,61,20) (A,60,21) (A,61,22) (A,60,22) (A,61,23)

RS1/16SS4R7J RS1/16SS56R0D RS1/16SS1800D RS1/16SS2R2J RS1/16SS47R0D RS1/16SS0R0J RS1/16SS39R0D

R R R R R

5008 5009 5010 5011 5012

(A,60,24) (A,61,25) (A,60,26) (A,61,27) (A,60,28)

RS1/16SS4R7J RS1/16SS1000D RS1/16SS8R2J RS1/16SS1300D RS1/16SS0R0J

R R R R R

5013 5014 5015 5016 5017

(A,61,29) (A,60,30) (A,61,31) (A,61,33) (A,64,33)

RS1/16SS1000D RS1/16SS8R2J RS1/16SS39R0D RS1/16SS4R7J RS1/16SS47R0D

R R R R R

5018 5019 5020 5021 5022

(A,66,33) (A,67,33) (A,69,33) (A,70,32) (A,70,30)

RS1/16SS0R0J RS1/16SS1800D RS1/16SS2R2J RS1/16SS33R0D RS1/16SS2R4J

R R R R R

5024 5026 5028 5029 5101

(B,30,35) (B,24,35) (B,25,33) (B,26,35) (A,17,60)

RS1/16SS473J RS1/16SS473J RS1/16SS473J RS1/16SS473J RS1/16SS103J

R R R R R

5103 5104 5106 5107 5108

(A,24,61) (A,25,60) (A,27,63) (A,21,70) (A,24,73)

RS1/16SS203J RS1/16SS104J RS1/16SS472J RS1/16SS0R0J RS1/16SS103J

R R R R R

5109 5110 5111 5112 5116

(A,30,63) (A,28,64) (A,28,63) (B,65,79) (A,21,63)

RS1/16SS1502D RS1/16SS8201D RS1/16SS1502D RS1/16SS0R0J RS1/16SS3001D

R R R R R

5117 5122 5124 5125 5126

(A,21,62) (A,9,28) (A,10,28) (A,13,30) (A,14,30)

RS1/16SS1502D RS1/16SS472J RS1/16SS105J RS1/16SS682J RS1/16SS0R0J

R 5128 R 5129 R 5134

(A,15,35) (A,15,32) (A,16,62)

RS1/16SS101J RS1/16SS0R0J RS1/16SS0R0J

R 5135 R 5136

(A,19,62) (A,18,62)

RS1/16SS1203D RS1/16SS472J

R R R R R

5140 5141 5142 5143 5144

(A,30,67) (A,30,66) (A,31,69) (A,29,69) (B,23,68)

RS1/16SS9102D RS1/16SS1802D RS1/16SS1003D RS1/16SS9101D RS1/16SS0R0J

R R R R R

5202 5203 5205 5206 5207

(A,113,76) (A,114,76) (B,108,66) (B,108,67) (A,97,74)

RS1/16SS273J RS1/16SS511J RS1/16SS1503D RS1/16SS1003D RS1/16SS101J

R R R R R

5212 5213 5219 5220 5222

(B,106,65) (B,106,66) (A,103,74) (A,103,73) (A,74,63)

RS1/16SS3603D RS1/16SS2402D RS1/16SS104J RS1/16SS154J RS1/10SR0R0J

R R R R R

5223 5225 5302 5304 5305

(A,132,71) (A,112,60) (B,119,21) (A,109,27) (A,109,28)

RS1/10SR0R0J RS1/8SQ2R2J RS1/16SS201J RS1/16SS472J RS1/16SS472J

R R R R R

5306 5307 5308 5309 5310

(A,119,25) (A,118,25) (A,118,27) (B,110,27) (B,117,25)

RS1/16SS0R0J RS1/16SS621J RS1/16SS181J RS1/16SS101J RS1/16SS0R0J

R R R R R

5311 5312 5318 5401 5402

(A,109,29) (A,119,26) (B,111,24) (A,102,45) (A,103,45)

RS1/16SS101J RS1/16SS620J RS1/16SS101J RS1/16SS680J RS1/16SS560J

R R R R R

5405 5406 5409 5410 5413

(A,100,40) (A,99,40) (A,97,44) (A,96,44) (A,99,42)

RS1/16SS680J RS1/16SS560J RS1/16SS680J RS1/16SS560J RS1/16SS103J

R R R R R

5414 5415 5416 5417 5418

(A,101,39) (A,96,46) (A,39,60) (A,40,61) (A,41,60)

RS1/16SS103J RS1/16SS103J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J

R R R R R

5419 5420 5421 5422 5423

(A,42,61) (A,44,61) (A,44,58) (A,43,57) (A,45,58)

RS1/16SS0R0J RS1/16SS270J RS1/16SS0R0J RS1/16SS270J RS1/16SS270J

R R R R R

5424 5425 5426 5427 5428

(A,45,57) (A,47,58) (A,47,56) (A,48,58) (A,48,56)

RS1/16SS270J RS1/16SS270J RS1/16SS270J RS1/16SS270J RS1/16SS270J

R R R R R

5429 5430 5431 5432 5433

(A,50,58) (A,50,56) (A,51,58) (A,51,56) (A,52,56)

RS1/16SS270J RS1/16SS270J RS1/16SS270J RS1/16SS270J RS1/16SS270J

R 5434 R 5435 R 5436

(A,53,58) (A,54,56) (A,55,58)

RS1/16SS270J RS1/16SS270J RS1/16SS270J

AVH-X1600DVD/XNUC 5

6

8

Part No.

7

8

A

B

C

D

E

F

181

1

Circuit Symbol and No.

A

2

3

Part No.

R 5437 R 5438

(A,55,56) (A,56,58)

RS1/16SS270J RS1/16SS270J

R 5439 R 5440

(A,57,56) (A,59,58)

RS1/16SS270J RS1/16SS0R0J

CAPACITORS

B

C

D

E

F

C C C C C

5009 5010 5011 5012 5021

(A,63,27) (A,63,28) (A,63,29) (A,63,30) (A,31,37)

CKSSYB102K50 CKSSYB104K16 CKSSYB102K50 CKSSYB104K16 CKSSYB102K50

C C C C C

5023 5025 5026 5029 5030

(A,31,39) (A,15,47) 10 uF (A,8,44) (A,28,38) (A,28,39)

CKSSYB104K16 CCG1236 CKSSYB102K50 CKSSYB102K50 CKSSYB104K10

C C C C C

5031 5034 5035 5037 5039

(A,9,50) 10 uF (A,22,40) (A,21,42) 4.7 uF (A,17,43) (A,20,38)

CCG1192 CKSSYB104K16 CCG1201 CKSQYB225K16 CKSRYB104K50

C C C C C C

5040 5042 5101 5102 5103 5104

(A,17,37) (A,16,33) (A,20,78) 4.7 uF (A,21,67) (A,20,66) 1 uF (A,21,60)

CKSQYB334K50 CKSSYB104K16 CCG1201 CKSSYB102K50 DCH1246 CKSSYB123K16

C C C C C

5105 5106 5107 5109 5110

(A,23,60) (A,28,60) (A,24,62) (A,32,63) (A,35,64)

CKSSYB104K10 CKSRYB105K10 CKSSYB682K25 CCSSCH101J50 CKSSYB122K50

C C C C C

5111 5112 5113 5114 5115

(A,15,64) 10 uF (A,15,67) 10 uF (A,21,64) (A,11,28) (A,8,30) 10 uF

CCG1236 CCG1236 CKSSYB471K50 CKSSYB104K16 CCG1236

C C C C C

5116 5117 5118 5120 5121

(A,69,44) 4.7 uF (A,73,44) 4.7 uF (A,60,63) (A,33,72) (A,35,72)

CCG1201 CCG1201 CKSSYB104K10 CKSQYB105K25 CKSQYB105K25

C C C C C

5122 5123 5124 5125 5127

(A,32,67) (A,35,66) (A,31,77) (A,34,77) (A,28,73)

CKSRYB105K10 CKSRYB104K50 CKSQYB474K25 CKSQYB474K25 CKSYB475K16

C C C C C

5128 5140 5203 5204 5205

(A,74,38) (A,31,70) (B,110,66) 2.2 uF (A,115,76) (A,101,62) 10 uF

CKSSYB104K10 CKSSYB561K50 CCG1218 CKSSYB104K10 CCG1236

C C C C C

5206 5208 5209 5211 5212

(A,114,77) (A,116,56) 10 uF (A,104,17) (A,118,56) 10 uF (A,122,63)

CKSSYB104K10 CCG1236 CKSSYB104K10 CCG1236 CCSSCH101J50

(A,79,65) (A,116,74)

CKSSYB104K16 CKSSYB104K16

C 5213 C 5214

182

4

Circuit Symbol and No.

Part No.

C 5215 C 5301 C 5302

(A,114,60) (A,113,21) 10 uF (A,108,24) 10 uF

CKSSYB332K50 CCG1192 CCG1192

C C C C C

5303 5304 5305 5306 5307

(A,114,23) (A,110,25) (B,123,25) (B,116,25) (A,117,24)

CKSSYB104K10 CKSSYB104K10 CKSSYB103K16 CKSSYB103K16 CKSSYB103K16

C 5308 C 5314 C 5401

(B,121,21) (A,106,23) (A,68,64)

CKSSYB103K16 CKSSYB104K10 CKSSYB104K10

E Unit Number : CXX6059 Unit Name

: Service Unit(Keyboard)

MISCELLANEOUS IC 4801 D 4801 S 4801 S 4802

(A,9,90) IR RC REC Module (A,14,43) LED (A,12,18) Push Switch (A,12,7) Push Switch

PNJ4833M SMLVN6RGB2UK(B) CSG1155 CSG1155

S S S S S

4803 4804 4805 4806 4807

(A,12,28) Push Switch (A,8,43) Push Switch (A,23,93) Push Switch (A,12,58) Push Switch (A,12,79) Push Switch

CSG1155 CSG1155 CSG1155 CSG1155 CSG1155

S 4808 S 4809 CN4801

(A,12,69) Push Switch (A,17,93) Push Switch (B,14,43) Connector

CSG1155 CSG1155 CKS6063

RESISTORS R R R R R

4801 4802 4803 4804 4805

(B,8,72) (A,10,12) (A,9,13) (A,7,38) (A,15,63)

RS1/16SS470J RS1/16SS222J RS1/16SS472J RS1/16SS123J RS1/16SS182J

R 4806 R 4807 R 4808

(A,14,65) (A,14,72) (A,10,13)

RS1/16SS222J RS1/16SS472J RS1/16SS182J

CAPACITORS C 4805

(B,11,91) 10 uF

CCG1192

AVH-X1600DVD/XNUC 1

2

3

4