DVD Portable Player
PET700/00/05/44/75
Service Manual TABLE OF CONTENTS Chapter
Technical Specification…………………………………………1 Safety Instructions.……………………………………………...2 Instruction for Use.……………………………………………...3 Mechanical Instructions……………………………………….. 4 Troubleshooting & Service tips……………………………….5 Overall block diagram………………………….………...…... 6 Overall wiring diagram………………………………………… 7 Electrical diagram………………………………………………. 8 Component layout……………………………………………… 9 Service part list………………………………………………….10 Revision list………………………………………………………11
©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips
3141 785 30565
Version 1.5
1.0 TECHNICAL SPECIFICATION and SERVICE HINT General
Dimensions (WxLxH):
Audio CD:
Weight: Power supply: Power consumption: Operating temp. range: Laser wavelength: Video system:
19 x 14.6 x 2.9 cm 7.48 x 5.75 x 1.14 inches 1kg / 2.2 lb DC 9V 2.2A 20W 0 - 50°C (32 ~ 122°F) 650nm NTSC / PAL / AUTO
Frequency response:
20Hz ~ 20KHz ± 1dB
Signal/noise ratio: Audio distortion + noise:
85dB -80(1KHz)
Channel separation: Dynamic range:
85dB 80dB
Output Audio out (analog audio):
Output level: 2V ± 10%
Load impedance:
10K
Video out Output level:
1Vp - p ± 20%
Load impedance:
75
Current consumption
DC-IN SUPPLY (9.0V) Battery Charging Current 1.2A typ. BATT. SUPPLY (7.2V) Power Off 0A Playback with TFT on <1.2A typ. Playback without TFT on <600mA Battery playtime >2.5hrs Headphone out (headphone output load 2x16ohm)
Maximum output power: Frequency response: SNR (A-wght): THD (1kHz): Left-Right Channel Separation: Left-Right Channel Balance: Supported disc type
DVD video discs:
Video CD:
>10mW 20Hz - 20kHz 80dB typ. <1% 32dB typ. 1dB
In addition, this unit can play DVD+R & DVD+RW and CD-R & CD-RW that contains audio titles or MP3 or JPEG files. You cannot play disc other than the above listed. (CVD, CD-ROM, CD-Extra, CD-G and CD-I discs cannot be played on this DVD player)
Software upgrades
For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available. To check the software version of your DVD Portable. 1. Press the SETUP key to enter the setup menu. 2. Press RETURN and then press 1. 2 and 3 on the remote control. 3. The display will show the software version as the date of which the software was built on the bottom of the screen. E.g. 050303 Procedure on how to upgrade the software of the DVD Portable 1. Download the latest software from the Philips support site. 2. Unzipped the files and then burn it onto a CD ROM then playback the CD ROM on the DVD Portable. Pixel specification
<= 4 (max. 0 bright dots and 3 dark dots)
2.0 SAFTETY INSTRUCTIONS
GB
NL
ESD
WARNING
Alle IC’s en vele andere halfgeleiders zijn gevoelig voor electrostatische ontladingen (ESD). Onzorgvuldig behandelen tijdens reparatie kan de levensduur drastisch doen verminderen. Zorg ervoor dat u tijdens reparatie via een polsband met weerstand verbonden bent met hetzelfde potentiaal als de massa van het apparaat. Houd componenten en hulpmiddelen ook op ditzelfde potentiaal.
All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential.
F
WAARSCHUWING
ATTENTION
I Tous les IC et beaucoup d’autres semi-conducteurs sont sensibles aux décharges statiques (ESD). Leur longévité pourrait être considérablement écourtée par le fait qu’aucune précaution n’est prise à leur manipulation. Lors de réparations, s’assurer de bien être relié au même potentiel que la masse de l’appareil et enfiler le bracelet serti d’une résistance de sécurité. Veiller à ce que les composants ainsi que les outils que l’on utilise soient également à ce potentiel.
D
AVVERTIMENTO
WARNUNG
Alle ICs und viele andere Halbleiter sind empfindlich gegenüber elektrostatischen Entladungen (ESD). Unsorgfältige Behandlung im Reparaturfall kan die Lebensdauer drastisch reduzieren. Veranlassen Sie, dass Sie im Reparaturfall über ein Pulsarmband mit Widerstand verbunden sind mit dem gleichen Potential wie die Masse des Gerätes. Bauteile und Hilfsmittel auch auf dieses gleiche Potential halten.
Tutti IC e parecchi semi-conduttori sono sensibili alle scariche statiche (ESD). La loro longevità potrebbe essere fortemente ridatta in caso di non osservazione della più grande cauzione alla loro manipolazione. Durante le riparazioni occorre quindi essere collegato allo stesso potenziale che quello della massa dell’apparecchio tramite un braccialetto a resistenza. Assicurarsi che i componenti e anche gli utensili con quali si lavora siano anche a questo potenziale.
GB Safety regulations require that the set be restored to its original condition and that parts which are identical with those specified, be used.
“Pour votre sécurité, ces documents doivent être utilisés par des spécialistes agréés, seuls habilités à réparer votre appareil en panne”.
NL Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie in zijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen, identiek aan de gespecificeerde, worden toegepast.
CLASS 1 LASER PRODUCT 3122 110 03420
F Les normes de sécurité exigent que l’appareil soit remis à l’état d’origine et que soient utiliséés les piéces de rechange identiques à celles spécifiées.
GB
Warning !
Invisible laser radiation when open. Avoid direct exposure to beam.
D Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zu beachten. Der Original zustand des Geräts darf nicht verändert werden; für Reparaturen sind Original-Ersatzteile zu verwenden.
S
Varning !
Osynlig laserstrålning när apparaten är öppnad och spärren är urkopplad. Betrakta ej strålen.
SF Varoitus ! I Le norme di sicurezza esigono che l’apparecchio venga rimesso nelle condizioni originali e che siano utilizzati i pezzi di ricambio identici a quelli specificati.
Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina näkymättömälle laserisäteilylle. Älä katso säteeseen!
DK Advarse ! "After servicing and before returning set to customer perform a leakage current measurement test from all exposed metal parts to earth ground to assure no shock hazard exist. The leakage current must not exceed 0.5mA."
Usynlig laserstråling ved åbning når sikkerhedsafbrydere er ude af funktion. Undgå udsaettelse for stråling.
2.1 ESD PROTECTION
Whenthepowersupplyisbeingturnedon,youmaynotremovethislasercautionslabel.Ifitremoves,radiationoflaser maybereceived.
PREPARATIONOFSERVICING PickupHeadconsistsofalaserdiodethatisverysusceptibletoexternalstaticelectrocity. Althoughitoperatesproperlyafterreplacement,ifitwassubjecttoelectrostaticdischargeduringreplacement, itslifemightbeshortened.Whenreplacing,useaconductivemat,solderingironwithgroundwire,etc.to protectthelaserdiodeformdamagebystaticelectricity. Andalso,theLSIandICaresameasabove.
Groundconductive wriststrapforbody.
Solderingiron withgroundwire orceramictype
1M Conductivemat Thegroundresistance betweenthegroundline andthegroundislessthan10
SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do
Measure the AC voltage across the 1500
resistor.
not use an isolation transformer for this check). Use an
The test must be conducted with the AC switch on and
AC voltmeter, having 5000 per volt or more sensitivity. Connect a 1500 10W resistor,paralleled by a 0.15uF
then repeated with the AC switch off. The AC voltage indicated by the meter may not exceed 0.3V.A reading
150V AC capacitor between a knomn good earth ground
exceeding 0.3V indicates that a dangerous potential
(water pipe, conduit, etc.) and all exposed metal parts of cabinet (antennas, handle bracket, metal cabinet screwheads, metal overlays, control shafts, etc.).
exists, the fault must be located and corrected. Repeat the above test with the DVD VIDEO PLAYER power plug reversed. NEVER RETURN A DVD VIDEO PLAYER TO THE CUSTOMER WITHOUT TAKING NECESSARY CORRECTIVE ACTION.
READING SHOULD NOT EXCEED 0.3V
AC VOLTMETER
DVD VIDEO PLAYER
(5000 per volt or more sensitivity)
1500 10W
AC OUTLET
Good earth ground such as a water pipe, conduit, etc.
0.15uF 150V AC
Test all exposed metal. Voltmeter Hook-up for Leakage Current Check
The lightning flash with arrowhead symbol, within an equilateral triangle, is intended to alert the user to the presence of uninsulated "dangerous voltage" within the product's enclosure that may be of sufficient magnitude to constitute a risk of electric shock to persons. The exclamation point within an equilateral triangle is intended to alert the user to the presence of important operating and maintenance (servicing) instructions in the literature accompanying the appliance.
English
3.0 INSTRUCTIONS FOR USE Front of player
POWER / CHG Power and charging indicator Grip Opens display and disc tray
OPEN
CHG
POWER
Left of player
POWER ON / OFF Switches the player on / off
ON POWER OFF
Right of player
VOLUME
VOLUME Volume control PHONES 1 & 2 Headphones jack AUDIO/VIDEO AV cable jack
PHONE 1
PHONE 2
AUDIO/VIDEO TV OUT •
•TFT ON
COAXIAL
DC IN 9V
DC IN 9V Power supply socket COAXIAL Digital audio output jack (coaxial) TV OUT / TFT ON Selects video output
English
Disc tray FUNCTION Selects display mode 9/: For previous (ı 9 ) or next ( : ) chapters, tracks or titles
OPEN Opens disc tray Disc tray Open to inser or remove disc
, , , 5634 Up / down / left / right cursor OK Confirms selection TITLE Display TITLE page MENU Display MENU page OSD On Screen Display on / off PLAY Starts / resumes playback PAUSE Pause playback STOP Press twice to stop playback
English
Remote control OSD On Screen Display on / off LANGUAGE Language selector AUDIO Audio language selector SCAN Playback of the first 10 seconds of each chapter / index on the disc BOOKMARK Selects bookmark options MENU Displays MENU page TITLE Displays TITLE page
SETUP Enters SETUP menu SUBTITLE Subtitle language selector ANGLE Selects DVD camera angle PLAY MODE Selects play order options ZOOM Enlarges / chapter / video image REPEAT Repeats chapter / title / disc A-B To repeat or loop a sequence in a title
9 Previous chapter, track or title
: Next chapter, track or title
7 Search backward
8 Search forward
PLAY / OK Confirms selection and starts playback STOP Press twice to stop playback PAUSE Pause playback 0-9 Numerical keypad
, , , 5634 Up / down / left / right cursor SLOW PLAY Slow motion / Frame by frame playback RETURN For VCD menu page TIME SEARCH Searches by time MUTE Muting player volume
4.0 Mechnical instructions 1. Back View as Fig.1 Remove screws to Disassemble the base
5. Remove top cover as Fig.5
remove screws
screws
remove screws
Fig.1 2. Soldered short pattern for laser diode as Fig.2
remove screws Fig.5 6. Disassemble the IF board and HV board as Fig.6
soldered Fig.2 3. Disassemble the DVD drive and main board as Fig.3,4 Disconnect the DVD drive and main board
Fig.6 7. Detach the LCD TFT as Fig.7 Take off the screws to remove LCD TFT
Fig.3 Disassemble the key board and other parts
Fig.4
Fig.7
5.0 TROUBLESHOOTING & SERVICE TIPS 5.1 Procedure to change regioncode
1. Power on player and open DVD Door. 2. Press <Set Up> at Remote Control. In <Set Up Menu> select
and press . 3. For PET700 - Press successively 2 5 2 3 1 5. . . 4. Display will show for Europe: 5. Press key to input preference region code (see below table). 6. Switch off and re-switch on the product. 7. Verify Region code change done. Region Code 1 2 3
4 5 6
Region USA EUROPE ASIA PACIFIC AUSTRALIA, NEW ZEALAND, LATAM RUSSIA, INDIA CHINA
REMARKS: 1. Password is CONFIDENTIAL. 2. Region code is printed on product type plate. Due to DVD legislation region codes different to assigned region may not be released.
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: NO POWER, NO GREEN LED
start
Check if the power cable and AC adapter OK?
no
replace cable/ adapter
set OK?
no
replace connector and switch unit
no
yes
No defect, return set to customer
yes
Check if the power and play button OK?
yes
replace MAIN BOARD
go to other SYMPTOM
SYMPTOM: NO IMAGE OR SOUND COMES OUT FROM THE EXTERNAL OUTPUT start
Check operation of the DVD drive. Does the DVD drive work? yes
Replace the main board or the connector
no
replace DVD drive
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: THE INITIAL SCREEN IS NOT DISPLAYED ON THE LCD Refer to the symptom NO POWER, NO GREEN LED
start
Check if the LED on the front lights up?
Replace broken harness
no
yes
yes Check if the backlight is OK?
Repair connector
no
Open the top and bottom assembly to check the connector harness
Is the connector harness broken?
no
no
Remove the LCD cover and plate of the LCD unit to check the connector of the FL harness
Is the connector OK?
yes
Replace FL inverter or LCD
yes
Check if the lighting of the LCD is OK?
no
Open the top and bottom assembly to check the connector to the main board
Is the connector broken?
yes
yes
Replace LCD unit or main board
Replace LCD harness or main board
Connect the LCD harness to the LCD unit
no
Remove the LCD cover and plate of the LCD unit to check the connection of the harness to the LCD unit
no
Is the connection OK? yes
Replace LCD unit or main board
SYMPTOM: NO IMAGE OR SOUND COMES OUT FROM THE EXTERNAL INPUT start
Replace the main board or the connector
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: THE DVD DRIVE DOES NOT WORK Press the DISC cover switch at the center of the DVD player and turn on the power. Then check whether or not the optical pickup lens of the DVD drive lights. CAUTION: Visible laser radiation when open and interlock defeated. Do not stare into Laser beam.
start
yes Check the optical pick up lens?
Replace DVD drive
Pick up lens light up dim
Pick up lens does not light up at all Check the connectors of the DVD drive and main board?
OK
Pick up lens light up OK Not OK Secure the connection of the DVD drive and main board
Insert a DVD disc and turn on the power The DVD drive works but the initializing operation of the optical pick-up lens does not start (the optical pick-up lens operates twice), or abnormal noise sound DVD drive does not work
Replace DVD drive or main board
What is the reaction of the DVD drive?
The operation of the DVD player stops at initializing display.
Γoading?displayed
Is there any message shown on display
Γ HECK DISK?displayed
Does the image output stop during the operation?
DVD disc OK
Check the DVD disc for fingerprints, dirt,
No defect, return set to customer
Nothing on display
yes
Is the DVD disc OK? no
DVD disc dirty
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: THE DVD DRIVE DOES NOT OPERATE WITH BATTERY
start
Install a good battery does the LED lights up orange while the AC adapter is connected and does the DVD drive operate OK? NOTE: - For this check, use a battery which is not fully charged (because the LED does not light when the battery is fully charged.) - Before this check, make sure other function work correctly.
yes
Replace battery
no Is the connection of the battery OK inside the DVD player?
no
Secure the connection of the battery harness inside the DVD player
yes
Replace main board
SYMPTOM: NO SOUND COMES FROM THE HEADPHONES
start
Insert a good headphones and check if the problem persist?
yes
Replace main board
no
CustomerΓ headphones defective
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: NO SOUND COMES FROM THE HEADPHONES
start
Insert a good headphones and check if the problem persist?
yes
Replace main board
no
CustomerΓ headphones defective
6.0 OVERALL BLOCK DIAGRAM 27MHz UPD5100 TC4W53
8M FlashROM
64M SDRAM
MX29LV008TTC-70
NT56V6620C0T-75S
74HCU04
TFT MONITOR
TFT POWER
HIGH VOLTAGE ASS'Y
DC 9V
+5V -14.5V +16V
27MHz
VIDEO OUT KHM-252 PU mechanism
SERVO & DVD PROCESSOR MPEG-2 DECODER & VIDEO ENCODER D2881
RF AMP D2891
S-VIDEO OUT +3.3V +5V L
L R
DRIVER (BA5954FP)
AUDIO OUT
AUDIO D/A (PCM1742)
AUDIO AMP (NJM4558) R
DRIVER +5V AUDIO +5V
PHONE OUT
AUDIO +/-5V
PHONE AMP (NJM4580) BATTERY
DC IN +9V
R
DC / DC (R1224) (TPS5100)
DC 9V
110~240V 50/60Hz AC Adapter
DC / DC (R1224)
(BQ2057C)
(TPC8207)
L
SPEAKER AMP (D2822)
SPEAKER LOUT
(VG202C) SPEAKER ROUT
7.0 Overall wiring diagram
1 2 3
1 GND POWERSW 2 DCIN 3
SWITCH PCB
LOADING
LIMIT GND SLSL+ SP+ SP-
GND GND ISEN VSEN
1 2 3 4
30 29 28 27 26 25 24 23 22 21 20 19 18 17 XS1 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
VCOMS TFT-16V SPIO NC NC CLD MODE1 GND VDD1 GND SPOI GND LCD R LCD G LCD B TFT5V TFT5V GND GND TFT+13V COMS GND GND MODE2 CLS SPS VDD1 GND VDD3V3 VDD3V3
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
HV POWER PCB
1 2 3 4
GND GND ISEN VSEN
1 2 3 4
XS001
XS4
1 2 3 4 XS401 5 6
MAIN PCB
XS403 1 2 3 4 5 6 7 8
1 2 3 4 5 6
24 23 22 21 20 19 18 XS5 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
KEYIN3 KEYIN2 KEYIN1 KEYIN0 KEYOUT0 KEYOUT1 KEYOUT2 KEYOUT3
NC LD/VCC V20 GND F E CD/DVD SW RF C D B A VRCD VRDVD MD LD/CD GND LD/DVD NC VCC FCSTRK+ TRKFCS+
1 2 3 4 5 6 7 8
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1 XS4 2 3 4
FUNCTION BUTTON PCB
XS3
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
VCOMS GND 3.3V GND B G R GND MODE2 MODE1 SPOI SPIO SPS CLD NC CLS GND GND TFT +5V TFT +5V
1 2 3 4 5 6 XS6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
1 GND 2 COMB 3 GND 4 -14.5V 5 GND 6 +16.5V 7 GND 8 GND IF PCB 9 3.3V 10 3.3V 11 GND 12 XS3 SPKR 13 GND 14 SPKL 15 GND 16 GND TFT ON/OFF 17 BRIGHT-CO 18 TFT-HV9V 19 TFT-HV9V 20
LCD
8.0 ELECTRICAL DIAGRAM
DC POWER CIRCUIT DIAGRAM
L005 CDRH6D38-330MC
c099 100U/16V VD040 CRG01
VD010 ISS355
R010 10K
S 1
7 D
G 2
6 D
S 3
3 CO
5 D
G 4
4 VM
N019
TPC8207
1K
R059 1M
1 SENS 2 DO
R058 1K
VCC 8 S8232AUFT
R055
8 D
C057 100n
C080 10U/16V
ICT 6 VSS 5
N018
t IP405B217S
C055 220N
t
1K C054 220N
GND 2
OUT 3
CB05 100n
C493 10U/16V L413 BGH2012B601LT
N015 PQ05DZ11
GND
1 7 6 5 R049 1K
+P5V CB82 100n
CB25 100n
C048 100U/16v
C046 470P
VIDEO +5V CB10 100n
C316 100U/6V L008 LQH4N101J04
VD031A RB040L
RVCCIN +5V
AUDIO +5V
C461 100U/6V
L007 LQH4N101J04
8 2 3 4
AV33 CB06 100n
CB01 100n
L305 BGH2012B601LT
POWER ON/OFF N014 NJM2360
DV33 CB32 100n
AUDIO -5V
C049 100U/16v
TFT +5V
OUT 3 C15 10U/16V
CB81 100n
L7 BGH2012B601LT
TFT +3.3V
CB3 100n
C18 10U/16V
1 IN
PTC
XS003 1 2 3 4
GND
D4 LT1117-1V8
SRF96E R057
VC 7
C050 100U/6V
V25
C077 10U/16V
GND
1 IN
NC
OUT 3
PTC
t R056 1K
C498 100U/6V
C076 100n
TFT ON/OFF
C053 220N
L430 BGH2012B601LT
2
GND
VOUT EXT 4
L016 BGH2012B601LT
2
XS002
GND
1 IN
VD206 LED
C417 10U/16V
CB16 100n
HV VCC
N5 BA033
4
CHRG
BQ2057C
C078 100n
N013 PQ05DZ11
R036 56K
CO
N020
R033 56K
R218 1K
5
STAT 5
C079 10U/16V
C032 100n
2
4 TS
VR002 5K
4
VSS 6
3
CC 7
3 VCC
R047 0.25
L009 LQH4N100J04
Littelfuse 451005 F 5A/125V
2
2 BAT
R014 2.7K
C014 NC
F002
C016 100n
R015 20K
2
R035 56K
R032 1K
C022 100U/6V
OUT 3
L408 BGH2012B601LT
1 IN
R050 3K
1
R034 39K
COMP 8
L420 BGH2012B601LT
C015 100n
C021 100u/16V
VD033 U5FWK24C42
1
C031 100N
1 SNS
C012 1000P
R016 47K
R031 120K
R001 0.075
1 IN
VD015 2SD601AR
R011 4.7K
VD009 UDZS7E-1715B
VD028 2SJ401 3 2
VD017 RB060-40L
C424 10U/16V L419 BGH2012B601LT
NC
C010 100n
R018 2.7K
GND
VD045 KTA1298
CB14 100n
C412 10U/16V
4
VD011 ISS355
R013 91K
C011 10U/16V
OUT 3
N006 UPC29M05
L002 CDRH6D38-330MC
N004 R1224N R012 10
1
R003 47K
R088 47K
R007 1K
R002 1K
N003 IR7304
CB108 100n
CO
R087 10K VD014 2SD601AR
C020 100u/16V
C018 1000P
R020 20K
VOUT EXT 4
POWER SWITCH
VD001 UPA1716G
VD016 ISS355
VD018 RB060-40L
3
R017 4.7K
GND
R006 47K
CE
R008 10K
1
VD032 LED
SW003 ESD1062
C008 100n
N001 R1224N
1 IN
R019 56K
3
VD004 RB060L-40
R009 10
VIN 5
R005 10K
C003 16V/100U
VIN 5
DC IN +9V
C005 100n
2
VD013 UDZS7E-174.7B
R052 2K
R030 100K
L001 CDRH6D38-330MC
VD003 RB060L-40
CE
VD002 IN5402T
2
FM001 LV902
2
T3A/1 25V
5
N003 IR7304
Littelfuse
F001 452003
L017 BGH2012B601LT
N005 BA033
cation: REPLACE PUSE WITH SAME TYPE AND RATING
JS001 HEC4801-010110
c081 100n
OUT 3 C14 10U/16V
CB6 100n
L3 BGH2012B601LT C17 10U/16V
CB43 100n
TFT +1.8V
DV33
V33 CB73
S8 RETURN
S9 STOP
S10 DOWN
CB41 0.1uF
C446 1uF
1 LPFIP
TP30 TP31
1 LPFOP 1 JITFO
C450 0.01uF
C452 100pF
R443 TP34 0 R444 10k R445 15k R409 0
CB46 0.1uF
S15 QUICK
VCC GND RMC
S13 PREV
R401 10
S12 MENU
S14 PAUSE
S16 UP R407 10K
CB84 0.1uF
FCE# PRD# PWR#
R406 0
C485 47U/ 6V
A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20 CE OE WE
IR
+
R568 100K C510 47U/ 6V
VD521 ISS355 +
R560 470
VD407 KTA1298
14
Y6 Y5 GND Y4 DACV33A Y3 GND Y2 DACV33B Y1 GND
1 1
1
TP26 VSYNC#
HSYNC# TP24
TP25 Y7
URST XTALI
DV33 SPBCK SPLRCK V25 SPDATA SPMCLK HSYNC# GND Y7 VSYNC# BLANK#
DV33
GND
+
+ +
+
ADIN TP19
R417 18k
C426 1000pF
+
L425 BGH2012B601LT CB101 0.1uF
162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109
Y0 VREF 1 DACV33C R583 ASDAT4 2.2k TP28 ASDAT3 ASDAT2 ASDAT1 ASDAT0 ASPDIF AMDAT ACLK DV33 ALRCK ABCK DQ16 KEYIN0 DQ17 KEYIN1 GND DQ18 KEYIN2 DQ19 KEYIN3 DQ20 KEYOUT0 DQ21 KEYOUT1 V25 DQ22 KEYOUT2 DQ23 KEYOUT3 DQM2 DQM3 GND DQ24 TFTSW DQ25 BATDET DQ26 NC DQ27 TFTON/O FF DV33 DQ28 DISPLAY0 DQ29 DISPLAY1 DQ30 PAL/ NTSC DQ31 CS GND MA3 MA2 MA1 MA0 V25 MA10 BA1 DQM0 DQM1 GND MA4 MA5 TFT SW MA6 DV33 MA7
JP2 TO KEYBODY 1 2 3 4 5 6 7 8
SW003 TFT SW
L437-L448 BSZ2012-600T BATDET
CB104 0.1uF
NC TFTON/O FF DISPLAY0
R453 AV33 4.7
DISPLAY1 PAL/ NTSC
R527 1K
VD509 2SD601AR
VD510 2SD601AR
C513 10uF/ 16V R507 150K
R545 100K
R508 150K
N503 2822 C532 3n3
R510 10K
R509 10K
1
+
C535 47U
C545 51P
VCC 2 R-OUT 3 L-OUT
1
GND 4
C495 100uF/ 6V
C542 100U VD513 STZ6.2N
L502 100UH
C531 100U/ 16V 6 IN-L 7 IN-R
JS503
RN419 22 DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15 2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53
R-OUT
5 IN8 IN-
C534 47U +
2 INR547 5.1K
VCC 8 GND 4
CB91 0.1uF
N413 24C01
+
HEAD PHONES
AUX
AUDIO VCC C530 100n
C538 100U/ 16V
SW002 AUX SW
LS1 SPEAKER
TO TFT BOARD V25
CB14
CB15
CB16
CB17
CB18
CB19
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
DV33 CB4 0.1uF
NC NC
R541 10K
C512 10uF/ 16V
7
+
DQML DQMH
N501B 4558
R529 10K
C514 10uF
R526 1K
L-OUT
3 IN+ 5 IN+
C556 100U
CLK
CB54 0.1uF
54 41 28
R520 10K
C508 10uF
C544 51P
N502 4580 6 IN-
CS
EM407 FK2125T186AL
C467 100uF/ 6V
CB5
CB6
CB7
CB8
CB9
CB10
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
N419 ESMT M12L64164A-? SMD TSOP(II)-54D400x875mil
CLOSE SW001 CLOSESW
C536 100U/ 16V
LS2 SPEAKER
TO TFT Y
TO TFT C
DV33
+
+
R463 4.7K
DV33
36 40
C519 300P
R530 10K
R529 100
JS502 HEAD PHONES
R315 10
C314 47U/ 4V
C425 10uF/ 16V
CB102 0.1uF
VCC 114 VCC 27 VCC VCCQ 93 VCCQ 43 VCCQ 49 VCCQ VSSQ 612 VSSQ 46 VSSQ 52 VSSQ
VCCI
R544 5.1K
R540 10K
-5v
7
6
R543 100K
C515 10uF
R306 10
DI
CS RAS CAS WE
5
VR1 WHXB-2-20K
C525 3n3
C511 220U/ 10V
C318 47U/ 4V
C317 100uF/ 16v
SD33
15 39
VD524 KTA1298 VD522 ISS355
R511 10K R522 100K
R530 100
R464 4.7K
19 18 17 16
R519 5.6K C517 3n
R567 0
VD523 ISS355
VCC5V
C516 3n R521 3.9K
3
C575 C576 100uF/ 16V 100n
+
C509 10uF
JS504 AUDIO OUT
DQM0 DQM1
R559 VD505 2SD601AR 4.7K
R557 1K
100uF/ 16V C540
N501A 4558 1
2
VCC-5V
VD512 STZ6.2N
DCS# DRAS# DCAS# DWE#
MUTE
C555 10uF VCC5V
R452 4.7
CLK CKE
VD526 ISS355
VCC+5V
C518 300P
R514 3.9K R513 5.6K
AV33
38 37
R521 10K
R556 1K R558 10K
8
CB107 0.1uF
SDCLK SDCKE
CB22 0.1uF
ROUT
V33
SMD LQFP-216
DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15
C487 10uF/ 16V VD525 ISS355
9 GND
7
V25
N509
D2871
C321 100uF/ 6V
L410 BGH2012B601LT
+
C428 10uF/ 16V
YUV0/ CIN FS VREF DACVDDC ASDATA4 ASDATA3 ASDATA2 ASDATA1 ASDATA0 SPDIF MC_DATA ACLK DVDD3 ALRCK ABCK RD16 RD17 DVSS RD18 RD19 RD20 RD21 DVDD2 RD22 RD23 DQM2 DQM3 DVSS RD24 RD25 RD26 RD27 DVDD3 RD28 RD29 RD30 RD31 DVSS RA3 RA2 RA1 RA0 DVDD2 RA10 BA1 DQM0 DQM1 DVSS RA4 RA5 RA6 DVDD3 RA7 DMVSS
A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10/AP A11 BA0/A13 BA1/A12
+
C554 10uF
CB52 0.1uF
DV33
IREF PLLVSS LPIOP LPION LPFON LPFIP LPFIN LPFOP JITFO JITFN PLLVDD3 FOO TRO TROPENPWM PWMOUT1 PWMOUT2 DVDD2 DMO FMO DVSS FG HIGHA0 HIGHA1 HIGHA2 HIGHA3 HIGHA4 HIGHA5 DVSS HIGHA6 HIGHA7 AD7 AD6 AD5 AD4 DVDD3 AD3 AD2 AD1 AD0 IOA0 IOA1 DVDD2 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 A16 A17 IOA18 IOA19 IOA20 APLLVSS
23 24 25 26 29 30 31 32 33 34 22 35 20 21
CB01 0.1uF
11
A2 A3 A4 A5 A6 A7 A16 A17 A18 A19 A20
GND
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54
MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 DBA0 DBA1
C460 100uF/ 16v
C574 100n
R517 10K
R516 100K
12
GND
N412 MX29LV008TTC-70 SMD TSOP-40(10x20mm)
R515 10K
13
N301 BA7660FS
JS501 VIDEO OUT C319 47U/ 4V
+
+
+
C312 100uF/ 16v
C308 20p
VCCI
C573 100uF/ 16V
ML 15 MC 14
MD 5 +3.3V ZERONA 6 +5V ZERO OA 10 VCOM LOUT
AUDIO 5V
R465 33
V25
A8 A9 A10 A11 A12 A13
AD3 AD2 AD1 AD0 A0 A1
NC 11 NC 29 RESET 10 RY/ BY 12 VCC 30 VCC 31 23 VSS 39 VSS
1 PWMOUT1
A14 A15 AD7 AD6 AD5 AD4
AD0 AD1 AD2 AD3 AD4 AD5 AD6 AD7
25 26 27 28 32 33 34 35
C451 0.01uF
+
3 LRCK 4 DGND
VD411 ISS355
SCK
16
C455 330pF
+
VD410 ISS355
1 BCK 2 DATA
7 INC OUTC1 10 8 GND OUTC2 9
L416-L436 BSZ2012-600T
8 4
R494 33
+5v
D0 D1 D2 D3 D4 D5 D6 D7
C456 330pF
+
N417 PCM1742
R593 10
L302 1UH
R304 180
VSS VSS VSS
S7 NC
JP2 KEYBODY
+
C414 100uF/ 16v
S11 NEXT
4 INB OUTB1 13 5 GND OUTB2 12 6 NC DTC2 11
C313 100uF/ 16v
+
DRVCC5V
S6 NC
N406 HSB0038
1 2 3
DRVCC DRVCC LIMIT SLED+ SLED+ SLEDSLED-
8 7 6 5 4 3 2 1
21 20 19 18 17 16 15 14 8 7 36 6 5 4 3 2 1 40 13 37 38 22 24 9
C457 0.015uF
C449 0.01uF
R438 750k
R440 20k R442 18k
PWMOUT2
C447 0.01uF R433 8.2k
C448 0.01uF TP29
FOSO TRSO
+P5V
DMSO ECR FG FR GND GND
7
CB33 0.1uF C445 100pF
C493 47uF/ 16v
A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19
C304 20p
IR V25 RXD TXD UWR# URD# GND DQ7 DQ6 DQ5 DQ4 V25 DQ3 DQ2 DQ1 DQ0 WE# CAS# RAS# CS# BA0 GND DQ15 DQ14 DQ13 DQ12 DV33 DQ11 DQ10 DQ9 DQ8 GND DCLK DCKE MA11 MA9 MA8
C444 47uF/ 16v
DV33
+
SCL
S5 RIGHT
XS402 TO SPM0TOR
S4 MONITOR
C315 100uF/ 16v
R305 18
C320 100uF/ 6V
1 MUTE VCC 16 2 INA OUTA1 15 3 GND OUTA2 14
216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163
R432 4.7
L301 1UH
RFIP RFIN RFDTSLVN RFDTSLVP ADCVDD3 PWM2VREF PWMVREF HRFZC RFRP_AC RFRP_DC RFLEVEL FEI CSO TEI TEZISLV RFSUBI ADIN ADCVSS BDO SLCK SDEN SDATA WOBSI UDGATE DVDD3 IDGATE VFO13 DVSS PRST XTALI XTALO DVDD3 SPBCK SPLRCK DVDD2 SPDATA SPMCLK HSYN DVSS YUV7 VSYN BLANK# ICE YUV6/R YUV5/B DACVSSA YUV4/G DACVDDA YUV3/CVBS DACVSSB YUV2/Y DACVDDB YUV1/C DACVSSC
CB35 0.1uF
DMSO FMSO
S3 TOPMENU
RFRP
AV33 +
V1P4 S2 PLAY
RFIP C439 1000pF
C311 20p
R303 180
RFIN
RFOP
RVCCIN
C443 100U/ 16V
S1 LEFT
C437 1000pF
RFON
RFON RFOP
C474 20p
R305 180
1
10uF/ 10v
AV33
RVCCIN
Y2 Crystal :
DIP +SMD
L303 1UH
ADIN GND BDO SCLK SDEN SDATA
0.1uF
10uF/ 10v
1 TP22
RFL FEO CSO TEO
0.1uF 0.1uF
CB02 0.1uF
CB36 0.1uF
CB39 0.1uF
TP18 1
RFZC RFRPC
C499
SDA P3.0
+
CB86
CB42 0.1uF
14 13 12 11 10 9 8 7 6 5 4 3 2 1
7
RESETAV MUTE FG FR
SCLK
CD/DVD SW ASTB STBY LIMIT
AVDDP AGNDX AGNDP DPDMUTE RST SDATA SDEN GNDS SCLK XCK16M VDDS IOB IOA IO9 IO8 IO7 IO6 IO5 IO4 IO3 IO2 IO1 IO0 HDGATE UDGATE GND
C442 150p
FOSO
N402 BA5954FP
C495 10uF/ 16v
RFDTSLVN
CB26 CB27 C415
CB37 0.1uF
+
CB26 0.1uF RFDTSLVP
CB29 0.1uF
C427 0.015uF
C430 47uF/ 16v
R430 20K
C408 0.033uF
SCL SDA
V1P4
C407 470p
TP11 TEO TP12 CSO TP13 RFL TP15 FEO
A0 VDD 87 A1 NC 6 A2 SCL 5 A3 SDA
TRSO V1P4 STBY
CB40 0.1uF
G1 29 7 6 5 4 3 2 1
V2P8
390p 1 1 1 1
C415 10uF/ 16v
1 2 3 4
C441 150p
DRVCC5V
VNFFC VOSL VINSLVINSL+ CF2 CF1 VINFC
C406
CB27 0.1uF
VD301 STZ6.2N
C316 100uF/ 16v
C466 TZC03A-200P
R411 100k
C405 390p TEO CSO RFL FEO V20 V1P4 V2P8
V1P4
HTRC
2
L305 100UH
CB10 0.1uF
+
G401 C27MHz
C472 1000P C473 5.1P
VSCK VSDA
30 G2 22 23 PREGND VINLD 24 CTK2 25 26 CTK1 VINTK 27 BIAS 28 STBY
FMSO
RVCCIN
C403 0.01U
C404 10pF
BDO CB20 0.1uF
R410 27k C402 27p
VD413 ISS355
VIDEO 5V
XTALI C471 C
APLLVDD3 ALE IOOE# IOWR# IOCS# DVSS UP1_2 UP1_3 UP1_4 UP1_5 UP1_6 DVDD3 UP1_7 UP3_0 UP3_1 INT0# IR DVDD2 UP3_4 UP3_5 UWR# URD# DVSS RD7 RD6 RD5 RD4 DVDD2 RD3 RD2 RD1 RD0 RWE# CAS# RAS# RCS# BA0 DVSS RD15 RD14 RD13 RD12 DVDD3 RD11 RD10 RD9 RD8 DVSS CLK CLE RA11 RA9 RA8 DMVDD3
R429 20k
D A
14 13 12 11 10 9 8
F E
SL+ SLDRVCC5V
VOFC+ VOFCVOSL+ VOSLPGND PVCC1 VCC
RFRP
103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128
R421 0.5 VOTK+ VOTKVOLD+ VOLDPGND VNFTK PVCC2
4 74HC04
55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108
2
3
D C419DD C 1uF CC AA BB B C420 1uF A C421 1uF AA CC B C
C411 47uF/ 16v LDO1
+
38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
MDI2 MDI1 LDO1 LDO2
+
VD406 2SB1132 1
D2890
VFO13 VDD AGNDX AGNDX AGNDX DPFO DPFN GNDP HTRC TRLP TRLPA CRTPLP CRTP HRFRP LRFRP DEFECT VDDP TEO CSO LVL FEO V20 VREFO V2REFO AVDDT TM4 AGNDT TM3 TM2 TM1 AGNDO RFON RFOP AVDDO AGNDX AGNDX WVDD WOBSO
1
R414 100k R416 R R415 0
RFRPC HTRC
ALE PRD# PWR# PCE# GND
CB24 0.1uF C418 1uF
N401
MC MD SA SB AGND IR AVDD SC SD CDFOP CDFON SVDD TPI TNI SGND WGAND AGC1 WAVDD AGC2 AGC3 MDI2 MDI1 LDO1 LDO2 RFSUBO WGND
C401 47uF/ 16v LDO_AVCC
15 16 17 18 19 20 21
CB3 0.1uF
A
R413 10
3
CB23 0.1uF
LDO2
AGNDF VCON AVDDF AGNDX AVDDM COSPHI HALLCOS REFCOS AGNDM HALLSIN REFSIN SINPHI SW0 SW2 SW1 MOP MON AGNDX AGNDX CEON CEOP RFGCI RFGCU RFFGC OSP OSN CDD CDC CDB CDA DVDRFIN DVDRFIP DVDD DVDC DVDB DVDA MA MB
R425 33k
2
CB21 0.1uF VD404 2SB1132
CB98 0.1uF
L409 10
D409B
3
1M
+
L404 10uH
R419 0.5
R405
RFVCC
+
TOP
CB12 0.1uF
XS401 SF-HD8C HEADER 24SMD0.5 TOP
2 74HC04
+
65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102
CB11 0.1uF
V20
1
R462 39k
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39
C401 100uF/ 16v
+
CB31 0.1uF
L407 10uH
PWMOUT2 URST SDATA SDEN
V20
CB25 0.1uF
RVCCIN
+
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
0.1uF
D409A
1
CD/DVD SW
VEE 3 VSS 4
N403 TC4W53
5
CH1
VDD
7
8 C497 100uF/ 16v A
6
L430 10uH
CH2
COM 1 INH 2
14
+
+
C476 10uF/ 16v
AVCC5V
8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM
DVD1731T-AS IF PCB BOARD DIAGRAM
9.0 COMPONENT LAYOUT
DVD1650H HV PCB BOARD DIAGRAM
PET700 MAIN BOARD DIAGRAM
10.0 SERVICE PART LIST Service 12NC Model 994000000722 PET700
Description BATTERY
Location Code Photo BATTERY
994000000726 PET700
AV CABLE
AVCABLE
994000000724 PET700
REMOTE CONTROL
RC
994000000727 PET700 994000001902 PET700
TRAVEL BAG CAR CIGARTTE ADAPTOR
BAG CARADAPTOR
994000003524 PET700/05
ADPV18A ADAPTOR /05 ACADAPTOR
994000001898 PET700/00
ADPV18A ADAPTOR /00 ACADAPTOR
994000002897 PET700/44
ADPV18A ADAPTOR /44 ACADAPTOR
994000002156 PET700/75
ADPV18A ADAPTOR /75 ACADAPTOR
10.0 SERVICE PART LIST 994000002876 PET700
MAIN PCB ASS'Y
100
994000002875 PET700
IF PCB ASS'Y
110
994000002878 PET700
HV PCB ASS'Y
120
994000002877 PET700 994000002891 PET700
FUNCTION PCB ASS'Y 20 PIN HARNESS (LE105)
130 142
994000002892 PET700
20 PIN HARNESS (L140) 144
994000004203 PET700
TFT LCD
200
994000002228 PET700
DV23 LOADER
210
994000002893 PET700
SPEAKER
220
10.0 SERVICE PART LIST 994000002881 PET700
TOP COVER
300
994000002882 PET700
DISPLAY FRAME
310
994000002883 PET700
MIDDLE CABINET
320
994000002884 PET700 994000002885 PET700
BOTTOM CABINET BASE COVER
330 331
994000002988 PET700
CONTROL KEY PAD
350
994000002886 PET700
DOOR
360
994000003766 994000002338 994000002888 994000002887 996500039078 996500041639
TOP COVER LOCK DOOR SPRING TOP COVER LOCK SPRING OPEN BUTTON SPRING ON/OFF SWITCH SWITCH SW1
400 410 420 430 OFSWITCH SW1
PET700 PET700 PET700 PET700 PET700 PET700
10.0 SERVICE PART LIST 996510001857 PET700
LOCKING KEY ON MID CAB 440
11.0 REVISION LIST Version 1.0 (3141 785 30560) Initial release PET700/00/05/44/75 Version 1.1 (3141 785 30561) Chapter 10: Service parts list adapted with new parts and revised 12NC as listed below • Added photo on speaker (994000002893) • Deleted DVD mark (994000002889) • Added the new part control key pad (994000002988) Version 1.2 (3141 785 30562) Chapter 10: Service parts list revised 12NC as listed below • Corrected typo of 20 PIN harness (LE105) from 9940 000 02891 to 9940 000 02891 • Changed DV23 loader from 9940 000 02894 to 9940 000 02228 • Changed adaptor/05 from 9940 000 00728 to 9940 000 02229 • Changed adaptor/00 from 9940 000 00723 to 9940 000 01898 • Added the new part Top Cover Lock (994000003766) Version 1.3 (3141 785 30563) Chapter 10: • Added the new part ON/OFF SWITCH (996500039078) Version 1.4 (3141 785 30564) Chapter 10: • Added 12NC of new spare part SWITCH SW1 (996500041639) • Added location code on spare parts Version 1.5 (3141 785 30565) Chapter 10: • Added 12NC of locking key on mid cabinet (996510001857)